Mechanical Injection System
| Injection Pump Type | Bosch VE distributor | |
|---|---|---|
| Injector Type | Pintaux | |
| Opening pressure | kPa | 14,710 |
Home/Opel/Monterey/Opel Monterey A (1992-1999)/Repair manual/Fuel Injection Systems/Technical Data - Mechanical Injection System - 4JG2T
Contents
Section: Fuel Injection Systems- Introduction
- Introduction (Electrical Engine System GMP4 6VD1)
- The Checking System
- Diagnosis (Electrical Engine System GMP4 6VD1)
- General Instructions/safety Measures
- General Safety and Repair Information (Electrical Engine System GMP4)
- Injectors - Monterey with 4JG2 Engine as of MY '93
- Differences Between MY '92 and MY '93
- Electronic Engine System GMP4 6VD1 Important
- Checking Equipment
- F2:Trouble Code - Trouble Code 13 02 Sensor Circuit
- Survey of System/engine Compartment Survey
- F2:Trouble Code - Trouble Code 14 Coolant Sensor Circuit
- Survey of Vehicle Wiring Harness
- F2:Trouble Code - Trouble Code 21 Throttle Valve Pot. Sensor Circuit
- Block Diagram
- F2:Trouble Code - Trouble Code 23 Intake Air Temperature Sensor Circuit
- Explanation of Modes (Checking with Tech 1)
- F2:Trouble Code - Trouble Code 24 No Speed Signal
- How to Connect to Vehicle and Carry Out Test the Tech 1
- F2:Trouble Code - Trouble Code 32 EGR System Fault
- Abbreviations, Definitions
- F2:Trouble Code - Trouble Code 33 MAP Sensor Circuit
- Quick Check F0:Data List Test Step 01 Battery Voltage
- F2:Trouble Code - Trouble Code 42 Bypass or Est Line Fail
- Quick Check F0:Data List Test Step 02 Air Injection Reaction
- F2:Trouble Code - Trouble Code 44 Lean Exhaust
- Quick Check F0:Data List Test Step 03 Coolant Temperature
- F2:Trouble Code - Trouble Code 45 Rich Exhaust
- Quick Check F0:Data List Test Step 04 Intake Air Temperature
- F2:Trouble Code - Trouble Code 51 Replace ECU
- Quick Check F0:Data List Test Step 05 TPS Signal
- F2:Trouble Code - Trouble Code 52 Immobiliser No/wrong Signal
- Quick Check F0:Data List Test Step 06 Sim. Part Pos Sw
- F0:Data List - Test Step- NR.01 Battery Voltage
- Quick Check F0:Data List Test Step 07 MAP Sensor
- F0:Data List - Test Step- NR.02 Immobiliser Sig.
- Quick Check F0:Data List Test Step 08 Barometer Sensor
- F0:Data List - Test Step- NR.03 TPS Signal
- Quick Check F0:Data List Test Step 09 Ref. Ignition Pulse
- F0:Data List - Test Step- NR.04 Sim. Idle Pos.sw
- Quick Check F0:Data List Test Step 10 Ignition Status
- F0:Data List - Test Step No.05 MAP Sensor
- Quick Check F0:Data List Test Step 11 Min. Desired Idle
- F0:Data List - Test Step - No.06 Barometer Sensor
- Quick Check F0:Data List Test Step 12 Engine Speed
- F0:Data List - Test Step - No.07 Coolant Temperature
- Quick Check F0:Data List Test Step 13 Spark Advance
- Terminal Assignment of Wiring Harness Connector, Controller (4JG2T Diesel)
- F0:Data List - Test Step - No.08 Intake Air Temperature
- Quick Check F0:Data List Test Step 14 Injection Pulse
- Engine Temperature Monitoring 4JG2T Diesel Engine
- F0:Data List - Test Step - No.09 Park/neutral Sw.
- Quick Check F0:Data List Test Step 15 O2 Sensor Loop
- Motor Add-On Components, Petrol Motor 6VE1 Motor Regulation, Location of Components
- F0:Data List - Test Step - No.10 A/c Informat. Sw
- Quick Check F0:Data List Test Step 16 O2 Sensor
- Petrol Motor 6VE1, Wind to End, Suction Pipe with Var. Volumen, Nockenwellensensor ...
- F0:Data List - Test Step - No.11 Spark Advance
- Quick Check F0:Data List Test Step 17 O2 Integrator
- Motor Add-On Components, Petrol Motor 6VE1 Motor Regulation, Block Diagram
- F0:Data List - Test Step - No.12 Injection Pulse
- Quick Check F0:Data List Test Step 18 O2 Blm Enable
- Motor Add-On Components, Petrol Motor 6VE1 Motor Regulation, Pin Assignments
- F0:Data List - Test Step - No.13 Sec. Air Inj.
- Quick Check F0:Data List Test Step 19 O2 Blm Cell No.
- F0:Data List - Test Step - No.14 EGR Valve
- Quick Check F0:Data List Test Step 20 Blm Cell Cont
- F0:Data List - Test Step - No.15 Evap Control V.
- Quick Check F0:Data List Test Step 21 Mixture Status
- F0:Data List - Test Step - No.16 O2 Sensor
- Quick Check F0:Data List Test Step 22 Air/fuel Ratio
- F0:Data List - Test Step - No.17 Air/fuel Ratio
- Quick Check F0:Data List Test Step 23 Power Steering
- F0:Data List - Test Step - No.18 O2 Sensor Circuit
- Quick Check F0:Data List Test Step 24 Idle Air Control
- F0:Data List - Test Step - No.19 Air/fuel Status
- Quick Check F0:Data List Test Step 25 Egr-Valve
- F0:Data List - Test Step - No.20 O2 Integrator
- Quick Check F0:Data List Test Step 26 Compressor Control Valve
- F0:Data List - Test Step - No.21 O2 Blm
- Quick Check F0:Data List Test Step 27 Park/neutral Sw.
- F0:Data List - Test Step - No.22 O2 Blm
- Quick Check F0:Data List Test Step 28 A/c Informat. Sw
- F0:Data List - Test Step - No.23 O2 Blm
- Quick Check F0:Data List Test Step 29 A/c Relay
- F0:Data List - Test Step - No.24 Ref Pulse Dis
- Quick Check F0:Data List Test Step 30 Power Enrichment
- F0:Data List - Test Step - No.25 Ignition Status
- Quick Check F0:Data List Test Step 31 Vehicle Speed
- F0:Data List - Test Step - No.26 Engine Speed
- Quick Check F0:Data List Test Step 32 Time Since Start
- F0:Data List - Test Step - No.27 Idle Air Control
- Additional Fault Diagnosis - Note
- F0:Data List - Test Step - No.28 Desired Idle
- Additional Fault Diagnosis - Test Step 01 - Fuel Pump Relay
- F0:Data List - Test Step - No.29 A/c Relay
- How to Check the Table 1, Diagnostic Plug Aldl and Voltage Supply
- F0:Data List - Test Step - No.30 Power Steering
- Multec M Trouble Code Table - T-Code 13 O2 Sensor Loop
- F0:Data List - Test Step - No.31 Vehicle Speed
- Multec M Trouble Code Table - T-Code 14 Coolant Sensor Circuit
- F0:Data List - Test Step - No.32 Power Enrichment
- Multec M Trouble Code Table - T-Code 21 Throttle Posit. Sensor Circuit
- F5:actuator Test Check Light
- Multec M Trouble Code Table - T-Code 23 Intake Air Temperature Sensor Circuit
- Motor Add-On Components, Turbo Diesel 4JX1 Oil/fuel Injection Circulation
- F5:actuator Test A/c Relay
- Multec M Trouble Code Table - T-Code 24 No Vehicle Speed Signal
- Motor Add-On Components, Turbo Diesel 4JX1 Oil/fuel Pumps Assembly
- F5:actuator Test Evap Control V.
- Multec M Trouble Code Table - T-Code 32 EGR System Fault
- Motor Add-On Components, Turbo Diesel 4JX1 Fuel Filter
- F5:actuator Test EGR Valve
- Multec M Trouble Code Table - T-Code 33 MAP Sensor Circuit
- Motor Add-On Components, Turbo Diesel 4JX1 Distributing Pipe
- F5:actuator Test Sec. Air Inj.
- Multec M Trouble Code Table - T-Code 42 Bypass/ter.a or Est/ter.b Line Fail
- F5:actuator Test Immo.signal Test
- Multec M Trouble Code Table - T-Code 44 Lean Exhaust
- Motor Add-On Components, Turbo Diesel 4JX1 Edc: General
- F6:ecu Reset o2 Blm Cells
- Multec M Trouble Code Table - T-Code 45 Rich Exhaust
- Motor Add-On Components, Turbo Diesel 4JX1 Edc: Location of Components
- F8:ecu Control Controlled RPM
- Multec M Trouble Code Table - T-Code 51 Replace ECU
- Motor Add-On Components, Turbo Diesel 4JX1 Edc: Functional Overview
- Table 4, Engine Does Not Start
- Motor Add-On Components, Turbo Diesel 4JX1 Edc: Block Diagram
- Table 5, F:5 Actuator Test Test Step 01 Telltale
- Motor Add-On Components, Turbo Diesel 4JX1 Edc: Control Unit
- Table 5, F:5 Actuator Test Test Step 02 A/c Relay
- Motor Add-On Components, Turbo Diesel 4JX1 Edc: Accelerator Position Sensor, Ll-Dz Switch
- Table 5, F:5 Actuator Test Test Step 03 Compressor Control Valve
- Turbo Diesel 4JX1: Edc; Crankshaft Sensor Camshaft-, Temperature Sensor
- Table 5, F:5 Actuator Test Test Step 04 EGR Valve
- Turbo Diesel 4JX1, Edc: Suction Piper Sensor Solenoid Valve, Oil Pressure Distributing Pipe
- Table 5, F:5 Actuator Test Test Step 05 Air Injection Reaction
- Turbo Diesel 4JX1, Edc: Injection Valves General, Functional Overview
- How to Reset the Table 6, Control Unit (Step 01 Select Reset o2 Blm Cells)
- How to Remove and Install the Oil/fuel Pump (4JX1)
- How to Check the Table 8, Control Unit (Step 01 Select Control, Controlled RPM)
- How to Remove and Install the Injection Nozzle (4JX1)
- Table 8, Trouble-Shooting Chart
- Terminal Assignment of 24-Pin Wiring Plug C-2 of Engine Control Unit
- Terminal Assignment of 32-Pin Wiring Plug C-2 of Engine Control Unit
- Terminal Assignment - Diverse Wiring Harness Plugs
- Engine Compartment Fuse Box
- Signal Images - Signal Image, Inductive Pulse Pick-Up
- Signal Images - Signal Image, Inductive Pulse Pick-Up + "Ref-High" Signal
- Signal Images, Controlled Canister Purge Valve
- Circuit Diagram, Starter Circuit and A/c
- Circuit Diagram, 3.2l V6 SOHC Engine
- Circuit Diagram, Automatic Transmission
- Circuit Diagram/cruise Control
- Time Allowance
- How to Check and Adjust the Adjustment of Injection Pump (4JG2T)
- How to Check the Fuel Shut-Off Valve (4JG2T)
- How to Remove and Install the Injection Pump (4JG2T)
- How to Adjust the Accelerator Cable (4JG2T)
- How to Adjust the Accelerator Pedal (4JG2T)
- How to Remove and Install 4JG2T the Injection Nozzle
- How to Check the Injection Nozzle (4JG2T)
- How to Clean and Adjust 4JG2T the Injection Nozzle
- Technical Data - Mechanical Injection System - 4JG2T
- Ignition and Injection System Mpfi General Data - 6VD1
- Survey of Engine Compartment (Top View) - 6VD1
- How to Remove and Install the Electronic Control Unit (6VD1)
- How to Remove and Install the Ignition Coils, Direct Ignition (6VD1)
- How to Remove and Install the Injection Valves (6VD1)
- How to Remove and Install the Fuel Pressure Regulator (6VD1)
- How to Remove and Install the Intake Manifold Temperature Gauge (6VD1)
- How to Remove and Install the Intake Manifold Absolute Pressure Gauge (6VD1)
- How to Remove and Install the Oxygen Sensor (6VD1)
- How to Remove and Install the Coolant Temperature Gauge (6VD1)
- How to Remove and Install the Throttle Valve Housing (6VD1)
- How to Remove and Install the Idle Air Control Valve (6VD1)
- How to Remove and Install the Throttle Valve Sensor (6VD1)
- How to Remove and Install the Multec Control Unit (6VE1)
- How to Remove and Install the Ignition Coils (6VE1)
- How to Remove and Install the Crankshaft Pulse Pick-Up (6VE1)
- How to Remove and Install the Injection Valves (6VE1)
- How to Remove and Install the Fuel Pressure Regulator and Distributor Pipe (6VE1)
- How to Remove and Install the Intake Air Temperature Gauge (6VE1)
- How to Remove and Install the Intake Manifold Absolute Pressure Gauge (6VE1)
- How to Remove and Install the Oxygen Sensor (6VE1)
- Coolant Temperature Gauge - 6VE1
- How to Remove and Install the Throttle Valve Housing (6VE1)
- How to Remove and Install the Idle Air Control Valve (6VE1)
- How to Remove and Install the Throttle Valve Sensor (6VE1)
- How to Remove and Install the Solenoid Valve, Intake Manifold Switchover (6VE1)
- How to Replace the Camshaft Sensor (6VE1)
- How to Replace the Knock Sensor (6VE1)
- How to Replace the Fuel Vapour Valve (6VE1)
- How to Remove and Install the Actuator, Intake Manifold Switchover (6VE1)
- ABS
- ABS 5.3
- Accessories
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Automatic Transmission Rear Wheel Drive
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Cooling System
- Diesel Engine
- Distributor Transmission Four Wheel Drive
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Cruise Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Four Wheel Drive
- Manual Transmission Rear Wheel Drive
- OHC Petrol Engine
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Power Steering
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Rear Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses