Special Service Tools
KM - 135 Adapter for KM - 498 - B
| To check engine oil pressure | |||
|---|---|---|---|
| .P. C7308.tif | 9 | 7,5 | tiff;; |
KM - 139 - A Flywheel Locking Device (replaced by KM - 652)
| To lock flywheel (transmission removed) | |||
|---|---|---|---|
| .P. A6605.tif | 9 | 7,5 | tiff;; |
KM - 234 Remover/Installer (no longer available)
| To remove and install camshaft bearing | |||
|---|---|---|---|
| .P. A2712.tif | 9 | 7,5 | tiff;; |
KM-235-D Ring Installer
| To install the bearing and seal ring in crankshaft | |||
|---|---|---|---|
| .P. B7868.tif | 9 | 7,5 | tiff;; |
KM - 237 Clutch Guide Bolt
| To centre the clutch disc | |||
|---|---|---|---|
| .P. A6613.tif | 9 | 7,5 | tiff;; |
KM - 241 Reamer 0.075 mm oversize*
KM - 242 Reamer 0.300 mm oversize*
KM - 244 Reamer 0.150 mm oversize*
To ream the valve guide
| *no longer available | |||
|---|---|---|---|
| .P. A6614.tif | 9 | 7,5 | tiff;; |
KM - 252 - A Engine Lifter*
| To remove and install engine | |||
|---|---|---|---|
| .P. C3514.tif | 9 | 7,5 | tiff;; |
KM - 257 Valve Holder*
| To hold the closed valve | |||
|---|---|---|---|
| .P. B7859.tif | 9 | 7,5 | tiff;; |
KM - 263 - B Lifter/Holder
To lift or hold the engine
| * no longer available | |||
|---|---|---|---|
| .P. A6623.tif | 9 | 7,5 | tiff;; |
KM - 288 Spring Compressor
| To replace the valve springs using KM - 257 | |||
|---|---|---|---|
| .P. B7860.tif | 9 | 7,5 | tiff;; |
KM - 289 Ring Installer
| To install the seal ring in the timing gear case | |||
|---|---|---|---|
| .P. A6617.tif | 9 | 7,5 | tiff;; |
MKM - 320 Splined Wrench
| To remove and install the camshaft timing gear | |||
|---|---|---|---|
| .P. C9650.tif | 9 | 7,5 | tiff;; |
KM - 328 - B Remover
| To remove the crankshaft needle bearing | |||
|---|---|---|---|
| .P. A7927.tif | 9 | 7,5 | tiff;; |
KM - 337 Remover/Installer
To remove and install the piston pin
| (only 6 cyl.) | |||
|---|---|---|---|
| .P. A7614.tif | 9 | 7,5 | tiff;; |
KM-340-C Cutter Set
| To rework the valve seats | |||
|---|---|---|---|
| .P. A4597.tif | 9 | 7,5 | tiff;; |
KM - 348 Spring Compressor
| To compress the valve springs | |||
|---|---|---|---|
| .P. B3160.tif | 9 | 7,5 | tiff;; |
KM-352 Installer
| To install the valve stem seal | |||
|---|---|---|---|
| .P. D1165.tif | 9 | 7,5 | tiff;; |
KM-412-4 Adapter
| To mount engine in Stand KM-412 | |||
|---|---|---|---|
| .P. B8050.tif | 9 | 7,5 | tiff;; |
KM - 418 Drift (no longer available)
| To install the oil dipstick guide pipe | |||
|---|---|---|---|
| .P. A7602.tif | 9 | 7,5 | tiff;; |
KM-470-B Angular Torque Wrench
| To tighten bolts/nuts by angular torque method | |||
|---|---|---|---|
| .P. D3258.tif | 9 | 7,5 | tiff;; |
KM-498-B Pressure Gauge
| To measure engine oil pressure with KM - 135 | |||
|---|---|---|---|
| .P. D1069.tif | 9 | 7,5 | tiff;; |
KM - 517 Locking Device
| To lock the flywheel (engine installed) | |||
|---|---|---|---|
| .P. B2521.tif | 9 | 7,5 | tiff;; |
MKM - 588 Pressure Gauge
| To check fuel pressure | |||
|---|---|---|---|
| .P. C6082.tif | 9 | 7,5 | tiff;; |
MKM - 596 Gauge
| To measure oil temperature | |||
|---|---|---|---|
| .P. C1483.tif | 9 | 7,5 | tiff;; |
MKM - 597 Removing Pliers
| To remove valve shaft seals | |||
|---|---|---|---|
| .P. C2704.tif | 9 | 7,5 | tiff;; |
MKM-604-B Torx Socket Wrench Set
| To loosen/tighten inner/outer Torx bolts | |||
|---|---|---|---|
| .P. C2709.tif | 9 | 7,5 | tiff;; |
KM - 609 Electronic Kit I
| For diagnosis on electric and electronic systems | |||
|---|---|---|---|
| .P. C5793.tif | 9 | 7,5 | tiff;; |
KM - 652 Flywheel Locking Device
| To lock the flywheel (transmission removed) | |||
|---|---|---|---|
| .P. C7300.tif | 9 | 7,5 | tiff;; |
Cooling System
KM - 471 Adapter
| To check the cooling system under pressure (together with commercially available radiator tester) | |||
|---|---|---|---|
| .P. A9550.tif | 9 | 7,5 | tiff;; |