Manual sections
Wiring diagrams- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Cng
- Communication / Navigation
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Folding Sunroof
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Radiator Grille
- Radio
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Распиновка разъёмов
Repair manual
DOHC Diesel Engine Opel Combo C
Step-by-step instructions on "DOHC Diesel Engine" for Opel Combo C (2002–2011). Pick an article — removal, installation, adjustment and diagnostics with illustrations.
195articles
1684illustrations
Articles in this section
195 articles- Air Mass Meter, 4 Cylinder Diesel 2
- Z 13 DT DOHC Diesel Engine
- Battery / Starter, Diesel (Current Measurement) 2
- Z 17 DTH DOHC Diesel Engine
- Replace Heat Shield Sleeve (Y 17 DT, Y 17 DTL, Y 30 DT, Z 30 DT) 3
- Compression 4-cylinder, Diesel 1
- How to Replace (Y 17 DT the Valve Guide (Y 17 DTL)) 1
- Crankshaft Impulse Sensor, Diesel 2
- Adjustment Data for Combo-C Z 13 DTJ (1.3 CDTI Ecotec) 55 kW
- Adjustment Data for Combo-C Z 17 DTH (1.7 CDTI Ecotec) 74 kW
- Diesel Glow Plugs (Current Measurement), 4 Cylinder 2
- Injection Pump Shaft Position 2
- Load Pressure Sensor, Edc Hdrc 2
- Z 13 DTJ Diesel Engine
- Spill Valve (Diesel Injection Pump) 2
- Remove and Install Exhaust Gas Recirculation Valve 10
- How to Remove and Install the Exhaust Gas Recirculation Pipe 6
- How to Remove and Install the Solenoid Valve, Exhaust Gas Recirculation System 1
- Svs Lamp on - DTC: P0380 Is Set
- Engine Identification Code / Engine Number 1
- How to Check and Adjust (Y 17 DTL) the Valve Clearance 11
- How to Check and Correct (Y 17 DTL the Toothed Belt Tension (Without AC, Lhd)) 16
- Illustration Y 17 DTL 1
- Illustration Y 17 DT 1
- How to Replace (Y 17 DTL the Ribbed V-Belt (Without AC, Lhd)) 2
- How to Replace (Y 17 DTL the Ribbed V-Belt Tensioner (Without AC, Lhd)) 3
- How to Replace (Y 17 DTL the Upper Toothed Belt Cover (Without AC, Lhd)) 8
- How to Replace (Y 17 DTL the Lower Toothed Belt Cover (Without AC, Lhd)) 9
- How to Replace (Y 17 DTL the Toothed Belt (Without AC, Lhd)) 15
- How to Replace (Y 17 DTL the Toothed Belt Tension Roller (Without AC, Lhd)) 17
- How to Replace (Y 17 DTL the Toothed Belt Guide Roller (Without AC, Lhd)) 17
- How to Remove and Install (Y 17 DTL the J463810A Camshaft Housing Cover (Without AC, Lhd)) 8
- How to Replace (Y 17 DTL the Gasket - Intake Manifold (Without AC, Lhd)) 12
- How to Replace (Y 17 DTL the Gasket - Exhaust Manifold (Without AC, Lhd)) 8
- How to Remove and Install (Y 17 DTL the Both Camshafts (Without AC, Lhd)) 36
- How to Replace (Y 17 DTL the Camshaft Housing (Without AC, Lhd)) 37
- How to Replace (Y 17 DTL the Seal Ring - Camshaft (Without AC, Lhd)) 18
- How to Remove and Install (Y 17 DTL the Flywheel (Without AC, Lhd)) 2
- How to Replace (Y 17 DTL the J 452700-010 Piston (Y 17 DT)) 2
- Engine Oil with Filter Change (Y 17 DTL, Z 17 DT) 2
- How to Remove and Install (Y 17 DTL the Oil Filter Housing (Without AC, Lhd)) 7
- How to Remove and Install (Y 17 DTL the Oil Pump (Without AC, Lhd)) 27
- How to Remove and Install (Y 17 DTL the Oil Pump Pressure Valve (Without AC, Lhd)) 4
- How to Remove and Install (Y 17 DTL the Oil Pan - Lower Part (Without AC, Lhd)) 2
- How to Remove and Install (Y 17 DTL the Oil Pan - Upper Part (Without AC, Lhd)) 4
- How to Replace (Y 17 DTL the Font Reaction Member (Without AC, Lhd)) 1
- How to Replace (Y 17 DTL the Rear Reaction Member (Without AC, Lhd)) 1
- How to Replace (Left) (Y 17 DTL the Engine Damping Block (Without AC, Lhd)) 6
- How to Replace (Right) (Y 17 DTL the Engine Damping Block (Without AC, Lhd)) 5
- How to Remove and Install (Y 17 DTL the Engine (Without AC, Lhd)) 26
- How to Replace (Left and Right) (Y 17 DTL the Engine Damping Blocks (Without AC, Lhd)) 8
- Special Service Tools 41
- Sealants, Lubricants and Locking Compounds
- Specifications
- Checking and Adjustment Values
- Ribbed V-Belt
- Toothed Belt
- Oil Circuit
- Cylinder Head 1
- Crank Drive, Cylinder Block 3
- Torque Guide Values (Y 17 DTL, Y 17 DT)
- How to Check (Y 17 DT the Ribbed V-Belt Tensioner (Y 17 DTL)) 2
- How to Check (Y 17 DTL) the Compression 8
- How to Check (Y 17 DT the Compression (Without AC, Rhd)) 8
- How to Measure (Y 17 DT the Oil Temperature (Y 17 DTL)) 1
- How to Check (Y 17 DT the Timing (With AC, Lhd)) 8
- How to Remove and Install (Y 17 DTL the Both Camshafts (With AC, Lhd)) 37
- How to Remove and Install (Y 17 DT the Engine (With AC, Lhd)) 27
- How to Replace (Y 17 DT the J 470300 Gasket - Exhaust Manifold (With AC, Lhd)) 14
- How to Replace (Y 17 DTL the J 470200 Return Manifold (Without AC, Lhd)) 9
- How to Remove and Install (Y 17 DTL the J 457300 Cylinder Head (With AC, Lhd)) 50
- How to Replace (Y 17 DT the J 459015 Valve Stem Seals (With AC, Lhd)) 42
- How to Remove and Install (Y 17 DT the J 452700 All Pistons with Con-Rods (With AC, Lhd)) 63
- How to Replace (Y 17 DT) the J 452700-012 Piston Rings 4
- How to Replace (Y 17 DT the J 317700 Oil Dipstick Guide Tube (With AC, Lhd)) 4
- Check Engine Pressure Loss Y 17 DTL, Y 17 DT 7
- Check Timing (Y 17 DTL, with Air Conditioning, Lhd) 8
- Adjust Timing (Y 17 DT, with Air Conditioning, Lhd) 12
- Replace Rear Toothed Belt Cover (Y 17 DTL, with Air Conditioning, Ldh) 19
- Replace Rear Crankshaft Sealing Ring (Y 17 DT, Without Air Conditioning, Rhd) 2
- Replace Front Crankshaft Sealing Ring (Y 17 DTL, with Air Conditioning, Lhd) 18
- Check Crankshaft Alignment (Y 17 DT, Y 17 DTL) 13
- Replace One Con-Rod Bearing (Y 17 DT, Y 17 DTL) 3
- Removing and Installing Crankshaft (Y 17 DTL) 29
- Replace Oil Pump Sealing Ring (Y 17 DTL, with Air Conditioning, Lhd) 17
- Replace Oil Pressure Switch (Y 17 DTL, Without Air Conditioning, Rhd) 1
- Repair Engine Using an Engine Short Block (Y 17 DT) 63
- Removing and Attaching Manual Transmission From/to Engine (Y 17 DTL, Without Air Conditioning, Lhd) 12
- Chemical Products
- How to Remove and Install the Solenoid Valve, Exhaust Gas Recirculation Valve 8
- Flexible Maintenance Intervals 2
- Engine Number 1
- How to Check the Timing 5
- Ribbed V-Belt,. Replace 1
- How to Replace the Ribbed V-Belt, Tensioner 2
- How to Replace the Vacuum Pump 3
- How to Replace the Intake Manifold Gasket 7
- How to Replace the Exhaust Manifold Gasket 6
- Engine Oil with Oil Filter Change 1
- How to Remove and Install the Oil Pump Pressure-Regulating Valve 3
- Replacing Oil Dipstick Guide Tube 14
- How to Remove and Install the Front Reaction Member 1
- How to Replace the Rear Reaction Member (Assembly) 2
- How to Replace the Left Hand Engine Damping Block 4
- How to Replace the Right Hand Engine Damping Block 3
- Mta Manual Transmission from Engine, Detach and Attach 10
- Torque Guide Values
- How to Check (Z 17 DTH the Timing (With AC, Lhd)) 8
- How to Replace (Z 17 DTH the Ribbed V-Belt (With Air Conditioning, Lhd)) 3
- How to Remove and Install (Z 17 DTH the Toothed Belt Cover (With AC, Lhd)) 7
- How to Remove and Install (Z 17 DTH the Lower Toothed Belt Cover (With AC, Lhd)) 11
- How to Replace (Z 17 DTH the Toothed Belt (With AC, Lhd)) 16
- How to Replace (Z 17 DTH the Toothed Belt Tension Roller (With AC, Lhd)) 17
- How to Replace (Z 17 DTH the Toothed Belt Guide Roller (With AC, Lhd)) 17
- How to Replace (Z 17 DTH the Gasket, Lower Part of Intake Manifold (With AC, Lhd)) 9
- How to Replace (Z 17 DTH the Camshaft Seal Ring (With AC, Lhd)) 22
- How to Replace (Z 17 DTH the Front Crankshaft Seal Ring (With AC, Lhd)) 18
- Engine Oil with Filter Change (Z 17 DTH, with AC, Lhd) 2
- How to Replace (Z 17 DTH the Oil Pump Seal Ring (With AC, Lhd)) 17
- How to Replace (Z 17 DTH the Oil Pump Drive Gear (With AC, Lhd)) 16
- How to Remove and Install (Z 17 DTH the Oil Pump (With AC, Lhd)) 27
- How to Remove and Install (Z 17 DTH the Oil Pan Lower Section (With AC, Lhd)) 3
- How to Replace (Z 17 DTH the Vacuum Pump (With Air Conditioning, Lhd)) 1
- Special Tools (Z 17 DTH) 48
- Recommend Torque Values (Z 17 DT)
- DOHC Diesel Engine (Z 17 DTH) - Engine Number/engine Code 1
- Check Compression 7
- Measure Oil Temperature 1
- Check Engine Oil Pressure 2
- Replace Timing Chain 2
- How to Replace the Timing Chain Sliding Rail 2
- How to Replace the Exhaust Manifold 1
- How to Replace the Both Camshafts 37
- How to Replace the Camshaft Sprocket 1
- How to Replace the Camshaft Housing 1
- How to Replace the Camshaft Housing Gasket 29
- How to Replace the All Hydraulic Valve Lifters 2
- How to Replace the All Roller Cam Followers 1
- How to Remove and Install the All Pistons with Con-Rod 3
- How to Replace the One Piston And/or Con-Rod 4
- How to Remove and Install the Oil Filter Housing 3
- How to Remove and Install the Oil Pump 1
- How to Remove and Install the Oil Pan 6
- How to Replace the Oil Intake Pipe 1
- How to Replace the Oil Baffle Plate 1
- How to Replace the Oil Pipe Inside Engine 2
- How to Replace the Oil Filler Port 1
- How to Replace the Engine Damping Block ( Both Sides) 5
- How to Check (Z 17 DTH the Compression (With Air Conditioning, Lhd)) 1
- How to Measure (Z 17 DTH the Oil Temperature (With Air Conditioning, Lhd)) 1
- How to Adjust (Z 17 DTH the Valve Clearance (With Air Conditioning, Lhd)) 7
- How to Adjust (Z 17 DTH the Timing (With Air Conditioning, Lhd)) 16
- How to Check and Correct (Z 17 DTH the Toothed Belt Tension (With Air Conditioning, Lhd)) 14
- How to Check (Z 17 DTH the Ribbed V-Belt Tensioner (With Air Conditioning, Lhd)) 2
- How to Replace the Toothed Belt Drive Gear - Crankshaft Sprocket
- How to Replace (Z 17 DTH the Ribbed V-Belt Tensioner (With Air Conditioning, Lhd)) 1
- How to Remove and Install (Z 17 DTH the Camshaft Housing Cover (With Air Conditioning, Lhd)) 13
- How to Replace (Z 17 DTH the Piston Rings (Without Air Conditioning, Lhd)) 4
- How to Replace (Z 17 DTH the Piston (Without Air Conditioning, Lhd)) 2
- How to Remove and Install (Z 17 DTH the Oil Filter Housing (With Air Conditioning, Lhd)) 7
- How to Remove and Install (Z 17 DTH the Oil Pan Upper Section (With AC, Lhd)) 9
- How to Replace (Z 17 DTH the Oil Feed Line, Vacuum Pump (With Air Conditioning, Lhd)) 3
- How to Replace (Z 17 DTH the Oil Return Hose, Vacuum Pump (With Air Conditioning, Lhd)) 1
- Manual Transmission From/to Engine, Detach and Attach (Z 17 DTH, with Air Conditioning, Lhd) 11
- How to Replace (Z 17 DTH the Front Reaction Member (With Air Conditioning, Lhd)) 1
- How to Replace (Z 17 DTH the Right Hand Engine Damping Block (With Air Conditioning, Lhd)) 4
- How to Replace (Z 17 DTH the Rear Toothed Belt Cover (With Air Conditioning, Lhd)) 22
- How to Remove and Install (Z 17 DTH the Both Camshafts (With Air Conditioning, Lhd)) 48
- How to Replace (Z 17 DTH the Rear Reaction Member (With Air Conditioning, Lhd)) 2
- Check Axial Play of Crankshaft
- How to Remove and Install ( Without Air Conditioning the Flywheel (Rhd)) 1
- Replace Oil Separator 3
- Replacing Oil Pump Seal Ring 5
- Replacing Oil Spray Nozzles 1
- Checking Engine Pressure Loss 7
- Replacing Ribbed V-Belt Guide Roller 4
- How to Replace (Z 17 DTH the Camshaft Housing (Without AC, Lhd)) 39
- How to Remove and Install the Crankshaft 34
- Measuring Crankshaft 13
- Replacing Oil Pressure Switch 1
- How to Check the Engine Pressure Loss (Diesel Engine) 10
- Remove and Install Torsional Vibration Damper 1
- Remove and Install Cylinder Head Attaching Parts 5
- Check Cylinder Head for Plane Surface 1
- Replace Con-Rod Bearing 3
- Check Con-Rod Bearing Clearance (Use Plastigage) 3
- Check Crankshaft Bearing Clearance (With Plastigage) 3
- Check the Bearing Clearance of the Crankshaft (Use Micrometer and Internal Measuring Device) 3
- Check Oil Pump 3
- Repair Engine Using a Short-Block 49
- Check Con-Rod Bearing Clearance (Use Micrometer and Internal Measuring Device) 2
- How to Replace the Piston Rings 3
- Pressure Loss Check - Charge Air System 4
- How to Replace the Cooler - Exhaust Gas Recirculation Valve
- Replace Metering Unit 9