Remove
- 1. Remove crankshaft
- 2. Remove oil spray nozzles (1) using suitable tool
Install
- 3. Insert oil spray nozzles in cylinder block using KM-655
Note. Do not tilt oil spray nozzles during installation - ensure proper fitting
- 4. Install crankshaft
Home/Opel/Meriva/Opel Meriva A (2003-2011)/Repair manual/DOHC Diesel Engine/Replace Oil Spray Nozzles
Contents
Wiring diagrams Section: DOHC Diesel Engine- Air Mass Meter, 4 Cylinder Diesel
- Z 17 DT, Z 17 DTR Diesel Engine
- Battery / Starter, Diesel (Current Measurement)
- Replace Heat Shield Sleeve (Y 17 DT, Y 17 DTL, Y 30 DT, Z 30 DT)
- Compression 4-cylinder, Diesel
- How to Replace (Y 17 DT the Valve Guide (Y 17 DTL))
- Diesel Glow Plugs (Current Measurement), 4 Cylinder
- Z 13 DT DOHC Diesel Engine - Tigra-B, Meriva
- Load Pressure Sensor, Edc Hdrc
- Z 13 DTJ Diesel Engine
- Spill Valve (Diesel Injection Pump)
- Camshaft Sensor, Z17DT
- Z 17 DTH DOHC Diesel Engine
- High-Pressure Pump - Z 17 DTH Engine
- How to Remove and Install the Exhaust Gas Recirculation Valve
- How to Remove and Install the Pipe - Exhaust Gas Recirculation Valve
- How to Remove and Install the Solenoid Valve - Exhaust Gas Recirculation Valve
- Engine Identification Code / Engine Number
- Check Compression Pressure (Y 17 DT, with Air Conditioning, Lhd)
- Check Engine Pressure Loss (Y 17 DT, with Air Conditioning, Lhd)
- Check Engine Oil Pressure (Y 17 DT, with Air Conditioning, Lhd)
- Measure Oil Temperature (Y 17 DT, Y 17 DTL)
- Check Timing (Y 17 DT, with Air Conditioning, Lhd)
- Adjust Timing (Y 17 DT, with Air Conditioning, Lhd)
- Check Diesel Fuel Injection Pump Setting (Y 17 DT, with Air Conditioning, Lhd)
- Adjust Diesel Fuel Injection Pump (Y 17 DT, with Air Conditioning, Lhd)
- Test and Correct Toothed Belt Tension (Y 17 DT, with Air Conditioning, Lhd)
- Adjust Valve Play (Y 17 DT, with Air Conditioning, Lhd)
- Illustration Y 17 DT
- Replace Ribbed V-Belt (Y 17 DT, with Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Y 17 DT, with Air Conditioning, Lhd)
- Replace Front Toothed Belt Cover (Top) (Y 17 DT, with Air Conditioning, Lhd)
- Replace Front Toothed Belt Cover (Bottom) (Y 17 DT, with Air Conditioning, Lhd)
- Replace Toothed Belt (Y 17 DT, with Air Conditioning, Lhd)
- Replace Toothed Belt Tension Gear (Y 17 DT, with Air Conditioning, Lhd)
- Replace Toothed Belt Guide Roller (Y 17 DT, with Air Conditioning, Lhd)
- Replace Rear Toothed Belt Cover (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Camshaft Housing Cover (Y 17 DT, with Air Conditioning, Lhd)
- Replace Intake Manifold (Y 17 DT, with Air Conditioning, Lhd)
- Replace Exhaust Manifold Gasket (Y 17 DT, with Air Conditioning, Lhd)
- Replace Return Manifold (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Camshafts (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Camshaft Housing (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Cylinder Head (Y 17 DT, with Air Conditioning, Lhd)
- Replace Camshaft Seal Ring (Y 17 DT, with Air Conditioning, Lhd)
- Replace Rear Crankshaft Seal Ring (Y 17 DT, Without Air Conditioning, Rhd)
- Replace Front Crankshaft Seal Ring (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Flywheel (Y 17 DT)
- Engine Oil with Oil Filter Change (Y 17 DTL, Y 17 DT)
- Removing and Installing Oil Filter Housing (Y 17 DT, with Air Conditioning, Lhd)
- Replace Oil Pump Seal Ring (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Oil Pump (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Oil Pump Control Valve (Y 17 DT, with Air Conditioning, Lhd)
- Replace Oil Pressure Switch (Y 17 DT, with Air Conditioning, Lhd)
- Replace Oil Dipstick Guide Tube (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Oil Pan Lower Part (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Oil Pan Upper Part (Y 17 DT, with Air Conditioning, Lhd)
- Replace Dynamic Oil Level Monitoring Sensor (Y 17 DT, with Air Conditioning, Lhd)
- Replace Front Reaction Member (Y 17 DT, with Air Conditioning, Lhd)
- Replace Rear Reaction Member (Y 17 DT, with Air Conditioning, Lhd)
- Replace Right and Left Engine Damping Blocks (Y 17 DT, with Air Conditioning, Lhd)
- Replace Left Engine Damping Block (Y 17 DT, with Air Conditioning, Lhd)
- Replace Right Engine Damping Block (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Engine with Manual Transmission (Y 17 DT, with Air Conditioning, Lhd)
- Repair Engine Using an Engine Short Block (Y 17 DT, with Air Conditioning, Lhd)
- Detaching and Attaching Manual Transmission To/from Engine (Y 17 DT, with Air Conditioning, Lhd)
- Replace Charge Air Cooler (Y 17 DT, with Air Conditioning, Lhd)
- Replace Exhaust Gas Recirculation Valve (Y 17 DT, with Air Conditioning, Lhd)
- Replace Vacuum Pump (Z 17 DT, with Air Conditioning, Lhd)
- Special Service Tools
- Sealants, Lubricants and Locking Agents
- Specifications
- Checking and Adjustment Values
- Ribbed V-Belt
- Toothed Belt
- Oil Circuit
- Cylinder Head
- Crank Drive, Cylinder Block
- Torque Guide Values
- DOHC Diesel Engine (Z17 DTH) - Engine Number/engine Code
- Replace Ribbed V-Belt (Z 17 DTH, Without Air Conditioning, Lhd)
- How to Replace the Gasket - Intake Manifold Lower Part
- How to Replace the Exhaust Manifold Gasket
- Replace Exhaust Manifold (Z 17 DTH, Without Air Conditioning, Lhd)
- Engine Oil with Oil Filter Change (Z 17 DTH)
- Removing and Installing Oil Pan Lower Section (Z 17 DTH, Without Air Conditioning, Lhd)
- Removing and Installing Oil Filter Housing (Z 17 DTH, Without Air Conditioning, Lhd)
- Replace Oil Pressure Switch (Z 17 DTH, Without Air Conditioning, Lhd)
- Removing and Installing Oil Pan Upper Section (Z 17 DTH, Without Air Conditioning, Lhd)
- Replace Vacuum Pump (Z 17 DTH, Without Air Conditioning, Lhd)
- Special Tools (Z 17 DTH)
- Torque Guide Values (Z 17 DTH)
- Test Ribbed V-Belt Tensioner (Z 17 DTH)
- How to Replace (Z 17 DTH the Vacuum Pump Oil Feed Line (Without Air Conditioning, Lhd))
- Vacuum Pump Oil Return Hose (Z 17 DTH, Without Air Conditioning, Lhd)
- Check Compression Pressure (Z 17 DTH, Without Air Conditioning, Lhd)
- Check Timing (Z 17 DTH, Without Air Conditioning, Lhd)
- Adjust Timing (Z 17 DTH, Without Air Conditioning, Lhd)
- How to Check and Correct (Z 17 DTH the Toothed Belt Tension (Without Air Conditioning, Lhd))
- How to Measure (Z 17 DTH) the Oil Temperature
- How to Replace the Ribbed V-Belt Tensioner
- How to Replace (Z 17 DTH the Toothed Belt Guide Roller (Without Air Conditioning, Lhd))
- How to Remove and Install (Z 17 DTH the Upper Toothed Belt Cover (Without Air Conditioning, Lhd))
- How to Remove and Install (Z 17 DTH the Lower Toothed Belt Cover (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Toothed Belt (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Toothed Belt Tension Roller (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Toothed Belt Drive Gear (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Rear Toothed Belt Cover (Without Air Conditioning, Lhd))
- How to Replace the Camshaft Housing Cover
- How to Remove and Install the Cylinder Head
- How to Replace the Camshaft Seal Ring
- How to Replace (Z 17 DTH the Crankshaft Front Seal Ring (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Piston Rings (Without Air Conditioning, Lhd))
- How to Replace the Pistons
- How to Replace (Z 17 DTH the Front Reaction Member (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Rear Reaction Member (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Right-Hand Engine Damping Block (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Right and Left-Hand Engine Damping Blocks (Without Air Conditioning, Lhd))
- Repair Engine Using a Short Block Engine
- Manual Transmission from Engine, Detach and Attach (Z 17 DTH, Without Air Conditioning, Lhd)
- How to Replace the Oil Pump Drive Gear
- How to Replace the Oil Pump Seal Ring
- Check Engine Oil Pressure
- Checking Engine Pressure Loss
- Replacing Ribbed V-Belt Guide Roller
- How to Remove and Install the Crankshaft
- Measuring Crankshaft
- Replacing Oil Spray Nozzles
- How to Remove and Install the Oil Pump
- Replacing Oil Dipstick Guide Tube
- Replacing Con-Rod Bearings
- Checking Crankshaft / Crankshaft Longitudinal Play
- Illustration: Air Ducting
- Engine Number / Engine Identification Code
- Check Compression Pressure
- Check Engine Pressure Loss
- Replacing the Air Cleaner Housing
- How to Remove and Install the Ribbed V-Belt
- How to Remove and Install the Ribbed V-Belt Tensioning Device
- How to Remove and Install the Torsional Vibration Damper
- How to Check the Timing
- How to Remove and Install the Oil Pump Pressure Control Valve
- How to Remove and Install the Engine
- How to Remove and Install the Timing Case
- How to Replace the Hydraulic Chain Tensioner
- How to Replace the Timing Chain
- How to Replace the Camshaft Sprocket
- How to Replace the Toothed Belt Drive Gear - Crankshaft Sprocket
- How to Replace the Timing Chain Sliding Rail
- Replace Timing Chain Tension Rail
- Replace Inner Oil Pipe in Engine
- Seal Camshaft Housing in Respect of Cylinder Head
- How to Replace the Camshaft Housing
- Remove and Install Both Camshafts
- How to Replace the All Valve Tappets/hydraulic Valve Lifters
- How to Replace the Valve Stem Seals
- How to Remove and Install the Attaching Parts - Cylinder Head
- How to Check for Plane Surface the Cylinder Head
- Remove and Install All Pistons with Con-Rods
- Replace One Piston And/or Con-Rod
- How to Replace the Con-Rod Bearing
- How to Check (With Plastigage) the Con-Rod Bearing Play
- Check Crankshaft Axial Play
- Check Crankshaft Bearing Play (With Plastigage)
- Check Crankshaft Bearing Play (With Micrometer Gauge and Internal Measuring Instrument)
- How to Replace the Seal Ring - Rear Crankshaft
- How to Remove and Install the Flywheel
- Replace Oil Separator
- How to Remove and Install the Oil Filter Housing
- How to Replace the Engine Oil Cooler/heat Exchanger
- How to Remove and Install the Oil Pan
- Replace Oil Baffle Plate
- How to Check the Oil Pump
- How to Remove and Install the Oil Intake Pipe
- Replace Oil Spray Nozzles
- How to Remove from Engine and Install the Manual Transmission
- Replace Front Engine Suspension (Damping Block)
- Replace Rear Engine Suspension (Engine Damping Block)
- Replace Left Engine Suspension (Engine Damping Block)
- Replace Right Engine Suspension (Engine Damping Block)
- Replace Piston Rings
- Check Con-Rod Bearing Play (With Micrometer Gauge and Internal Measuring Instrument)
- Illustration of Engine Damping Blocks
- How to Replace the Accessory Drive
- Crankshaft Bearing System
- How to Replace the Oil Filter Module
- How to Replace the Oil Filler Neck
- How to Remove and Install the Engine Damping Block
- DOHC Diesel Engine Z17 DTR - Engine Number/engine Code
- How to Check the Ribbed V-Belt Tensioner
- How to Check the Compression
- How to Measure the Oil Temperature
- Checking Engine for Leaks
- How to Adjust the Timing
- How to Replace the Ribbed V-Belt
- How to Replace the Ribbed V-Belt Guide Roller
- How to Replace the Front Toothed Belt Cover (Upper)
- How to Replace the Front Toothed Belt Cover (Lower)
- How to Replace the Toothed Belt Drive Gear
- How to Replace the Toothed Belt Tensioning Device
- How to Replace the Toothed Belt Guide Roller
- How to Replace the Rear Toothed Belt Cover
- How to Remove and Install the Engine Cover
- How to Remove and Install the Intake Manifold
- How to Replace the Intake Manifold Intake Pipe
- How to Remove and Install the Exhaust Manifold
- How to Remove and Install the Camshaft Housing Cover
- How to Replace the Cup Tappets
- How to Check for Plane Surface the Camshaft Housing
- How to Replace the Exhaust Gas Recirculation Valve
- How to Replace the Exhaust Gas Recirculation Cooler
- How to Replace the Crankshaft Rear Seal Ring
- How to Replace the Crankshaft Front Seal Ring
- How to Check for Plane Surface the Cylinder Block
- How to Check (With Micrometer) the Con-Rod Bearing Play
- How to Replace the One Piston/con-Rod
- How to Check the Crankshaft End Play
- How to Check the Crankshaft Out-Of-Round
- How to Check (Calculate Bearing Clearance with Plastigage) the Crankshaft Bearing Clearance
- Engine Oil with Oil Filter Change
- How to Remove and Install the Oil Pump Drive Gear
- How to Replace the Pressure Relief Valve in Oil Circuit
- Replace Oil Pressure Sensor
- How to Remove and Install the Oil Pan Upper Part
- How to Remove and Install the Oil Pan Lower Part
- How to Replace the Front Reaction Member
- How to Replace the Rear Reaction Member
- How to Replace the Right Engine Damping Block
- How to Replace the Left Engine Damping Block
- How to Remove and Install the Air Intake Pipe
- Replace Rocker Arm
- How to Remove and Install the Bracket for Crankshaft Rear Seal Ring
- Replace Cooer, Exhaust Gas Recirculation Valve
- Replace Metering Unit
- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- ABS 8/ESP
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Anti-Theft Warning System-S
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- CAN Bus
- Central Door Locking System
- Central Electrics
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bolted)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Info Display Ccrt 700
- Instruments, Telltales
- Lpg
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses