| Engine | Z 16 SE | |
|---|---|---|
| Ribbed V-belt | ||
| Length | ||
| without air conditioning | mm | 940 |
| with air conditioning | mm | 1212 |
| Ribbed V-belt | Automatic tension roller |
Contents
Wiring diagrams Section: OHC Petrol Engine- How to Check and Measure the Cylinder Head and Attaching Parts (Survey)
- How to Check the Cylinder Head Height
- How to Check for Plane Surface the Cylinder Head
- How to Measure the Valve
- How to Check the Inner Diameter of Valve Guide
- Valve Stem Play, Determine
- How to Check the Installation Height of Valves
- How to Check the Installation Height of Valve Guide
- Battery / Starter, Petrol (Current Measurement)
- Battery / Starter (Voltage Measurement)
- How to Overhaul the Cylinder Head
- Cylinder Head, Attach to Assembly Tool Set KM-6215
- Cylinder Head, Disassemble
- Flexible Maintenance Intervals - Corsa-C, Meriva, Tigra-B
- How to Remove the Valves
- Compression 4-cylinder, Unsynchronised
- Valve Seat, Cut (In Cylinder Head)
- Valve Guide, Ream
- Crankshaft Impulse Sensor, Petrol and Z19DT
- Valve, Grind
- Valve, Grind In
- How to Replace the Valve Stem Seals
- How to Assemble the Cylinder Head
- Cylinder Head Machining Special Tools
- Measuring Oil Consumption
- Injector (Multi-Point Fuel Injection), All Except Z22YH
- Intake Manifold Absolute Pressure (MAP) Sensor
- Engine Identifier
- Knock Sensor
- Ignition, Primary, Frontera-B Y22SE, Corsa-C Z16SE
- Damage Diagnosis, Dual Mass Flywheel
- All OHC and Dohc-Ii Petrol Engines
- Introduction
- Toothed Belt Diagnosis - Possible Causes and Remedys
- Toothbelt - Service Intervall Overview
- Spark Plug Damages - Possible Causes and Failure Modes
- Engine Number
- How to Check (Z 16 SE the J 979600 Compression (With AC, Lhd))
- How to Check (Z 16 SE the J 451700 Engine Oil Pressure (With AC, Lhd))
- How to Check (Z 16 SE the J 792900 Timing (With AC, Lhd))
- How to Adjust (Z 16 SE the J 792910 Engine Timing (With AC, Lhd))
- How to Check and Correct (Z 16 SE the Toothed Belt Tension (With AC, Lhd))
- Illustration (Z 16 SE)
- How to Replace (Z 16 SE the J 607000 Ribbed V-Belt (Rhd))
- How to Replace (Z 16 SE the J 607300 Ribbed V-Belt Tensioner (Rhd))
- How to Remove and Install (Z 16 SE the J 313740 Toothed Belt Cover Upper Part (Rhd))
- How to Replace (Z 16 SE the J 313750 Toothed Belt Cover Lower Part (Rhd))
- J 313900 Replace Toothed Belt (Z 16 SE, Rhd)
- How to Replace (Z 16 SE the J 313910 Toothed Belt Tension Roller (Rhd))
- How to Replace (Z 16 SE the J 313760 Rear Toothed Belt Cover (Rhd))
- How to Remove and Install (Z 16 SE the J 304700 Camshaft Housing Cover (With AC, Lhd))
- How to Replace (Z 16 SE the J 314300 Camshaft Sprocket (With AC, Lhd))
- How to Replace the J 314600 Front Seal Ring - Camshaft
- How to Replace (Z 16 SE the J 303000 Exhaust Manifold Seal Ring (Rhd))
- How to Replace (Z 16 SE the J 301500 Intake Manifold Seal Ring (Rhd))
- How to Replace (Z 16 SE the J 307300 Hydraulic Valve Lifters (With AC, Lhd))
- How to Remove and Install (Z 16 SE the J 312000 Cylinder Head (With AC, Lhd))
- How to Remove and Install the J 335500 Flywheel
- How to Replace (Z 16 SE the J 320720 Rear Crankshaft Seal Ring (With AC, Lhd))
- How to Replace the J 951300 Cylinder Block Ventilation Flange (Petrol Engine (Z 16 SE, with AC, Lhd))
- Engine Oil Change (Z 16 SE, with AC, Lhd)
- How to Replace (Z 16 THE J 321500 Oil Pump Seal Ring (Se, Rhd))
- How to Remove and Install (Z 16 SE the J 315500 Oil Pan (With AC, Lhd))
- How to Remove and Install (Z 16 SE the J 316300 Oil Pan (With AC, Lhd))
- How to Check (Z 16 SE the J 316500 Oil Pump (With AC, Lhd))
- How to Replace the J 316800 Pressure Relief Valve in Oil Circuit
- How to Replace the J 315500-009 Oil Intake Pipe
- How to Check for Leaks the Engine ((CO Content in Coolant))
- How to Replace (Z 16 SE the J 337000 Engine Damping Blocks (Both Sides) (Rhd))
- How to Remove and Install (Z 16 SE the J 338100 Front Reaction Member (Rhd))
- How to Remove and Install (Z 16 SE the J 338000 Rear Reaction Member (Rhd))
- How to Remove and Install (Z 16 SE the J 337100 Engine Damping Block (Right Side) (Rhd))
- How to Remove and Install (Z 16 SE the J 337200 Engine Damping Block (Left Side) (Rhd))
- How to Remove and Install (Z 16 SE the J 340100 Engine with Transmission (With AC, Lhd))
- How to Remove and Install (Z 16 SE the 007 Manual Transmission from Engine (With AC, Lhd))
- Multec S Engine Management System
- How to Check (Z 16 SE the J 857400 Fuel Pressure (With AC, Lhd))
- Special Service Tools
- Specifications
- Checking and Adjustment Values
- Ribbed V-Belt
- Toothed Belt
- Coolant Circuit
- Oil Circuit
- Cylinder Head
- Crank Drive, Cylinder Block
- Engine Management
- Sealants, Lubricants and Locking Compounds
- Recommended Torque Values (Z 16 SE)
- Remove and Install Exhaust Gas Recirculation Valve
- Check Ribbed V-Belt Tension
- Check Oil Temperature
- Check Engine Pressure Loss (Z 16 SE, with Air Conditioning, Lhd)
- Check Camshaft Housing for Plane Surface
- Replace Camshaft (Z 16 SE, with Air Conditioning, Lhd) (Cylinder Head Installed)
- Replace Camshaft Housing - Petrol Engine (Z 16 SE, with Air Conditioning, Lhd)
- Replace Rear Camshaft Housing Seal Ring (Z 16 SE, AC, Lhd)
- Replace Valve Stem Seals (Z 16 SE, with Air Conditioning, Lhd) (Cylinder Head Installed)
- Remove and Install All Pistons with Con-Rod (Z 16 SE, with Air Conditioning, Lhd)
- Replace One Con-Rod Bearing (Z 16 SE, with Air Conditioning, Lhd)
- Replace Piston Rings
- Remove and Install Crankshaft (Z 16 SE Without AC, Rhd)
- Check Crankshaft Alignment (Z 16 SE)
- Additional Work When Replacing Oil Pan (Z 16 SE, with Air Conditioning, Lhd)
- Removing and Installing Oil Dipstick Guide Tube (Z 16 SE, with Air Conditioning, Lhd)
- Replace Oil Filter Short-Circuit Valve (Z 16 SE, with Air Conditioning, Lhd)
- Repair Engine Using Short Block (Z 16 SE, Without Air Conditioning, Rhd)
- Flexible Maintenance Intervals
- Chemical Products
- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Cng
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Folding Sunroof
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Radiator Grille
- Radio
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses