Note. When a short block engine is installed the engine number must be marked on the cylinder block before installing the engine
The engine identification code is embossed on the flattened area of the cylinder block (arrow) at the transmission side
Home/Opel/Corsa/Opel Corsa D (2007-2011)/Repair manual/DOHC Petrol Engine/Engine Identification Code / Engine Number
Contents
Wiring diagrams Section: DOHC Petrol Engine- How to Check and Measure the Cylinder Head and Attaching Parts (Survey)
- How to Check the Cylinder Head Height
- How to Check for Plane Surface the Cylinder Head
- How to Measure the Valve
- How to Check the Inner Diameter of Valve Guide
- Z 16 LEL Turbo Petrol Engine
- Valve Stem Play, Determine
- How to Check the Installation Height of Valves
- How to Check the Installation Height of Valve Guide
- Z 16 LER Petrol Engine
- Torque and Output Curve of the Z 16 LER Petrol Engine
- How to Overhaul the Cylinder Head
- Cylinder Head, Attach to Assembly Tool Set KM-6215
- Cylinder Head, Disassemble
- How to Remove the Valves
- Valve Seat, Cut (In Cylinder Head)
- Valve Guide, Ream
- Valve, Grind
- Valve, Grind In
- How to Replace the Valve Stem Seals
- Adjustment Data for Corsa-D A 10 XEP (1.0 Twinport Ecotec) 48 kW
- How to Assemble the Cylinder Head
- Adjustment Data for Corsa-D A 12 XEL (1.2 Twinport Ecoflex) 51 kW
- Cylinder Head Machining Special Tools
- Survey of All Vehicle Types
- Adjustment Data for Corsa-D A 12 XER (1.2 Twinport Ecoflex) 63 kW
- Oil Filter
- Adjustment Data for Corsa-D Z 12 XEP Lpg (1.2 Lpg Ecoflex) 59 kW
- Adjustment Data for Corsa-D A 14 XEL (1.4 Twinport Ecoflex) 64 kW
- Measuring Oil Consumption
- Adjustment Data for Corsa-D Z 14 XEP Lpg (1.4 Lpg Ecoflex) 66 kW
- Adjustment Data for Corsa-D A 16 LER (1.6 Turbo Ecotec) 141 kW
- Adjustment Data for Corsa-D A 16 LEL (1.6 Turbo Ecotec) 110 kW
- Damage Diagnosis, Dual Mass Flywheel
- Specified Time Allowance
- How to Check the Compression
- Check Engine Pressure Loss
- How to Measure the Oil Temperature
- How to Check the Engine Oil Pressure
- Testing Ribbed V-Belt Tensioner
- How to Replace the Ribbed V-Belt (Without Air Conditioning)
- How to Replace the Ribbed V-Belt (With Air Conditioning)
- Replace Ribbed V-Belt Tensioner
- How to Remove and Install the Cylinder Head Cover
- Replace EGR Valve
- How to Remove and Install the Hydraulic Valve Lifter
- How to Replace the Twinport Vacuum Unit
- How to Replace the Seal Ring - Rear Crankshaft
- How to Remove and Install the All Pistons with Con-Rods
- How to Check for Plane Surface the Cylinder Block
- How to Remove and Install the Oil Pan
- How to Remove and Install the Oil Dipstick Guide Tube
- Engine Oil with Oil Filter Change
- How to Check for Leaks the Engine ((CO Content in Cooling System))
- How to Remove and Install the Right Engine Damping Block
- Replace Left Engine Damping Block
- How to Remove and Install the Spark Plugs
- How to Remove and Install the Guide Rail
- How to Remove and Install the Chain Tensioner
- How to Replace the Intake Manifold Gasket
- Replace Ignition Module
- How to Remove and Install the Flywheel
- How to Remove and Install the Drive Disc
- How to Remove and Install the Dynamic Oil Level Check
- How to Remove and Install the Oil Pressure Switch
- Replace Right-Hand Engine Damping Block
- How to Replace the Rear Reaction Member
- Replace Exhaust Camshaft Position Sensor
- Replace Intake Camshaft Position Sensor
- Replace Camshaft Adjuster Solenoid Valve (Intake and Exhaust Side)
- Illustration of Coolant Hoses
- Illustration of Air Ducting
- Engine Identification Code / Engine Number
- How to Replace the Seal Ring - Front Crankshaft
- Replace Fuel Rail
- Check Crankshaft Bearing Play (With Micrometer Gauge Internal Measuring Device)
- How to Check the Crankshaft End Play
- How to Check the Radial Run-Out of Crankshaft
- How to Remove and Install the Crankshaft
- How to Remove and Install the Crankshaft Gear
- Check Con-Rod Bearing Clearance (Use Micrometer and Internal Measuring Device)
- How to Remove and Install the Tension Rail
- How to Remove and Install the Timing Case
- How to Remove and Install the Timing Chain
- How to Check the Fuel Pressure
- Replace Air Cleaner Housing
- How to Replace the Resonator
- How to Replace the Exhaust Gas Recirculation Pipe
- Detaching and Attaching Components, Cylinder Head
- How to Replace the Con-Rod Bearing
- How to Check (With Plastigage) the Con-Rod Bearing Play
- Measure Axial Play
- How to Check (With Plastigage) the Crankshaft Bearing Play
- How to Replace the Piston Rings
- Replace Oil Pressure Regulating Valve
- Replace Oil Pressure Switch
- How to Remove and Install the Oil Filter Housing
- How to Check the Oil Pump
- Removing and Installing Oil Baffle Plate
- How to Remove and Install the Manual Transmission from Engine
- Replace Hot Film Mass Air Flow Sensor
- How to Remove and Install the Accelerator Pedal Module
- Special Service Tools
- Sealants, Lubricants and Locking Agents
- Specifications
- Checking and Adjustment Values
- Ribbed V-Belt
- Engine Timing
- Cooling System
- Oil Circuit
- Cylinder Head
- Crank Drive, Cylinder Block
- Engine Management
- Torque Guide Values
- Replace Timing Chain Drive Gear
- Replace Valve Springs
- Removing and Installing Roller Cam Followers
- Measure Radial Run-Out
- How to Remove from Engine and Install the Mta-Manual Transmission
- Ribbed V-Belt - Engine Timing
- Illustration Vacuum Routing Engine Compartment
- Illustration Engine Management System
- Replace Ribbed V-Belt
- Replace Front Toothed Belt Cover (Top)
- Replace Front Toothed Belt Cover (Lower)
- Replace Auxiliary Drive
- Replace Toothed Belt
- Replace Toothed Belt Guide Roller
- Replace Toothed Belt Drivewheel
- Replace Toothed Belt Tensioner
- How to Remove and Install the Cylinder Head
- How to Replace the Seal Ring - Camshaft
- Replace Intake Manifold - Petrol Engine
- Remove and Install Exhaust Manifold with Turbocharger
- Removing and Installing Both Camshafts
- Replace Engine Vent Pipe
- Removing and Installing Cup Tappet
- Replace Camshaft Sprockets
- How to Remove and Install the Piston with Con-Rod
- Replace Piston
- Check Con-Rod Bearing Clearance (With Plastigage)
- How to Check the Crankshaft Out-Of-Round
- Check Crankshaft Bearing Clearance (With Micrometer Gauge Internal Measuring Device)
- Check Crankshaft Bearing Clearance (With Plastigage)
- Replace Engine Oil Level Sensor
- Replace Turbocharger Oil Feed Line
- Replace Turbocharger Oil Return Line
- Cooling System, Charge and Bleed
- Replace Heat Exchanger
- Repair Lower Radiator Mounting Pin
- Repair Intercooler Mount
- Replace Engine Damping Blocks
- How to Remove and Install the Engine
- Remove and Install Manual Transmission on Engine (Engine Out)
- Checking and Adjustment Values - Dohc-I
- Toothed Belt
- Coolant Circuit
- Toothed Belt Diagnosis - Possible Causes and Remedys
- Engine Management System Illustration (Intake Side)
- Engine Management System Illustration (View of Engine Compartment)
- How to Remove and Install the Coolant Pump Drive Gear
- Spark Plug Damages - Possible Causes and Failure Modes
- Engine Z10/12/14XEP - Loss of Oil Between Oil Filter Modul and Engine Block
- How to Remove and Install the Drive Disk
- Replacing the Air Cleaner Housing
- How to Replace the Timing Case Seal Ring
- Replace All Valve Stem Seals (Cylinder Head Installed)
- How to Remove and Install the Attaching Parts - Cylinder Head
- How to Remove and Install the Oil Intake Pipe
- How to Remove from Engine and Install the Manual Transmission
- Oil Circulation
- Crankshaft Drive, Cylinder Block
- Illustration of Air Ducts
- How to Remove and Install the Crankshaft Wheel
- How to Replace the Seal Ring - Crankshaft (Front)
- Check Con-Rod Bearing Clearance (With Micrometer Gauge and Internal Measuring Device)
- Engine A/Z10/12/14XEP/L - Crankcase Ventilation Hoses Cracked
- How to Check the Oil Pressure
- How to Replace the Ribbed V-Belt, Tensioner
- Replacing Oil Dipstick Guide Tube
- Attach and Detach Engine to Engine Overhaul Stand
- Attach and Detach Automatic Transmission with Torque Converter
- Removing and Installing Air Cleaner Housing
- How to Check the Timing
- Replace Camshaft Sensor
- How to Remove and Install the Engine Control Unit
- How to Install and Remove the Accelerator Pedal
- ABS 8
- ABS 8/ESP
- Adhesive Foiles
- Air Conditioning
- Airbag
- Anti-Theft Warning System-M
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Car Level Control
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bonded)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Info Display Ccrt 700
- Instruments, Telltales
- Lpg
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Special Installations
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Stopp/start System
- Switches
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Распиновка разъёмов
