| Engine | Z 17 DTR | ||
|---|---|---|---|
| Idle speed | |||
| Manual transmission up to MY 08 | rpm | 850 - 1000 | |
| Manual transmission from MY 08 | rpm | 850 | |
| Cut-off speed | rpm | 4630 -- 4830 | |
| Compression | kPa | 2600 - 3000- | |
| Pressure loss | not more than 25% per cylinder | ||
| Valve lash | |||
| (cold) | |||
| Intake valve | mm | 0.40 ± 0.05 | |
| Exhaust valve | mm | 0.40 ± 0.05 | |
Home/Opel/Corsa/Opel Corsa D (2007-2011)/Repair manual/Fuel Injection Systems/Checking and Adjustment Values
Contents
Wiring diagrams Section: Fuel Injection Systems- Measurement of the Diesel Fuel Return Quantity
- Common Rail System
- Replace Air Cleaner Housing
- How to Replace the Resonator
- Switch to Pressure-Based Engine Load Measurement Me 7.6.2
- Measuring the Diesel Fuel Return Quantity of Bosch Solenoid Valve Injectors
- Remove and Install Accumulator
- How to Remove and Install the High-Pressure Pump
- Replace Fuel High Pressure Line - Pressure Accumulator - Injector
- Replace Fuel High Pressure Line (High Pressure Pump - Accumulator)
- Remove and Install Oil Leak Line
- Replace Sheathed Glow Plugs
- Replace Pre-Heating System Control Unit
- Remove and Throttle Valve Module
- Replace Mixture Regulation Oxygen Sensor
- Remove and Refit Drive Pedal Module
- Engine Management
- Torque Guide Values -
- How to Remove and Install the Pulse Pick-Up, Crankshaft
- Removing and Installing Camshaft Sensor
- Replace Coolant Temperature Sensor
- Removing and Installing Charge Pressure Sensor
- Replace Pressure Sensor, Accumulator
- Remove and Install Mass Air Flow Meter
- Replace Differential Pressure Sensor
- Replace Particle Filter Temperature Sensor
- Replace Injectors
- Replace Air Intake Pipe
- How to Remove and Install the High-Pressure Pump Drive Gear
- How to Replace the High-Pressure Lines
- Replace Fuel Line from High Pressure Pump to Pressure Reservoir
- How to Remove and Install the One Injector
- Replace Pressure Reservoir
- Replace Fuel Return Line
- How to Replace the Metering Unit
- Replace Crankshaft Pulse Generator
- Replace Camshaft Sensor
- Replace Charge Air Sensor
- Replace Charge Pressure Control Solenoid Valve
- Replace Solenoid Valve for Exhaust Manifold Bypass
- Replace Throttle Valve Potentiometer
- Replace Hot Film Mass Air Flow Sensor
- How to Remove and Install the Engine Control Unit
- How to Remove and Install the Sheathed Glow Plugs
- Replace Oxygen Sensor
- Replace Pre-Catalytic Converter Temperature Sensor
- Replace Rear Particulate Filter Temperature Sensor
- Torque Guide Values
- Replace Ignition Module
- Removing and Installing Throttle Valve Module
- Replace Intake Pipe Pressure Sensor
- Replace Knock Sensor
- Replace Throttle Valve Module
- Replace Coolant Connection Coolant Temperature Sensor
- Replace Catalytic Converter Monitor Oxygen Sensor
- Replace Mixture Regulator Lambda Sensor
- Replace Catalytic Converter Control Oxygen Sensor
- Removing and Installing Air Cleaner Housing
- Removing and Installing Fuel Rail
- Replace Spark Plugs
- Replace Vacuum Control Solenoid Valve
- How to Remove and Install the Accelerator Pedal Module
- Replace Servo Motor for Intake-Manifold Switchover Valves
- Replace Pressure Relief Valve
- Engine Y/Z13DT/H/J - Bad Cold Start Behavior at Low Ambient Temperatures
- Engine Z13DTJ/H - Diesel Particulate Filter System DTC P1901(7) Set Together with P2003(7)
- Engine Z13DTH, ECU (Trouble Code U2105 Set, Crank No Start)
- Replacing the Air Cleaner Housing
- Replace Air Induction Pipe
- Removing and Installing Charge Air Pipe
- How to Remove and Install the High Pressure Pump Drive Gear
- Replace Induction Pipe from Intake Manifold
- Engine Z17DT/DTR - Poor Drive Off
- Replace Oil Pressure Sensor
- Replace Oil Level Sensor
- Engine Z17DT/R - Trouble Code P0425(2) and P042A(2) Set
- Replace High-Pressure Lines
- How to Replace the High Pressure Fuel Line, High Pressure Pump to Pressure Chamber
- Replace the Accumulator
- How to Remove and Install the High Pressure Pump
- Replace Crankshaft Pulse Pick-Up
- Replace Charge Pressure Sensor
- Replace Charge-Air Control Solenoid Valve
- Replace Solenoid Valve, Change-Over Flaps, Intake Manifold
- Replace Bypass Solenoid Valve Intake Manifold
- Replace Throttle Potentiometer
- Replace Hot Film Mass Air Flow Meter
- Special Service Tools
- Engine Z17DT/Z17DTR/Z17DTJ - Injector Malfunction DTC P0301-P0304 Is Set
- Checking and Adjustment Values
- Replace Particulate Filter Temperature Sensor
- Replace Primary Catalytic Converter Temperature Sensor
- Replace Temperature Sensor Behind Particulate Filter
- Engine A/Z17DT/J/R, Turbocharger (Lack of Power, DTC P0234(52) Set)
- Engine Z13DT/J/H - Lack of Power After Rework 08-R-014 Was Done
- Engine A/Z16LEL (Gsi) - Noise During Acceleration
- Remove and Install Air Intake Pipe
- Replace Charge Air Pipe
- Engine Z16XE1/XEP/XER/LEL/LET/LER, Z18XER (Oil Leakage Crankshaft Sealing Ring)
- Engine Z12XEP - Rough Idle and Bad Throttle Response After Cold Start
- Z13DTH Engine - P0190(07) Set, Stalls, Crank,but No Start, Unstable Idle
- Engine Z13DT/J/H - Smoke And/or Sizzling Noise from Cylinder Head
- Replace Fuel Pressure Regulator (High Pressure)
- Replace Engine Oil Level Sensor
- Remove and Install Throttle Valve Connector (Z13DTH)
- Replace Solenoid, Throttle Valve (Z13DTH)
- Engine Z/A16LET/L/R - Does Not Start or Unstable Idle, 0 Mileage Defects Only
- Intercooler - Connection to Turbo Charger Boost Hose Leaky, Oil Mist
- Turbo Charger - Connection Turbo Charger to Intercooler Hose Leaky, Oil Mist.
- Engine Z12/14XEP - Jerking
- Illustration of Engine Management System (Intake Side)
- Illustration of Engine Management System (Engine Compartment View)
- Engine Z/A17DTX, Engine Control Unit: (Hang Up During Programming with Mdi)
- A/Z17DTX Engine, Suction Control Valve (Engine Stalls, DTC P0093 Set.)
- Engine Z13DTJ - Lack of Power, DTC P2002 (07) Set.
- Engine A/Z17DTX: EGR Valve - Trouble Code P0400, P0403, P0409 Set
- How to Replace the Twinport Vacuum Unit
- Replace Intake Air Temperature Sensor
- Replace Mixture Regulator Oxygen Sensor
- Engine A/Z17DTX, Turbocharger (Loss of Power, Trouble Code P0234, P0299 Set)
- Replacing Injection Valves
- How to Remove and Install the Spark Plugs
- Engine Z13DTJ/H - Trouble Code P0683 Set
- Illustration of the Engine Management System (Intake Side)
- Engine A12XEL/R - Engine Stalls with Pressed Clutch and High Ambient Temperature
- How to Replace the Intake Pipe Pressure Sensor
- How to Replace the Air Intake Temperature Sensor
- Replace Fuel Rail
- ABS 8
- ABS 8/ESP
- Adhesive Foiles
- Air Conditioning
- Airbag
- Anti-Theft Warning System-M
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Car Level Control
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bonded)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Info Display Ccrt 700
- Instruments, Telltales
- Lpg
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Special Installations
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Stopp/start System
- Switches
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses