| Engine | X 17 DTL | ||
|---|---|---|---|
| Designation | EDC 15 M | ||
| Distributor injection pump | |||
| Designation | VP 29 | ||
| Injection sequence | 1-3-4-2 | ||
| Injector nozzle | |||
| Type | |||
| Opening pressure | kPa | 13000 - 14300 | |
Contents
Wiring diagrams Section: Diesel Engine- Air Mass Meter, 4 Cylinder Diesel
- Checklist Y17DT for Feedback - Astra-G
- Battery / Starter, Diesel (Current Measurement)
- Replace Heat Shield Sleeve (Y 17 DT, Y 17 DTL, Y 30 DT, Z 30 DT)
- Compression 4-cylinder, Diesel
- Crankshaft Impulse Sensor, Diesel
- Crankshaft Sensor (Hall Type), Astra-G Y17DT (MY 2000)
- Diesel Glow Plugs (Current Measurement), 4 Cylinder
- Load Pressure Sensor, PSG16, Denso 0100, Dde 4.0, G9T 750, G9U 754,Z13DT, Z19DT(H), Z20LEL
- Y 20 DTH OHC 16 V Engine
- Engine Management System Edc 15 M, Y 20 DTH
- Air Ducts/charge Air, Y 20 DTH (Charge Air Hoses, Y 20 DTH)
- Illustration of Air Duct, Y 20 DTH
- Exhaust System, X 20 XER
- Pedal Position, Astra Y17DT (MY 2000)
- Illustration of Exhaust System, X 20 XER
- OHC 16V Diesel Engine Y 22 DTR
- Pedal Position Single Signal, Astra-G/zafira, Diesel (MY 2000)
- Engine, Engine Attaching Parts X 17 DTL Ohc-Ii Turbodiesel Engine
- Engine, Engine Attaching Parts Torque and Performance Curve, X 17 DTL
- Engine, Engine Attaching Parts Timing, X 17 DTL
- Engine, Engine Attaching Parts V-Belt / Ribbed V-Belt, X 17 DTL
- Engine, Engine Attaching Parts Intake Module/intake Manifold, X 17 DTL
- Engine, Engine Attaching Parts Cylinder Block, Crank Drive, X 17 DTL
- Engine, Engine Attaching Parts Crankshaft, X 17 DTL
- Engine, Engine Attaching Parts Oil Pan, X 17 DTL
- Exhaust Gas Recirculation Valve Without Feedback, All Diesel exceptZ13DT
- Engine, Engine Attaching Parts X 20 DTL 16 V OHC Turbodiesel Engine Ribbed V-Belt Return Roller, X 20 DTL
- Pedal Position Double Signal, Diesel (MY2002, MY 2003 and MY2004)
- Engine, Engine Attaching Parts Oil Filter Housing / Heat Exchanger
- Exhaust Gas Recirculation Valve, PSG16
- Y 20 DTH Engine from MY 2003
- OHC 16-V Diesel Engine - Y 20 DTL - All Vehicle Types
- Engine Specifications - Y 20 DTL - All Vehicle Types
- View of Engine, Intake Side (Y 20 DTL - All Vehicle Types)
- View of Engine, Exhaust Side (Y 20 DTL - All Vehicle Types)
- Engine Compartment Survey - Y 20 DTL - All Vehicle Types
- Injection Pump - Y 20 DTL - All Vehicle Types
- Intake Manifold - Y 20 DTL - All Vehicle Types
- Electro-Pneumatic Pressure Transducer (Exhaust Gas Recirculation) - Y 20 DTL - All Vehicle Types
- Block Diagram - Y 20 DTL - All Vehicle Types
- Diesel Engines Y 20 DTL, Y 20 DTH, Y 22 DTH, Y 22 DTR (Cylinder Block with Coolant Drain Screws - All Vehicle Types)
- Engine - Oil Dipsticks Difficult to Read
- Ribbed Belt - Premature Wear
- Oil Escaping Between Engine Block and Transmission
- Ribbed V Belt Makes Squeaking Noises
- Turbocharger Hose Clamps Become Loose with Time
- Loss of Power, Jerky Power Fluctuations
- Alternator Belt - Noisy
- How to Remove and Install the Alternator
- How to Remove and Install the Starter
- OHC Diesel Engine (X 20 DTL, Y 20 DTL, Y 20 DTH, Y 22 DTR) (Engine Identification / Engine Number)
- Vacuum Routing in Engine Compartment (X 20 DTL, Y 20 DTL, Y 20 DTH Up to MY 2003)
- How to Check the Ribbed V-Belt Tensioner
- Test Compression Pressure (X 20 DTL, Y 20 DTL, Y 20 DTH Up to MY 2003)
- How to Check the Pressure Loss
- How to Measure the Oil Temperature
- How to Check the Oil Pressure
- How to Measure the Oil Consumption
- Engine, Lock at 1st Cylinder TDC (Timing, Check)
- How to Adjust the Timing
- How to Check for Leaks the Low Pressure System
- Illustration: Air Ducts, X 20 DTL, Y 20 DTL
- How to Remove and Install the Ribbed V-Belt
- How to Remove and Install the Ribbed V-Belt Tensioner Assembly
- How to Remove and Install the Timing Case Cover
- How to Remove and Install the Simplex Timing Chain Guide Rail
- How to Remove and Install the Simplex Injection Pump Pulley, Remove and Install / Simplex Timing Chain
- How to Remove and Install the Simplex Chain Tensioner
- How to Remove and Install the Duplex Chain Tensioner
- How to Replace the Seal Ring - Timing Case, Replace / Front Seal Ring - Crankshaft
- How to Remove and Install the Cylinder Head Cover
- How to Remove and Install the Vacuum Pump
- Removing and Installing Inlet Manifold Upper Section (X 20 DTL, Y 20 DTL, Y 20 DTH Up to MY 2003)
- How to Remove and Install the Intake Manifold - Lower Part
- How to Remove and Install the Exhaust Manifold with Turbocharger
- How to Remove and Install the Camshaft
- How to Remove and Install the Cylinder Head
- How to Remove and Install the Flywheel
- How to Remove and Install the Drive Disc
- How to Replace the Con-Rod Bearing
- How to Check (Determine Bearing Play with Plastigage) the Con-Rod Bearing Play
- How to Check (Determine Bearing Play with Micrometer and Inside Micrometer) the Con-Rod Bearing Play
- How to Remove and Install the Piston with Con-Rod
- How to Remove and Install the Piston Rings
- How to Replace the Piston
- How to Check the Crankshaft
- How to Check (Determine Bearing Play with Plastigage) the Crankshaft Bearing Play
- How to Check (Determine Bearing Play with Micrometer and Inside Micrometer) the Crankshaft Bearing Play
- How to Check for Plane Surface the Cylinder Block
- Engine Oil with Oil Filter Change
- How to Remove and Install the Oil Pressure Switch
- How to Remove and Install the Oil Filter Housing (Heat Exchanger)
- How to Remove and Install the Heat Exchanger
- How to Remove and Install the Oil Pan
- How to Remove and Install the Oil Intake Pipe
- How to Remove and Install the Dynamic Oil Level Control
- How to Remove and Install the Oil Temperature Sensor
- How to Remove and Install the Oil Pressure Regulating Valve
- How to Remove and Install the Safety Valve
- How to Remove and Install the Oil Pump
- How to Remove and Install the Oil Spray Nozzle
- Cooling System, Charge and Bleed
- How to Check for Leaks the Cooling System
- How to Check for Leaks the Engine ((CO Content in Cooling System))
- How to Remove and Install the Thermostat/thermostat Housing (Radiator)
- How to Remove and Install the Alternator Bracket (Coolant Flange)
- How to Remove and Install the Coolant Pump
- How to Remove and Install the Coolant Pipe
- How to Remove and Install the Front Engine Damping Block
- How to Remove and Install the Rear Engine Damping Block
- How to Remove and Install the Engine Damping Block, Left
- How to Remove and Install the Engine Damping Block, Right
- Removing and Installing Engine (X 20 DTL, Y 20 DTL, Y 20 DTH Up to MY 2003)
- Removing and Installing Injection Lines (X 20 DTL, Y 20 DTL, Y 20 DTH Up to MY 2003)
- How to Remove and Install the Injection Nozzle Traverse
- How to Remove and Install the Injection Nozzles
- How to Remove and Install the Crankshaft Pulse Pick-Up
- How to Remove and Install the Coolant Temperature Sensor
- Removing and Installing Charge Pressure Sensor (X 20 DTL, Y 20 DTL, Y 20 DTH Up to MY 2003)
- How to Remove and Install the Engine Control Unit
- How to Remove and Install the Charge Pressure Control Solenoid Valve
- How to Remove and Install the Switchover Valves Solenoid Valve
- How to Remove and Install the Switchover Valves Vacuum Unit
- How to Remove and Install the Glow Plugs
- How to Remove and Install the Return Manifold
- How to Remove and Install the Turbocharger
- How to Remove and Install the Turbocharger Oil Feed Line
- How to Remove and Install the Oil Return Line - Turbocharger
- How to Remove and Install the Accelerator Pedal Module with Pedal Position Sensor
- How to Remove and Install the Immobiliser Control Unit
- Special Service Tools
- Specifications
- Checking and Adjustment Values
- Ribbed V-Belt
- Engine Timing
- Cooling System
- Oil Circuit
- Cylinder Head
- Crank Drive, Cylinder Block
- Engine Management
- Sealants, Lubricants and Locking Agents
- Recommended Torque Values
- OHC Ii Turbo-Diesel-Engine (X 17 DTL) Number
- How to Check and Adjust the V-Belt Tension, Check and Adjust Belt Tension
- How to Check the Compression
- How to Measure the Oil Consumption (General)
- How to Check the Timing
- How to Check the Toothed Belt Tension
- How to Adjust the Toothed Belt Tension
- Air Cleaner Housing, Air Duct Ducts
- How to Remove and Install Remove and Install the Ribbed V-Belt
- How to Remove and Install the V-Belt
- How to Remove and Install the Ribbed V-Belt Tensioner
- How to Remove and Install the Toothed Belt Cover, Upper Part
- How to Remove and Install the Toothed Belt Cover, Lower Part
- How to Remove and Install the Toothed Belt
- How to Remove and Install the Toothed Belt Tension Roller
- How to Remove and Install the Toothed Belt Guide Roller
- How to Remove and Install the Rear Toothed Belt Cover
- How to Replace Replace the Seal Ring - Camshaft
- How to Remove and Install the Intake Manifold
- How to Remove and Install (Cylinder Head Installed) the Camshaft
- How to Replace (Cylinder Head the Rocker Arm, Replace (Cylinder Head Installed), Hydraulic Valve Lifter (Installed))
- How to Check for Plane Surface the Cylinder Head
- How to Remove and Install Remove and Install the Flywheel
- How to Replace the Seal Ring - Rear Crankshaft
- How to Replace the Front Seal Ring - Crankshaft, Replace, Seal Ring - Oil Pump
- How to Remove and Install the Con-Rod Bearing
- How to Check (Determine Bearing Play with Plastigage) Plastigage) the Con-Rod Bearing Play
- How to Remove and Install the Crankshaft
- How to Check the Crankshaft, Check; Crankshaft Longitudinal Play, Check; Crankshaft Radial Run-Out
- How to Check the Piston Projection
- How to Replace the Oil Filter
- How to Replace the Bypass Valve
- How to Remove and Install the Lower Part of Oil Pan
- How to Remove and Install the Upper Part of Oil Pan
- How to Check the Oil Pump
- How to Replace the Oil Pressure Regulating Valve
- How to Remove and Install the Oil Cooler
- How to Remove and Install the Thermostat (Engine Oil Cooling)
- How to Remove and Install the Thermostat Housing (Engine Oil Cooling)
- How to Remove and Install the Oil Spray Nozzles
- How to Remove and Install the Oil Dipstick Guide Tube
- Cooling System, Charge and Bleed System
- How to Remove and Install the Fan Motor
- How to Remove and Install Motor the Auxiliary Fan Motor
- How to Remove and Install (Without Air Conditioning) the Radiator
- How to Remove and Install the Radiator (With Air Conditioning)
- How to Remove and Install the Thermostat
- How to Remove and Install the Thermostat Housing
- How to Remove and Install the Control Unit - Cooling Module
- How to Remove and Install Remove and Install the Engine Damping Block, Front
- How to Remove and Install the Engine
- How to Repair Using Short-Block the Engine
- How to Remove and Install the Injector Nozzle, Remove and Install Injection System
- Injector Nozzle, Disassemble and Assemble
- How to Check the Injector Nozzle
- How to Remove and Install Install the Injection Lines
- How to Remove and Install the Fuel Injection Pump
- How to Remove and Install the Crankshaft Pulse Pick-Up - Edc 15 M Engine Management System
- How to Remove and Install the Charge Pressure Sensor
- How to Remove and Install Remove and Install the Turbocharger
- How to Remove and Install the Intercooler
- How to Remove and Install and Install the Glow Plugs
- How to Remove and Install Install the Immobiliser Control Unit
- How to Remove and Install Accelerator the Accelerator Pedal
- How to Remove and Install Install the Alternator
- Sealants, Lubricants and Locking Agents Compounds
- V-Belt - Ribbed V-Belt, Toothed Belt Belt
- Coolant Circuit
- How to Remove and Install the Valve Bridges
- Illustration, Air Duct Y 20 DTH Up to MY 2003
- Removing and Installing Charge Air Cooler (Y 20 DTH, Y 22 DTR).
- How to Remove and Install the Attaching Parts - Cylinder Head
- Check and Measure Cylinder Head and Attaching Parts - Overhaul Cylinder Head
- Vacuum Routing in Engine Compartment (Y 20 DTH Up to MY 2003)
- Vacuum Routing in Engine Compartment (Y 22 DTR)
- Test Compression Pressure (Y 20 DTH as of MY 2003, Y 22 DTR)
- Illustration, Air Duct Y 20 DTH as of MY 2003, Y 22 DTR
- Removing and Installing Inlet Manifold Upper Section (Y 20 DTH as of MY 2003, Y 22 DTR).
- Removing and Installing Throttle Valve Connecting Piece
- Replace Valve Shaft Seals
- Removing and Installing Balancer Shaft Unit
- Dismantling and Assembling Differential (Balancer Shaft Unit)
- Removing and Installing Coolant Return Pipe
- Removing and Installing Engine (Y 20 DTH as of MY 2003, Y 22 DTR)
- Removing and Installing Vacuum Container
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- Accessories
- Additional Lighting
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Automatic Transmission Front Wheel Drive
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Car Level Control
- Central Door Locking System
- Central Electrics
- Central Locking with Atws (Electronic)
- Check Control
- Clutch
- Clutch and Transmission
- Cng
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Ehps - Electrical Hydraulic Power Steering
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Cruise Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- Multitimer
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Radiator Grille
- Radio
- Radio Interference Suppression
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Xenon Control Unit (Headlamp Range Control)