Manual sections
Wiring diagrams- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- ABS 8/ESP
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Anti-Theft Warning System-S
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- CAN Bus
- Central Door Locking System
- Central Electrics
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bolted)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Info Display Ccrt 700
- Instruments, Telltales
- Lpg
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Распиновка разъёмов
Repair manual
DOHC Petrol Engine Opel Meriva A
Step-by-step instructions on "DOHC Petrol Engine" for Opel Meriva A (2003–2011). Pick an article — removal, installation, adjustment and diagnostics with illustrations.
288articles
1170illustrations
Articles in this section
288 articles- Z 16 XEP with F13+ Manual Transmission
- Air Mass Meter, Z18XE, Z20LEL, Y22XE, Z22XE 2
- Z 16 LET Turbo Petrol Engine
- Intake Manifold Z 16 LET Turbo Petrol Engine
- Oil Filter Housing Z 16 LET Turbo Petrol Engine 1
- Piston Cooling Z 16 LET Turbo Petrol Engine 1
- Camshaft Bearing Bridge for Z 16 LET and Z 18 XER Petrol Engines 5
- Survey of All Vehicle Types
- Oil Filter 1
- Lubrication of Radial Shaft Seal Rings No Longer Applicable
- Camshaft Sensor, Multec S/f Except Z14XE MY2004 2
- Camshaft Sensor, Simtec 70/71/81 2
- Ignition, Primary, Z14XE, Z16XE, Z16YNG 2
- Illustration - Air Cleaner Housing, Air Ducts Z 16 XE 1
- Engine Number 1
- Throttle Valve Potentiometer (Double Signal), Multec/trionic (MY 2001,MY 2002 and MY 2003), Simtec (MY 2001 and MY 2002) 2
- Survey of Engine Compartment (Z 16 XE) 3
- Check Compression Pressure (Z 16 XE, with Air Conditioning, Rhd) 3
- Check Engine Pressure Loss (Z 16 XE) 7
- Check Oil Temperature (Z 16 XE) 1
- Check Engine Oil Pressure (Z 16 XE, with Air Conditioning, Rhd) 4
- Pedal Position Double Signal, All Petrol (MY 2002, MY 2003 and MY 2004) 2
- Check Timing (Z 16 XE, with Air Conditioning, Rhd) 3
- Check and Set Timing (Z 16 XE, with Air Conditioning, Rhd) 13
- Check and Correct Toothed Belt Tension (Z 16 XE, with Air Conditioning, Rhd) 12
- Check Toothed Belt Tension (Z 16 XE, with Air Conditioning, Rhd) 8
- Replace Ribbed V-Belt (Z 16 XE, with Air Conditioning, Rhd) 2
- Replace Ribbed V-Belt Tensioner (Z 16 XE, with Air Conditioning, Rhd) 3
- Engine Overview
- Replace Front Upper Part of Toothed Belt Cover (Z 16 XE, with Air Conditioning, Rhd) 2
- Engine Code
- Exhaust Gas Recirculation Valve, All Petrol (MY 2002, MY 2003 and MY2004) 2
- Replace Front Lower Part of Toothed Belt Cover (Z 16 XE, with Air Conditioning, Rhd) 7
- Overview of Engine Parameters and Engine Management Systems
- Replace Toothed Belt (Z 16 XE, with Air Conditioning, Rhd) 16
- Mileage and Consumption Values
- Replace Toothed Belt Tension Roller (Z 16 XE, with Air Conditioning, Rhd) 14
- Engine/transmission Bearing 1
- Replace Toothed Belt Guide Roller (Z 16 XE, with Air Conditioning, Rhd) 14
- Replace Rear Toothed Belt Cover (Z 16 XE, with Air Conditioning, Rhd) 22
- Remove / Install Cylinder Head Cover (Z 16 XE, with Air Conditioning, Rhd) 4
- Replace Camshaft Timing Gears (Z 16 XE, with Air Conditioning, Rhd) 15
- New Camshaft Sensor - Z 10 XEP, Z 12 XEP, Z 14 XEP Petrol Engines 1
- Replace Front Camshaft Seal Ring (Z 16 XE, with Air Conditioning, Rhd) 16
- Remove / Install Both Camshafts (Z 16 XE, with Air Conditioning, Rhd) 22
- Replace Exhaust Manifold (Z 16 XE, with Air Conditioning, Rhd) 6
- Elimination of Twinport Sensor - Z 10 XEP, Z 12 XEP and Z 14 XEP Petrol Engines 1
- Z 18 XE Dohc-I Petrol Engine - Overview
- Replace Upper Part of Intake Manifold (Z 16 XE, with Air Conditioning, Rhd) 13
- DOHC-0 Engine Z 14 XEP - Corsa-C Combo, Meriva and Tigra-B
- View of Z 18 XE Engine 2
- Replace Intake Manifold Seal (Z 16 XE, with Air Conditioning, Rhd) 14
- Z 18 XE Torque and Output Curve 1
- Throttle Valve Potentiometer (Double Signal), Simtec (MY 2003), Simtecand Multec-F (MY 2004) 2
- Specific Characteristics of the Z 14 XEP Engine
- Z 18 XE Block Diagram 1
- Remove / Install Flywheel (Z 16 XE, with Air Conditioning System, Mta, Rhd) 1
- View of the Engine, Z 12 XEP, Z 14 XEP 2
- Replace Rear Crankshaft Seal Ring (Z 16 XE, with Air Conditioning, Rhd) 2
- Replace Engine Vent Flange (Z 16 XE, with Air Conditioning, Rhd) 4
- Torque and Power Diagram, Z 14 XEP
- Engine Oil with Filter Change (Z 16 XE) 1
- Exhaust Manifold, Z 12 XEP, Z 14 XEP 1
- Replace Oil Filter Short-Circuit Valve (Z 16 XE, with Air Conditioning, Lhd) 2
- Replace Front Crankshaft Seal Ring (Z 16 XE, with Air Conditioning, Rhd) 13
- Camshaft Control, Z 10 XEP, Z 12 XE, Z 14 XEP (From End MY 2004 to MY 2005) 4
- Remove / Install Oil Pan (Z 16 XE, with Air Conditioning, Rhd) 3
- Camshaft Control, Z 10 XEP, Z 12 XEP, Z 14 XEP (MY 2005 Onwards) 2
- Remove / Install Oil Pump (Z 16 XE, with Air Conditioning, Rhd) 26
- Setting the Phase Sensor Disc with KM-954 1
- Check Oil Pump 1
- Camshaft Sensor 1
- Wheel Speed Sensor, Except Vectra-C/signum and Astra-H 2
- Remove / Install Oil Pump Pressure Regulating Valve (Z 16 XE, with Air Conditioning, Rhd) 1
- Timing Case 1
- Replace Intake Pipe for Oil Pump (Z 16 XE, with Air Conditioning, Rhd) 1
- Timing Chain Tensioner 2
- Remove / Install Oil Baffle Plate (Z 16 XE, with Air Conditioning, Rhd) 1
- Bosch Motronic 7.6.2 Engine Control Unit
- Replace Oil Dipstick Guide Tube (Z 16 XE, with Air Conditioning, Rhd) 3
- Replace Dynamic Oil Level Monitoring Sensor (Z 16 XE, with Air Conditioning, Rhd) 1
- Vacuum Hose Connector, Brake Servo 1
- Top Up and Bleed Cooling System 1
- Remove / Install Coolant Connector (Z 16 XE, with Air Conditioning, Rhd) 7
- Crankshaft Guide Bearing, DOHC Engines
- Check Engine for Leaks (CO Content in Cooling System) (Z 16 XE) 1
- Replace Fan Motor (Z 16 XE, with Air Conditioning, Rhd) 6
- Replace Radiator (Z 16 XE, with Air Conditioning, Rhd) 8
- Replace Thermostat (Z 16 XE, with Air Conditioning, Rhd) 3
- Remove / Install Thermostat Housing (Z 16 XE, with Air Conditioning, Rhd) 2
- Replace Coolant Pump (Z 16 XE, with Air Conditioning, Rhd) 16
- Replace Coolant Pipe (Z 16 XE, with Air Conditioning, Rhd) 14
- Replace Engine Damping Blocks (Both Sides) (Z 16 XE, with Air Conditioning, Rhd) 7
- Remove / Install Front Reaction Member (Z 16 XE, Rhd) 1
- Remove / Install Rear Reaction Member (Z 16 XE, Rhd) 1
- Remove / Install Right Engine Damping Block (Z 16 XE, with Air Conditioning, Rhd) 5
- Remove / Install Left Engine Damping Block (Z 16 XE, with Air Conditioning, Rhd) 5
- Remove / Install Engine with Transmission (Z 16 XE, with Air Conditioning, Mta, Rhd) 26
- Overhaul Engine Using an Engine Short Block (Z 16 XE, with Air Conditioning, Rhd) 31
- Remove / Install Mta Manual Transmission of Engine (Z 16 XE, with Air Conditioning, Rhd) 9
- Remove / Install Throttle Valve Module (Z 16 XE, with Air Conditioning, Rhd) 2
- Replace Injectors (Z 16 XE, with Air Conditioning, Lhd) 7
- Replace Intake Air Temperature Sensor (Z 16 XE, with Air Conditioning, Rhd) 1
- Check Fuel Pressure (Z 16 XE, with Air Conditioning, Rhd) 1
- Replace Oxygen Sensor, Mixture Regulation (Z 16 XE, with Air Conditioning, Rhd) 1
- Replace Lambda Sensor for Catalytic Converter Control (Z 16 XE, with Air Conditioning, Rhd) 1
- Replace Dis Ignition Module (Z 16 XE, with Air Conditioning, Rhd) 1
- Replace Intake Manifold Pressure Sensor (Z 16 XE, with Air Conditioning, Rhd) 1
- Replace Crankshaft Sensor (Z 16 XE, with Air Conditioning, Rhd) 1
- Replace Knock Sensor (Z 16 XE, with Air Conditioning, Rhd) 2
- Replace Coolant Temperature Sensor (Z 16 XE, with Air Conditioning, Rhd) 1
- Replace Camshaft Sensor (Z 16 XE, with Air Conditioning, Rhd) 3
- Replace Pedal Sensor (Z 16 XE, with Air Conditioning, Rhd) 1
- Replace Starter (Z 16 XE, with Air Conditioning, Rhd) 2
- How to Remove and Install or Replace (Z 16 XE the Alternator (With AC, Rhd)) 8
- Replace Regulator for Alternator (Z 16 XE, with Air Conditioning, Rhd) 10
- Special Service Tools 45
- Sealants, Lubricants and Locking Compounds
- Specifications
- Cooling System
- Ribbed V-Belt
- Engine Control Unit
- Engine Management
- Torque Guide Values
- Engine, Built-On Engine Parts 1
- Air Cleaner Housing, Air Ducts 1
- Survey of Engine Compartment (Z 18 XE 3
- Check Engine Pressure Loss (Z 18 XE) 7
- Check Oil Temperature (Z 18 XE) 1
- Check Engine Oil Pressure (Z 18 XE, with Air Conditioning, Lhd) 4
- How to Check (Z 18 XE the Timing (With AC, Lhd)) 3
- How to Check and Set (Z 18 XE the Timing (With AC, Lhd)) 13
- How to Check and Adjust (Z 18 XE the Toothed Belt Tension (With AC, Lhd)) 12
- Check Toothed Belt Tension (Z 18 XE, with Air Conditioning, Lhd) 8
- Replace V-Belt (Z 18 XE, with AC, Lhd) 2
- Replace V-Belt Tensioner (Z 18 XE, with AC, Lhd) 3
- Replace Front Toothed Belt Cover (Top) (Z 18 XE, with AC, Lhd) 2
- Replace Front Toothed Belt Cover (Bottom) (Z 18 XE, with AC, Lhd) 7
- Replace Toothed Belt (Z 18 XE, with AC, Lhd) 16
- Replace Toothed Belt Tension Roller (Z 18 XE, with AC, Lhd) 13
- Replace Toothed Belt Guide Rollers (Z 18 XE, with AC, Lhd) 14
- Replace Rear Toothed Belt Cover (Z 18 XE, with AC, Lhd) 22
- Replace Camshaft Sprockets (Z 18 XE, with AC, Lhd) 15
- Replace Front Camshaft Seal Ring (Z 18 XE, with AC, Lhd) 16
- Remove and Install Both Camshafts (Z 18 XE, with AC, Lhd) 22
- Replace Exhaust Manifold Gasket (Z 18 XE, with Air Conditioning, Lhd) 7
- Replace Inlet Manifold Gasket (Z 18 XE, with AC, Lhd) 12
- Replace Oil Filter Short Circuit Valve (Z 18 XE, with AC, Lhd) 2
- Removing and Installing Oil Pump Pressure Regulating Valve (Z 18 XE, with Air Conditioning, Lhd) 1
- Replace Dynamic Oil Level Control Sensor (Z 18 XE, with AC, Lhd) 1
- How to Remove and Install (Z 18 XE the Oil Dipstick (With AC, Lhd)) 1
- Check Engine for Leaks (Co-Content in Cooling System) (Z 18 XE) 1
- Replace Engine Damping Blocks (Both Sides) (Z 18 XE, with AC, Lhd) 7
- How to Remove and Install (Z 18 XE the Front Reaction Member (With AC, Lhd)) 1
- How to Remove and Install (Z 18 XE the Rear Reaction Member (With AC, Lhd)) 1
- How to Remove and Install (Z 18 XE the Right-Hand and Left-Hand Engine Damping Block (With AC, Lhd)) 5
- How to Remove and Install (Z 18 XE the Left-Hand Engine Damping Block (With AC, Lhd)) 5
- Check Fuel Pressure (Z 18 XE, with Air Conditioning, Lhd) 1
- Replace Coolant Temperature Sensor (Z 18 XE, with AC, Lhd) 3
- Replace Pedal Sensor (Z 18 XE, with AC, Lhd) 1
- Sealants, Lubricants and Locking Agents
- How to Remove and Install the Exhaust Gas Recirculation Valve 1
- Z18XE Engine - No Compression Because of a Broken Valve Spring
- Replace One Con-Rod Bearing (Z 16 XE, with Air Conditioning, Rhd) 3
- Remove and Install Oil Pan (Z 16 XE, with Air Conditioning, Rhd) 2
- Replace One Con-Rod Bearing (Z 18 XE, with Air Conditioning, Lhd) 3
- How to Check the Oil Pump 1
- Remove and Install Oil Intake Pipe (Z 18 XE, with Air Conditioning, Lhd) 1
- Replace Front Crankshaft Seal Ring (Z 18 XE, with AC, Lhd) 14
- Remove and Install Both Spark Plugs (Z 18 XE, with AC, Lhd) 2
- Engine Z10/Z12/Z14XE/P - Strong Vibration from Poly-V-Belt, Often Together with DTC P0300-P0304 (Misfire)
- Engine Z18XE - DTC P1372(2) Crankshaft Segment Failure
- Engine Identification Code / Engine Number 1
- How to Check the Compression 2
- Check Engine Pressure Loss 7
- How to Measure the Oil Temperature 1
- How to Check the Oil Pressure 1
- How to Check for Leaks the Engine ((CO Content in Cooling System)) 1
- Replacing Resonator 1
- Replace Ribbed V-Belt (Without Air Conditioning) 7
- Replace Ribbed V-Belt Tensioner (Without Air Conditioning) 9
- Replace Timing Case Sealing Ring 4
- How to Remove and Install the Cylinder Head Cover 4
- Replace All Valve Stem Seals (Cylinder Head Installed) 9
- Replace Exhaust Manifold 4
- How to Remove and Install the Attaching Parts - Cylinder Head 5
- Replace EGR Valve 5
- Replace Exhaust Gas Recirculation Pipe 1
- How to Remove and Install the Hydraulic Valve Lifter 1
- Removing and Installing Roller Cam Followers
- How to Replace the Seal Ring - Front Crankshaft
- How to Replace the Con-Rod Bearing
- How to Check (With Plastigage) the Con-Rod Bearing Play 2
- Check Con-Rod Bearing Clearance (With Micrometer Gauge and Internal Measuring Device) 2
- How to Check the Crankshaft End Play 1
- How to Check the Crankshaft Out-Of-Round 1
- How to Check (With Plastigage) the Crankshaft Bearing Play 3
- Check Crankshaft Bearing Play (With Micrometer Gauge and Internal Measuring Device) 2
- How to Check for Plane Surface the Cylinder Block 1
- Engine Oil with Oil Filter Change 2
- How to Remove and Install the Oil Filter Housing 1
- How to Remove and Install the Oil Pressure Switch 1
- How to Remove and Install the Oil Pan
- How to Remove and Install the Oil Intake Pipe 1
- Replace Oil Pressure Regulating Valve
- Replacing Oil Dipstick Guide Tube 1
- Replace Engine Damping Block (Front) 1
- Replace Engine Damping Block (Rear) 1
- Replace Left Engine Damping Block 6
- Replace Right Engine Damping Block 5
- Z14XEP Manual Transmission, Removing from and Attaching to Engine 9
- Checking and Adjustment Values
- Ribbed V-Belt - Engine Timing
- Oil Circuit
- Cylinder Head 1
- Crank Drive, Cylinder Block 3
- Engine Z10/12/14XEP - Loss of Oil Between Oil Filter Modul and Engine Block
- Coolant Hose Illustration 1
- How to Check the Ribbed V-Belt Tensioner 1
- Check Compression Pressure 2
- Check Oil Pressure 2
- How to Check the Fuel Pressure 1
- Removing and Installing Air Cleaner Housing 1
- Replace Resonator 1
- How to Replace the Ribbed V-Belt
- Replace Ribbed V-Belt Tensioner
- How to Replace the Front Toothed Belt Cover (Upper)
- How to Replace the Front Toothed Belt Cover (Lower)
- How to Replace the Toothed Belt
- Replace Toothed Belt Tensioner
- Replace Toothed Belt Guide Roller
- How to Replace the Toothed Belt Drive Gear
- How to Check the Timing 2
- How to Adjust the Timing 3
- How to Replace the Camshaft Sprockets
- Removing and Installing Both Camshafts
- How to Check and Adjust the Valve Play 26
- How to Replace the Camshaft Seal Ring 9
- How to Remove and Install the Bucket Tappets 2
- How to Replace the Exhaust Manifold Gasket 7
- How to Replace the Intake Manifold Gasket 12
- How to Replace the Intake Manifold Flange 3
- How to Remove and Install the Flywheel
- How to Replace the Seal Ring - (Front) Crankshaft 2
- How to Replace the Crankshaft Rear Seal Ring 5
- How to Replace the Engine Vent Pipe 3
- Replace Piston Rings 2
- Check Con-Rod Bearing Clearance (With Plastigage) 2
- Check Con-Rod Bearing Play (With Micrometer Gauge and Internal Measuring Instrument)
- Engine Oil and Oil Filter Change 1
- How to Replace the Engine Oil Level Sensor 8
- How to Remove and Install the Oil Pump 22
- Replace Oil Pressure Switch 2
- How to Remove and Install the Engine 33
- How to Remove and Install (Engine Removed) the Mta Transmission from Engine 10
- How to Remove and Install the Spark Plugs
- Sealants, Lubricants and Locking Compounds (Dohc-I -)
- Checking and Adjustment Values - Dohc-I
- Toothed Belt
- Coolant Circuit
- Illustration: Air Ducting 1
- Check Engine Oil Pressure 2
- How to Replace the Accessory Drive 4
- How to Replace the Toothed Belt Tensioner
- How to Replace the Intake Manifold (Petrol Engine) 17
- How to Remove and Install the Exhaust Manifold with Turbocharger
- How to Remove and Install the Piston with Con-Rod 4
- How to Replace the Pistons
- Check Crankshaft Bearing Play (With Micrometer Gauge and Internal Measuring Instrument) 2
- Check Crankshaft Bearing Play (With Plastigage)
- How to Remove and Install the Oil Baffle Plate
- How to Replace the Pressure Relief Valve 1
- How to Replace the Turbocharger Oil Feed Line 1
- How to Replace the Turbocharger Oil Return Line 1
- How to Replace the Engine Damping Blocks 4
- Engine A/Z10/12/14XEP/L - Crankcase Ventilation Hoses Cracked
- How to Remove from Engine and Install the Manual Transmission 13
- Replace Rear Seal Ring for the Crankshaft (2005 Model Year and Beyond) 4
- Engine Management Illustration 2
- How to Remove and Install the Thermostat Housing
- Replace Intake Air Temperature Sensor 1
- Replacing Upper Engine Cover 1
- How to Replace (Cylinder Head Installed) the All Valve Stem Seals 9
- How to Remove and Install the Crankshaft 3
- Check Crankshaft Bearing Play (With Plastigage) - 2
- Check Crankshaft Bearing Play (With External Micrometer and Interior Measuring Instrument) 2
- Starter
- Alternator