Multec- S X 14 XE / X 16 XE (L) F0:DATA LIST
| No. | TECH 1 Display | Conditions for Checking | Nominal Value | Trouble Codes | Terminal |
|---|---|---|---|---|---|
| 07 | COOLANT TEMP. | Engine running at idle speed, operating temperature | 85 to 110 °C/ |
185 to 230 °F
| 2.21 to 1.43 V | 14, 15 | B3; B2 |
|---|---|---|
| Notes on Trouble-shooting: | Nominal Value: | Cause of fault: |
(If nominal value is not attained)
· Ignition OFF
· Disconnect wiring harness plug from:
P30 coolant temperature sensor
X10 plug, engine & injectors
(Corsa- B, Tigra)
· Ignition ON
· Using multimeter, measure voltage:
from: P30 wiring harness plug for coolant temperature sensor Ter. 2
to: ground
| 4.9 to 5.1 V | · Short circuit to voltage |
(with measured value higher than 5.1 V) or short circuit to ground/circuit interruption
(with measured value lower than 4.9 V)
from: K57 wiring harness plug for engine control unit Ter. B3
to: P30 wiring harness plug for coolant temperature sensor Ter. 2
| · K57 engine control unit defective |
· Bridge wiring harness plug
from: P30 wiring harness plug forcoolant temperature sensor Ter. 1
to: P30 wiring harness plug for coolant temperature sensor Ter. 2
· TECH 1 data list no. 07 COOLANT TEMP.
| higher than 145°C/293 °F |
lower than 0.1 V
| · Short circuit to voltage or circuit interruption |
from: P30 wiring harness plug for coolant temperature sensor Ter. 1
to: K57 wiring harness plug for engine control unit Ter. B2
· K57 engine control unit defective
· Using multimeter, measure resistance:
from: P30 coolant temperature sensor Ter. 1
to: P30 coolant temperature sensor Ter. 2
| Temperature Resistance |
[°C] [kW]
0 approx. 5.9
20 approx. 2.5
50 approx. 0.8
100 approx. 0.2
| · P30 coolant temperature sensor defective |
· Check according to data list no. 05, TPS SIGNAL
| Nominal values OK | ||
|---|---|---|
| · Remedy according to data list no. 05, TPS SIGNAL | ||
| · Check according to data list no. 25, EGR POS. FDBK | Nominal values OK | · Remedy according to data list no. 25, EGR POS. FDBK |