Disconnect negative battery cable. On right manifold, remove torsion bar. On left manifold, disconnect O2 sensor connector. On both manifolds, remove front exhaust pipe. On right manifold, remove EGR pipe bolts and gasket from exhaust manifold. On both manifolds, remove exhaust manifold heat shield. Remove exhaust manifolds from engine. To install, reverse removal procedure. Tighten bolts and nuts to specification. See TORQUE SPECIFICATIONS .
Contents
Wiring diagrams Section: Mechanical- Engine Identification
- Valve Clearance Adjustment
- Accelerator Cable
- Fuel Pressure Release
- Removal & Installation (DOHC)
- Removal & Installation (SOHC)
- Removal & Installation (DOHC Left Side - Amigo, Passport & Rodeo)
- Removal & Installation (DOHC Right Side - Amigo, Passport & Rodeo)
- Removal & Installation (DOHC Left Side - Slx & Trooper)
- Removal & Installation (DOHC Right Side - Slx & Trooper)
- Removal & Installation (SOHC Left Side)
- Removal & Installation (SOHC Right Side)
- Removal (DOHC)
- Removal (SOHC)
- Installation (SOHC)
- Installation (DOHC)
- Removal & Installation
- Oil Pan
- Cylinder Head
- Valve Springs
- Valve Stem Oil Seals
- Valve Guides
- Valves
- Valve Seat Correction Angles
- Rocker Arm Assembly (SOHC)
- Valve Lifters (SOHC)
- Piston & Rod Assembly
- Fitting Pistons
- Piston Pins
- Piston Rings
- Rod Bearings
- Crankshaft & Main Bearings
- Thrust Bearing
- Cylinder Block
- Engine Lubrication System
- Crankcase Capacity
- Oil Pressure
- Removal & Disassembly
- Reassembly & Installation
- Torque Specifications
- Engine Specifications
- Crankshaft, Main & Connecting Rod Bearings
- Connecting Rods
- Pistons, Pins & Rings
- Valves & Valve Springs
- Camshaft
- Valve Lifters
- Abbreviations
- Accessory Drive Belts
- Adjustments
- Airbag
- Anti-Lock/traction Control
- Application
- Automatic Trans
- Axle Shafts
- Basic Trouble Shooting
- Brakes
- Charging System
- Check Lists
- Clutches Manual & Hydraulic
- Computer Relearn
- Cooling System (mechanical)
- Cruise Control Systems
- Diagnostic Connector Locations
- Differentials & Drive Axles
- Door Locks & Anti-Theft Systems
- Driveline/axles
- DTC Index
- Electrical
- Electrical Component Locations
- Emission Applications
- Engine
- Engine Performance
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing - All Makes
- Heated Glass/defoggers
- Heater
- Identification
- Locking Hubs
- Manual & Power Steering
- Manual HVAC System
- Manual Trans
- MAP Guidelines
- Mechanical
- Mechanical - Hydraulic
- Metric Conversions
- Mirrors
- Mode 6
- Oem General Information
- Pin Voltage Charts
- Procedures
- Removal & Installation
- Restraints
- Seats
- Sensor Range Charts
- Specifications
- Starter
- Steering
- Steering Column
- Steering Column Switches
- Sun Roof/t-Top/convertible Top
- Suspension Front
- Suspension Rear
- Testing & Diagnostics
- Theory & Operation
- Timing Belt
- Transfer Case
- Transmission
- Wheel Alignment
- Windows
- Wiper/washer Systems
- Wiring Diagrams - Engine Performance