| Engine | Z 17 DTH | |
|---|---|---|
| No. of cylinders/ layout | 4 in line | |
| No. of valves | 16 | |
| Capacity | cm 3 | 1686 |
| Bore diameter | mm | 79.0 |
| Stroke | mm | 86.0 |
| Power output | kW / rpm | 74 / 4400 |
| Torque | Nm / rpm | 240 / 2300 |
| Compression | 18.4 | |
| Exhaust emissions standard | Euro 4 |
Contents
Wiring diagrams Section: DOHC Diesel Engine- Air Mass Meter, 4 Cylinder Diesel
- Z 13 DT DOHC Diesel Engine
- Battery / Starter, Diesel (Current Measurement)
- Z 17 DTH DOHC Diesel Engine
- Replace Heat Shield Sleeve (Y 17 DT, Y 17 DTL, Y 30 DT, Z 30 DT)
- Compression 4-cylinder, Diesel
- How to Replace (Y 17 DT the Valve Guide (Y 17 DTL))
- Crankshaft Impulse Sensor, Diesel
- Adjustment Data for Combo-C Z 13 DTJ (1.3 CDTI Ecotec) 55 kW
- Adjustment Data for Combo-C Z 17 DTH (1.7 CDTI Ecotec) 74 kW
- Diesel Glow Plugs (Current Measurement), 4 Cylinder
- Injection Pump Shaft Position
- Load Pressure Sensor, Edc Hdrc
- Z 13 DTJ Diesel Engine
- Spill Valve (Diesel Injection Pump)
- Remove and Install Exhaust Gas Recirculation Valve
- How to Remove and Install the Exhaust Gas Recirculation Pipe
- How to Remove and Install the Solenoid Valve, Exhaust Gas Recirculation System
- Svs Lamp on - DTC: P0380 Is Set
- Engine Identification Code / Engine Number
- How to Check and Adjust (Y 17 DTL) the Valve Clearance
- How to Check and Correct (Y 17 DTL the Toothed Belt Tension (Without AC, Lhd))
- Illustration Y 17 DTL
- Illustration Y 17 DT
- How to Replace (Y 17 DTL the Ribbed V-Belt (Without AC, Lhd))
- How to Replace (Y 17 DTL the Ribbed V-Belt Tensioner (Without AC, Lhd))
- How to Replace (Y 17 DTL the Upper Toothed Belt Cover (Without AC, Lhd))
- How to Replace (Y 17 DTL the Lower Toothed Belt Cover (Without AC, Lhd))
- How to Replace (Y 17 DTL the Toothed Belt (Without AC, Lhd))
- How to Replace (Y 17 DTL the Toothed Belt Tension Roller (Without AC, Lhd))
- How to Replace (Y 17 DTL the Toothed Belt Guide Roller (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the J463810A Camshaft Housing Cover (Without AC, Lhd))
- How to Replace (Y 17 DTL the Gasket - Intake Manifold (Without AC, Lhd))
- How to Replace (Y 17 DTL the Gasket - Exhaust Manifold (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the Both Camshafts (Without AC, Lhd))
- How to Replace (Y 17 DTL the Camshaft Housing (Without AC, Lhd))
- How to Replace (Y 17 DTL the Seal Ring - Camshaft (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the Flywheel (Without AC, Lhd))
- How to Replace (Y 17 DTL the J 452700-010 Piston (Y 17 DT))
- Engine Oil with Filter Change (Y 17 DTL, Z 17 DT)
- How to Remove and Install (Y 17 DTL the Oil Filter Housing (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the Oil Pump (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the Oil Pump Pressure Valve (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the Oil Pan - Lower Part (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the Oil Pan - Upper Part (Without AC, Lhd))
- How to Replace (Y 17 DTL the Font Reaction Member (Without AC, Lhd))
- How to Replace (Y 17 DTL the Rear Reaction Member (Without AC, Lhd))
- How to Replace (Left) (Y 17 DTL the Engine Damping Block (Without AC, Lhd))
- How to Replace (Right) (Y 17 DTL the Engine Damping Block (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the Engine (Without AC, Lhd))
- How to Replace (Left and Right) (Y 17 DTL the Engine Damping Blocks (Without AC, Lhd))
- Special Service Tools
- Sealants, Lubricants and Locking Compounds
- Specifications
- Checking and Adjustment Values
- Ribbed V-Belt
- Toothed Belt
- Oil Circuit
- Cylinder Head
- Crank Drive, Cylinder Block
- Torque Guide Values (Y 17 DTL, Y 17 DT)
- How to Check (Y 17 DT the Ribbed V-Belt Tensioner (Y 17 DTL))
- How to Check (Y 17 DTL) the Compression
- How to Check (Y 17 DT the Compression (Without AC, Rhd))
- How to Measure (Y 17 DT the Oil Temperature (Y 17 DTL))
- How to Check (Y 17 DT the Timing (With AC, Lhd))
- How to Remove and Install (Y 17 DTL the Both Camshafts (With AC, Lhd))
- How to Remove and Install (Y 17 DT the Engine (With AC, Lhd))
- How to Replace (Y 17 DT the J 470300 Gasket - Exhaust Manifold (With AC, Lhd))
- How to Replace (Y 17 DTL the J 470200 Return Manifold (Without AC, Lhd))
- How to Remove and Install (Y 17 DTL the J 457300 Cylinder Head (With AC, Lhd))
- How to Replace (Y 17 DT the J 459015 Valve Stem Seals (With AC, Lhd))
- How to Remove and Install (Y 17 DT the J 452700 All Pistons with Con-Rods (With AC, Lhd))
- How to Replace (Y 17 DT) the J 452700-012 Piston Rings
- How to Replace (Y 17 DT the J 317700 Oil Dipstick Guide Tube (With AC, Lhd))
- Check Engine Pressure Loss Y 17 DTL, Y 17 DT
- Check Timing (Y 17 DTL, with Air Conditioning, Lhd)
- Adjust Timing (Y 17 DT, with Air Conditioning, Lhd)
- Replace Rear Toothed Belt Cover (Y 17 DTL, with Air Conditioning, Ldh)
- Replace Rear Crankshaft Sealing Ring (Y 17 DT, Without Air Conditioning, Rhd)
- Replace Front Crankshaft Sealing Ring (Y 17 DTL, with Air Conditioning, Lhd)
- Check Crankshaft Alignment (Y 17 DT, Y 17 DTL)
- Replace One Con-Rod Bearing (Y 17 DT, Y 17 DTL)
- Removing and Installing Crankshaft (Y 17 DTL)
- Replace Oil Pump Sealing Ring (Y 17 DTL, with Air Conditioning, Lhd)
- Replace Oil Pressure Switch (Y 17 DTL, Without Air Conditioning, Rhd)
- Repair Engine Using an Engine Short Block (Y 17 DT)
- Removing and Attaching Manual Transmission From/to Engine (Y 17 DTL, Without Air Conditioning, Lhd)
- Chemical Products
- How to Remove and Install the Solenoid Valve, Exhaust Gas Recirculation Valve
- Flexible Maintenance Intervals
- Engine Number
- How to Check the Timing
- Ribbed V-Belt,. Replace
- How to Replace the Ribbed V-Belt, Tensioner
- How to Replace the Vacuum Pump
- How to Replace the Intake Manifold Gasket
- How to Replace the Exhaust Manifold Gasket
- Engine Oil with Oil Filter Change
- How to Remove and Install the Oil Pump Pressure-Regulating Valve
- Replacing Oil Dipstick Guide Tube
- How to Remove and Install the Front Reaction Member
- How to Replace the Rear Reaction Member (Assembly)
- How to Replace the Left Hand Engine Damping Block
- How to Replace the Right Hand Engine Damping Block
- Mta Manual Transmission from Engine, Detach and Attach
- Torque Guide Values
- How to Check (Z 17 DTH the Timing (With AC, Lhd))
- How to Replace (Z 17 DTH the Ribbed V-Belt (With Air Conditioning, Lhd))
- How to Remove and Install (Z 17 DTH the Toothed Belt Cover (With AC, Lhd))
- How to Remove and Install (Z 17 DTH the Lower Toothed Belt Cover (With AC, Lhd))
- How to Replace (Z 17 DTH the Toothed Belt (With AC, Lhd))
- How to Replace (Z 17 DTH the Toothed Belt Tension Roller (With AC, Lhd))
- How to Replace (Z 17 DTH the Toothed Belt Guide Roller (With AC, Lhd))
- How to Replace (Z 17 DTH the Gasket, Lower Part of Intake Manifold (With AC, Lhd))
- How to Replace (Z 17 DTH the Camshaft Seal Ring (With AC, Lhd))
- How to Replace (Z 17 DTH the Front Crankshaft Seal Ring (With AC, Lhd))
- Engine Oil with Filter Change (Z 17 DTH, with AC, Lhd)
- How to Replace (Z 17 DTH the Oil Pump Seal Ring (With AC, Lhd))
- How to Replace (Z 17 DTH the Oil Pump Drive Gear (With AC, Lhd))
- How to Remove and Install (Z 17 DTH the Oil Pump (With AC, Lhd))
- How to Remove and Install (Z 17 DTH the Oil Pan Lower Section (With AC, Lhd))
- How to Replace (Z 17 DTH the Vacuum Pump (With Air Conditioning, Lhd))
- Special Tools (Z 17 DTH)
- Recommend Torque Values (Z 17 DT)
- DOHC Diesel Engine (Z 17 DTH) - Engine Number/engine Code
- Check Compression
- Measure Oil Temperature
- Check Engine Oil Pressure
- Replace Timing Chain
- How to Replace the Timing Chain Sliding Rail
- How to Replace the Exhaust Manifold
- How to Replace the Both Camshafts
- How to Replace the Camshaft Sprocket
- How to Replace the Camshaft Housing
- How to Replace the Camshaft Housing Gasket
- How to Replace the All Hydraulic Valve Lifters
- How to Replace the All Roller Cam Followers
- How to Remove and Install the All Pistons with Con-Rod
- How to Replace the One Piston And/or Con-Rod
- How to Remove and Install the Oil Filter Housing
- How to Remove and Install the Oil Pump
- How to Remove and Install the Oil Pan
- How to Replace the Oil Intake Pipe
- How to Replace the Oil Baffle Plate
- How to Replace the Oil Pipe Inside Engine
- How to Replace the Oil Filler Port
- How to Replace the Engine Damping Block ( Both Sides)
- How to Check (Z 17 DTH the Compression (With Air Conditioning, Lhd))
- How to Measure (Z 17 DTH the Oil Temperature (With Air Conditioning, Lhd))
- How to Adjust (Z 17 DTH the Valve Clearance (With Air Conditioning, Lhd))
- How to Adjust (Z 17 DTH the Timing (With Air Conditioning, Lhd))
- How to Check and Correct (Z 17 DTH the Toothed Belt Tension (With Air Conditioning, Lhd))
- How to Check (Z 17 DTH the Ribbed V-Belt Tensioner (With Air Conditioning, Lhd))
- How to Replace the Toothed Belt Drive Gear - Crankshaft Sprocket
- How to Replace (Z 17 DTH the Ribbed V-Belt Tensioner (With Air Conditioning, Lhd))
- How to Remove and Install (Z 17 DTH the Camshaft Housing Cover (With Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Piston Rings (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Piston (Without Air Conditioning, Lhd))
- How to Remove and Install (Z 17 DTH the Oil Filter Housing (With Air Conditioning, Lhd))
- How to Remove and Install (Z 17 DTH the Oil Pan Upper Section (With AC, Lhd))
- How to Replace (Z 17 DTH the Oil Feed Line, Vacuum Pump (With Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Oil Return Hose, Vacuum Pump (With Air Conditioning, Lhd))
- Manual Transmission From/to Engine, Detach and Attach (Z 17 DTH, with Air Conditioning, Lhd)
- How to Replace (Z 17 DTH the Front Reaction Member (With Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Right Hand Engine Damping Block (With Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Rear Toothed Belt Cover (With Air Conditioning, Lhd))
- How to Remove and Install (Z 17 DTH the Both Camshafts (With Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Rear Reaction Member (With Air Conditioning, Lhd))
- Check Axial Play of Crankshaft
- How to Remove and Install ( Without Air Conditioning the Flywheel (Rhd))
- Replace Oil Separator
- Replacing Oil Pump Seal Ring
- Replacing Oil Spray Nozzles
- Checking Engine Pressure Loss
- Replacing Ribbed V-Belt Guide Roller
- How to Replace (Z 17 DTH the Camshaft Housing (Without AC, Lhd))
- How to Remove and Install the Crankshaft
- Measuring Crankshaft
- Replacing Oil Pressure Switch
- How to Check the Engine Pressure Loss (Diesel Engine)
- Remove and Install Torsional Vibration Damper
- Remove and Install Cylinder Head Attaching Parts
- Check Cylinder Head for Plane Surface
- Replace Con-Rod Bearing
- Check Con-Rod Bearing Clearance (Use Plastigage)
- Check Crankshaft Bearing Clearance (With Plastigage)
- Check the Bearing Clearance of the Crankshaft (Use Micrometer and Internal Measuring Device)
- Check Oil Pump
- Repair Engine Using a Short-Block
- Check Con-Rod Bearing Clearance (Use Micrometer and Internal Measuring Device)
- How to Replace the Piston Rings
- Pressure Loss Check - Charge Air System
- How to Replace the Cooler - Exhaust Gas Recirculation Valve
- Replace Metering Unit
- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Cng
- Communication / Navigation
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Folding Sunroof
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Radiator Grille
- Radio
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Распиновка разъёмов