- 1. Grind valve • Lubricate valve stem with oil • Use fine-grained grinding paste, ensure even distribution around valve head, grind valve rhythmically
- 2. Inspect valve for correct contact over entire circumference
- 3. Clean valve and cylinder head
Contents
Wiring diagrams Section: Diesel Engine- Air Mass Meter, 4 Cylinder Diesel
- Battery / Starter, Diesel (Current Measurement)
- Compression 4-cylinder, Diesel
- Diesel Glow Plugs (Current Measurement), 4 Cylinder
- Camshaft Sensor, F9Q, Y26SE, Y32SE, Z32SE, ZD3
- Accessory Drive Belt for F9Q 760 and F9Q 762 Engines
- Pedal Position Double Signal, Diesel (MY2002, MY 2003 and MY2004)
- Engine Number
- How to Measure the Fuel Consumption
- Adjustment Data for Vivaro F9Q U760 (1.9 CDTI) 74 kW
- How to Replace (With Air Conditioning) the Ribbed V-Belt, Tensioner and Guide Roller
- Special Service Tools (Group J)
- Torque and Output Curves, F9Q 760
- Technical Data (Group J)
- Recommended Torque Values (Group J)
- Air Mass Meter, F9Q, G9T, G9U
- OHC Diesel Engines F9Q 760 and F9Q 762, General
- Injector, Common Rail Diesel, F9Q and Y25DT
- Exhaust Gas Recirculation Valve, F9Q
- How to Replace (F9Q 760) the Air Cleaner Element
- How to Replace the Exhaust Manifold
- How to Replace the Intake Manifold
- How to Remove and Install the Vacuum Pump
- How to Replace the Engine Oil Filter
- How to Replace the Engine Oil with Filter
- How to Check the Engine Oil Pressure
- How to Measure (F9Q 760 the Oil Consumption (F9Q 762))
- How to Check (F9Q 760) the Timing
- How to Replace (F9Q 760) the Timing Belt
- How to Replace the Oil Pan And/or Gasket
- How to Replace the Engine Oil Level Sensor
- How to Replace the Oil Pressure Switch
- How to Check the Compression
- How to Check and Replace (F9Q 760) the Timing Belt
- How to Remove and Install the Engine Cover Insulation
- How to Replace (F9Q 760) the Tensioner, Timing Belt
- How to Remove and Install the Oil Pump and Pick-Up Filter
- How to Replace the Tension Roller, Ribbed V-Belt
- How to Check the Valve Clearance
- How to Remove and Install the Cylinder Head Cover
- How to Remove and Install the Engine with Transmission
- How to Check the Timing
- How to Replace the Timing Belt
- How to Replace the Tensioner, Timing Belt
- How to Replace the Oil Separator
- How to Replace the Pipe, Oil Separator to Turbocharger Inlet Hose
- How to Replace the Engine Damping Block, Right Side
- How to Replace the Engine Damping Block, Left Side
- How to Replace the Engine Stabiliser, Upper
- How to Replace the Engine Stabiliser, Lower
- How to Replace the Camshaft Pulley
- How to Replace the Camshaft Oil Seal
- How to Replace the Front Cover, Timing Belt
- How to Check the Engine Pressure Loss
- How to Measure the Engine Oil Temperature
- How to Replace the Hose, Oil Separator to Engine, Lower
- Fuel Injection Pump Engine Poor Idling
- How to Replace the Pulley, High Pressure Pump
- How to Check and Replace the Con-Rod or Piston
- How to Check the Crankshaft, Lateral Play
- How to Check the Crankshaft Bearing Clearance (Plastigage Method)
- How to Check (Micrometer Method) the Crankshaft Bearing Clearance
- How to Replace the Crankshaft Oil Seal, Rear
- How to Check the Oil Pump
- How to Replace the Oil Spray Nozzles
- How to Check for Plane Surface the Cylinder Head
- How to Check the Valve Protrusion from Cylinder Head
- Valve Seat, Cut
- Valve, Grind-In
- How to Replace the Con-Rod Bearings
- How to Replace the Crankshaft Oil Seal, Front
- How to Measure the Oil Consumption
- How to Replace the Pulley, Crankshaft, Timing Belt
- How to Replace (Without Air Conditioning) the Ribbed V-Belt and Tensioner
- How to Check the Vacuum Pump
- 'Poor Roads' Equipment
- ABS
- ABS 430
- ABS 8
- Accessories
- Additional Lighting
- Adhesive Foiles
- Air Conditioning
- Air Conditioning, Rear
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Colour Info Display
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Diesel Engine
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Cruise Control
- Electronic Module
- Electronic Temperature Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bolted)
- Glassfibre Parts (Bonded)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Info Display Ccrt 700
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Parkpilot
- Power Steering
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Welded)
- Special Installations
- Steering
- Steering Coupling
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
