- 1. see illustration of engine management system
Home/Opel/Astra/Opel Astra H (2004-2011)/Repair manual/Fuel Injection Systems/Replace Pre-Catalytic Converter Temperature Sensor
Contents
Wiring diagrams Section: Fuel Injection Systems- Measurement of the Diesel Fuel Return Quantity
- Engine Management Edc 16 C 39
- Measuring the Diesel Fuel Return Quantity of Bosch Solenoid Valve Injectors
- Injector Programming in Common Rail Engines
- Retrofit Kit for Diesel Particulate Filter - Z 19 DT, Z 19 DTH, Z 19 DTL Diesel Engines
- Replace Knock Sensor
- Replace Camshaft Sensor
- Replace Crankshaft Pulse Pick-Up
- Replace Throttle Valve Module
- Replacing Injection Valves
- Replace Mixture Regulator Lambda Sensor
- Replace Catalytic Converter Control Oxygen Sensor
- Replace Ignition Module
- How to Remove and Install the Spark Plugs
- Replace Hot Film Mass Air Flow Meter
- Replace Coolant Temperature Sensor
- How to Remove and Install the Engine Control Unit
- How to Remove and Install the Accelerator Pedal Module
- Engine Management
- Replace Injectors
- Replace Crankshaft Pulse Generator
- Replace Hot Film Mass Air Flow Sensor
- Replace Tank Vent Valve
- Replace Switchover Valve Solenoid Valve
- How to Install and Remove the Accelerator Pedal
- How to Remove and Install the Injectors
- How to Replace (Z16XEP) the Intake Pipe Pressure Sensor
- How to Replace (Z16XEP) the Intake Air Temperature Sensor
- How to Remove and Install (Z16XEP) the Engine Control Unit
- How to Remove and Install the Tank Vent Valve
- How to Replace (Z 20 LEL the Boost Pressure Sensor (Z 20 LER))
- Removing and Installing Throttle Valve Module
- Replace Fuel Pressure Regulator
- Replace Atmospheric Pressure Sensor
- Replacing the Air Cleaner Housing
- Replace Air Intake Pipe
- How to Remove and Install the High-Pressure Pump Drive Gear
- How to Remove and Install the Heat Protection Sleeve
- Replace EGR Valve
- How to Replace the High Pressure Fuel Lines, Pressure Chamber to Injectors
- Replace High Pressure Fuel Lines from High Pressure Pump to Accumulator
- How to Remove and Install the Accumulator
- Replace Pressure Regulator
- How to Remove and Install the One Injector
- How to Remove and Install the High-Pressure Pump
- Replace Fuel Return Line
- Replace Charge Pressure Sensor
- How to Replace the Pressure Chamber Pressure Sensor
- How to Remove and Install the Solenoid Valve - Turbocharger
- Diesel Engine - Booming Noise
- How to Remove and Install the Vacuum Unit Change-Over Valves
- Z17DTL/H Engine - ESP Warning Light Comes On. P0703 (58) Set, Svs Illuminates
- Replace Accelerator Pedal Module
- Z17DTH Engine - Wrong Indication of Engine Type (Z17DTL) in ECU After ECU Replacement
- Engine Z10XEP / Z12XE / Z14XEP (MY04 Only) - Ratting Noise from Timing Chain
- Engine Z19DT/Z19DTH - Oil Level Indicator Comes Up Too Early
- ECU - Svs Telltale on During Ignition On, DTC P0070 (71) And/or P1811 (72) Set
- Engine Z16XEP - Poor Take off Behavoir When Engine Cold
- Engine Z18XE / Z18XEL - Nocking / Ratting Noise from Engine Compartment
- Engine Z17DTL/H, High Pressure Pump (Engine Does Not Start or Stalls During Driving)
- Engine Z19DTH, Swirl Flap Actuator (Posibility for DTC P1109)
- Engine Z16XEP - Engine Sporadically Stalls with Depressed Clutch Pedal During Coasting
- Engine Z17DTL/H - Jerking at Steady State
- Engine Z14XEP - Trouble Code P1602 (4C) Stored in ECU After Sps Programming
- Engine Y/Z13DT/H/J - Bad Cold Start Behavior at Low Ambient Temperatures
- Engine Z19DT/L - Oil Level Warning Lamp Illuminates Too Late
- Engine Z18XER: Airflow Meter - Driveability Complaints, MIL On, Trouble Code P0100 Set, Deactivation of ESP
- Engine Z13DTH, ECU (Trouble Code U2105 Set, Crank No Start)
- Engine Z18XE - Jerking After Shifting
- Engine Z18XER - Different Driveability Complaints, DTC P0601 (30) Set
- Engine Z16/18XER - Trouble Code P0136(02), P0130(02) And/or P0170(12) Is Set
- Engine Z19DTH/J, Rail Pressure Sensor (Engine Stalls, Trouble Code P0190 (07) Set)
- How to Replace the Twinport Sensor
- How to Replace the Twinport Vacuum Unit
- Engine Z19DT/Z19DTL - Jerking in Certain RPM Range
- Replace High-Pressure Pump
- Replace Turbocharger Solenoid Valve
- Replace Pre-Heating System Control Unit
- Replace Oxygen Sensor
- Engine Z17DT/Z17DTR/Z17DTJ - Injector Malfunction DTC P0301-P0304 Is Set
- Engine Z19DT/L/H - Svs On, Trouble Code P2452(58), DPF Sensor Hose Malfunction Set
- Engine Z19DT/H/L - Changed Characteristic After Sps Programming with Tis 2000-DVD, Version 83
- Engine Z17/19DTx, Cylinder Balance Test (Rugh Idle, Engine Cuts Out)
- Engine Z16/18XER - No Start, Somtimes TC P0340 or P0365 Set
- Illustration of Common Rail
- Illustration of Air Duct
- Engine A/Z17DT/J/R, Turbocharger (Lack of Power, DTC P0234(52) Set)
- Engine Z13DT/J/H - Lack of Power After Rework 08-R-014 Was Done
- Engine Z16XER - Low Torque Below 2000 RPM
- How to Replace the High Pressure Fuel Lines, High Pressure Pump to Pressure Chamber
- Replace Oil Leak Line
- How to Replace the One Injector
- How to Remove and Install the Oil Regulating Valve
- How to Replace the Rail Pressure Sensor
- How to Remove and Install the Actuating Drive, Change-Over Valves
- Engine Z16XE1/XEP/XER/LEL/LET/LER, Z18XER (Oil Leakage Crankshaft Sealing Ring)
- Z13DTH Engine - P0190(07) Set, Stalls, Crank,but No Start, Unstable Idle
- How to Replace (With Air Conditioning) the Air Intake Hose for Intercooler
- Engine Z16XER - Low Idle (400-600 RPM) After Cold Start
- Engine Z16/18XE1/P/R, Thermostat (MIL On, Trouble Code P0115 Is Stored)
- Engine Z13DT/J/H - Smoke And/or Sizzling Noise from Cylinder Head
- Engine Z19DT/L, Agr Valve (Trouble Code P0400 (5A) Is Set)
- Z20LEH Engine - Flow Noise Out of the Engine When Engine Is Hot and Decelerating with 1500 - 2200 RPM.
- Engine A/Z/16/18XER - Rattling Noise Sometimes P0011 or P0014 Stored, Svs On
- How to Replace the One Fuel High Pressure Line (Pressure Reservoir - Injector)
- How to Replace (High Pressure Pump the Fuel High Pressure Line (Accumulator))
- Engine Z/A16LET/L/R - Does Not Start or Unstable Idle, 0 Mileage Defects Only
- How to Remove and Install the High Pressure Pump
- How to Remove and Install the Oil Leak Line
- How to Remove and Install the Crankshaft Pulse Pick-Up
- How to Remove and Install the Camshaft Sensor
- How to Remove and Install the Charge Pressure Sensor
- How to Replace the Accumulator Pressure Sensor
- How to Replace the Fuel Pressure Regulator (High Pressure)
- How to Replace the Oil Pressure Sensor
- Replace Engine Oil Level Sensor
- How to Remove and Install the Air Mass Flow Meter
- How to Remove and Install the Throttle Valve Body
- How to Replace the Throttle Valve Solenoid Valve
- How to Replace the Control Unit for Pre-Heating System
- Engine A/Z16/18XE/P/R, Thermostat Assembly (Engine Overheated)
- How to Replace the Oxygen Sensor, Mixture Regulation
- How to Replace the Vacuum Reservoir
- How to Remove and Install the Accelerator Pedal with Pedal Sensor
- Turbo Charger - Connection Turbo Charger to Intercooler Hose Leaky, Oil Mist.
- Engine Z12/14XEP - Jerking
- Engine A/Z17DTJ/R - Fuel Filter Heater Not Activated
- Engine Z16XE1 - Cruise Control Cannot Be Deactivated by Stalk Switch
- Engine Z/A17DTX, Engine Control Unit: (Hang Up During Programming with Mdi)
- A/Z17DTX Engine, Suction Control Valve (Engine Stalls, DTC P0093 Set.)
- Engine Z16XER, Coolant Temperatur Sensor (Svs on , P2182(17) Set)
- Engine Z16XEP - Poor Performance, MIL Illuminates, P0171 Fuel Trim System Lean Set.
- Engine A/Z17DTX: EGR Valve - Trouble Code P0400, P0403, P0409 Set
- How to Replace (Z 20 LEH) the Boost Pressure Sensor
- Engine A/Z17DTX, Turbocharger (Loss of Power, Trouble Code P0234, P0299 Set)
- Replace High-Pressure Pump Drive Gear
- Engine Z/A17DTX - Lack of Power and DPF Glogged, Svs On, DTC: P242F And/or P2003 Might Be Locked
- How to Remove and Install the Injector
- Replace Accumulator Sensor
- Replace Particle Filter Temperature Sensor
- Replace Differential Pressure Sensor
- Replace Pre-Catalytic Converter Temperature Sensor
- How to Replace the Metering Unit
- Engine Z13DTH, Electro Pneumatic Valve (Epv) (Lack of Power Dtc's P0108, P0243 Set)
- How to Replace the Mixture Regulator Oxygen Sensor
- How to Replace the Camshaft Sensors
- Replace Mass Air Flow Sensor
- Replace Fuel Return Damping Case
- Illustration of Common Rail System
- Illustration of Engine Management System
- Removing and Installing Charge Air Pipe
- Replace Exhaust Gas Recirculation Valve
- Replace Residual Oil Quantity Sensor
- How to Replace the High-Pressure Lines
- How to Replace the High-Pressure Fuel Lines, High-Pressure Pump to Pressure Chamber
- How to Replace the Pressure Chamber
- Replace Charge Pressure Control Solenoid Valve
- Replace Solenoid Valve for Intake Manifold Switchover Valve
- Replace Solenoid Valve for Exhaust Manifold Bypass
- Replace Throttle Valve Potentiometer
- How to Remove and Install the Sheathed Glow Plugs
- Particle Filter Temperature Sensor 1
- Particle Filter Temperature Sensor 2
- Replace Intake Pipe Pressure Sensor
- Replace Intake Air Temperature Sensor
- How to Replace the Twinport Solenoid Valve
- Remove and Install Fuel Rail
- Replace Mixture Regulator Oxygen Sensor
- Replace Dis Ignition Module
- How to Replace (Z 22 YH the Coolant Temperature Sensor (Rhd))
- Replace Fuel Pressure Sensor (High Pressure)
- How to Replace (Z 22 YH the Fuel Pressure Sensor (High Pressure) (Rhd))
- Remove Injectors from Cylinder Head
- Replace Intake Manifold Switchover Valve Control Motor
- How to Replace the Pedal Travel Sensor
- Replace Fuel Rail
- Illustration Engine Management A16XER, Z16XER
- ABS MK60 ESP
- ABS MK70
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Anti-Theft Warning System-M
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Car Level Control
- Central Door Locking System
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Ehps - Electrical Hydraulic Power Steering
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Electronic Ride Control
- Electronic Temperature Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Lpg
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Fog Lamp
- Rear Wheel Brake
- Roof
- Sac Semi Automatic Climate Control
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses