Con - Rods
The permissible weight variation of con - rods without piston and bearing shell inside an engine is 8 g.
As the con - rods do not have balancing studs, reworking is not possible.
Con - rods must only be replaced in sets.
Home/Opel/Frontera/Opel Frontera A (1992-1998)/Repair manual/DOHC Petrol Engine/Technical Data - Con-Rods
Contents
Section: DOHC Petrol Engine- New X22XE DOHC Petrol Engine
- Engine-Specific Characteristic Data (X22XE)
- Illustration - Perspective View, Intake Side (X22XE)
- Illustration - Perspective View, Exhaust Side (X22XE)
- Cylinder Head (X22XE)
- Camshaft, Camshaft Drive and Valves (X22XE)
- Engine Block and Crank Drive (X22XE)
- Auxiliary Drive (X22XE)
- Illustration - X 22 XE - Perspective View, Intake Side
- Illustration - X 22 XE - Perspective View, Exhaust Side
- Illustration - X 22 XE - Engine, Longitudinal Section
- Illustration - X 22 XE - Engine, Cross Section
- Illustration - X 22 XE - Engine Timing
- Safety Measures X 22 XE Engine
- How to Check the Ribbed V-Belt Tension
- How to Check the Compression
- How to Check the Engine Pressure Loss
- How to Measure the Engine Oil Temperature
- How to Check the Engine Oil Pressure
- How to Measure the Engine Oil Consumption
- How to Check the Timing
- How to Adjust the Timing
- How to Check and Adjust the Toothed Belt Tension
- Illustration - Air Cleaner
- Illustration - Ribbed V-Belt Routing with Power Steering
- Illustration - Toothed Belt Routing
- How to Replace the Ribbed V-Belt
- How to Replace the Ribbed V-Belt Tension Roller
- How to Replace the Toothed Belt
- How to Replace the Toothed Belt Tension Roller
- How to Replace the Toothed Belt Guide Roller
- How to Remove and Install the Camshaft Pulleys
- How to Replace the Front Crankshaft Radial Seal Ring
- How to Remove and Install the Rear Toothed Belt Cover
- How to Replace the Exhaust Manifold Gasket to Cylinder Head
- How to Replace the Intake Manifold Gasket to Cylinder Head
- How to Replace the Camshaft
- How to Remove and Install the Cylinder Head
- Cylinder Head, Disassemble and Assemble
- How to Overhaul the Cylinder Head (Valve, Grind In)
- How to Overhaul the Cylinder Head (Valve, Grind)
- How to Overhaul the Cylinder Head (Valve Guide, Ream)
- How to Overhaul the Cylinder Head (Valve Seat, Mill)
- How to Check for Plane Surface the Cylinder Head
- How to Replace the Needle Bearing, Crankshaft
- How to Remove and Install the Flywheel
- How to Replace the Rear Crankshaft Radial Seal Ring
- How to Remove and Install the Piston with Con-Rod
- How to Replace the Piston Rings
- How to Replace the Con-Rod Bearing
- How to Replace the Con-Rod
- How to Remove and Install the Crankshaft
- How to Check the Crankshaft
- How to Check for Plane Surface the Cylinder Block
- How to Replace the Oil Filter
- How to Replace the Bypass Valve
- How to Remove and Install the Oil Cooler
- How to Replace (Up to MY'97) the Oil Pan Gasket
- How to Replace (As of MY'97) the Oil Pan Gasket
- How to Remove and Install the Oil Pump
- How to Check the Oil Pump
- How to Replace the Safety Valve
- How to Check for Leaks (CO Content in Cooling System) the Combustion Chamber
- How to Replace the Gasket, Coolant Port to Cylinder Head
- How to Replace the Gasket, Dis Ignition Module Adapter to Cylinder Head
- How to Remove and Install the Power Steering Pump
- How to Replace the Front Engine Damping Blocks
- How to Replace the Rear Engine Damping Block
- Engine with O Transmission, Remove/install
- How to Repair Using Short-Block the Engine
- How to Assemble the New Short-Block
- Survey of Engine Compartment Motronic M 1.5.4
- Wiring Harness Routing in Engine Compartment (Schematic) Motronic M 1.5.4
- How to Remove and Install the Camshaft Sensor
- Special Service Tools (Motor X 22 XE)
- Technical Data - Engine Oil Quality
- Technical Data - Engine Oil Viscosity
- Technical Data - Engine Oil Disposal
- Technical Data - Engine Oil Filling Capacities
- Technical Data - Oil Pump
- Technical Data - Ribbed V-Belt Dimensions
- Technical Data - Toothed Belt Dimensions
- Technical Data - Idle Speed, CO Content, Ignition Timing
- Technical Data - Adjustment/checking Values
- Technical Data - Cylinder Head Gasket
- Technical Data - Valve Dimensions
- Technical Data - Valve Seat, Mill
- Technical Data - Intake and Exhaust Camshaft
- Technical Data - Cylinder Grinding and Piston Dimensions
- Technical Data - Cylinder Bore
- Technical Data - Piston
- Technical Data - Piston Rings
- Technical Data - Piston Pins
- Technical Data - Con-Rods
- Technical Data - Crankshaft Grinding Dimensions
- Technical Data - Crankshaft
- Technical Data - Flywheel
- Recommended Torque Values X 22 XE Engine
- ABS
- ABS 415
- Accessories
- Additional Lighting
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Cih Petrol Engine
- Clutch
- Clutch and Transmission
- Cooling System
- Diesel Engine
- Distributor Transmission Four Wheel Drive
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Four Wheel Drive
- OHC Petrol Engine
- Other Accessories
- Paint
- Painting Repair Operations
- Painting Repair System
- Power Steering
- Radiator Grille
- Radio
- Radio Interference Suppression
- Rear Axle and Rear Wheel Suspension
- Rear Axle Four Wheel Drive
- Rear Axle Rear Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses