System Voltage System Voltage Immobiliser Immobiliser Immobiliser Signal Immobiliser Signal Accelerator Position Sensor Signal Accelerator Position Sensor Signal Idle Switch Idle Position Switch Mass Air Flow Sensor Mass Air Flow Sensor Barometer Sensor Barometer Sensor Brake Switch Brake Switch A/C Information Switch (Air Conditioning) Air Conditioning System Information Switch Coolant Temperature Engine Coolant Temperature Fuel Temperature Fuel Temperature Fuel Cutoff Valve Fuel Cutoff Solenoid Desired Injection Quantity Desired Fuel Quantity Desired Idle Injection Quantity Idle Speed, Desired Fuel-Injection Quantity Injection Quantity Fuel Injection Quantity Maximum Fuel Quantity Accelerator Pedal Sensor, Fuel-Injection Quantity Desired Injection Start Desired Injection Start Actual Injection Start Actual Injection Start EGR Command (Exhaust-Gas Recirculation Command) Exhaust Gas Recirculation Command EGR Pulse Ratio (Exhaust Gas Recirculation) Exhaust Gas Recirculation Valve Pulse Ratio Desired Engine Idle Speed Desired Idle Engine Speed Engine Speed Idle Speed Offset Idle Speed Offset Diagnosis Glow Time Relay Diagnosis Glow Time Glow Time Relay Glow Time Relay A/C Relay (Air Conditioning) Air Conditioning System Relay Vehicle Speed Vehicle Speed Input Telltale (Check Light) Engine Telltale Glow Time Telltale Glow Time Telltale Max. Fuel Quantity Offset (Maximum) Max. Fuel Quantity Offset Start Fuel Quantity Offset Start Fuel Quantity Offset EGR Offset (Exhaust-Gas Recirculation) Exhaust Gas Recirculation Offset
Home/Opel/Frontera/Opel Frontera A (1992-1998)/Repair manual/Fuel Injection Systems/Abbreviations, Definitions
Contents
Section: Fuel Injection Systems- The Checking System
- Introduction (Checking Procedures Motronic M 1.5.4)
- Motronic 1.5.4 Introduction
- Motronic M 1.5 Checking Procedures
- General Instructions/safety Measures
- Motronic 1.5.4 Survey of Systems Table
- Standard Diagnostic Checking Equipment
- Correct Coding of Octane Number Plug (Octane Number Coding), Choice of Fuel
- Checking Equipment
- General Instructions/safety Measures (Checking Procedures Motronic M 1.5.4)
- Motronic 1.5.4 Diagnosis
- Block Diagram
- Abbreviations, Definitions
- Checking Equipment (Checking Procedures Motronic M 1.5.4)
- Motronic 1.5.4 General Safety and Repair Instructions
- Components
- Checking with Tech 1
- Function Circuit Diagram, Motronic M Motronic M 1.5.4 (20SE/X20SE and 22XE/X22XE)
- Motronic 1.5.4 Electronic Engine Systems
- Control Unit, Parts and Catalogue Number (Service) 25 Tds
- F0: Data List - Test Step 01 Battery Voltage
- Survey of Engine Compartment, 20SE and X20SE Engine
- F2:Trouble Code Table - Trouble Code 10 Variant Coding Not Programmed
- Octane Number Plug (Octane No. Coding), Fuel Selection
- F0: Data List - Test Step 02 Vehicle Sp. Pulse
- Survey of Engine Compartment, 22XE and X22XE Engine
- F2:Trouble Code Table - Trouble Code 13 02 Sensor Open Circuit (Motronic 1.5.4)
- System Specific Features
- F0: Data List - Test Step 03 Exhaust Coding
- Block Circuit Diagram, Motronic M 1.5.4
- F2:Trouble Code Table - Trouble Code 14 Coolant Temperature Voltage Low (Motr. 1.5.4)
- A, Diagnostic System Check
- F0: Data List - Test Step 04 Transm. Coding
- System Specific Special Features
- F2:Trouble Code Table - Trouble Code 15 Coolant Temperature Voltage High (Motr. 1.5.4)
- B-01, Diagnostic Trouble Code p0100 Mass Air Flow Sensor Circuit Low Input
- F0: Data List - Test Step 05 Intake Air Temperature
- Diagnostic Switch KM-640
- F2:Trouble Code Table - Trouble Code 16 Knock Signal Circuit
- B-01, Diagnostic Trouble Code p0100 Mass Air Flow Sensor Circuit Range/performance
- F0: Data List - Test Step 06 Coolant Temperature
- F2:Trouble Code Table - Trouble Code 18 Knock Control Module; Replace ECU
- B-01, Diagnostic Trouble Code p0115 Engine-Coolant Temperature Sensor Circuit High Input
- F0: Data List - Test Step 07 Air Flow Sensor
- Displays in Tech 1
- F2:Trouble Code Table - Trouble Code 19 Incorrect RPM Signal
- B-01, Diagnostic Trouble Code p0115 Engine-Coolant Temperature Sensor Circuit Low Input
- F0: Data List - Test Step 08 Idle CO Pot.
- Abbreviations
- F2:Trouble Code Table - Trouble Code 21 Throttle Posit. Sensor Voltage High
- B-01, Diagnostic Trouble Code p0120 Pedal Position Sensor Voltage Supply Circuit High Input
- F0: Data List - Test Step 09 TPS Signal
- F0: Data List - Test Step No.01 Battery Voltage
- F2:Trouble Code Table - Trouble Code 22 Throttle Posit. Sensor Voltage Low
- B-01, Diagnostic Trouble Code p0120 Pedal Position Sensor Voltage Supply Circuit Low Input
- F0: Data List - Test Step 10 Engine Load Sig.
- F0: Data List - Test Step No.02 TPS Signal
- F2:Trouble Code Table - Trouble Code 25 Injector Valve 1 Voltage High
- B-01, Diagnostic Trouble Code p0120 Pedal Position Sensor Circuit High Input
- F0: Data List - Test Step 11 Sim.idle Pos.sw.
- F0: Data List - Test Step No.03 Sim. Idle Pos.sw
- F2:Trouble Code Table - Trouble Code 26 Injector Valve 2 Voltage High
- B-01, Diagnostic Trouble Code p0120 Pedal Position Sensor Potentiometer Error
- F0: Data List - Test Step 12 Sim.full Pos.sw.
- F0: Data List - Test Step No.04 Sim. Full Pos.sw
- F2:Trouble Code Table - Trouble Code 27 Injector Valve 3 Voltage High
- B-01, Diagnostic Trouble Code p0120 Pedal Position Sensor Brake Switch Error
- F0: Data List - Test Step 13 Injection Pulse
- F0: Data List - Test Step No.05 Intake Air Temperature
- F2:Trouble Code Table - Trouble Code 28 Injector Valve 4 Voltage High
- B-01, Diagnostic Trouble Code p0120 Pedal Position Sensor General Error
- F0: Data List - Test Step 14 Engine Speed
- F0: Data List - Test Step No.06 Coolant Temperature
- F2:Trouble Code Table - Trouble Code 31 No Engine RPM Signal
- B-01, Diagnostic Trouble Code p0400 Exhaust Gas Recirculation Circuit High Input
- F0: Data List - Test Step 15 Spark Advance
- F0: Data List - Test Step No.07 Mass Air Flow S.
- F2:Trouble Code Table - Trouble Code 33 EGR Valve Voltage Low
- B-01, Diagnostic Trouble Code p0400 Exhaust Gas Recirculation Circuit Open
- F0: Data List - Test Step 16 Torque Control
- F0: Data List - Test Step No.08 Knock Signal
- F2:Trouble Code Table - Trouble Code 34 EGR Valve Voltage High
- B-01, Diagnostic Trouble Code p0400 Exhaust Gas Recirculation Flow Excessive Detected
- F0: Data List - Test Step 17 Iac Pulse Ratio
- F0: Data List - Test Step No.09 Vehicle Speed
- F2:Trouble Code Table - Trouble Code 38 02 Sensor Circuit Voltage Low
- B-01, Diagnostic Trouble Code p0400 Exhaust Gas Recirculation Flow Insufficient Detected
- F0: Data List - Test Step 18 Iac Integrator
- F0: Data List - Test Step No.10 Vehicle Sp.pulse
- F2:Trouble Code Table - Trouble Code 39 02 Sensor Circuit Voltage High
- B-01, Diagnostic Trouble Code p0500 Vehicle Speed Sensor Circuit High Input
- F0: Data List - Test Step 19 Park/neutral Sw.
- F0: Data List - Test Step No.11 A/c Thermost. Sw
- F2:Trouble Code Table - Trouble Code 44 02 Sensor Lean Exhaust
- B-01, Diagnostic Trouble Code p0500 Vehicle Speed Sensor Circuit Incorrect Signal
- F0: Data List - Test Step 20 Iac Block Learn
- F0: Data List - Test Step No.12 Coolant Temperaturesw.
- F2:Trouble Code Table - Trouble Code 45 02 Sensor Rich Exhaust
- B-01, Diagnostic Trouble Code p0560 System Voltage Low Input
- F0: Data List - Test Step 21 A/c Informat. Sw
- F0: Data List - Test Step No.13 Park/neutral Sw.
- F2:Trouble Code Table - Trouble Code 46 Secondary Air P. Voltage Low
- B-01, Diagnostic Trouble Code p0606 Replace Control Unit
- F0: Data List - Test Step 22 A/c Compress. Sw
- F0: Data List - Test Step No.14 Torque Control
- F2:Trouble Code Table - Trouble Code 47 Secondary Air P. Voltage High
- F0: Data List - Test Step 23 Eng. Oil Temperaturesw
- F0: Data List - Test Step No.15 Ign. Coil 1+4
- F2:Trouble Code Table - Trouble Code 48 Battery Voltage Low (Motronic 1.5.4)
- F0: Data List - Test Step 24 Tran.oil Temperaturesw
- F0: Data List - Test Step No.16 Ign. Coil 2+3
- F2:Trouble Code Table - Trouble Code 49 Battery Voltage High (Motronic 1.5.4)
- F0: Data List - Test Step 25 Ron Coding
- F0: Data List - Test Step No.17 Sec.air Pump Rel
- F2:Trouble Code Table - Trouble Code 52 Check Light Voltage High
- F0: Data List - Test Step 26 Fuel Pump Relay
- F0: Data List - Test Step No.18 TC TPS Load Sig
- F2:Trouble Code Table - Trouble Code 53 Fuel Pump Relay Voltage Low
- F0: Data List - Test Step 27 A/c Cutoff Relay
- F0: Data List - Test Step No.19 Fuel Pump Relay
- F2:Trouble Code Table - Trouble Code 54 Fuel Pump Relay Voltage High
- B-01, Diagnostic Trouble Code p0725 Engine-Speed Sensor Input Circuit Incorrect Signal
- F0: Data List - Test Steps 28 and 29 O2 Sensor Loop/ o2 Sensor
- F0: Data List - Test Step No.20 A/c Relay
- F2:Trouble Code Table - Trouble Code 55 Replace ECU (Motronic 1.5.4)
- B-01, Diagnostic Trouble Code p0725 Engine-Speed Sensor Input Circuit No Signal
- F0: Data List - Test Step 30 O2 Integrator
- F0: Data List - Test Step No.21 EGR Solenoid
- F2:Trouble Code Table - Trouble Code 56 Idle Air Control Voltage High
- B-01, Diagnostic Trouble Code p0725 Engine-Speed Sensor Input Circuit Signal Range/performance(overspeed)
- F0: Data List - Test Step 31 O2 Blm Idle Thr.
- F0: Data List - Test Step No.22 EGR Pulse Ratio
- F2:Trouble Code Table - Trouble Code 57 Idle Air Control Voltage Low
- B-01, Diagnostic Trouble Code p1105 Barometric Pressure Sensor Circuit Low Input
- F0: Data List - Test Step 32 O2 Blm Part Thr.
- F0: Data List - Test Step No.23 Engine Type
- F2:Trouble Code Table - Trouble Code 61 Fuel Tank Vent. Valve Voltage Low
- B-01, Diagnostic Trouble Code p1180 Fuel Temperature Sensor Circuit High Input
- F0: Data List - Test Step 33 Fuel Tank Vent.
- F0: Data List - Test Step No.24 Transm. Coding
- F2:Trouble Code Table - Trouble Code 62 Fuel Tank Vent. Valve Voltage High
- B-01, Diagnostic Trouble Code p1180 Fuel Temperature Sensor Circuit Low Input
- F0: Data List - Test Step No.25 Fuel Tank Vent.
- F2:Trouble Code Table - Trouble Code 69 Intake Air Temperature Voltage Low
- B-01, Diagnostic Trouble Code p1201 Injection Start Sensor Circuit High Input
- F0: Data List - Test Step No.26 Engine Sp. Pulse
- F2:Trouble Code Table - Trouble Code 71 Intake Air Temperature Voltage High
- B-01, Diagnostic Trouble Code p1201 Injection Start Sensor Circuit Low Input
- Explanation of Tables
- F0: Data List - Test Step No.27 Min.desired Idle
- F2:Trouble Code Table - Trouble Code 73 Mass Air Flow Sensor Voltage Low
- B-01, Diagnostic Trouble Code p1220 Fuel Injection Quantity Control Excessive Detected (Cold)
- How to Check the Table 1 - Diagnostic Plug Aldl and Voltage Supply
- F0: Data List - Test Step No.28 Engine Speed
- F2:Trouble Code Table - Trouble Code 74 Mass Air Flow Sensor Voltage High
- B-01, Diagnostic Trouble Code p1220 Fuel Injection Quantity Control Insufficient Detected (Cold)
- Table 2 - Trouble Code Table: Trouble Code 13
- F0: Data List - Test Step No.29 Desired Air Idle
- F2:Trouble Code Table - Trouble Code 75 Torque Control Voltage Low
- B-01, Diagnostic Trouble Code p1220 Fuel Injection Quantity Control Excessive Detected (Warm)
- Table 2 - Trouble Code Table: Trouble Code 14
- F0: Data List - Test Step No.30 Actual Air Idle
- F2:Trouble Code Table - Trouble Code 76 Continuous Torque Control
- B-01, Diagnostic Trouble Code p1220 Fuel Injection Quantity Control Insufficient Detected (Warm)
- Table 2 - Trouble Code Table: Trouble Code 15
- F0: Data List - Test Step No.31 Idle Air Control
- F2:Trouble Code Table - Trouble Code 81 Injector Valve 1 Voltage Low
- B-01, Diagnostic Trouble Code p1225 Fuel Injection Quantity Control Circuit High Input
- Table 2 - Trouble Code Table: Trouble Codes 16 and 17
- F0: Data List - Test Step No.32 Iac Adapt. Slope
- F2:Trouble Code Table - Trouble Code 82 Injector Valve 2 Voltage Low
- B-01, Diagnostic Trouble Code p1225 Fuel Injection Quantity Control Circuit Low Input
- Table 2 - Trouble Code Table: Trouble Code 18
- F0: Data List - Test Step No.33 Iac Integrator
- F2:Trouble Code Table - Trouble Code 83 Injector Valve 3 Voltage Low
- B-01, Diagnostic Trouble Code p1225 Fuel Injection Quantity Control Circuit Incorrect Signal
- Knock Sound in Cold Engine at Approximately 1200-1500 RPM (Like Valve Rattling)
- Table 2 - Trouble Code Table: Trouble Code 19
- F0: Data List - Test Step No.34 Iac Block Learn
- F2:Trouble Code Table - Trouble Code 84 Injector Valve 4 Voltage Low
- B-01, Diagnostic Trouble Code p1225 Fuel Injection Quantity Control Flow Detected
- Table 2 - Trouble Code Table: Trouble Code 21
- F0: Data List - Test Step No.35 O2 Sensor Loop
- F2:Trouble Code Table - Trouble Code 87 A/c Relay Voltage Low
- B-01, Diagnostic Trouble Code p1230 Injection Start Control Excessive Pressure Detected
- Table 2 - Trouble Code Table: Trouble Code 22
- F0: Data List - Test Step No.36 O2 Sensor
- F2:Trouble Code Table - Trouble Code 88 A/c Relay Voltage High
- B-01, Diagnostic Trouble Code p1530 A/c Compressor Cutoff Relay Primary Circuit High Input
- Table 2 - Trouble Code Table: Trouble Code 23
- F0: Data List - Test Step No.37 Air/fuel Ratio
- F2:Trouble Code Table - Trouble Code 135 Checklight Voltage Low
- B-01, Diagnostic Trouble Code p1530 A/c Compressor Cutoff Relay Primary Circuit Open
- Table 2 - Trouble Code Table: Trouble Code 25
- F0: Data List - Test Step No.38 CO Adjustment
- F2:Trouble Code Table - Trouble Code 136 Unknown Output Driver Error
- B-01, Diagnostic Trouble Code p1560 System Voltage High Input
- Table 2 - Trouble Code Table: Trouble Code 31
- F0: Data List - Test Step No.39 O2 Integrator
- F2:Trouble Code Table - Trouble Code 137 ECU Box Temperature High
- B-01, Diagnostic Trouble Code p1560 System Voltage Low Input
- Table 2 - Trouble Code Table: Trouble Code 38
- F0: Data List - Test Step No.40 O2 Blm Idle Thr.
- F2:Trouble Code Table - Trouble Code 143 Immobiliser No or Wrong Coding
- B-01, Diagnostic Trouble Code p1571 Immobiliser Not or Wrong Initialised
- Table 2 - Trouble Code Table: Trouble Code 39 or 45
- F0: Data List - Test Step No.41 O2 Blm Part Thr.
- F2:Trouble Code Table - Trouble Code 144 Immobiliser No Signal
- B-01, Diagnostic Trouble Code p1572 Immobiliser No Frequency Code Received
- Table 2 - Trouble Code Table: Trouble Code 48
- F0: Data List - Test Step No.42 Spark Advance
- F2:Trouble Code Table - Trouble Code 145 Immobiliser Wrong Signal
- B-01, Diagnostic Trouble Code p1573 Immobiliser Wrong Frequency Code Received
- Table 2 - Trouble Code Table: Trouble Code 49
- F0: Data List - Test Step No.43 Knock Retard
- F0:Data List - Test Step 01 Battery Voltage (Motronic 1.5.4)
- B-01, Diagnostic Trouble Code p1604 Variant Coding Wrong Code Programmed
- Table 2 - Trouble Code Table: Trouble Code 52
- F0: Data List - Test Step No.44 Injection Pulse
- F0:Data List - Test Step 02 TPS Signal
- B-01, Diagnostic Trouble Code p1604 Variant Coding Not Programmed
- Table 2 - Trouble Code Table: Trouble Code 53
- F0: Data List - Test Step No.45 Engine Load Sig.
- F0:Data List - Test Step 03 Sim. Idle Pos.sw
- B-01, Diagnostic Trouble Code p1604 Replace Control Unit
- Table 2 - Trouble Code Table: Trouble Code 54
- F0: Data List - Test Step No.46 Check Light
- F0:Data List - Test Step 04 Sim. Full Pos.sw
- Table 2 - Trouble Code Table: Trouble Code 55
- F0: Data List - Test Step No.47 Diag. Request
- F0:Data List - Test Step 05 Intake Air Temperature
- B-01, Diagnostic Trouble Code p1620 Replace Control Unit
- Table 2 - Trouble Code Table: Trouble Code 56
- F0: Data List - Test Step No.48 Injector Cutoff
- F0:Data List - Test Step 06 Coolant Temperature
- Table 2 - Trouble Code Table: Trouble Code 57
- F0: Data List - Test Step No.49 Immobiliser
- F0:Data List - Test Step 07 Mass Air Flow S.
- B-01, Diagnostic Trouble Code p1625 Power Supply Relay Switched off Too Early
- Table 2 - Trouble Code Table: Trouble Code 61
- F0: Data List - Test Step No.50 Immobiliser Sig.
- F0:Data List - Test Step 08 Knock Signal
- B-01, Diagnostic Trouble Code p1625 Power Supply Relay Switched off Too Late
- Table 2 - Trouble Code Table: Trouble Code 62
- How to Check the Table 1, Aldl Diagnostic Plug X13 AND Supply Voltage K61
- F0:Data List - Test Step 09 Vehicle Speed
- B-01, Diagnostic Trouble Code p1630 Injection Start Control Circuit High Input
- Table 2 - Trouble Code Table: Trouble Code 63
- Table 2, Trouble Codes General Information
- Fuel Injection Pump
- F0:Data List - Test Step 10 Vehicle Sp. Pulse
- B-01, Diagnostic Trouble Code p1630 Injection Start Control Circuit Open
- Table 2 - Trouble Code Table: Trouble Code 65
- Table 2, Trouble Codes-Trouble Code No.10 Variant Coding
- Illustration - Air Cleaner and Intake System (X22XE)
- Fuel Injectors
- F0:Data List - Test Step 11 A/c Thermostat. Sw
- B-01, Diagnostic Trouble Code p1635 Glow Device Circuit High Input
- Table 2 - Trouble Code Table: Trouble Code 66
- Table 2, Trouble Codes-Trouble Code No.13 O2 Sensor Loop Open
- Intake Air Resonator (X22XE)
- F0:Data List - Test Step 12 Coolant Temperaturesw.
- B-01, Diagnostic Trouble Code p1635 Glow Device Circuit Open
- Table 2 - Trouble Code Table: Trouble Code 69
- Table 2, Trouble Codes-Trouble Code No.14 Coolant Temperature Voltage Low
- F0:Data List - Test Step 13 Park/neutral Sw.
- B-01, Diagnostic Trouble Code p1635 Glow Device Circuit General Error
- Table 2 - Trouble Code Table: Trouble Code 71
- Table 2, Trouble Codes-Trouble Code No.15 Coolant Temperature Voltage High
- Electronic Diesel Control System
- F0:Data List - Test Step 14 Torque Control
- B-01, Diagnostic Trouble Code p1650 Malfunction Indication Lamp (MIL) Circuit High Input
- Table 2 - Trouble Code Table: Trouble Code 73
- Table 2, Trouble Codes-Trouble Code No.16 Knock Signal Circuit
- Location of Components (Engine - Engine Attaching Parts)
- F0:Data List - Test Step 15 Ign. Coil CYL1+4
- B-01, Diagnostic Trouble Code p1650 Malfunction Indication Lamp (MIL) Circuit Open
- Table 2 - Trouble Code Table: Trouble Code 74
- Table 2, Trouble Codes-Trouble Code No.18 Knock Control Module; Replace ECU
- Ignition System (X22XE)
- Function
- F0:Data List - Test Step 16 Ign. Coil CYL2+3
- B-01, Diagnostic Trouble Code p1660 Fuel Cutoff Solenoid Valve Circuit High Input
- Table 2 - Trouble Code Table: Trouble Code 75
- Table 2, Trouble Codes-Trouble Code No.19 Incorrect RPM Signal
- Block Diagram (Engine - Engine Attaching Parts)
- F0:Data List - Test Step 17 Sec.air Pump Rel
- B-01, Diagnostic Trouble Code p1660 Fuel Cutoff Solenoid Valve Circuit Malfunction
- Table 2 - Trouble Code Table: Trouble Code 81
- Table 2, Trouble Codes-Trouble Code No.21 Throttle Posit.sensor Voltage High
- Injection Pump
- F0:Data List - Test Step 18 TPS Load Signal
- B-01, Diagnostic Trouble Code p1725 Injection Start Sensor Circuit Incorrect Signal
- Table 2 - Trouble Code Table: Trouble Code 87
- Table 2, Trouble Codes-Trouble Code No.22 Throttle Posit. Sensor Voltage Low
- Edc Control Unit
- F0:Data List - Test Step 19 Fuel Pump Relay
- B-01, Diagnostic Trouble Code p1725 Injection Start Sensor Circuit Range/performance
- Table 2 - Trouble Code Table: Trouble Code 88
- Table 2, Trouble Codes-Trouble Code No.25 Injector Valve 1 Voltage High
- Pedal Position Sensor
- F0:Data List - Test Step 20 A/c Relay
- B-01, Diagnostic Trouble Code p1845 Cooling Fan Relay High Input
- Table 2 - Trouble Code Table: Trouble Code 93
- Table 2, Trouble Codes-Trouble Code No.26 Injector Valve 2 Voltage High
- Illustration - Air Cleaner and Intake System (4JB1T)
- F0:Data List - Test Step 21 EGR Solenoid
- B-01, Diagnostic Trouble Code p1845 Cooling Fan Relay Circuit Malfunction
- Table 2 - Trouble Code Table: Trouble Code 94
- Table 2, Trouble Codes-Trouble Code No.27 Injector Valve 3 Voltage High
- Start of Injection Sensor
- F0:Data List - Test Step 22 EGR Pulse Ratio
- B-02, Data List Test Step T01 System Voltage
- Table 3 - Coding Tables
- Table 2, Trouble Codes-Trouble Code No.28 Injector Valve 4 Voltage High
- Coolant Temperature Sensor
- F0:Data List - Test Step 23 Engine Type
- B-02, Data List Test Step T02 Immobiliser
- Table 4 - Engine Does Not Start
- Table 2, Trouble Codes-Trouble Code No.31 No Engine RPM Signal
- Air Mass Sensor
- F0:Data List - Test Step 24 Transm. Coding
- B-02, Data List Test Step T03 Immobiliser Signal
- Table 5 - Test Step 01 Iac Position
- Table 2, Trouble Codes-Trouble Code No.33 EGR Valve Voltage Low
- Wiring Harness, Engine
- F0:Data List - Test Step 25 Fuel Tank Vent.
- B-02, Data List Test Step T04 Accelerator Position Sensor Signal
- Table 5 - Test Step 02 Fuel Injectors
- Table 2, Trouble Codes-Trouble Code No.34 EGR Valve Voltage High
- Circuit Diagram (Engine - Engine Attaching Parts)
- F0:Data List - Test Step 26 Engine Sp. Pulse
- B-02, Data List Test Step T05 IDLE Switch
- Table 5 - Test Step 03 Fuel Tank Vent.
- Table 2, Trouble Codes-Trouble Code No.38 O2 Sensor Circuit Voltage Low
- Terminal Assignment of Wiring Harness Plug
- F0:Data List - Test Step 27 Desired Idle
- B-02, Data List Test Step T06 MASS Air Flow Sensor
- Trouble Code Readout with Diagnostic Switch KM-640
- Table 2, Trouble Codes-Trouble Code No.39 O2 Sensor Circuit Voltage High
- F0:Data List - Test Step 28 Engine Speed
- B-02, Data List Test Step T07 Barometer Sensor
- Terminal Assignment of Control Unit Plug
- Table 2, Trouble Codes-Trouble Code No.44 O2 Sensor Lean Exhaust
- F0:Data List - Test Step 29 Desired Air Idle
- B-02, Data List Test Step T08 Brake Switch
- Table 2, Trouble Codes-Trouble Code No.45 O2 Sensor Rich Exhaust
- F0:Data List - Test Step 30 Actual Air Idle
- B-02, Data List Test Step T09 A/c Information Switch (Air Conditioning)
- Table 2, Trouble Codes-Trouble Code No.46 Secondary Air P. Voltage Low
- Engine Management System Motronic M1.5.4 Function (X20SE, X22XE)
- F0:Data List - Test Step 31 Idle Air Control
- B-02, Data List Test Step T10 Coolant Temperature
- Table 2, Trouble Codes-Trouble Code No.47 Secondary Air P. Voltage High
- Illustrations - Location of Components, X20SE Engine (Motronic M 1.5.4)
- F0:Data List - Test Step 32 Iac Adapt. Slope
- B-02, Data List Test Step T11 FUEL Temperature
- Table 2, Trouble Codes-Trouble Code No.48 Battery Voltage Low
- Illustrations - Location of Components, X22XE Engine (Motronic M 1.5.4)
- F0:Data List - Test Step 33 Iac Integrator
- B-02, Data List Test Step T12 FUEL Cutoff Valve
- Table 2, Trouble Codes-Trouble Code No.49 Battery Voltage High
- Illustration - Schematic Diagram (Motronic M 1.5.4)
- F0:Data List - Test Step 34 Iac Block Learn
- B-02, Data List Test Step T13 Desired Injection Quantity
- Table 2, Trouble Codes-Trouble Code No.52 Check Light Voltage High
- Illustration - Block Diagram (Motronic M 1.5.4)
- F0:Data List - Test Step 35 02 Sensor Loop
- B-02, Data List Test Step T14 Desired Idle Injection Quantity
- Table 2, Trouble Codes-Trouble Code No.53 Fuel Pump Relay Voltage Low
- Description of Components (Motronic M 1.5.4)
- F0:Data List - Test Step 36 02 Sensor
- B-02, Data List Test Step T15 Injection Quantity
- Table 2, Trouble Codes-Trouble Code No.54 Fuel Pump Relay Voltage High
- Control Unit (Motronic M 1.5 4)
- F0:Data List - Test Step 37 Air/fuel Ratio
- B-02, Data List Test Step T16 Maximum Fuel Quantity
- Table 2, Trouble Codes-Trouble Code No.55 Replace ECU
- Direct Ignition System (Motronic M 1.5.4)
- F0:Data List - Test Step 38 CO Adjustment
- B-02, Data List Test Step T17 Desired Injection Start
- Table 2, Trouble Codes-Trouble Code No.56 Idle Air Control Voltage High
- Knock Control (Motronic M 1.5.4)
- F0:Data List - Test Step 39 02 Integrator
- B-02, Data List Test Step T18 Actual Injection Start
- Table 2, Trouble Codes-Trouble Code No.57 Idle Air Control Voltage Low
- Fuel Pump/injection System Relay
- F0:Data List - Test Step 40 02 Blm Idle Thr.
- B-02, Data List Test Step T19 EGR Command (Exhaust-Gas Recirculation Command)
- Table 2, Trouble Codes-Trouble Code No.61 Fuel Tank Vent. Valve Voltage Low
- Idle Speed Adjuster
- F0:Data List - Test Step 41 02 Blm Part Thr.
- B-02, Data List Test Step T20 EGR Pulse Ratio (Exhaust Gas Recirculation)
- Table 2, Trouble Codes-Trouble Code No.62 Fuel Tank Vent. Valve Voltage High
- F0:Data List - Test Step 42 Spark Advance
- B-02, Data List Test Step T21 Desired Engine Idle Speed
- Table 2, Trouble Codes-Trouble Code No.69 Intake Air Temperature Voltage Low
- F0:Data List - Test Step 43 Knock Retard
- B-02, Data List Test Step T22 Engine Speed
- Table 2, Trouble Codes-Trouble Code No.71 Intake Air Temperature Voltage High
- F0:Data List - Test Step 44 Injection Pulse
- B-02, Data List Test Step T23 IDLE Speed Offset
- Table 2, Trouble Codes-Trouble Code No.73 Air Flow Sensor Voltage Low
- F0:Data List - Test Step 45 Engine Load Sig.
- B-02, Data List Test Step T24 Diagnosis Glow Time Relay
- Table 2, Trouble Codes-Trouble Code No.74 Mass Air Flow Sensor Voltage Low
- F0:Data List - Test Step 46 Check Light
- B-02, Data List Test Step T25 GLOW Time Relay
- Table 2, Trouble Codes-Trouble Code No.75 Torque Control Voltage Low
- F0:Data List - Test Step 47 Diag. Request
- B-02, Data List Test Step T26 A/c Relay (Air Conditioning)
- Table 2, Trouble Codes-Trouble Code No.76 Continuous Torque Control
- F0:Data List - Test Step 48 Injector Cutoff
- B-02, Data List Test Step T27 Vehicle Speed
- Table 2, Trouble Codes-Trouble Code No.81 Injector Valve 1 Voltage Low
- F0:Data List - Test Step 49 Immobiliser
- B-02, Data List Test Step T28 Telltale (Check Light)
- Table 2, Trouble Codes-Trouble Code No.82 Injector Valve 2 Voltage Low
- F0:Data List - Test Step 50 Immobiliser Sig.
- B-02, Data List Test Step T29 GLOW Time Telltale
- Table 2, Trouble Codes-Trouble Code No.83 Injector Valve 3 Voltage Low
- F1:Circuit Test - Test Step 01 Coolant Temperature (Motronic 1.5.4)
- B-02, Data List Test Step T30 MAX. Fuel Quantity Offset (Maximum)
- Table 2, Trouble Codes-Trouble Code No.84 Injector Valve 4 Voltage Low
- F1:Circuit Test - Test Step 02 02 Sensor Loop (Motronic 1.5.4)
- B-02, Data List Test Step T31 Start Fuel Quantity Offset
- Table 2, Trouble Codes-Trouble Code No.87 A/c Relay Voltage Low
- F1:Circuit Test - Test Step 03 02 Sensor (Motronic 1.5.4)
- B-02, Data List Test Step T32 EGR Offset (Exhaust-Gas Recirculation)
- Table 2, Trouble Codes-Trouble Code No.88 A/c Relay Voltage High
- F5:actuator Test Ign. Coil 1+4
- How to Connect Diagnostic Tester and Establish Communication the B-03
- Table 2, Trouble Codes-Trouble Code No.135 Check Light Voltage Low
- F5:actuator Test Ign. Coil 2+3
- B-04, Actuator Test Test Step T01 Immobiliser Signal Test
- Table 2, Trouble Codes-Trouble Code No.136 Unknown Output Driver Error
- F5:Actuator Test Check Light (Motronic 1.5.4)
- B-04, Actuator Test Test Step T02 Exhaust Gas Recirculation Solenoid
- Table 2, Trouble Codes-Trouble Code No.143 Immobiliser No or Wrong Coding
- F5:actuator Test Idle Air Control
- B-04, Actuator Test Test Step T03 GLOW Time Relay Test
- Table 2, Trouble Codes-Trouble Code No.144 Immobiliser No Signal
- F5:actuator Test Fuel Tank Vent
- B-04, Actuator Test Test Step T04 A/c Relay Test
- Table 2, Trouble Codes-Trouble Code No.145 Immobiliser Wrong Signal
- F5:actuator Test A/c Rlay
- B-04, Actuator Test Test Step T05 Engine Telltale (Check Light) Test
- Table 3, System Components Control Unit (Part Numbers)
- F5:actuator Test EGR Puls.ratio
- B-04, Actuator Test Test Step T06 GLOW Time Telltale Test
- Table 4, Instructions for "Engine Does Not Start"
- F5:actuator Test Immo.sig. Test
- B-05, Additional Functions Test Step T01 READ ECU Identification
- Table 5, F5: Actuator Test (No.01 Ign. Coil CYL1+4)
- F5:actuator Test Sec. Air P.rel
- B-05, Additional Functions Test Step T02 READ Vehicle Identification Number
- Table 5, F5: Actuator Test (No.02 Ign. Coil CYL2+3)
- F6:adjustments Idle Speed
- B-06, Programming Test Step T01 Immobiliser Programming
- Table 5, F5: Actuator Test (No.03 Check Light)
- F6:adjustments 02 Blm Reset
- B-07, Engine Does Not Start
- Table 5, F5: Actuator Test (No.04 Idle Air Control)
- F6:adjustments Iac Blm Reset
- B-08, Non ECU Supported Function Check
- Table 5, F5: Actuator Test (No.05 Fuel Tank Vent)
- F6:adjustments CO Adjustment
- B-09, Immobiliser Check
- Table 5, F5: Actuator Test (No.06 A/c Relay)
- F7:programming Variant Coding
- C-01, No Communication Between Diagnostic Tester and Control Unit
- Table 5, F5: Actuator Test (No.07 EGR Pulse Ratio)
- F7:programming Init. ECU
- C-02, Control Unit Hard- and Software
- Table 5, F5: Actuator Test (No.08 Immo.signal Test)
- F7:Programming Immobiliiser (Motronic 1.5.4)
- C-03, System Voltage Circuit
- Table 5, F5: Actuator Test (No.09 Sec.air Pump Rel)
- F8:ecu Control RPM Control
- C-04, Power Supply Circuit
- Table 6, F6: Adjustment (No.01 Adj.idle Speed)
- F8:ecu Control Iac Control
- C-05, Immobiliser Circuit
- Table 6, F6: Adjustment (No.02 O2 Blm Reset)
- F8:ecu Control Inj. Control
- C-06, Pedal Position Sensor Circuit
- Table 6, F6: Adjustment (No.03 Iac Blm Reset)
- F8:ecu Control Controlled EGR
- C-07, Mass Air Flow Circuit
- Table 6, F6: Adjustment (No.04 CO Adjustment)
- C-08, Barometer Sensor Circuit
- Table 7, F7: Programming Note
- C-09, Engine Coolant Temperature Sensor Circuit
- Table 7, F7: Programming (No.01 Variant Coding)
- C-10, Fuel Temperature Sensor Circuit
- Table 7, F7: Programming (No.02 Init. ECU)
- C-11, Brake-Light Switch Circuit
- Table 7, F7: Programming (No.03 Immobilisation)
- C-12, Air Conditioning System Information Switch Circuit
- Table 8, F8: ECU Control (No.01 RPM Control)
- C-13, Diesel Cutoff Solenoid Circuit
- Table 8, F8: ECU Control (No.02 Iac Control)
- C-14, Injection Start Circuit
- Table 8, F8: ECU Control (No.03 Inj.control)
- C-15, Fuel-Injection Quantity Circuit
- Table 8, F8: ECU Control (No.04 Controlled EGR)
- C-16, Glow Time Relay Circuit
- Table 9, Exh. Test F1:CNTL.CIRC.T. No.01 (Coolant Temperature)
- C-17, Exhaust Gas Recirculation Valve Circuit
- Table 9, Exh. Test F1:CNTL.CIRC.T. No.02 (O2 Sensor Loop)
- C-18, Engine Speed Input Signal Circuit
- Table 9, Exh. Test F1:CNTL.CIRC.T. No.03 (O2 Sensor)
- C-19, Blower Relay Circuit
- How to Check the Table 10, Linked Electronic Systems
- C-20, Air Conditioning System Cutoff Relay Circuit
- Survey of Wiring Harness Plugs, Frontera
- C-21, Cooling Fan Relay Circuit
- Survey of Control Unit, Relays
- C-22, Vehicle Speed Sensor Circuit
- Terminal Assignment of the 23-pin Wiring Harness Plug X23
- C-23, Engine Speed Output Signal Circuit
- Terminal Assignment of the Aldl Diagnostic Plug X13
- C-24, Engine Telltale Circuit
- Terminal Assignment of the Hot Film Mass Air Flow Meter P44
- C-25, Glow Time Telltale Circuit
- Terminal Assignment of the Direct Ignition Module L2
- Terminal Assignment Control Unit Wiring Harness Plug K70
- Terminal Assignment of the Control Unit Plug
- Terminal Assignment Component Plug P67
- Wiring Diagram - Motronic M 1.5.4 for Frontera
- Terminal Assignment Component Plug K7
- Table of Complaints
- Parts Location
- Time Allowance (Motronic M 1.5.4 for Frontera)
- Wiring Schematic Diagram 1
- Wiring Schematic Diagram 2
- Engine Telltale Illuminates and Set Fc P0606 as Well as P1530
- Irregular Idle Speed (600 - 1,400 RPM)
- TC0606 in Connection with TC 17 in Cu Transponder Engine Warning Lamp Illuminates
- Power Loss, Engine Misfire or Vehicle Will Not Start
- Irregular Idling-Speed (300-1500 RPM)
- Engine - Poor Driveability, Hesitation on Drive Away from Rest
- How to Remove and Install the Air Flow Meter
- How to Remove and Install the Pressure Regulator
- How to Remove and Install the Control Unit
- How to Remove and Install the Coolant Temperature Sensor
- How to Remove and Install the Idle Speed Adjuster
- How to Remove and Install the Ignition Coil
- How to Remove and Install the Ignition Distributor
- How to Remove and Install the Inductive Pulse Pick-Up
- How to Remove and Install the Injectors
- Octane Number Plug, Set Code
- How to Remove and Install the Oxygen Sensor
- How to Check the Ignition Timing
- How to Remove and Install the Throttle Valve Potentiometer
- How to Check Adjustment the Accelerator Pedal and Cable
- Technical Data Idle Speed, CO Content, Ignition Timing
- Illustrations
- How to Remove and Install the Control Relays
- How to Check the Fuel Injection Quantity
- How to Remove and Install the Ight Voltage Ignition Distributor
- Inductive Pulse Pick-Up, Remove/install
- How to Remove and Install the Injector
- How to Remove and Install the Tank Filler Valve
- Illustration Air Cleaner
- How to Remove and Install the Air Cleaner Housing
- Motronic M 1.5.4 General Instructions
- How to Remove and Install the Dis Ignition Module
- How to Remove and Install the Throttle Body
- Fuel Pressure Regulator, Remove/install
- How to Remove and Install the Hot Film Mass Air Flow Meter
- How to Remove and Install the Crankshaft Pulse Pick-Up
- How to Remove and Install the Knock Sensor
- How to Check the Fuel Pressure
- How to Remove and Install the Fuel Pump Relay
- Injection System Relay, Remove/install
- How to Remove and Install the Intake Air Temperature Sensor
- How to Remove and Install the Controlled Canister Purge Valve
- Technical Data Injection System
- General Instructions Motronic M 1.5.4
- Technical Data - Motronic M 1.5.4
- How to Remove and Install the Fuel Pump
- How to Remove and Install the Fuel Filter
- How to Drain Water the Fuel Filter
- How to Check the Injector Nozzle
- How to Clean (Injector Nozzle Removed) the Injector Nozzle
- How to Remove and Install the Injector Nozzle
- How to Remove and Install the Injection Pump
- How to Remove and Install the Injection Pump Solenoid Valve
- Technical Data Mechanically Controlled Injection System
- How to Check the Solenoid Valve, Cold Start Device
- How to Remove and Install the Immobiliser, Fuel Cutoff Valve
- How to Remove and Install the Fuel Cutoff Valve
- How to Adjust the Accelerator Pedal
- How to Adjust the Cable, Accelerator Pedal
- Injector Nozzle Check
- How to Clean and Adjust the Injector Nozzle
- Technical Data Mechanical Injection System
- How to Remove and Install the Electronic Diesel Control Unit
- How to Replace the Accel. Pedal Position Sensor
- How to Remove and Install the Engine Speed Sensor
- How to Clean the Injector Nozzle
- ABS
- ABS 415
- Accessories
- Additional Lighting
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Cih Petrol Engine
- Clutch
- Clutch and Transmission
- Cooling System
- Diesel Engine
- Distributor Transmission Four Wheel Drive
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Four Wheel Drive
- OHC Petrol Engine
- Other Accessories
- Paint
- Painting Repair Operations
- Painting Repair System
- Power Steering
- Radiator Grille
- Radio
- Radio Interference Suppression
- Rear Axle and Rear Wheel Suspension
- Rear Axle Four Wheel Drive
- Rear Axle Rear Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses