Important. Security code must be reset with TECH 2 before replacing or swapping the engine control unit
- 1. see engine management system illustration
Home/Opel/Meriva/Opel Meriva A (2003-2011)/Repair manual/Fuel Injection Systems/How to Remove and Install the Engine Control Unit
Contents
Wiring diagrams Section: Fuel Injection Systems- Measurement of the Diesel Fuel Return Quantity
- Measuring the Diesel Fuel Return Quantity of Bosch Solenoid Valve Injectors
- Damper Casing, Fuel Return (Z 13 DTJ Diesel Engine)
- Injector Programming in Common Rail Engines
- Engine Management System - Z 17 DTH Engine
- How to Remove and Install (Z 18 XE the Throttle Valve Module (With AC, Lhd))
- Replace Injection Valves (Z 18 XE, with AC, Lhd)
- Replace Lambda Sensor, Mixture Regulator (Z 18 XE, with AC, Lhd)
- Replace Lambda Sensor, Catalytic Converter Control (Z 18 XE, with AC, Lhd)
- How to Remove and Install (Z 18 XE the Dis-Ignition Module (With AC, Lhd))
- Replace Crankshaft Sensor (Z 18 XE)
- Replace Camshaft Sensor (Z 18 XE, with AC, Lhd)
- Replace Knock Sensor (Z 18 XE, with AC, Lhd)
- Replace Hot Film Mass Air Flowmeter (Z 18 XE, with AC, Lhd)
- Engine - Stalling
- Z18XE Engine - Jerking at Partial Load and P1555 (All Symptom Bytes) Stored in ECU
- Common Rail Engines - Bad Idle, Lack of Power After ECU or Injector Replacement
- Z16XE, Z16SE Engine Throttle Actuator (Failure Code P1500 and P1550 (A+b) Set, Engine Running in Emergency-Operation Mode)
- Z16XE, Z16SE Engine (Idle Speed Fluctuating When High Electrical Load Is Applied)
- Z16XE, Z16SE Engine (Battery Charge Indicator Flashes Sporadically. TC B1485 (9) Is Stored in the BCM.)
- Meriva - Engine Does Not Start at Temperatures Below Minus 10° Celsius
- Air Cleaner Housing - Water Ingress
- Engine Z16XE/SE - P0335(0) Crankshaft Sensor Failure
- Engine Z16XE/SE - P0120(8) Throttle Position Sensor Failure
- Engine Z17DTH, High Pressure Pump (Reset of Learned Values After Replacement of High Pressure Pump)
- Engine Y17DT/L - Start Problems During Wiper Motor Is On, TC P0370(4) Set
- Replace Fuel Injection Lines (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Fuel Injection Nozzles (Y 17 DT, with Air Conditioning, Lhd)
- Replace Fuel Injection Pump (Y 17 DT, with Air Conditioning, Lhd)
- Replacing Injection Pump Control Unit (Y 17 DT, with Air Conditioning, Lhd)
- Replacing Inner Oil Leak Line (Y 17 DT, with Air Conditioning, Lhd)
- Replacing Outer Oil Leak Line (Y 17 DT, with Air Conditioning, Lhd)
- Replace Crankshaft Pulse Generator (Y 17 DT, with Air Conditioning, Lhd)
- Replace Coolant Temperature Sensor (Y 17 DT, with Air Conditioning, Lhd)
- Replace Charge Pressure Sensor
- Replace Atmospheric Pressure Sensor (Y 17 DT, with Air Conditioning, Lhd)
- Replace Hot Film Mass Air Flow Sensor (Y 17 DT, with Air Conditioning, Lhd)
- Removing and Installing Engine Control Unit (Y 17 DT, with Air Conditioning, Lhd)
- Replace Pedal Position Sensor (Y 17 DT, with Air Conditioning, Lhd)
- Engine Management
- How to Replace (Z 17 DTH the Crankshaft Sensor (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Camshaft Sensor (Without Air Conditioning, Lhd))
- Replace Coolant Temperature Sensor (Z 17 DHT, Without Air Conditioning, Lhd)
- Replace Charge Pressure Sensor (Z 17 DTH, Without Air Conditioning, Lhd)
- Replace Hot Film Mass Air Flow Meter (Z 17 DTH, with Air Conditioning, Lhd)
- How to Replace (Z 17 DTH the Solenoid Valve - Boost Pressure Control (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Solenoid Valve - Intake Manifold Switchover Valves (Without Air Conditioning, Lhd))
- How to Replace (Z 17 DTH the Dynamic Oil Level Check Sensor (Without Air Conditioning, Lhd))
- Replace Throttle Valve Module (Z 17 DTH, Without Air Conditioning, Lhd)
- Replace Pedal Sensor (Z 17 DTH)
- Engine Z17DTH, Turbocharger (Trouble Code P1243 (Turbo Boost Positive Deviation) Set)
- How to Remove and Install (Z 17 DTH the Air Cleaner Housing (Without Air Conditioning, Lhd))
- Engine Z13DTJ - Idle Speed Deviation When Engine Is Cold
- Engine Z16XE - High Oil Consumption
- Engine Y/Z13DT/H/J - Bad Cold Start Behavior at Low Ambient Temperatures
- How to Replace the Injectors
- How to Replace (Z 17 DTH the High Pressure Lines (Injector Pressure Accumulator) (Without Air Conditioning, Lhd))
- Engine Z17DTH - DTC P0602(A) Set After Replacement of Fuel Injector
- Replacing Accumulator
- How to Replace the Fuel Return Line
- Replacing Atmospheric Pressure Sensor
- Engine Z13DTJ/H - Diesel Particulate Filter System DTC P1901(7) Set Together with P2003(7)
- Engine Z17DTH, TECH2 Programming (Error Massage After Injector Programming)
- Engine Z17DTH - Stalls, Trouble Code P0093 Set in ECU
- How to Check the Fuel Pressure
- Replacing the Air Cleaner Housing
- Replace Knock Sensor
- Replace Camshaft Sensor
- Replace Crankshaft Pulse Pick-Up
- Replace Mixture Regulator Lambda Sensor
- Replace Catalytic Converter Control Oxygen Sensor
- Replace Ignition Module
- Engine Z10/12/14XEP - Lack of Performance, Misfire Failure Code Stored in ECU
- How to Remove and Install the Spark Plugs
- Replace Hot Film Mass Air Flow Meter
- Engine Z17DT/DTR - Poor Drive Off
- Replace Coolant Temperature Sensor
- How to Remove and Install the Engine Control Unit
- Replace Twinport Sensor
- Replace Twinport Vacuum Unit
- Replace Accelerator Pedal Module
- Engine Z17DT/R - Trouble Code P0425(2) and P042A(2) Set
- Engine Z17DTH - Instable Idle Running or Engine Stalls in Cold Condition
- Replace High Pressure Line (High Pressure Pump Accumulator) (Z 17 DTH, with Air Conditioning, Lhd)
- Illustration: Common Rail System
- Replace Fuel High Pressure Lines - Accumulator - Injector
- Replace Fuel High Pressure Line (Accumulator High Pressure Pump)
- How to Remove and Install the Accumulator
- How to Remove and Install the Leakage Oil Line
- How to Remove and Install the Crankshaft Pulse Pickup
- How to Remove and Install the Camshaft Sensor
- How to Remove and Install the Charge Pressure Sensor
- Replace Accumulator Pressure Sensor
- Replace Fuel Pressure Controller (High Pressure)
- Replace Oil Pressure Sensor
- Engine Z17DT/Z17DTR/Z17DTJ - Injector Malfunction DTC P0301-P0304 Is Set
- How to Remove and Install the Mass Air Flow Sensor
- How to Remove and Install the Accelerator Pedal with Pedal Travel Sensor
- Replace High Pressure Pump
- Engine A/Z17DT/J/R, Turbocharger (Lack of Power, DTC P0234(52) Set)
- Illustration of Engine Management System / Sensors
- Engine Z13DT/J/H - Lack of Power After Rework 08-R-014 Was Done
- How to Replace the Fuel Return Damper Housing
- How to Replace the Particulate Filter Temperature Sensor
- How to Replace the Differential Pressure Sensor
- Engine Z16XE1/XEP/XER/LEL/LET/LER, Z18XER (Oil Leakage Crankshaft Sealing Ring)
- Replace Throttle Valve Module
- How to Remove and Install the Injectors
- How to Replace the Mixture Control Oxygen Sensor
- Engine Z13DT/J/H - Smoke And/or Sizzling Noise from Cylinder Head
- How to Replace the Intake Manifold Pressure Sensor
- How to Remove and Install the Tank Vent Valve
- Illustration - Engine Management System
- Engine Z/A16LET/L/R - Does Not Start or Unstable Idle, 0 Mileage Defects Only
- Engine A/Z16/18XE/P/R, Thermostat Assembly (Engine Overheated)
- Turbo Charger - Connection Turbo Charger to Intercooler Hose Leaky, Oil Mist.
- Engine Z12/14XEP - Jerking
- Replacing Injection Valves
- How to Remove and Install the Fuel Rail
- How to Remove and Install the Accelerator Pedal Module
- A/Z17DTX Engine, Suction Control Valve (Engine Stalls, DTC P0093 Set.)
- Engine Z16XEP - Poor Performance, MIL Illuminates, P0171 Fuel Trim System Lean Set.
- Engine A/Z17DTX: EGR Valve - Trouble Code P0400, P0403, P0409 Set
- How to Replace the Spark Plugs
- Engine A/Z17DTX, Turbocharger (Loss of Power, Trouble Code P0234, P0299 Set)
- Engine Management Illustration
- How to Replace the Air Intake Pipe
- How to Replace the Charge Air Pipe
- How to Remove and Install the High Pressure Pump Drive Gear
- How to Replace the Residual Oil Quantity Sensor
- How to Replace the High Pressure Lines
- How to Replace the High Pressure Fuel Line Between High Pressure Pump and Accumulator
- How to Remove and Install the One Injector
- How to Remove and Install the High Pressure Pump
- How to Replace the Charge Pressure Control Solenoid Valve
- How to Replace the Solenoid Valve - Intake Manifold Switchover Valve
- How to Replace the Solenoid Valve - Exhaust Manifold Bypass
- How to Replace the Throttle Valve Potentiometer
- How to Replace the Control Unit - Pre-Heating System
- How to Remove and Install the Sheathed Glow Plugs
- How to Replace the Oxygen Sensor
- How to Replace the Temperature Sensor - Pre-Catalytic Converter
- How to Replace the Temperature Sensor Behind Particulate Filter
- How to Replace the Pedal Sensor
- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- ABS 8/ESP
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Anti-Theft Warning System-S
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- CAN Bus
- Central Door Locking System
- Central Electrics
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bolted)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Info Display Ccrt 700
- Instruments, Telltales
- Lpg
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Servo Motors
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses