Motronic M 2.8.1 F2: TROUBLE CODE TABLE
| Trouble Code | Information Sensor |
|---|---|
| Cause of Fault | Remedy in |
F0: DATA LIST
| No. | Trouble Code Storage when... |
137
| ECU BOX TEMPERATURE HIGH |
|---|
| · Temperature in control unit higher than 96 °C / 205 °F |
Home/Opel/Omega/Opel Omega B (1994-2003)/Repair manual/Fuel Injection Systems/F2: Trouble Codes - Trouble Code 137 ECU Box Temperature Hi…
Contents
Wiring diagrams Section: Fuel Injection Systems- Introduction
- Motronic M 1.5.4 (20 Se, X 20 SE) Survey of Engine Compartment
- Simtec 56/56.1 - Introduction
- General Instructions / Safety Measures
- Programmable Control Units
- Checking Equipment
- The Checking System
- Motronic M 1.5.4 (20 Se, X 20 SE) Function
- Diagnosis
- Simtec 56/56.1 - Diagnosis
- Motronic 1.5.4 (Control Unit)
- Function Diagram, Motronic M 1.5.4 (20 Se / X 20 SE)
- Function Diagram, Motronic M 2.8.1
- General Instructions/safety Measures
- Motronic M 1.5.4 (20 Se, X 20 SE) Schematic Diagram
- Read Trouble Code
- Simtec 56/56.1 - Read Trouble Code
- Block Diagram
- Survey of Engine Compartment, Omega-B (20 Se / X 20 SE)
- Survey of Engine Compartment, Omega-B (X 25 XE / X 30 XE)
- Function Diagram Simtec 56.1 (X 20 XEV)
- Motronic M 1.5.4 (20 Se, X 20 SE) Block Diagram
- Check Data List Parameters
- Simtec 56/56.1 - Check Data List Parameters
- Components
- Installation of Air Cleaner Insert and Air Cleaner Housing
- Block Diagram, Motronic M 1.5.4 (20 Se / X 20 SE)
- Block Diagram, Motronic 2.8.1
- Block Diagram Simtec 56.0
- Illus. - Survey of Engine Compartment
- Motronic M 1.5.4 (20 Se, X 20 SE) Description of Individual Components
- Carry Out Actuator Tests
- Simtec 56/56.1 - Carry Out Actuator Tests
- Control Unit, Part and Catalogue Numbers
- Features Specific to This System
- Block Diagram Simtec 56.1
- Block Diagram, Cruise Control for Dde 2.1
- Motronic M 1.5.4 (20 Se, X 20 SE) Control Unit
- Carry Out Control Tests
- Simtec 56/56.1 - Carry Out Control Tests
- Abbreviations, Definitions
- Diagnostic Switch KM-640
- Illustration - Components of Electronic Diesel Injection Regulation
- Motronic M 1.5.4 (20 Se, X 20 SE) Dis Ignition System
- Snapshot Mode
- Simtec 56/56.1 - Snapshot Mode
- System Specific Features
- Checking with Tech 1
- Motronic M 1.5.4 (20 Se, X 20 SE) Knock Control
- Final System Test
- Simtec 56/56.1 - Final System Test
- A, Diagnostic System Check
- Replacement of Idle Air Control Valve
- Tech 1 Displays
- Survey of Engine Compartment, Omega-B (X 20 XEV Engine)
- Automatic System Test (Quick Check)
- Motronic M 1.5.4 (20 Se, X 20 SE) EGR System
- Vehicle Systems Model Year 95
- Simtec 56/56.1 - General Safety Measures and Repair Instructions
- How to Connect Diagn. Tester A. Establish Communication the B-01
- How to Connect Diagnostic Tester and Establish Communication the B-01
- Abbreviations
- Motronic M 1.5.4 (20 Se, X 20 SE) Fuel Pump Relay and Inj. System Relay
- General Safety Measures and Repair Instructions
- Survey of Vehicle
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0100 Mass Air Flow Sensor Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 14 Coolant Temperature Voltage Low
- F0: Data List - Test Step 01 Battery Voltage
- Circuit Interruption with Activated Anti-Theft Warning System/immobiliser
- System Checking with Tech 1
- Motronic M 1.5.4 (20 Se, X 20 SE) Idle Speed Adjuster
- Survey of Vehicles
- F2: Trouble Code Table - Trouble Code 13 O2 Sensor Open Circuit
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0100 Mass Air Flow Sensor Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 15 Coolant Temperature Voltage High
- F0: Data List -Test Step 02 TPS Signal
- F0: Data List - Test Step 02 TPS Signal
- Temperature Switch S58
- F0: Data List
- Motronic M 1.5.4 (20 Se, X 20 SE) Wiring Harness Routing, Schematic
- F2: Trouble Codes - Trouble Code 13 O2 Sensor Open Circuit
- F2: Trouble Code Table - Trouble Code 14 Coolant Temperature Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0110 Intake Air Temperature Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 16 Fuel Temperature Voltage Low
- F0: Data List - Test Step 03 Sim. Idle Pos.sw
- Motronic M 1.5.4 (20 Se, X 20 SE) Circuit Diagram
- F2: Trouble Codes - Trouble Code 14 Coolant Temperature Voltage Low
- F2: Trouble Code Table - Trouble Code 15 Coolant Temperature Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0110 Intake Air Temperature Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 17 Fuel Temperature Voltage High
- F0: Data List - Test Step 04 Sim. Full Pos.sw
- How to Connect to Vehicle the Tech 1
- F0: Data List - Test Step 02 Coolant Temperature
- Motronic M 1.5.4 (20 Se, X 20 SE) Terminal Assignment, Wiring Harness Plug
- F2: Trouble Codes - Trouble Code 15 Coolant Temperature Voltage High
- F2: Trouble Code Table - Trouble Code 16 Knock Signal Circuit
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0115 Coolant Temperature Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 19 Incorrect RPM Signal
- F0: Data List - Test Step 05 Intake Air Temperature
- F0: Data List - Test Step 03 Fuel Temperature
- Motronic M 1.5.4 (20 Se, X 20 SE) Trouble Code Table
- F2: Trouble Codes - Trouble Code 16 Knock Signal Circuit
- F2: Trouble Code Table - Trouble Code 19 Incorrect RPM Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0115 Coolant Temperature Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 21 Aps Signal Voltage High
- F0: Data List - Test Step 06 Coolant Temperature
- F0: Data List - Test Step 04 Boost Temperatur
- Engine Management System Simtec 56.1 Survey of Engine Compartment
- F2: Trouble Codes - Trouble Code 18 Knock Control Module; Replace ECU
- F2: Trouble Code Table - Trouble Code 21 Throttle Posit. Sensor Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0120 Throttle Posit. Sensor Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 23 Aps Signal Volt. Not in Idle Range
- F0: Data List - Test Step 07 Mass Air Flow S.
- F0: Data List - Test Step 05 Boost Pressure
- Engine Management System Simtec 56.1 Function
- F2: Trouble Codes - Trouble Code 19 Incorrect RPM Signal
- F2: Trouble Code Table - Trouble Code 22 Throttle Posit. Sensor Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0120 Throttle Posit. Sensor Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 24 Vehicle Speed Sens. Incorrect Signal
- F0: Data List - Test Step 08 Knock Signal
- F0: Data List - Test Step 06 Barometer Sensor
- Engine Management System Simtec 56.1 Schematic Diagram of Simtec 56.1
- F2: Trouble Codes - Trouble Code 21 Throttle Posit. Sensor Voltage High
- F2: Trouble Code Table - Trouble Code 23 Knock Signal Out of Range
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0130 O2 Sensor Circuit Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 31 No Engine RPM Signal
- Miscellaneous Problems in Vehicles with Motronic Ignition/injection System
- F0: Data List - Test Step 09 Vehicle Speed
- F0: Data List - Test Step 04 Sim. Part Pos.sw
- F0: Data List - Test Step 07 Brake Switch 1
- Engine Management System Simtec 56.1 Block Diagram
- F2: Trouble Codes - Trouble Code 22 Throttle Posit. Sensor Voltage Low
- F2: Trouble Code Table - Trouble Code 24 No Vehicle Speed Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0130 O2 Sensor Circuit Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 34 Inj. Timing Control Out of Range
- Various Problems with Vehicles with Simtec Ign./injection System
- F0: Data List - Test Step 10 Hall Sensor
- F0: Data List - Test Step 05 Sim. Full Pos.sw
- F0: Data List - Test Step 08 Brake Switch 2
- Engine Management System Simtec 56.1 Control Unit
- F2: Trouble Codes - Trouble Code 25 Injector Valve 1 Voltage High
- F2: Trouble Code Table - Trouble Code 25 Injector Valve 1 Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0130 O2 Sensor Range / Perf.
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 37 Incorrect Brake Switch Signal
- F0: Data List - Test Step 11 Vehicle Speed
- F0: Data List - Test Step 06 Transm. Coding
- F0: Data List - Test Step 09 Park/neutral Sw.
- Engine Management System Simtec 56.1 Hot Film Mass Air Flow Meter
- F2: Trouble Codes - Trouble Code 26 Injector Valve 2 Voltage High
- F2: Trouble Code Table - Trouble Code 26 Injector Valve 2 Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0135 O2 Sensor Heating Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 39 Anti Theft Injection Lock Active
- F0: Data List - Test Step 12 Vehicle Sp.pulse
- F0: Data List - Test Step 07 Intake Air Temperature
- F0: Data List - Test Step 10 Clutch Switch
- Engine Management System Simtec 56.1 EGR System
- F2: Trouble Codes - Trouble Code 27 Injector Valve 3 Voltage High
- F2: Trouble Code Table - Trouble Code 27 Injector Valve 3 Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0135 O2 Sensor Heating Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 41 Boost Pressure Voltage Low
- After Replacing Engine Control Unit, TC10 Is Set,engine Telltale Illum. Perm.
- F0: Data List - Test Step 13 Park/neutral Sw.
- F0: Data List - Test Step 08 Coolant Temperature
- F0: Data List - Test Step 11 Transm. Coding
- Engine Management System Simtec 56.1 Secondary Air Injection
- F2: Trouble Codes - Trouble Code 28 Injector Valve 4 Voltage High
- F2: Trouble Code Table - Trouble Code 28 Injector Valve 4 Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0201 Injector Valve 1 Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 42 Boost Pressure Voltage High
- Trouble Code 136, Engine Telltale Not Illuminated,emergency Program Not Active
- F0: Data List - Test Step 14 Torque Control
- F0: Data List - Test Step 09 Mass Air Flow S.
- F0: Data List - Test Step 12 Anti Theft Warn.
- Engine Management System Simtec 56.1 Wiring Harness Routing, Schematic
- F2: Trouble Codes - Trouble Code 31 No Engine RPM Signal
- F2: Trouble Code Table - Trouble Code 33 EGR Valve Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0201 Injector Valve 1 Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 43 Invalid Boost Pressure
- F0: Data List - Test Step 15 Ign. Coil CYL1+4
- F0: Data List - Test Step 15 Park/neutral Sw.
- F0: Data List - Test Step 10 Knock Control
- F0: Data List - Test Step 13 A/c Informat. Sw
- Engine Management System Simtec 56.1 Circuit Diagram
- F2: Trouble Codes - Trouble Code 33 EGR Valve Voltage Low
- F2: Trouble Code Table - Trouble Code 34 EGR Valve Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0202 Injector Valve 2 Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 44 Incorrect Boost Pressure
- F0: Data List - Test Step 16 Ign. Coil CYL2+3
- F0: Data List - Test Step 16 Torque Control
- F0: Data List - Test Step 11 A/c Informat. Sw.
- F0: Data List - Test Step 14 A/c Cutoff Req.
- Engine Management System Simtec 56.1 Terminal Assignment of Engine Control Unit, 55-pin
- F2: Trouble Codes - Trouble Code 34 EGR Valve Voltage High
- F2: Trouble Code Table - Trouble Code 37 Check Light Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0202 Injector Valve 2 Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 48 Battery Voltage Low
- F0: Data List - Test Step 17 Engine Load Sig.
- F0: Data List - Test Step 17 Ign. Coil CYL1+4
- F0: Data List - Test Step 12 A/c Compress. Sw
- F0: Data List - Test Step 15 A/c Cutoff Relay
- Engine Management System Simtec 56.1 Trouble Code Table
- F2: Trouble Codes - Trouble Code 38 O2 Sensor Circuit Voltage Low
- F2: Trouble Code Table - Trouble Code 38 O2 Sensor Circuit Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0203 Injector Valve 3 Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 49 Glow Device General Error
- F0: Data List - Test Step 18 TPS Load Signal
- F0: Data List - Test Step 18 Ign. Coil CYL2+3
- F0: Data List - Test Step 16 Vehicle Speed
- Engine Management System M 2.8.1 Survey of Engine Compartment
- F2: Trouble Codes - Trouble Code 39 O2 Sensor Circuit Voltage High
- F2: Trouble Code Table - Trouble Code 39 O2 Sensor Circuit Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0203 Injector Valve 3 Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 54 Cutoff Sol. Test Incorr. or Short to GND
- F0: Data List - Test Step 19 Fuel Pump Relay
- F0: Data List - Test Step 19 Ign. Coil CYL2+5
- F0: Data List - Test Step 17 Crc Control Dev.
- Engine Management System M 2.8.1 Function
- F2: Trouble Codes - Trouble Code 44 O2 Sensor Lean Exhaust
- F2: Trouble Code Table - Trouble Code 44 O2 Sensor Lean Exhaust
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0204 Injector Valve 4 Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 55 Replace ECU
- F0: Data List - Test Step 20 A/c Cutoff Relay
- F0: Data List - Test Step 20 Ign. Coil CYL3+6
- F0: Data List - Test Step 15 Fuel Pump Relay
- F0: Data List - Test Step 18 Aps Signal
- Engine Management System M 2.8.1 Schematic Diagram
- F2: Trouble Codes - Trouble Code 45 O2 Sensor Rich Exhaust
- F2: Trouble Code Table - Trouble Code 45 O2 Sensor Rich Exhaust
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0204 Injector Valve 4 Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 61 Fuel Quantity Sensor Incorrect Signal
- F0: Data List - Test Step 21 EGR Solenoid
- F0: Data List - Test Step 21 Engine Load Sig.
- F0: Data List - Test Step 16 A/c Cutoff Relay
- F0: Data List - Test Step 19 Idle Position Sw
- Engine Management System M 2.8.1 Block Diagram
- F2: Trouble Codes - Trouble Code 48 Battery Voltage Low
- F2: Trouble Code Table - Trouble Code 46 Second. Air Pump Relay Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0230 Fuel Pump Relay Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 64 Fuel Quantity Control Out of Range
- F0: Data List - Test Step 22 EGR Pulse Ratio
- F0: Data List - Test Step 22 TPS Load Signal
- F0: Data List - Test Step 17 EGR Pulse Ratio
- F0: Data List - Test Step 20 Fuel Quant.sens.
- Engine Management System M 2.8.1 Control Unit
- F2: Trouble Codes - Trouble Code 49 Battery Voltage High
- F2: Trouble Code Table - Trouble Code 47 Second. Air Pump Relay Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0230 Fuel Pump Relay Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 65 ECU Box Temperature High
- F0: Data List - Test Step 23 Engine Type
- F0: Data List - Test Step 23 Fuel Pump Relay
- F0: Data List - Test Step 18 Sec.air Pump Rel
- F0: Data List - Test Step 21 Des. Fuel Quant.
- Engine Management System M 2.8.1 Dis Ignition System
- F2: Trouble Codes - Trouble Code 52 Check Light Voltage High
- F2: Trouble Code Table - Trouble Code 48 Battery Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0325 Knock Signal Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 81 Sens. Inj. Start Short or Open Circt.
- F0: Data List - Test Step 24 Transm. Coding
- F0: Data List - Test Step 19 Fuel Tank Vent.
- F0: Data List - Test Step 22 Inj. Regulation
- Engine Management System M 2.8.1 Stereo Oxygen Sensor Loop
- F2: Trouble Codes - Trouble Code 53 Fuel Pump Relay Voltage Low
- F2: Trouble Code Table - Trouble Code 49 Battery Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0325 Knock Signal No Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 82 Sens. Inj. Start Incorrect Rpm- Signal
- F0: Data List - Test Step 25 Fuel Tank Vent.
- F0: Data List - Test Step 20 Engine Speed Lim
- F0: Data List - Test Step 23 Actual Inj.start
- Engine Management System M 2.8.1 Secondary Air Injection
- F2: Trouble Codes - Trouble Code 54 Fuel Pump Relay Voltage High
- F2: Trouble Code Table - Trouble Code 52 Check Light Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0335 Incorrect RPM Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 83 Immobiliser No or Wrong Coding
- F0: Data List - Test Step 26 Engine Sp. Pulse
- F0: Data List - Test Step 26 Camshaft Control
- F0: Data List - Test Step 21 Desired Idle
- F0: Data List - Test Step 24 Des. Inj. Start
- Engine Management System M 2.8.1 Multi-Ram System
- F2: Trouble Codes - Trouble Code 55 Replace ECU
- F2: Trouble Code Table - Trouble Code 53 Fuel Pump Relay Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0340 Camshaft Sensor Incorrect Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 84 Immobiliser No Signal
- F0: Data List - Test Step 27 Min Desired Idle
- F0: Data List - Test Step 27 Int.manifold V.1
- F0: Data List - Test Step 22 Engine Speed
- F0: Data List - Test Step 25 Engine Speed
- Engine Management System M 2.8.1 EGR System
- F2: Trouble Codes - Trouble Code 56 Idle Air Control Voltage High
- F2: Trouble Code Table - Trouble Code 54 Fuel Pump Relay Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0403 EGR Valve Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 85 Immobiliser Wrong Signal
- F0: Data List - Test Step 28 Engine Speed
- F0: Data List - Test Step 28 Int.manifold V.2
- F0: Data List - Test Step 23 Iac Integrator
- F0: Data List - Test Step 26 Min.desired Idle
- Engine Management System M 2.8.1 Wiring Harness Routing, Schematic
- F2: Trouble Codes - Trouble Code 57 Idle Air Control Voltage Low
- F2: Trouble Code Table - Trouble Code 55 Replace ECU
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0403 EGR Valve Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 87 Mass Air Flow Sensor Voltage High
- F0: Data List - Test Step 29 Desired Air Idle
- F0: Data List - Test Step 29 Sec.air Pump Rel
- F0: Data List - Test Step 24 Iac Adapt. Slope
- F0: Data List - Test Step 27 Idle Speed Offs.
- F2: Trouble Code Table - Trouble Code 24 Vehicle Speed Sens. Incorrect Signal
- Engine Management System M 2.8.1 Circuit Diagram
- F2: Trouble Codes - Trouble Code 61 Fuel Tank Vent. Valve Voltage Low
- F2: Trouble Code Table - Trouble Code 56 Idle Air Control Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0410 Second. Air Pump Relay Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 88 Mass Air Flow Sensor Voltage Low
- F0: Data List - Test Step 30 Actual Air Idle
- F0: Data List - Test Step 30 EGR Solenoid
- F0: Data List - Test Step 25 Iac Block Learn
- F0: Data List - Test Step 28 Glow Time Relay
- F2: Trouble Code Table - Trouble Code 37 Incorrect Brake Switch Signal
- Engine Management System M 2.8.1 Terminal Assignment, Wiring Harness Plug
- F2: Trouble Codes - Trouble Code 62 Fuel Tank Vent. Valve Voltage High
- F2: Trouble Code Table - Trouble Code 57 Idle Air Control Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0410 Second. Air Pump Relay Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 89 Mass Air Flow Sensor Out of Range
- F0: Data List - Test Step 31 Idle Air Control
- F0: Data List - Test Step 31 EGR Pulse Ratio
- F0: Data List - Test Step 26 O2 Sensor Loop
- F0: Data List - Test Step 29 Diag.glow Time R
- F2: Trouble Code Table - Trouble Code 91 Crc Control Device Voltage Low
- Engine Management System M 2.8.1 Trouble Code Table
- F2: Trouble Codes - Trouble Code 69 Intake Air Temperature Voltage Low
- F2: Trouble Code Table - Trouble Code 59 Immobiliser No or Wrong Coding
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0443 Fuel Tank Vent. Valve Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 91 Crc Control Device Voltage Low
- F0: Data List - Test Step 32 Iac Adapt. Slope
- F0: Data List - Test Step 32 EGR Pos. Fdbk
- F0: Data List - Test Step 27 O2 Sensor
- F0: Data List - Test Step 30 Pre Heat. Ind.
- F2: Trouble Code Table - Trouble Code 92 Crc Control Dev. Open or Voltage High
- Digital Diesel Electronics, Dde 2.1 Survey of Engine Compartment
- F2: Trouble Codes - Trouble Code 71 Intake Air Temperature Voltage High
- F2: Trouble Code Table - Trouble Code 61 Fuel Tank Vent. Valve Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0443 Fuel Tank Vent. Valve Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 92 Crc Control Dev. Open or Voltage High
- F0: Data List - Test Step 33 Iac Integrator
- F0: Data List - Test Step 33 Engine Type
- F0: Data List - Test Step 28 Air/fuel Ratio
- F0: Data List - Test Step 31 Check Light
- Cruise Control for Diesel Engines (Dde 2.1) - Coding Table
- Digital Diesel Electronics, Dde 2.1 Function
- F2: Trouble Codes - Trouble Code 73 Mass Air Flow Sensor Voltage Low
- F2: Trouble Code Table - Trouble Code 62 Fuel Tank Vent. Valve Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0500 No Vehicle Speed Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 95 Output Amplifier Defect
- F0: Data List - Test Step 34 Iac Block Learn
- F0: Data List - Test Step 29 O2 Integrator
- F0: Data List - Test Step 32 Fuel Cutoff Sol
- Terminal Assignment, Wiring Harness Plug, Control Unit Dde 2.1
- Digital Diesel Electronics, Dde 2.1 Block Diagram
- F2: Trouble Codes - Trouble Code 74 Mass Air Flow Sensor Voltage High
- F2: Trouble Code Table - Trouble Code 65 ECU Box Temperature High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0505 Idle Air Control Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 96 EGR Valve Out of Range
- F0: Data List - Test Step 35 O2 Sensor Loop
- F0: Data List - Test Step 35 Transm. Coding
- F0: Data List - Test Step 30 O2 Blm Idle Thr.
- F0: Data List - Test Step 33 EGR Solenoid
- Terminal Assign., Wiring Harness Plug, Control Switch, Diesel Engines (Dde 2.1)
- Digital Diesel Electronics, Dde 2.1 Schematic Diagram
- F2: Trouble Codes - Trouble Code 75 Torque Control Voltage Low
- F2: Trouble Code Table - Trouble Code 69 Intake Air Temperature Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0505 Idle Air Control Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code 97 Wrong Fuelpump Adjustment
- F0: Data List - Test Step 36 O2 Sensor
- F0: Data List - Test Step 36 Engine Sp. Pulse
- F0: Data List - Test Step 31 O2 Blm Part Thr.
- F0: Data List - Test Step 34 Torque Control
- Excerpt from Circuit Diagram Omega-B for Diesel Engines (Dde 2.1)
- Digital Diesel Electronics, Dde 2.1 Injection Pump
- F2: Trouble Codes - Trouble Code 76 Continous Torque Control
- F2: Trouble Code Table - Trouble Code 71 Intake Air Temperature Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0560 Battery Voltage High
- B-03, F0: Data List Test Step T01 Battery Voltage
- F0: Data List - Test Step 37 Air/fuel Ratio
- F0: Data List - Test Step 37 Desired Idle
- F0: Data List - Test Step 32 Injection Pulse
- F0: Data List - Test Step 35 Aps Load Signal
- Digital Diesel Electronics, Dde 2.1 Control Unit
- F2: Trouble Codes - Trouble Code 81 Injector Valve 1 Voltage Low
- F2: Trouble Code Table - Trouble Code 73 Mass Air Flow Sensor Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0560 Battery Voltage Low
- B-03, F0: Data List Test Step T02 ANTI Theft Sig.
- F0: Data List - Test Step 38 CO Adjustment
- F0: Data List - Test Step 38 Engine Speed
- F0: Data List - Test Step 33 Spark Advance
- F0: Data List - Test Step 36 Max. Fuel Quant.
- Digital Diesel Electronics, Dde 2.1 Pedal Position Sensor
- F2: Trouble Codes - Trouble Code 82 Injector Valve 2 Voltage Low
- F2: Trouble Code Table - Trouble Code 74 Mass Air Flow Sensor Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1110 Intake Manifold Valve 1 Voltage High
- B-03, F0: Data List Test Step T03 Immobiliser
- F0: Data List - Test Step 39 O2 Integrator
- F0: Data List - Test Step 39 Desired Air Idle
- F0: Data List - Test Step 34 Knock Rtd. cyl.1
- F0: Data List - Test Step 37 Fuel Quantity
- Digital Diesel Electronics, Dde 2.1 Crankshaft Pulse Pick-Up
- F2: Trouble Codes - Trouble Code 83 Injector Valve 3 Voltage Low
- F2: Trouble Code Table - Trouble Code 75 Torque Control Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1110 Intake Manifold Valve 1 Voltage Low
- B-03, F0: Data List Test Step T04 Immobiliser Sig.
- F0: Data List - Test Step 40 O2 Blm Idle Thr.
- F0: Data List - Test Step 40 Actual Air Idle
- F0: Data List - Test Step 35 Knock Rtd. cyl.2
- F0: Data List - Test Step 38 Max.fuel Q.offs
- Digital Diesel Electronics, Dde 2.1 Start of Injection Sensor
- F2: Trouble Codes - Trouble Code 84 Injector Valve 4 Voltage Low
- F2: Trouble Code Table - Trouble Code 76 Continuous Torque Control
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1229 Power Supply Rel Second. Circuit High
- B-03, F0: Data List Test Step T05 APS Signal
- F0: Data List - Test Step 41 O2 Blm Part Thr.
- F0: Data List - Test Step 41 Idle Air Control
- F0: Data List - Test Step 36 Knock Rtd. cyl.3
- F0: Data List - Test Step 39 Start Fuel Q.off
- Digital Diesel Electronics, Dde 2.1 Coolant Temperature Sensor
- F2: Trouble Codes - Trouble Code 87 A/c Cutoff Relay Voltage Low
- F2: Trouble Code Table - Trouble Code 81 Injector Valve 1 Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1230 Power Supply Rel Second. Circuit Low
- B-03, F0: Data List Test Step T06 IDLE Position Sw
- F0: Data List - Test Step 42 Spark Advance
- F0: Data List - Test Step 42 Iac Adapt. Slope
- F0: Data List - Test Step 37 Knock Rtd. cyl.4
- F0: Data List - Test Step 40 Quantity Adapt.
- Digital Diesel Electronics, Dde 2.1 Charge Air Temperature Sensor
- F2: Trouble Codes - Trouble Code 88 A/c Cutoff Relay Voltage High
- F2: Trouble Code Table - Trouble Code 82 Injector Valve 2 Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1326 Knock Ctrl Max. Spark Limit Cyl. 1
- B-03, F0: Data List Test Step T07 MASS Air Flow S.
- F0: Data List - Test Step 43 Knock Retard
- F0: Data List - Test Step 43 Iac Integrator
- F0: Data List - Test Step 38 Check Light
- Terminal Assignment,wiring Harness Plug, 55-pin,Motronic Engine Management System
- Additional Fault Diagnosis (Diagnosis of Components Without Data List Parameters)
- Digital Diesel Electronics, Dde 2.1 Charge Pressure Sensor
- F2: Trouble Codes - Trouble Code 135 Checklight Voltage Low
- F2: Trouble Code Table - Trouble Code 83 Injector Valve 3 Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1327 Knock Ctrl Max. Spark Limit Cyl. 2
- B-03, F0: Data List Test Step T08 Check Light
- F0: Data List - Test Step 44 Injection Pulse
- F0: Data List - Test Step 44 Iac Block Learn
- F0: Data List - Test Step 39 Diag. Request
- Terminal Assign.,wiring Harn.Plug,55-pin Simtec 56.1 Engine Man. System (X20XEV)
- Additional Fault Diagnosis - No. 01 Fuel Filter Heating
- Digital Diesel Electronics, Dde 2.1 Wiring Harness Routing, Schematic
- F2: Trouble Codes - Trouble Code 136 Replace ECU
- F2: Trouble Code Table - Trouble Code 84 Injector Valve 4 Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1328 Knock Ctrl Max. Spark Limit Cyl. 3
- B-03, F0: Data List Test Step T09 Boost Pressure
- F0: Data List - Test Step 45 Check Light
- F0: Data List - Test Step 45 O2 Sensor Loop 1
- F0: Data List - Test Step 40 Injector Cutoff
- Terminal Assign.,wiring Harn.Plug,55-pin Digital Diesel Electrical, Dde 2.1 (25 Dt)
- Additional Fault Diagnosis - No. 02 Relay for Presupply Pump/presupply Pump
- Digital Diesel Electronics, Dde 2.1 Circuit Diagram
- F2: Trouble Code Table - Trouble Code 87 A/c Cutoff Relay Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1329 Knock Ctrl Max. Spark Limit Cyl. 4
- B-03, F0: Data List Test Step T10 Barometer Sensor
- F0: Data List - Test Step 46 Diag. Request
- F0: Data List - Test Step 46 O2 Sensor Loop 2
- F0: Data List - Test Step 41 Iac Control
- Additional Fault Diagnosis - No. 03 Temp. Switch Relay Box
- Digital Diesel Electronics, Dde 2.1 Terminal Assignment, Wiring Harness Plug
- F2: Trouble Code Table - Trouble Code 88 A/c Cutoff Relay Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1501 Immobiliser No or Wrong Coding
- B-03, F0: Data List Test Step T11 Brake Switch 1
- F0: Data List - Test Step 47 Injector Cutoff
- F0: Data List - Test Step 47 O2 Sensor 1
- Explanation of Tables
- How to Check the Table 1, Diagnostic Plug Xd and Voltage Supply
- Digital Diesel Electronics, Dde 2.1 Trouble Code Table
- F2: Trouble Code Table - Trouble Code 91 O2 Sensor Heating Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1502 Immobiliser No Signal
- B-03, F0: Data List Test Step T12 Brake Switch 2
- How to Check the Aldl Diagnostic Plug, Voltage Supply and Auxiliary Fan for Electronics Box
- F0: Data List - Test Step 48 O2 Sensor 2
- How to Check the Table 1, Diagnostic Plug (Xd or X13) and Voltage Supply
- F2: Trouble Code Table
- F2: Trouble Code Table - Trouble Code 92 Camshaft Sensor Incorrect Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1503 Immobiliser Wrong Signal
- B-03, F0: Data List Test Step T13 PARK/neutral Sw.
- Table 2, Trouble Codes (Trouble Code 13 O2 Sensor Open Circuit)
- F0: Data List - Test Step 49 Air/fuel Ratio 1
- F2: Trouble Code Table - Trouble Code 93 Immobiliser No Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1530 A/c Relay Voltage High
- B-03, F0: Data List Test Step T14 Clutch Switch
- Table 2, Trouble Codes (Trouble Code 14 Coolant Temperature Voltage Low)
- F0: Data List - Test Step 50 Air/fuel Ratio 2
- F2: Trouble Code Table - Trouble Code 94 Immobiliser Wrong Signal
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1530 A/c Relay Voltage Low
- B-03, F0: Data List Test Step T15 Transm. Coding
- Table 2, Trouble Codes (Trouble Code 15 Coolant Temperature Voltage High)
- F0: Data List - Test Step 51 O2 Integrator 1
- F2: Trouble Code Table - Trouble Code 16 Fuel Temperature Voltage Low
- F2: Trouble Code Table - Trouble Code 98 O2 Sensor Heating Voltage Low
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1600 Reprogram or Replace ECU
- B-03, F0: Data List Test Step T16 A/c Informat. Sw
- Crankcase Vent Hose May Chafe at Pressure Regulator Clamp
- Table 2, Trouble Codes (Trouble Code 16 Knock Signal Circuit)
- F0: Data List - Test Step 52 O2 Integrator 2
- F2: Trouble Code Table - Trouble Code 17 Fuel Temperature Voltage High
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1601 ECU Box Temperature High
- B-03, F0: Data List Test Step T17 Coolant Temperature
- Table 2, Trouble Codes (Trouble Code 18 Knock Control Module; Replace ECU)
- F0: Data List - Test Step 53 O2 Blm Idle 1
- Table 2, Trouble Codes (Trouble Code 19 Incorrect RPM Signal)
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1690 Check Light Voltage High
- B-03, F0: Data List Test Step T18 FUEL Temperature
- F0: Data List - Test Step 54 O2 Blm Idle 2
- Table 2, Trouble Codes (Trouble Code 21 Throttle Posit. Sensor Voltage High)
- F2: Trouble Code Table - Trouble Code 21 Aps Signal Voltage High
- F0: Data List - Test Step 10 Vehicle Sp.pulse
- F0: Data List - Test Step 03 Sim. Idle Pos. Sw
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1690 Check Light Voltage Low
- B-03, F0: Data List Test Step T19 FUEL Cutoff Sol
- TC 92/93. Engine Only Starts After Repeated Attempts
- F0: Data List - Test Step 55 O2 Blm Part 1
- Table 2, Trouble Codes (Trouble Code 22 Throttle Posit. Sensor Voltage Low)
- F2: Trouble Code Table - Trouble Code 23 Aps Signal Volt. Not in Idle Range
- F0: Data List - Test Step 04 Sim. Part Pos. Sw
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1740 Torque Control Voltage Low
- B-03, F0: Data List Test Step T20 INJ. Regulation
- F0: Data List - Test Step 56 O2 Blm Part 2
- Table 2, Trouble Codes (Trouble Code 23 Knock Signal Out of Range)
- F0: Data List - Test Step 05 Sim. Full Pos. Sw
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P1740 Continuous Torque Control
- B-03, F0: Data List Test Step T21 FUEL Quant.sens.
- Table 2, Trouble Codes (Trouble Code 25 Injector Valve 1 Voltage High)
- F0: Data List - Test Step 57 Spark Advance
- Table 2, Trouble Codes (Trouble Code 24 No Vehicle Speed Signal)
- F2: Trouble Code Table - Trouble Code 31 No Engine RPM Signal
- B-03, F0: Data List Test Step T22 FUEL Quantity
- Table 2, Trouble Codes (Trouble Code 26 Injector Valve 2 Voltage High)
- F0: Data List - Test Step 58 Knock Retard
- F2: Trouble Code Table - Trouble Code 34 Inj. Timing Out of Range
- B-03, F0: Data List Test Step T02 Blinkcode Req.
- B-03, F0: Data List Test Step T23 DES. Fuel Quant.
- Table 2, Trouble Codes (Trouble Code 27 Injector Valve 3 Voltage High)
- F0: Data List - Test Step 59 Injection Pulse
- B-03, F0: Data List Test Step T24 Actual Inj.start
- Table 2, Trouble Codes (Trouble Code 28 Injector Valve 4 Voltage High)
- F0: Data List - Test Step 60 Check Light
- F2: Trouble Code Table - Trouble Code 39 Anti Theft Injection Lock Active
- B-03, F0: Data List Test Step T25 DES. Inj. Start
- Table 2, Trouble Codes (Trouble Code 31 No Engine RPM Signal)
- F0: Data List - Test Step 61 Diag. Request
- F2: Trouble Code Table - Trouble Code 41 Boost Pressure Voltage Low
- B-03, F0: Data List Test Step T05 TPS Signal
- B-03, F0: Data List Test Step T26 EGR Solenoid
- Various Complaints About Vehicles with Motronic
- Table 2, Trouble Codes (Trouble Code 33 EGR Valve Voltage Low)
- F0: Data List - Test Step 62 Injector Cutoff
- F2: Trouble Code Table - Trouble Code 42 Boost Pressure Voltage High
- F0: Data List - Test Step 11 A/c Informat. Sw
- B-03, F0: Data List Test Step T06 SIM. Idle Pos.sw
- B-03, F0: Data List Test Step T27 Engine Speed
- Table 2, Trouble Codes (Trouble Code 34 EGR Valve Voltage High)
- F2: Trouble Code Table - Trouble Code 43 Invalid Boost Pressure
- B-03, F0: Data List Test Step T07 SIM. Part Pos.sw
- B-03, F0: Data List Test Step T28 Desired Idle
- Table 2, Trouble Codes (Trouble Code 38 O2 Sensor Circuit Voltage Low)
- Table 2, Trouble Codes (Trouble Code 13 O2 Sensor 1 Open Circuit)
- Table 2, Trouble Codes (Trouble Code 37 Check Light Voltage Low)
- F2: Trouble Code Table - Trouble Code 44 Incorrect Boost Pressure
- B-03, F0: Data List Test Step T08 SIM. Full Pos.sw
- B-03, F0: Data List Test Step T29 IDLE Speed Offs.
- List of Vehicle Systems That CAN Be Checked with Tech 2 - Techline
- Table 2, Trouble Codes (Trouble Code 39 O2 Sensor Circuit Voltage High)
- F2: Trouble Code Table - Trouble Code 49 Glow Device General Error
- B-03, F0: Data List Test Step T09 MASS Air Flow S.
- B-03, F0: Data List Test Step T30 DIAG.glow Time R
- Table 2, Trouble Codes (Trouble Code 44 O2 Sensor Lean Exhaust)
- F2: Trouble Code Table - Trouble Code 54 Cutoff Sol. Test Incorr. or Short to GND
- B-03, F0: Data List Test Step T10 FUEL Pump Relay
- B-03, F0: Data List Test Step T31 GLOW Time Relay
- Table 2, Trouble Codes (Trouble Code 45 O2 Sensor Rich Exhaust)
- Table 2, Trouble Codes (Trouble Code 16 Knock Signal Circuit 1)
- Table 2, Trouble Codes (Trouble Code 46 Second. Air Pump Relay Voltage Low)
- B-03, F0: Data List Test Step T11 Coolant Temperature
- B-03, F0: Data List Test Step T32 Torque Control
- Table 2, Trouble Codes (Trouble Code 48 Battery Voltage Low)
- Table 2, Trouble Codes (Trouble Code 17 Knock Signal Circuit 2)
- Table 2, Trouble Codes (Trouble Code 47 Second. Air Pump Relay Voltage High)
- F2: Trouble Code Table - Trouble Code 61 Fuel Quantity Sensor Incorrect Signal
- B-03, F0: Data List Test Step T12 Intake Air Temperature
- B-03, F0: Data List Test Step T33 APS Load Signal
- Table 2, Trouble Codes (Trouble Code 49 Battery Voltage High)
- Rafel 2, Trouble Codes (Trouble Code 48 Battery Voltage Low)
- F2: Trouble Code Table - Trouble Code 64 Fuel Quantity Control Out of Range
- F0: Data List - Test Step 18 Sec. Air Pump Rel
- B-03, F0: Data List Test Step T13 Transm. Coding
- B-03, F0: Data List Test Step T34 A/c Cutoff Req.
- Table 2, Trouble Codes (Trouble Code 52 Check Light Voltage High)
- B-03, F0: Data List Test Step T14 PARK/neutral Sw.
- B-03, F0: Data List Test Step T35 A/c Cutoff Relay
- Table 2, Trouble Codes (Trouble Code 53 Fuel Pump Relay Voltage Low)
- F2: Trouble Code Table - Trouble Code 73 Boost Temperature Sensor Voltage Low
- F0: Data List - Test Step 27 Min.desired Idle
- B-03, F0: Data List Test Step T15 A/c Informat. Sw
- B-03, F0: Data List Test Step T36 CRC Control Dev.
- Table 2, Trouble Codes (Trouble Code 54 Fuel Pump Relay Voltage High)
- F2: Trouble Code Table - Trouble Code 74 Boost Temperature Sensor Voltage High
- B-03, F0: Data List Test Step T16 A/c Compress. Sw
- B-03, F0: Data List Test Step T37 Vehicle Speed
- Table 2, Trouble Codes (Trouble Code 55 Replace ECU)
- F2: Trouble Code Table - Trouble Code 81 Sens. Inj. Start Short or Open Circt.
- B-03, F0: Data List Test Step T17 Camshaft Control
- B-03, F0: Data List Test Step T38 PRE Heating Ind.
- Table 2, Trouble Codes (Trouble Code 56 Idle Air Control Voltage High)
- F2: Trouble Code Table - Trouble Code 82 Sens. Inj. Start Incorrect RPM Signal
- B-03, F0: Data List Test Step T18 IGN./inj. Cutoff
- B-03, F0: Data List Test Step T39 MAX. Fuel Quant.
- Table 2, Trouble Codes (Trouble Code 57 Idle Air Control Voltage Low)
- B-03, F0: Data List Test Step T19 Spark Advance
- B-03, F0: Data List Test Step T40 MAX.fuel Q.offs.
- Engine Management System PCM 32 U - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 61 Fuel Tank Vent. Valve Voltage Low)
- B-03, F0: Data List Test Step T20 Knock Control
- B-03, F0: Data List Test Step T41 Start Fuel Q.off
- Table 2, Trouble Codes (Trouble Code 62 Fuel Tank Vent. Valve Voltage High)
- Table 2, Trouble Codes (Trouble Code 29 Injector Valve 5 Voltage High)
- F2: Trouble Code Table - Trouble Code 95 Output Amplifier Defect
- B-03, F0: Data List Test Step T21 Knock Rtd. cyl.1
- B-03, F0: Data List Test Step T42 Quantity Adapt.
- Edc 15 M Engine Management System Omega-B Engine Compartment Survey
- Control Unit - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 69 Intake Air Temperature Voltage Low)
- Table 2, Trouble Codes (Trouble Code 31 No Engine RPM Output Signal)
- Table 3, Control Unit Coding Table
- B-03, F0: Data List Test Step T22 Knock Rtd. cyl.2
- B-04, F5: Actuator Test Test Step T01 IMMO.sig. Test
- Table 2, Trouble Codes (Trouble Code 71 Intake Air Temperature Voltage High)
- Table 2, Trouble Codes (Trouble Code 32 Injector Valve 6 Voltage High)
- Table 4, Engine Does Not Start
- B-03, F0: Data List Test Step T23 Knock Rtd. cyl.3
- B-04, F5: Actuator Test Test Step T02 FUEL Cutoff S
- Table 2, Trouble Codes (Trouble Code 73 Mass Air Flow Sensor Voltage Low)
- F5: Actuator Test
- B-03, F0: Data List Test Step T24 Knock Rtd. cyl.4
- B-04, F5: Actuator Test Test Step T03 INJ. Regulat.
- Edc 15 M Engine Management System Omega-B Block Diagram
- Table 2, Trouble Codes (Trouble Code 74 Mass Air Flow Sensor Voltage High)
- F5: Actuator Test Fuel Cutoff Sol.
- B-03, F0: Data List Test Step T25 SEC.air Pump Rel
- B-04, F5: Actuator Test Test Step T04 EGR Solenoid
- Ignition Coils - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 75 Torque Control Voltage Hich)
- Table 2, Trouble Codes (Trouble Code 38 O2 Sensor 1 Circuit Voltage Low)
- F5: Actuator Test Inj. Regulat.
- B-03, F0: Data List Test Step T26 EGR Pulse Ratio
- B-04, F5: Actuator Test Test Step T05 GLOW Time Rel.
- Edc 15 M Engine Management System Electronic Components
- Crankshaft Pulse Pick-Up - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 76 Continuous Torque Control)
- Table 2, Trouble Codes (Trouble Code 39 O2 Sensor 1 Circuit Voltage High)
- Table 2, Trouble Codes (Trouble Code 75 Torque Control Voltage Low)
- F5: Actuator Test EGR Solenoid
- B-03, F0: Data List Test Step T27 FUEL Tank Vent.
- B-04, F5: Actuator Test Test Step T06 A/c Cutoff Rel
- Electropneumatic Layout Pressure Converter
- Knock Sensor - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 81 Injector Valve 1 Voltage Low)
- Table 2, Trouble Codes (Trouble Code 44 O2 Sensor 1 Lean Exhaust)
- F5: Actuator Test A/c Cutoff Rel
- B-03, F0: Data List Test Step T28 Check Light
- B-04, F5: Actuator Test Test Step T07 Check Light
- Mass Air Flow Meter - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 82 Injector Valve 2 Voltage Low)
- Table 2, Trouble Codes (Trouble Code 45 O2 Sensor 1 Rich Exhaust)
- F5: Actuator Test Glow Time Relay
- F0: Data List - Test Step 34 Knock Rtd. Cyl. 1
- B-03, F0: Data List Test Step T29 O2 Sensor
- B-04, F5: Actuator Test Test Step T08 PRE Heat. Ind.
- Throttle Valve Module - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 83 Injector Valve 3 Voltage Low)
- Table 2, Trouble Codes (Trouble Code 46 Secondary Air P. Voltage Low)
- F5: Actuator Test Pre Heat. Ind.
- F0: Data List - Test Step 35 Knock Rtd. Cyl. 2
- B-03, F0: Data List Test Step T30 O2 Sensor Loop
- B-05, F6: Additional Functions Test Step T01 IDLE Speed
- Injection System/injectors - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 84 Injector Valve 4 Voltage Low)
- Table 2, Trouble Codes (Trouble Code 47 Secondary Air P. Voltage High)
- F5: Actuator Test Check Light
- F0: Data List - Test Step 36 Knock Rtd. Cyl. 3
- B-03, F0: Data List Test Step T31 AIR/fuel Ratio
- B-05, F6: Additional Functions Test Step T02 MAX.fuel Q.off
- Exhaust System - Omega-B V8
- Table 2, Trouble Codes (Trouble Code 87 A/c Cutoff Relay Voltage Low)
- F6: Adjustment
- F0: Data List - Test Step 37 Knock Rtd. Cyl. 4
- B-03, F0: Data List Test Step T32 O2 Integrator
- B-05, F6: Additional Functions Test Step T03 Start F.quant.
- Illustration of Exhaust System - Omega- B V8
- Table 2, Trouble Codes (Trouble Code 88 A/c Cutoff Relay Voltage High)
- F6: Adjustment Idle Speed
- B-03, F0: Data List Test Step T33 O2 Blm Idle Thr.
- B-06, F7: Programming Test Step T01 Immobiliser
- Table 2, Trouble Codes (Trouble Code 135 Checklight Voltage Low)
- F6: Adjustment Max.fuel Q.off
- B-03, F0: Data List Test Step T34 O2 Blm Part Thr.
- B-06, F7: Programming Test Step T02 VEH. Ident. No.
- Table 2, Trouble Codes (Trouble Code 136 Replace ECU)
- Table 2, Trouble Codes (Trouble Code 91 O2 Sensor Heating Voltage High)
- F6: Adjustment Start F.quant.
- B-03, F0: Data List Test Step T35 Engine Speed
- B-06, F7: Programming Test Step T03 Fuelpump Corr.
- Table 3, System Components
- Table 2, Trouble Codes (Trouble Code 92 Camshaft Sensor Incorrect Signal)
- F6: Adjustment Inj.time V.cod
- F1: Closed Loop Test - No. 01 Coolant Temperature
- F0: Data List - Test Step 41 Controlled Iac
- B-03, F0: Data List Test Step T36 Engine Speed Lim
- B-07, Non ECU Supported System Operation
- Table 4, Notes on "Engine Does Not Start"
- Table 2, Trouble Codes (Trouble Code 98 O2 Sensor Heating Voltage Low)
- F6: Adjustment EGR Rate
- F1: Closed Loop Test - No. 02 O2 Sensor Loop
- F0: Data List - Test Step 42 Immobiliser
- B-03, F0: Data List Test Step T37 Desired Idle
- B-08, Engine Does Not Start
- F5: Actuator Test - No. 01 Select Actuator Ign. Coil 1+4
- Table 8, Trouble-Shooting Chart
- F1: Closed Loop Test - No. 03 O2 Sensor
- F0: Data List - Test Step 43 Immobiliser Sig.
- B-03, F0: Data List Test Step T38 IDLE Air Control
- C-01, No Communication Between Diagnostic Tester and Control Unit
- F5: Actuator Test - No. 02 Select Actuator Ign. Coil 2+3
- Wiring Harness Coding
- Terminal Assignment, Diagnostic Plug Xd
- F5: Actuator Test - No. 01 Ign. Coil 1+4
- F1: Control Circuit Test - Number 08 Coolant Temperature
- B-03, F0: Data List Test Step T39 IAC Integrator
- C-02, Control Unit Hard- and Software
- F5: Actuator Test - No. 03 Select Actuator Check Light
- Table 2, Trouble Codes (Trouble Code 59 Intake Manifold Valve 1 Voltage Low)
- Table 4, Emergency Characteristics, Notes on "Engine Does Not Start"
- Terminal Assignment, Control Unit Wiring Harness Plug
- F5: Actuator Test - No. 02 Ign. Coil 2+3
- F1: Control Circuit Test - Number 26 O2 Sensor Loop
- B-03, F0: Data List Test Step T40 IAC Adapt. Slope
- C-03, Control Unit Temperature Sensor Circuit
- F5: Actuator Test - No. 04 Select Actuator Idle Air Contr
- F5: Actuator Test - No. 01 Select Actuator Ign. Coil cyl1+4
- Terminal Assignment Injection Pump Wiring Harness Plug
- F5: Actuator Test - No. 03 Check Light
- F1: Control Circuit Test - Number 27 O2 Sensor
- B-03, F0: Data List Test Step T41 INT. Manifold V.
- C-04, System Voltage Circuit
- F5: Actuator Test - No. 05 Select Actuator Fuel Tank Vent
- F5: Actuator Test - No. 02 Select Actuator Ign. Coil cyl2+3
- Part Location Omega-B Td MY '94.5
- F5: Actuator Test - No. 04 Idle Air Contr
- F5: Actuator Test - Number 1 Ign. Coil Cyl 1+4
- B-03, F0: Data List Test Step T42 TPS Load Signal
- C-05, Immobiliser Circuit
- F5: Actuator Test - No. 06 Select Actuator A/c Cutoff Rel
- Table 2, Trouble Codes (Trouble Code 63 Intake Manifold Valve 1 Voltage High)
- F5: Actuator Test - No. 03 Select Actuator Fuel Pump Rel.
- Circuit Diagram Omega-B Td MY '94.5
- F5: Actuator Test - No. 05 Fuel Tank Vent
- F5: Actuator Test - Number 2 Ign. Coil Cyl 2+3
- B-03, F0: Data List Test Step T43 Torque Control
- C-06, Engine Coolant Temperature Sensor Circuit
- F5: Actuator Test - No. 07 Select Actuator EGR Puls.ratio
- Time Allowance
- F5: Actuator Test - Number 3 Fuel Pump Rel.
- B-03, F0: Data List Test Step T44 A/c Relay
- C-07, Fuel Temperature Sensor Circuit
- F6: ECU Adjustment - No. 01 Select Adjustmn. Idle Speed
- F5: Actuator Test - No. 07 EGR Puls.ratio
- F5: Actuator Test - Number 4 Idle Air Control
- B-03, F0: Data List Test Step T45 Vehicle Speed
- C-08, Glow Time Relay Circuit
- F6: ECU Adjustment - No. 02 Select Adjustmn. o2 Blm Reset
- F5: Actuator Test - No. 06 Select Actuator A/c Cutoff Relay
- F6: Adjustments - No. 01 Idle Speed
- F5: Actuator Test - Number 5 Fuel Tank Vent
- B-03, F0: Data List Test Step T46 Injection Pulse
- C-09, Fuel Pump Circuit
- F6: ECU Adjustment - No. 03 Select Adjustmn. Iac Blm Reset
- F5: Actuator Test - No. 07 Select Actuator Sec.air P.rel
- F6: Adjustments - No. 02 O2 Blm Reset
- F5: Actuator Test - Number 6 A/c Cutoff Rel
- B-03, F0: Data List Test Step T47 FUEL Consumption
- C-10, Filterheating Circuit
- F6: ECU Adjustment - No. 04 Select Adjustmn. CO Adjustment
- F5: Actuator Test - No. 08 Select Actuator EGR Solenoid
- F6: Adjustments - No. 03 Iac Blm Reset
- F5: Actuator Test - Number 7 Sec. Air P. Rel.
- B-03, F0: Data List Test Step T48 Injector Cutoff
- C-11, Anti Theft Warning System Circuit
- Table 7, F7: Programming
- F6: Adjustments - No. 01 Select Adjustmn. Min. Des. Idle
- F6: Adjustments - No. 04 CO Adjustment
- F5: Actuator Test - Number 8 EGR Solenoid
- B-04, F1: Exhaust Gas Test Test Step T11 Coolant Temperature
- C-12, Pedal Position Sensor Circuit
- F7: Programming - No. 01 Variant-Coding
- F7: Programming - Note
- F5: Actuator Test - Number 9 Immo. Sig. Test
- B-04, F1: Exhaust Gas Test Test Step T29 O2 Sensor
- C-13, Mass Air Flow Circuit
- Engine Speed Oscillation / Engine Stalls at Idle Speed, TC 73
- F7: Programming - No. 02 Select Program. Init. ECU
- F7: Programming - No. 01 Select Program. Init. ECU
- F7: Programming - No. 02 Init. ECU
- F6: Adjustments Min. Des. Idle
- B-04, F1: Exhaust Gas Test Test Step T30 O2 Sensor Loop
- C-14, Boost Pressure Sensor Circuit
- F8: ECU Control - No. 01 Select Control RPM Control
- F8: ECU Control - No. 01 RPM Control
- B-05, F5: Actuator Test Test Step T01 IMMO.sig. Test
- C-15, Clutch or Park/neutral Switch Circuit
- F8: ECU Control - No. 02 Select Control Iac Control
- F8: ECU Control - No. 02 Select Control Controlled Iac
- F8: ECU Control - No. 02 Iac Control
- F7: Programming - Number 1 Init. ECU
- B-05, F5: Actuator Test Test Step T02 FUEL Pump Rel.
- C-16, Brake Light Switch Circuit
- F8: ECU Control - No. 03 Select Control Inj.control
- Table 2, Trouble Codes (Trouble Code 85 Injector Valve 5 Voltage Low)
- F8: ECU Control - No. 03 Inj.control
- F7: Programming - Number 2 Immobiliser
- B-05, F5: Actuator Test Test Step T03 IGN. Coil 1+4
- C-17, Air Conditioning System Information Switch Circuit
- F8: ECU Control - No. 04 Select Control Controlled EGR
- Table 2, Trouble Codes (Trouble Code 86 Injector Valve 6 Voltage Low)
- F1: Closed Loop T - No. 01 Coolant Temperature
- Fuel Pump Relay - Astra-F (1.8 Ltr.), Omega-B (All), Calibra (X20XEV)
- F8: ECU Control - No. 04 Controlled EGR
- F8: ECU Control - Number 1 RPM Control
- B-05, F5: Actuator Test Test Step T04 IGN. Coil 2+3
- C-18, Fuel Cutoff Solenoid Circuit
- Exhaust Emiss. Test F1:CIRCUIT T No.01 Coolant Temperature
- F1: Closed Loop T - No. 02 O2 Sensor Loop
- F8: ECU Control - Number 2 Iac Control
- B-05, F5: Actuator Test Test Step T05 SEC. Air P.rel
- C-19, Fuel Injection Quantity Circuit
- Exhaust Emiss. Test F1:CIRCUIT T No.02 O2 Sensor Loop
- F1: Closed Loop T - No. 03 O2 Sensor
- F8: ECU Control - Number 3 Inj. Control
- B-05, F5: Actuator Test Test Step T06 EGR Puls.ratio
- C-20, Injection Start Circuit
- Exhaust Emiss. Test F1:CIRCUIT T No.03 O2 Sensor
- Table 2, Trouble Codes (Trouble Code 89 O2 Sensor 2 Open Circuit)
- B-05, F5: Actuator Test Test Step T07 FUEL Tank Vent
- C-21, Exhaust Gas Recirculation Valve Circuit
- Table 10, Checking Cross-Linked Electronic Systems
- Table 2, Trouble Codes (Trouble Code 91 O2 Sensor 2 Circuit Voltage High)
- Terminal Asignment of Control Unit Plug (X 20 XEV)
- B-05, F5: Actuator Test Test Step T08 IDLE Air Contr
- C-22, Engine Speed Input Signal Circuit
- Survey, Wiring Harness Plug Connections Omega-B Model Year 94 1/2
- Table 2, Trouble Codes (Trouble Code 93 Hall Sensor Voltage Low)
- B-05, F5: Actuator Test Test Step T09 INT. Manif. V.
- C-23, Torque Control Circuit
- Survey of Control Units, Relays
- Table 2, Trouble Codes (Trouble Code 94 Hall Sensor Voltage High)
- B-05, F5: Actuator Test Test Step T10 A/c Relay
- C-24, Pedal Position Sensor Load Signal Circuit
- Terminal Assignment in 107-pin Wiring Harness Plug X 1
- Table 2, Trouble Codes (Trouble Code 98 O2 Sensor 2 Circuit Voltage Low)
- Circuit Diagram Simtec 56.1 Omega-B (Motor X 20 XEV)
- B-05, F5: Actuator Test Test Step T11 Check Light
- C-25, Air Conditioning System Cutoff Relay Circuit
- Terminal Assignment in 20-pin Wiring Harness Plug X 3
- Table 2, Trouble Codes (Trouble Code 121 O2 Sensor 2 Lean Exhaust)
- Complaints Table
- B-06, F6: Additional Functions Test Step T01 READ ECU ID
- C-26, Air Conditioning System Cutoff Request Circuit
- Terminal Assignment in 6-pin Wiring Harness Plug X 26
- Table 2, Trouble Codes (Trouble Code 122 O2 Sensor 2 Rich Exhaust)
- B-06, F6: Additional Functions Test Step T02 READ VIN
- C-27, Vehicle Speed Sensor Circuit
- Table 2, Trouble Codes (Trouble Code 123 Intake Manifold Valve 1 Blocked)
- B-06, F6: Additional Functions Test Step T03 ADJ.idle Speed
- C-28, Cruise Control Circuit
- Table 2, Trouble Codes (Trouble Code 124 Intake Manifold Valve 2 Blocked)
- Domino Effect
- B-06, F6: Additional Functions Test Step T04 ADJ.idle Drive
- C-29, Engine Telltale Circuit
- Terminal Assignment of Hot Film Mass Air Flow Meter P 44
- Table 2, Trouble Codes (Trouble Code 132 EGR Valve Fdbk Incorrect Signal)
- Cause of Fault: Engine Control Unit Motronic M 2.8.1
- B-07, F7: Programming Test Step T01 Control Module
- C-30, Glow Time Telltale Circuit
- Terminal Assign., Dis Ignition Module L2
- Table 2, Trouble Codes (Trouble Code 133 Intake Manifold Valve 2 Voltage Low)
- Cause of Fault: Transmission Control Unit Ar 25/35
- B-07, F7: Programming Test Step T02 INIT. ECU
- Terminal Assignment
- Table 2, Trouble Codes (Trouble Code 134 Intake Manifold Valve 2 Voltage High)
- B-07, F7: Programming Test Step T03 Immobiliser
- Parts Location
- Excerpt,circuit Diagram (Motronic 1.5.4 (20 Se / X 20 SE) Omega-B MY '94 1/2)
- B-08, F8: ECU Control Test Test Step T01 INJ.control
- Wiring Schematic Diagram
- B-08, F8: ECU Control Test Test Step T02 EGR Control
- Table 2, Trouble Codes (Trouble Code 137 ECU Box Temperature High)
- F2: Trouble Codes - Trouble Code 13 O2 Sensor 1 Open Circuit
- B-08, F8: ECU Control Test Test Step T03 RPM Control
- B-08, F8: ECU Control Test Test Step T04 IAC Control
- B-02, F2: Diagnostic Trouble Code Table Trouble Code P0602 Control Module Programming Error
- F2: Trouble Codes - Trouble Code 16 Knock Signal Circuit 1
- F5: Actuator Test - No. 02 Select Actuator Ign. Coil 2+5
- F2: Trouble Codes - Trouble Code 17 Knock Signal Circuit 2
- F5: Actuator Test - No. 03 Select Actuator Ign. Coil 3+6
- Ignition System
- B-09, Engine Does Not Start
- F5: Actuator Test - No. 04 Select Actuator Check Light
- F5: Actuator Test - No. 05 Select Actuator Idle Air Contr
- F5: Actuator Test - No. 06 Select Actuator Fuel Tank Vent
- C-03, System Voltage Circuit
- F5: Actuator Test - No. 07 Select Actuator A/c Cutoff Rel
- C-04, Power Supply Circuit
- F5: Actuator Test - No. 08 Select Actuator Int. Manif. v1
- C-05, Immobiliser Signal Circuit
- F5: Actuator Test - No. 09 Select Actuator Int. Manif. v2
- C-06, Fuel Pump Relay Circuit
- F5: Actuator Test - No. 10 Select Actuator EGR Puls.ratiopф=
- C-07, Throttle/pedal Position Sensor/switch a Circuit
- F5: Actuator Test - No. 11 Select Actuator Sec. Air P.rel.
- F2: Trouble Codes - Trouble Code 29 Injector Valve 5 Voltage High
- C-08, Mass or Volume Air Flow Circuit
- F2: Trouble Codes - Trouble Code 31 No Engine RPM Output Signal
- C-09, Engine Coolant Temperature Sensor Circuit
- F6: ECU Adjustment - No. 02 Select Adjustmn. o2 Blm Cells
- F2: Trouble Codes - Trouble Code 32 Injector Valve 6 Voltage High
- C-10, Intake Air Temperature Sensor Circuit
- F6: ECU Adjustment - No. 03 Select Adjustmn. Lfr Iac Blm
- C-11, Park/neutral Switch Circuit
- C-12, Air Conditioning System Information Switch Circuit
- F2: Trouble Codes - Trouble Code 38 O2 Sensor 1 Circuit Voltage Low
- C-13, Air Conditioning System Compressor Switch Circuit
- F2: Trouble Codes - Trouble Code 39 O2 Sensor 1 Circuit Voltage High
- C-14, Camshaft Position Sensor Circuit
- F2: Trouble Codes - Trouble Code 44 O2 Sensor 1 Lean Exhaust
- C-15, Engine-Compression
- F2: Trouble Codes - Trouble Code 45 O2 Sensor 1 Rich Exhaust
- C-16, Ignition Coil a Primary/secondary Circuit
- F2: Trouble Codes - Trouble Code 46 Secondary Air P. Voltage Low
- C-17, Ignition Coil B Primary/secondary Circuit
- Exhaust Emissions Test f1:circuit T 01 Coolant Temperature
- F2: Trouble Codes - Trouble Code 47 Secondary Air P. Voltage High
- C-18, Cylinder 1 Injector Circuit
- Exhaust Emissions Test f1:circuit T 02 o2 Sensor Loop 1
- C-19, Cylinder 2 Injector Circuit
- Exhaust Emissions Test f1:circuit T 03 o2 Sensor Loop 2
- C-20, Cylinder 3 Injector Circuit
- Exhaust Emissions Test f1:circuit T 04 o2 Sensor 1
- C-21, Cylinder 4 Injector Circuit
- Exhaust Emissions Test f1:circuit T 05 o2 Sensor 2
- C-22, Knock Sensor 1 Circuit
- C-23, Secondary Air Pump Circuit
- Survey, Wiring Harness Plug Connections Omega-B Model Year '94 1/2
- C-24, Exhaust Gas Recirculation Valve Circuit
- C-25, Evaporative Emission Control System Circuit
- C-26, O2 Sensor Heater Circuit (Bank 1, Sensor 1)
- F2: Trouble Codes - Trouble Code 59 Intake Manifold Valve 1 Voltage Low
- C-27, O2 Sensor Circuit (Bank 1, Sensor 1)
- C-28, Crankshaft Sensor Circuit
- Terminal Assignment in 6-pin Wiring Harness Plug X 30
- C-29, Idle Speed Actuator Circuit
- Terminal Assignment in 7-pin Wiring Harness Plug X 31
- F2: Trouble Codes - Trouble Code 63 Intake Manifold Valve 1 Voltage High
- C-30, Intake Manifold Valve Circuit
- C-31, Throttle Position Sensor Load Signal Circuit
- C-32, Torque Control Circuit
- C-33, Ignition/injection Cutoff Circuit
- Terminal Assignment, Control Unit Plug (X 25 XE / X 30 XE) Omega-B MY '94 1/2
- C-34, Air Conditioning System Cutoff Relay Circuit
- Excerpt,circuit Diagram (Motronic 2.8.1)
- C-35, Vehicle Speed Sensor Circuit
- F2: Trouble Codes - Trouble Code 76 Continuous Torque Control
- C-36, Malfunction Indication Lamp (MIL) Circuit
- C-37, Blinkcode Request Circuit
- C-38, Duration of Injection
- C-39, Fuel Consumption Signal Circuit
- F2: Trouble Codes - Trouble Code 85 Injector Valve 5 Voltage Low
- F2: Trouble Codes - Trouble Code 86 Injector Valve 6 Voltage Low
- Trouble Code Table; Engine Control Units
- F2: Trouble Codes - Trouble Code 89 O2 Sensor 2 Open Circuit
- F2: Trouble Codes - Trouble Code 91 O2 Sensor 2 Circuit Voltage High
- F2: Trouble Codes - Trouble Code 93 Hall Sensor Voltage Low
- F2: Trouble Codes - Trouble Code 94 Hall Sensor Voltage High
- F2: Trouble Codes - Trouble Code 98 O2 Sensor 2 Circuit Voltage Low
- F2: Trouble Codes - Trouble Code 121 O2 Sensor 2 Lean Exhaust
- F2: Trouble Codes - Trouble Code 122 O2 Sensor 2 Rich Exhaust
- F2: Trouble Codes - Trouble Code 123 Intake Manifold Valve 1 Blocked
- F2: Trouble Codes - Trouble Code 124 Intake Manifold Valve 2 Blocked
- F2: Trouble Codes - Trouble Code 132 EGR Valve Fdbk Incorrect Signal
- F2: Trouble Codes - Trouble Code 133 Intake Manifold Valve 2 Voltage Low
- F2: Trouble Codes - Trouble Code 134 Intake Manifold Valve 2 Voltage High
- F2: Trouble Codes - Trouble Code 137 ECU Box Temperature High
- Throttle Valve Module (Electronic Accelerator Pedal) - All Vehicle Types
- Accelerator Pedal Module (Electronic Accelerator Pedal) - All Vehicle Types
- Emergency Operation Modes (Electronic Accelerator Pedal) - All Vehicle Types
- Excessive Coolant Temperature (Up to 125 C in Tech1) for Increased Engine Loads and Speeds Over 4000.
- F0: Data List - Test Step 34 Traction Control
- Immob. Func. for Engine - Introduction
- Engine Telltale Illuminates While Travelling. TC 13 (Oxygen Sensor)
- Immob. Func. for Engine - Diagnosis
- Immob. Func. for Engine - Read Trouble Code
- Immob. Func. for Engine - Check Data List Parameters
- Immob. Func. for Engine - Carry Out Actuator Tests
- Immob. Func. for Engine - Carry Out Control Tests
- Immob. Func. for Engine - Snapshot Mode
- Immob. Func. for Engine - Final System Test
- Immob. Func. for Engine - General Safety Measures and Repair Instructions
- Immobiliser Function for All Electronic Engine Systems
- F1: Closed Loop Test - No. 02 O2 Sensor Loop 1
- Survey of Vehicle (Simtec)
- F1: Closed Loop Test - No. 03 O2 Sensor Loop 2
- Simtec - F2: Trouble Code Table - TC 59 Immobiliser No or Wrong Coding
- F1: Closed Loop Test - No. 04 O2 Sensor 1
- Simtec - F2: Trouble Code Table - TC 93 Immobiliser No Signal
- F1: Closed Loop Test - No. 05 O2 Sensor 2
- Simtec - F2: Trouble Code Table - TC 94 Immobiliser Wrong Signal
- Simtec - F0:Data List - Test Step 01 Immobiliser
- F5: Actuator Test - No. 02 Ign. Coil 2+5
- Simtec - F0:Data List - Test Step 02 Immobiliser Sig.
- F5: Actuator Test - No. 03 Ign. Coil 3+6
- Simtec - F5:Actuator Test - Number 1 Immo. Sig. Test
- F5: Actuator Test - No. 04 Check Light
- Simtec - F7:Programming Immobiliser
- F5: Actuator Test - No. 05 Idle Air Contr
- F5: Actuator Test - No. 06 Fuel Tank Vent
- F5: Actuator Test - No. 07 A/c Cutoff Rel
- F5: Actuator Test - No. 08 Int. Manif. V1
- F5: Actuator Test - No. 09 Int. Manif. V2
- F5: Actuator Test - No. 10 EGR Puls.ratio
- F5: Actuator Test - No. 11 Sec. Air P.rel
- F6: Adjustments - No. 02 O2 Blm Cells
- Survey of Vehicle (Motronic)
- F6: Adjustments - No. 03 Iac Blm
- Motronic - F2:Trouble Code Table - TC143 Immobiliser No or Wrong Coding
- F7: Programming - No. 01 Init. ECU
- Motronic - F2:Trouble Code Table - TC144 Immobiliser No Signal
- Motronic - F2:Trouble Code Table - TC145 Immobiliser Wrong Signal
- Motronic - F0: Data List-Test Step 01 Immobiliser
- Motronic - F0: Data List-Test Step 02 Immobiliser Sig.
- F5:actuator Test - Immo. Sig. Test
- F7: Programming Immobiliser
- Vehicle Systems Model Year 1995
- F2: Trouble Codes - Trouble Code 23 Knock Signal Out of Range
- F2: Trouble Codes - Trouble Code 24 No Vehicle Speed Signal
- F2: Trouble Codes - Trouble Code 37 Check Light Voltage Low
- Fluctuating Idling-Speed & re=1; Fading Brake-Servo
- F2: Trouble Codes - Trouble Code 46 Second. Air Pump Relay Voltage Low
- F2: Trouble Codes - Trouble Code 47 Second. Air Pump Relay Voltage High
- F2: Trouble Codes - Trouble Code 91 O2 Sensor Heating Voltage High
- F2: Trouble Codes - Trouble Code 92 Camshaft Sensor Incorrect Signal
- F2: Trouble Codes - Trouble Code 98 O2 Sensor Heating Voltage Low
- F0: Data List - Test Step 18 Sec.air Pump Rel.
- Engine - Telltale Illuminates, Fault Code P0400
- F1: Closed Loop Test - No. 04 O2 Integrator
- F1: Closed Loop Test - No. 05 O2 Blm Idle Thr.
- F1: Closed Loop Test - No. 06 O2 Blm Part Thr.
- F5: Actuator Test - No. 03 Fuel Pump Rel.
- F5: Actuator Test - No. 04 Idle Air Control
- F0: Actuator Test - No. 05 Fuel Tank Vent
- F5: Actuator Test - No. 06 A/c Cutoff Rel
- F5: Actuator Test - No. 07 Sec. Air P.rel
- F5: Actuator Test - No. 08 EGR Puls.ratio
- F6: Adjustments - No. 01 Min. Des. Idle
- F8: ECU Control - No. 01 Controlled RPM
- F2: Trouble Codes - Trouble Code 16 Fuel Temperature Voltage Low
- F2: Trouble Codes - Trouble Code 17 Fuel Temperature Voltage High
- Engine Stalls - Idle Air Control Dirty
- F2: Trouble Codes - Trouble Code 21 Aps Signal Voltage High
- F2: Trouble Codes - Trouble Code 23 Aps Signal Volt. Not in Idle Range
- F2: Trouble Codes - Trouble Code 24 Vehicle Speed Sens. Incorrect Signal
- F2: Trouble Codes - Trouble Code 34 Inj. Timing Out of Range
- F2: Trouble Codes - Trouble Code 37 Incorrect Brake Switch Signal
- F2: Trouble Codes - Trouble Code 39 Anti Theft Injection Lock Active
- F2: Trouble Codes - Trouble Code 41 Boost Pressure Voltage Low
- F2: Trouble Codes - Trouble Code 42 Boost Pressure Voltage High
- F2: Trouble Codes - Trouble Code 43 Invalid Boost Pressure
- F2: Trouble Codes - Trouble Code 44 Incorrect Boost Pressure
- F2: Trouble Codes - Trouble Code 49 Glow Device General Error
- F2: Trouble Codes - Trouble Code 54 Cutoff Sol. Test Incorr. or Short to GND
- F2: Trouble Codes - Trouble Code 61 Fuel Quantity Sensor Incorrect Signal
- F2: Trouble Codes - Trouble Code 64 Fuel Quantity Control Out of Range
- F2: Trouble Codes - Trouble Code 65 ECU Box Temperature High
- F2: Trouble Codes - Trouble Code 73 Boost Temperature Sensor Voltage Low
- F2: Trouble Codes - Trouble Code 74 Boost Temperature Sensor Voltage High
- F2: Trouble Codes - Trouble Code 81 Sens. Inj. Start Short or Open Circt.
- F2: Trouble Codes - Trouble Code 82 Sens. Inj. Start Incorrect Rpm-Signal
- F2: Trouble Codes - Trouble Code 91 Crc Control Device Voltage Low
- F2: Trouble Codes - Trouble Code 92 Crc Control Dev. Open or Voltage High
- F2: Trouble Codes - Trouble Code 95 Output Amplifier Defect
- F0: Data List - Test Step 13 A/c Informat. Sw.
- F0: Data List - Test Step 19 Idle Position Sw.
- F0: Data List - Test Step 26 Desired Idle
- F0: Data List - Test Step 30 Pre Heating Ind.
- F0: Data List - Test Step 38 Max.fuel Q.offs.
- F5: Actuator Test - No. 01 Fuel Cutoff Sol
- F5: Actuator Test - No. 02 Inj. Regulat.
- F5: Actuator Test - No. 03 EGR Solenoid
- F5: Actuator Test - No. 04 A/c Cutoff Rel
- F5: Actuator Test - No. 05 Glow Time Rel.
- F5: Actuator Test - No. 06 Pre Heat. Ind.
- F5: Actuator Test - No. 07 Check Light
- F6: Adjustments - No. 02 Max.fuel Q.off
- F6: Adjustments - No. 03 Start F.quant.
- F6: Adjustments - No. 04 Inj.time V.cod
- F6: Adjustments - No. 05 EGR Rate
- F2: Trouble Codes - Trouble Code 72 Wrong Fuel Quantity Signal by Dde
- F2: Trouble Codes - Trouble Code 73 Wrong Engine Temperature Signal by Dde
- Illustrations - Engine Compartment Survey Motronic M1.5.4)
- Illustration - Wiring Harness Routing in Engine Compartment (Schematic)
- How to Remove and Install the Dis Ignition Module
- How to Remove and Install the Throttle Valve Potentiometer
- How to Remove and Install Remove and Install the Throttle Body
- How to Remove and Install the Fuel Pressure Regulator
- How to Remove and Install the Injectors
- How to Remove and Install the Hot Film Mass Air Flowmeter
- How to Remove and Install the Crankshaft Pulse Pick-Up
- How to Remove and Install the Knock Sensor
- F0: Data List - Test Step 06 Kickdown Sw. Dde
- How to Remove and Install (X 20 SE) the Oxygen Sensor
- How to Remove and Install the Idle Speed Adjuster
- How to Remove and Install the Injection System Relay
- How to Remove and Install Remove and Install the Fuel Pump Relay
- How to Remove and Install the Intake Air Temperature Sensor
- How to Remove and Install the Coolant Temperature Sensor
- How to Remove and Install the Engine Control Unit
- How to Remove and Install Remove and Install the Tank Vent Valve
- Coolant Temperature Sensor - Wiring Harness Connector Poor Contact
- Ar 25, 35 Transmission / TCM (DTC: P0742 Set Sporadically)
- Idle Air Adjuster - Engine Control Lamp Illumates
- ECU and Immobilizer - Engine Does Not Start Sporadically, P1613 Is Set
- Y25DT Engine - Noise in the Passenger Compartment
- Y25DT Engine - Turbocharger Oily
- Motronic M 2.8.1/M 2.8.3 (X 25 XE, X 30 XE) (Illustrations - Engine Compartment Survey)
- Wiring Harness Routing in Engine Compartment - X 25 XE, X 30 XE (Schematic)
- How to Remove and Install (X 25 XE the Dis Ignition Module (X 30 XE))
- How to Remove and Install (X 25 XE the Throttle Body (X 30 XE))
- How to Remove and Install the Knock Sensor (Cylinders 1-3-5)
- How to Remove and Install (Without AC) the Knock Sensor (Cylinders 2-4-6)
- How to Remove and Install (With Air Conditioning) the Knock Sensor (Cylinders 2-4-6)
- How to Check the Fuel Pressure
- How to Remove and Install the Solenoid Valve - Resonance Pipes Switchover Valve
- How to Remove and Install the Resonance Pipes Switchover Valve
- How to Remove and Install Install the Vacuum Unit - Resonance Pipes Switchover Valve
- How to Remove and Install the Solenoid Valve - Intake Plenum Switchover Valve
- How to Remove and Install the Vacuum Unit - Intake Plenum Switchover Valve
- How to Remove and Install (X 25 XE the Engine Control Unit (X 30 XE))
- Z22XE - Engine Control Indicator Flashes Ocassionally, DTC P0325 (8) Set
- Engine Compartment Survey - Simtec 56.1/56.5 - X 20 XEV Simtec 56.1/56.5 - X 20 XEV
- Wiring Harness Routing in Engine Compartment - Simtec 56.1/56.5 - X 20 XEV (Schematic)
- How to Remove and Install (X 20 XEV) the Dis Ignition Module
- How to Remove and Install (X 20 XEV) the Throttle Valve Potentiometer
- How to Remove and Install (X 20 XEV) the Throttle Body
- How to Remove and Install (X 20 XEV) the Knock Sensor
- Engine Y25DT - Jerking Cuts Out
- Engine Management (25 Dt, X 25 DT)
- How to Remove and Install the Fuel Injection Pump
- How to Remove and Install the Solenoid Valve - Charge Pressure Regulator
- How to Remove and Install the Exhaust Gas Recirculation Solenoid Valve
- Engine Compartment Survey - Simtec 71 - Y 22 XE, Z 22 XE
- How to Remove and Install (Y 22 XE the Ignition Module (Z 22 XE))
- How to Remove and Install (Y 22 XE the Throttle Body (Z 22 XE))
- How to Remove and Install (Y 22 XE the Knock Sensor (Z 22 XE))
- How to Remove and Install (Y 22 XE the Oxygen Sensor (Z 22 XE))
- How to Remove and Install (Y 22 XE) the Accelerator Position Sensor
- Motronic Me 3.1.1 (Y 26 SE, Y 32 SE) (Illustration - Engine Compartment Survey Survey)
- How to Remove and Install (Y 26 SE the Oxygen Sensors for Cylinders 1-3-5 (Y 32 SE))
- How to Remove and Install (Y 26 SE the Oxygen Sensors for Cylinders 2-4-6 (Y 32 SE))
- How to Remove and Install (Y 26 SE the Engine Control Unit (Y 32 SE))
- Engine Compartment Vacuum Routing, Y 25 DT
- Illustration, Air Ducts
- How to Remove and Install the Air Cleaner Housing
- How to Remove and Install the Solenoid Valve - Engine Damping Blocks
- Illustration - Common-Rail
- How to Remove and Install the High Pressure Pump
- How to Remove and Install the Pressure Reservoir
- How to Remove and Install the Pressure Lines - Pressure Reservoir to Injectors
- How to Remove and Install the Pressure Line - High Pressure Pump to Pressure Reservoir
- How to Remove and Install the Oil Leak Line
- How to Remove and Install the Pressure Sensor
- How to Replace the Pressure Regulator
- How to Remove and Install the Camshaft Pulse Pick-Up
- How to Remove and Install the Charge Pressure Sensor
- How to Remove and Install the Charge Pressure Control Solenoid Valve
- How to Remove and Install the Switchover Valves Solenoid Valve
- How to Remove and Install the Switchover Valves Vacuum Unit
- How to Remove and Install the Accelerator Pedal Module
- How to Remove and Install the Vacuum Vessel
- How to Remove and Install the Pre-Heater Relay
- Engine Management (Y 25 DT)
- Check Common-Rail-System
- How to Remove and Install the Engine Oil Level Sensor
- How to Remove and Install (With Air Conditioner) the Crankshaft Pulse Generator
- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Automatic Transmission Rear Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Car Level Control
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Check Control
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Socket Front/ Rear
- Electrical Window Winders
- Electronic Cruise Control
- Electronic Ride Control
- Electronic Traction Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Rear Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Power Steering
- Radiator Grille
- Radio
- Radio Interference Suppression
- Rear Axle and Rear Wheel Suspension
- Rear Axle Rear Wheel Drive
- Rear End
- Rear Wheel Brake
- Removing and Installing Assemblies Remove
- Roof Luggage Carrier (Railing)
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Damper
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Xenon Control Unit (Headlamp Range Control)
- Zf Servotronic Steering