The engine number is stamped on the flat surface (arrow) of the cylinder block beneath the oil filter housing.
When installing an engine short block, the engine number must be stamped on the cylinder block before the engine is installed.
Contents
Wiring diagrams Section: Diesel Engine- Air Mass Meter, 4 Cylinder Diesel
- Battery / Starter, Diesel (Current Measurement)
- Diesel Engine - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Engine Identifier - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Engine Number / Engine Identifier Locations - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Engine-Specific Characteristics - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Torque and Performance Curve - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Compression 4-cylinder, Diesel
- Engine View - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Cylinder Head - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Crankshaft Impulse Sensor, Diesel
- Engine Control Unit ECM Y 20 DTH / Y 22 DTR - Function
- Diesel Glow Plugs (Current Measurement), 4 Cylinder
- Vacuum Pump of Z 19 DT OHC Diesel Engine and Z 19 DTH DOHC Diesel Engine
- Crank Drive, Cylinder Block
- Engine Timing - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Oil Circuit - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Heat Exchanger
- V-Ribbed Belt - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Intake Manifold - Z 19 DT OHC Diesel Engine
- Exhaust Manifold with Turbocharger - Z 19 DT OHC Diesel Engine, Z 19 DTH DOHC Diesel Engine
- Load Pressure Sensor, PSG16, Denso 0100, Dde 4.0, G9T 750, G9U 754,Z13DT, Z19DT(H), Z20LEL
- Pedal Position Double Signal, Diesel (MY2002, MY 2003 and MY2004)
- Exhaust Gas Recirculation Valve, PSG16
- Camshaft Sensor, Z13DT, Z19DT(H)
- Y 20 DTH OHC 16V Diesel Engine - Survey
- View of Engine, Y 20 DTH
- Torque and Output Curve, Y 20 DTH
- Y 22 DTR SOHC 16V Diesel Engine - Survey
- View of Engine, Y 22 DTR
- Torque and Output Curve, Y 22 DTR
- Throttle Valve, Y 22 DTR
- Y 20 DTH SOHC 16V Diesel Engine - Overview
- View of Engine Y 20 DTH
- Torque and Power Curves of the Y 20 DTH
- Y 22 DTR SOHC 16V Diesel Engine - Overview
- View of Engine Y 22 DTR
- Torque and Power Curves of the Y 22 DTR
- Engine Number
- Engine Compartment Vacuum Routing (Y 20 DTH)
- Engine Compartment Vacuum Routing (Y 22 DTR, with Manual Transmission)
- Engine Compartment Vacuum Routing (Y 22 DTR, with Automatic Transmission)
- How to Check (Y 20 DTH the Ribbed V-Belt Tensioner (Y 22 DTR))
- How to Measure (Y 20 DTH the Oil Temperature (Y 22 DTR))
- How to Measure (Y 20 DTH the Engine Oil Pressure (Y 22 DTR))
- How to Check (Y 22 DTR the Timing (With AC, Rhd))
- How to Adjust (Y 22 DTR the Timing (With AC, Rhd))
- Air Duct Illustration (Y 20 DTH, Y 22 DTR)
- How to Replace (Y 22 DTR the Ribbed V-Belt (With AC, Lhd))
- How to Replace (Y 22 DTR the Ribbed V-Belt Tensioner (Assembly) (With AC, Lhd))
- How to Remove and Install (Y 22 DTR the Timing Case Cover (With AC, Rhd))
- How to Replace (Simplex/secondary Chain) (Y 22 DTR the Timing Chain Guide Rail (With AC, Rhd))
- How to Replace the Injection Pump Gear (Simplex), Replace, Simplex Timing Chain
- How to Replace (Y 22 DTR the Simplex Chain Tensioner (Secondary Chain) (With AC, Rhd))
- How to Replace (Y 22 DTR the Duplex Chain Tensioner (Primary Chain) (With AC, Rhd))
- How to Replace (Y 22 DTR the Seal Ring - Crankshaft, Front (Timing Case Seal Ring) (With AC, Rhd))
- How to Remove and Install (Y 22 DTR the Timing Case (With AC, Rhd))
- How to Remove and Install (Y 22 DTR the Cylinder Head Cover (With AC, Lhd))
- How to Replace (Y 22 DTR the Vacuum Pump (With AC, Lhd))
- How to Replace (Y 20 DTH the Gasket - Intake Manifold Upper Part (Y 22 DTR))
- How to Replace (Y 20 DTH the Gasket - Intake Manifold Lower Part (Y 22 DTR))
- How to Replace the Throttle Valve Module
- How to Replace (Y 22 DTR the Valve Bridges (With AC, Rhd))
- How to Replace (Y 22 DTR the All Hydraulic Valve Lifters (With AC, Rhd))
- How to Replace (Y 22 DTR the Gasket - Exhaust Manifold (With AC, Rhd))
- How to Replace (Y 22 DTR the Exhaust Manifold (With AC, Lhd))
- How to Remove and Install (Y 22 DTR the Cylinder Head (With AC, Rhd))
- How to Replace (Y 22 DTR the Flywheel or Drive Disc (With AC, Lhd, Mt))
- How to Replace (Y 22 DTR the Seal Ring - Crankshaft, Rear (With AC, Lhd, Mt))
- Engine Oil with Oil Filter Change (Y 20 DTH, Y 22 DTR)
- How to Remove and Install (Y 22 DTR the Oil Pan (With AC, Lhd))
- How to Remove and Install (Y 22 DTR the Sensor - Dynamic Oil Level Control (With AC, Lhd))
- How to Remove and Install (Y 22 DTR the Oil Pump Pressure Regulating Valve (With AC, Lhd))
- How to Remove and Install (Y 22 DTR the Oil Pump (With AC, Rhd))
- How to Remove and Install (Y 22 DTR) the Oil Pressure Switch
- How to Replace (Y 20 DTH the Pressure Relief Valve in Oil Circuit (Y 22 DTR))
- How to Replace (Y 22 DTR the Intake Pipe for Oil Pump (With AC, Lhd))
- How to Replace (Both Sides) (Y 20 DTH the Engine Damping Blocks (With AC, Rhd, F 23))
- How to Replace (Y 20 DTH the Engine Damping Block - Front (With AC, Lhd))
- How to Replace (Y 20 DTH the Engine Damping Block - Rear (With AC, Lhd))
- How to Replace (Y 20 DTH the Bracket - Engine Damping Block, Rear (With AC, Lhd))
- How to Replace (Y 22 DTR the Engine Damping Block - Right (With AC, Rhd))
- How to Replace (Y 20 DTH the Engine Damping Block - Left (With AC, Rhd, F 23))
- How to Replace (Y 22 DTR the Engine Damping Block - Left (With AC, Rhd, F 35))
- How to Remove and Install (Y 22 DTR the Engine (Manual Transmission with AC, Rhd))
- How to Repair Using Short-Block (Y 22 DTR the Engine (With AC, Rhd))
- Manual Transmission, From/on to Engine Remove and Install(Y 22 DTR, with AC)
- How to Replace (Y 22 DTR the Crankshaft Pulse Pickup (With AC, Lhd))
- How to Replace the Sensor - Oil Temperature
- How to Replace (Y 22 DTR the Solenoid Valve - Intake Plenum Switchover Valve (With AC, Lhd))
- How to Replace (Y 22 DTR the Vacuum Unit - Intake Plenum Switchover Valve (With AC, Lhd))
- How to Replace (Y 22 DTR the Vacuum Reservoir (With AC, Lhd))
- How to Replace (Y 22 DTR the Vacuum Control Valve (With AC, Lhd))
- Replace Sheathed Glow Plugs
- How to Replace (Y 22 DTR the Return Manifold (With AC, Lhd))
- How to Replace (Y 22 DTR the Oil Feed Line to Turbocharger (With AC, Lhd))
- How to Replace (Y 22 DTR the Oil Return Line from Turbocharger (With AC, Lhd))
- How to Replace (Y 20 DTH the Pedal Sensor (Y 22 DTR))
- Special Service Tools (Y 20 DTH, Y 22 DTR)
- Sealants, Lubricants and Locking Compounds (Y 20 DTH, Y 22 DTR)
- Main Data (Y 20 DTH, Y 22 DTR)
- Checking and Adjustment Values (Y 20 DTH, Y 22 DTR)
- Drive Belts (Y 20 DTH, Y 22 DTR)
- Engine Timing (Y 20 DTH, Y 22 DTR)
- Coolant Circuit (Y 20 DTH, Y 22 DTR)
- Oil Circuit (Y 20 DTH, Y 22 DTR)
- Cylinder Head (Y 20 DTH, Y 22 DTR)
- Crank Drive, Cylinder Block (Y 20 DTH, Y 22 DTR)
- Engine Management (Y 20 DTH, Y 22 DTR)
- Throttle Body Unit - Malfunction, DTC P1125 (Of) or P1125 (08) Set
- How to Check for Leaks (Y 20 DTH the Low-Pressure System (Y 22 DTR))
- How to Check and Measure the Cylinder Head and Attaching Parts (Cylinder Head, Overhaul)
- Recommended Torque Values (Y 20 DTH, Y 22 DTR)
- Engine Compartment Survey Y 20 DTH, Y 22 DTR
- How to Check (Y 20 DTH the Compression Pressure (Y 22 DTR))
- How to Remove and Install (Y 22 DTR the Balancer Shaft Unit (F 35, with AC, Lhd))
- How to Replace (Y 20 DTH the One Con-Rod Bearing (Y 22 DTR))
- How to Remove and Install (Y 22 DTR the Oil Dipstick Guide Tube (Af 33, with AC, Lhd))
- How to Remove and Install (Y 22 DTR the Oil Filter Housing (With AC, Lhd))
- How to Replace (Y 22 DTR the Oil Cooler/heat Exchanger (With AC, Lhd))
- How to Remove and Install (Y 22 DTR the Coolant Connection (With AC, Rhd))
- How to Dismantle and Assemble (Y 22 DTR) the Balancer Shaft Unit
- How to Replace (Piston with Con-Rod Dismantled) (Y 20 DTH the One Piston And/or Con-Rod (Y22 DTR))
- How to Replace (Y 20 DTH the Piston Rings (Y 22 DTR))
- How to Remove and Install (Y 22 DTR) the All Pistons with Con-Rods
- How to Remove and Install (Y 22 DTR) the Crankshaft
- Measure Crankshaft (Y 20 DTH, Y 22 DTR)
- How to Replace (Y 20 DTH the Oil Spray Nozzles (Y 22 DTR))
- OHC Diesel Engine Z 19 DT / Z 19 DTL - Engine Number/engine Code
- How to Measure the Oil Temperature
- How to Check the Engine Oil Pressure
- Engine Oil with Oil Filter Change
- Remove and Install Air Cleaner Housing
- Replace Ribbed V-Belt
- Replace Ribbed V-Belt Tensioner
- Replace Ribbed V-Belt Upper Guide Rollers
- Replace Right Engine Bracket
- Replace Toothed Belt Tension Roller
- Replace Toothed Belt Deflector Roller
- Replace Cylinder Head Cover
- How to Replace the Vacuum Pump
- Replace Metal Pipe, Exhaust Gas Recirculation
- Check Engine for Leaks(co Content in Cooling System)
- Replace Front Reaction Member
- Replace Rear Reaction Member
- Replace Engine Damping Block - Both Sides
- Replace Engine Damping Block - Right Side
- Replace Engine Damping Block - Left Side
- Replace Pressure Accumulator for Injection System
- Replace Pressure Line (High Pressure Pump, Pressure Accumulator)
- Replace Injectors
- Replace Pressure Lines (Pressure Accumulator, Injector)
- Replace Oil Leak Line (Oil Leak Hose)
- Replace Oil Pressure Switch
- Replace Crankshaft Pulse Pick-Up
- Replace Hot Film Mass Air Flow Meter
- Replace Pedal Travel Sensor
- How to Top Up and Bleed the Cooling System
- Special Service Tools
- Torque Guide Values
- Specifications
- Engine Management
- Engine Overview, Fuel System High + Low Pressure
- Adjust Timing
- Replace Upper Toothed Belt Cover
- Replace Intake Manifold Gasket
- Replace Intake Manifold
- Replace Exhaust Gas Recirculation Valve
- Replace Exhaust Manifold Gasket
- How to Replace the Exhaust Manifold with Turbocharger
- How to Remove and Install or Replace the Thermostat Housing
- Replace Fan Housing
- Replace Fan Motor
- How to Replace the High Pressure Pump
- Replace Damping Case, Fuel Return
- Replace Turbocharger Oil Supply Line
- Replace Turbocharger Oil Return Line
- Replace Oil Pump Seal Ring
- How to Remove and Install the Oil Pump
- Remove and Install Oil Pan
- Replace Intake Pipe for Oil Pump
- Replace Oil Baffle Plate
- Replace Camshaft Sensor.
- Replace Dynamic Oil Level Check Sensor
- How to Check (Y 20 DTH the Pressure Loss (Y 22 DTR))
- Illustration of Air Ducts
- Check Engine Compression Loss
- How to Check the Compression
- Remove and Install Valve Lifters
- Replace Metal Pipe, Exhaust Gas Recirculation, Centre
- Remove and Install Camshaft
- Replace Camshaft Drive Gear
- Replace Camshaft (Front) Seal Ring
- Remove and Install Flywheel
- Replace Coolant Pipe.
- Remove and Install Oil Filter Housing
- Remove and Install Oil Dipstick Tube
- Replace Charge Air Sensor
- Replace Glow Plug Cores
- Replace Pre-Heating System Control Unit
- How to Replace the One Piston And/or Con-Rod
- Engine Compartment Overview
- Check Valve Lash and Adjust
- How to Replace the Piston Rings
- Replace Con-Rod Bearing
- Check Con-Rod Play (With Plastigage)
- Check Crankshaft Longitudinal Play
- Check Crankshaft Bearing Clearance (Measure Bearing Clearance with Plastigage)
- Check Cylinder Block for Plane Surface
- Repair Upper Radiator Securing Pin
- Repair Lower Radiator Securing Pin
- Remove and Install Oil Spray Nozzles
- Replace Differential Pressure Sensor
- Repair Engine Using Part Engine
- Pressure Loss Test, Charge-Air System
- Checking and Adjustment Values
- Ribbed V-Belt
- Toothed Belt
- Oil Circulation
- Cylinder Head
- Replace Ribbed V-Belt Lower Guide Roller
- ABS
- ABS 430
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS Mk20i
- Air Conditioning
- Airbag
- Anti-Theft Warning System-M
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- CAN Bus
- Car Level Control
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Check Control
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Continuously Variable Transmission (Cvt) Front Drive
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Ehps - Electrical Hydraulic Power Steering
- Electrical Equipment and Instruments
- Electrical Socket Front/ Rear
- Electrical Window Winders
- Electronic Cruise Control
- Electronic Module
- Electronic Ride Control
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bolted)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Manual Transmission Rear Wheel Drive
- Mid (Multi Info Display)
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Power Steering
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Sac Semi Automatic Climate Control
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Xenon Control Unit (Headlamp Range Control)
- Распиновка разъёмов
