| Engine | Z 17 DTJ / Z 17 DTR / A 17 DTJ / A 17 DTR | ||
|---|---|---|---|
| Idle speed | |||
| with manual transmission | rpm | 850 | |
| with automatic transmission | rpm | - | |
| Cut-off speed | rpm | 4630 - 4830 | |
| Compression | kPa | 2600 - 3000- | |
| Pressure loss | not more than 25% per cylinder | ||
| Valve lash | |||
| (cold) | |||
| Intake valve | mm | 0.40 ± 0.05 | |
| Exhaust valve | mm | 0.40 ± 0.05 | |
Home/Opel/Astra/Opel Astra H (2004-2011)/Repair manual/DOHC Diesel Engine/Checking and Adjustment Values
Contents
Wiring diagrams Section: DOHC Diesel Engine- Battery / Starter, Diesel (Current Measurement)
- Compression 4-cylinder, Diesel
- Diesel Glow Plugs (Current Measurement), 4 Cylinder
- Introduction of the Z 13 DTH DOHC Engine - Astra-H Gtc
- CP1H High-Pressure Pump - Astra-H Gtc
- Torque and Power Curves for the Z 13 DTH Engine - Astra-H Gtc
- Z 13 DTH Intermediate Shaft Bracket - Astra-H Gtc
- CRIP2-MI Injector - Astra-H Gtc
- Load Pressure Sensor, Edc Hdrc
- Adjustment Data for Astra-H Z 13 DTH (1.3 CDTI Ecotec) 66 kW
- Adjustment Data for Astra-H Z 17 DTH (1.7 CDTI Ecotec) 74 kW
- Adjustment Data for Astra-H A 17 DTJ (1.7 CDTI Ecotec) 81 kW
- Adjustment Data for Astra-H Z 17 DTJ (1.7 CDTI Ecotec) 81 kW
- Adjustment Data for Astra-H A 17 DTR (1.7 CDTI Ecotec) 92 kW
- Adjustment Data for Astra-H Z 19 DT (1.9 CDTI Ecotec) 88 kW
- Adjustment Data for Astra-H Z 19 DTH (1.9 CDTI 16V Ecotec) 88 kW
- Adjustment Data for Astra-H Z 19 DTH (1.9 CDTI 16V Ecotec) 110 kW
- Common Rail Diesel - Z 17 DTL, Z 17 DTH, Z 19 DTH
- Fuel Rail Pressure Sensor
- DOHC Diesel Engine (Z 17 DTL / Z 17 DTH) - Engine Number/engine Code
- Testing Ribbed V-Belt Tensioner
- How to Check the Compression
- Check Engine Pressure Loss
- How to Measure the Oil Temperature
- How to Check the Engine Oil Pressure
- How to Adjust the Toothed Belt Tension
- Check Engine for Leaks
- How to Check the Timing
- How to Adjust the Timing
- Replace Ribbed V-Belt
- Replace Ribbed V-Belt Tensioner
- How to Replace the Ribbed V-Belt Guide Roller
- Replace Front Toothed Belt Cover (Top)
- Replace Front Toothed Belt Cover (Lower)
- Replace Toothed Belt
- Replace Toothed Belt Drivewheel
- Replace Toothed Belt Tensioner
- Toothed Belt Guide Roller. Replace
- Replace Rear Toothed Belt Cover
- Check and Adjust Valve Play
- How to Remove and Install the Engine Cover
- How to Remove and Install the Camshaft Housing Cover
- Replace Intake Manifold
- How to Remove and Install the Change-Over Valve Housing
- How to Replace the Seal Ring - Camshaft
- How to Remove and Install the Camshaft Sprocket
- Removing and Installing Both Camshafts
- How to Replace the Camshaft Housing
- Check Camshaft Housing for Plane Surface
- How to Remove and Install the Cylinder Head
- How to Check for Plane Surface the Cylinder Head
- How to Remove and Install the Attaching Parts - Cylinder Head
- How to Remove and Install the Flywheel
- How to Remove and Install the Bracket for Crankshaft Seal Ring (Rear)
- Replace Crankshaft Seal Ring (Rear)
- Replace Crankshaft Seal Ring (Front)
- How to Replace the Con-Rod Bearing
- Check Con-Rod Bearing Clearance (With Plastigage)
- Check Con-Rod Bearing Clearance (With Micrometer)
- How to Remove and Install the Piston with Con-Rod
- How to Replace the Piston Rings
- Replacing One Piston / Con-Rod
- How to Remove and Install the Crankshaft
- How to Check the Crankshaft End Play
- How to Check the Crankshaft Out-Of-Round
- Determine Crankshaft Bearing Clearance (Determine Bearing Clearance with Plastigage)
- Check Crankshaft Bearing Clearance (With Micrometer Gauge Internal Measuring Device)
- How to Check for Plane Surface the Cylinder Block
- Engine Oil with Oil Filter Change
- How to Remove and Install the Oil Filter Housing
- How to Remove and Install the Oil Pump Drive Gear
- How to Remove and Install the Oil Intake Pipe
- How to Remove and Install the Oil Pump
- Replace Oil Pump Seal Ring-
- How to Check the Oil Pump
- How to Remove and Install the Excess Pressure Valve
- How to Remove and Install the Oil Pressure Regulating Valve
- Replace Oil Pressure Switch
- Replace Engine Oil Level Sensor
- Replace Oil Dipstick Guide Tube
- How to Remove and Install the Lower Part of Oil Pan
- How to Remove and Install the Upper Part of Oil Pan
- Replace Engine Damping Block (Front)
- Replace Engine Damping Block (Rear)
- Replace Left Engine Damping Block
- Replace (Right) Engine Damping Block
- How to Remove and Install the Engine
- How to Remove from Engine and Install the Manual Transmission
- Engine Maintenance Using a Section Engine
- How to Remove and Install the Vacuum Pump
- Special Service Tools
- Sealants, Lubricants and Locking Agents
- Specifications
- Checking and Adjustment Values
- Ribbed V-Belt
- Toothed Belt
- Oil Circulation
- Cylinder Head
- Crankshaft Drive, Cylinder Block
- DOHC Diesel Engine (Z 19 DTH / Z 19 DTH (120PS)) - Engine Number/engine Code
- Check Ribbed V-Belt
- Replace Upper Ribbed V-Belt Guide Roller
- Replace Toothed Belt Guide Roller
- Replace Exhaust Gas Recirculation Valve
- Replacing Front Crankshaft Seal Ring
- Replace Residual Oil Quantity Sensor
- Replace Oil Baffle Plate
- Replace Engine Oil Filling Nozzle
- Replace Right Engine Damping Block
- Torque Guide Values
- How to Replace the Camshaft Sprocket
- How to Remove and Install the Camshaft Housing
- How to Remove and Install the Camshafts
- Attach and Detach Attaching Parts
- Removing and Installing Roller Cam Followers
- How to Remove and Install the Hydraulic Valve Lifter
- How to Check the Longitudinal Play of Crankshaft
- Replace Oil Pump Seal Ring
- How to Remove and Install the Oil Pump Pressure-Regulating Valve
- How to Remove and Install the Oil Spray Nozzles
- Illustration of Air Duct
- Illustration of Common Rail System
- Illustration of Coolant Hoses
- Vacuum Routing in the Engine Compartment
- Engine Number/engine Code
- How to Remove and Install the Ribbed V-Belt
- How to Remove and Install the Ribbed V-Belt Tensioner
- How to Replace the Hydraulic Chain Tensioner
- How to Replace the Timing Chain
- How to Replace the Toothed Belt Drive Gear - Crankshaft Sprocket
- How to Replace the Timing Chain Sliding Rail
- Replace Timing Chain Tension Rail
- How to Replace the Oil Spray Nozzle (Tube), Timing Chain
- How to Remove and Install the Torsional Vibration Damper
- How to Remove and Install the Exhaust Manifold
- Seal Camshaft Housing in Respect of Cylinder Head
- How to Replace the All Valve Tappets/hydraulic Valve Lifters
- How to Replace the Valve Stem Seals
- Replace EGR Cooler
- How to Check (With Plastigage) the Con-Rod Bearing Play
- How to Replace the Seal Ring - Rear Crankshaft
- How to Replace the Engine Oil Cooler/heat Exchanger
- How to Remove and Install the Oil Dipstick Guide Tube
- How to Replace the Intake Pipe for Oil Pump
- How to Remove and Install the Left Engine Damping Block
- How to Remove and Install the Right Engine Damping Block
- Recommended Torque Values
- How to Remove and Install the All Pistons with Con-Rod
- Replace One Piston And/or Con-Rod
- Check Con-Rod Bearing Clearance (With Micrometer Gauge and Internal Measuring Device)
- Check Crankshaft Axial Play
- Check Crankshaft Bearing Clearance (With Plastigage)
- Repair Engine Using a Short Block
- Pressure Loss Test, Charge Air System
- DOHC Diesel Engine Z 17 DTR, Z17DTJ, A 17 DTR and A17DTJ (Engine Number/engine Code)
- How to Replace the Toothed Belt Tensioner
- How to Replace the Intake Manifold Intake Pipe
- How to Replace the Cup Tappets
- How to Replace the Pressure Relief Valve in Oil Circuit
- Replace the Oil Spray Nozzle
- Replace Lower Ribbed V-Belt Guide Roller
- ABS MK60 ESP
- ABS MK70
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Anti-Theft Warning System-M
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Car Level Control
- Central Door Locking System
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Ehps - Electrical Hydraulic Power Steering
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Electronic Ride Control
- Electronic Temperature Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Lpg
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Fog Lamp
- Rear Wheel Brake
- Roof
- Sac Semi Automatic Climate Control
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses