C-12, Pedal Position Sensor Circuit
| C-12, Pedal Position Sensor Circuit |
|---|
| Test | Work Order Description | Nominal Value |
| T01 | Check: Short to Voltage/Ground/Interruption of Voltage Supply | |
| Ignition OFF Disconnect wiring harness connector from: P67 Sensor - Pedal Position Ignition ON Measure voltage between the following terminals: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 2 & Ground | 4.8 ... 5.2 V |
| Yes: T02 | No: T08 |
| T02 | Check: Short to Voltage/Interruption of Signal Circuit | |
| Measure voltage between the following terminals: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 2 & P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 4 | 4.8 ... 5.2 V |
| Yes: T03 | No: E07 |
| T03 | Check: Short to Voltage of Signal Circuit | |
| Diagnostic Tester Data List Parameter APS SIGNAL | less than 0.1 V |
| Yes: T04 | No: E06 |
| T04 | Check: Short to Ground/Interruption of Signal Circuit | |
| Ignition OFF Connect fused jumper wire to: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 2 & P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 1 Ignition ON Diagnostic Tester Data List Parameter APS SIGNAL | greater than 4.8 V |
| Yes: T05 | No: E05 |
| T05 | Check: Short to Ground/Interruption of Signal Circuit | |
| Remove fused jumper wire Measure voltage between the following terminals: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 5 & Ground | greater than 4.8 V |
| Yes: T06 | No: E04 |
| T06 | Check: Short to Voltage of Signal Circuit | |
| Ignition OFF Connect fused jumper wire to: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 5 & Ground Ignition ON Diagnostic Tester Data List Parameter IDLE POSITION SW | INACTIVE 0 V |
| Yes: T07 | No: E03 |
| T07 | Check: Circuit Interruption of Ground Circuit | |
| Ignition OFF Connect fused jumper wire to: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 5 & P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 8 Ignition ON Diagnostic Tester Data List Parameter IDLE POSITION SW | INACTIVE 0 V |
| Yes: E01 | No: E02 |
| T08 | Check: Short to Voltage/Ground/Interruption of Voltage Supply | |
| Ignition OFF Disconnect wiring harness connector from: P67 Sensor - Pedal Position Ignition ON Measure voltage between the following terminals: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 2 & Ground | greater than 5.2 V |
| Yes: E08 | No: E09 |
| C-12, Pedal Position Sensor Circuit |
|---|
| Result | Cause Of Fault |
| E01 | Defective component: P67 Sensor - Pedal Position |
| |
| E02 | Circuit interruption between: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 8 & Ground |
| |
| E03 | Short circuit to voltage between: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 5 & K70 Control Unit - Diesel Wiring Harness Connector (wiring harness side) Terminal 25 or Defective component: K70 Control Unit - Diesel |
| |
| E04 | Short circuit to ground/interruption of circuit between: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 5 & K70 Control Unit - Diesel Wiring Harness Connector (wiring harness side) Terminal 25 or Defective component: K70 Control Unit - Diesel |
| |
| E05 | Short circuit to ground/interruption of circuit between: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 1 & K70 Control Unit - Diesel Wiring Harness Connector (wiring harness side) Terminal 37 or Defective component: K70 Control Unit - Diesel |
| |
| E06 | Short circuit to voltage between: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 1 & K70 Control Unit - Diesel Wiring Harness Connector (wiring harness side) Terminal 37 or Defective component: K70 Control Unit - Diesel |
| |
| E07 | Circuit interruption between: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 4 & K70 Control Unit - Diesel Wiring Harness Connector (wiring harness side) Terminal 13 or Defective component: K70 Control Unit - Diesel |
| |
| E08 | Short circuit to voltage between: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 2 & K70 Control Unit - Diesel Wiring Harness Connector (wiring harness side) Terminal 33 or Defective component: K70 Control Unit - Diesel |
| |
| E09 | Short circuit to ground/interruption of circuit between: P67 Sensor - Pedal Position Wiring Harness Connector (wiring harness side) Terminal 2 & K70 Control Unit - Diesel Wiring Harness Connector (wiring harness side) Terminal 33 or Defective component: K70 Control Unit - Diesel |
| |
