Home/Opel/Agila/Opel Agila A (2000-2007)/Repair manual/DOHC Petrol Engine/Cylinder Head - Illustration
Contents
Wiring diagrams Section: DOHC Petrol Engine- How to Check and Measure the Cylinder Head and Attaching Parts (Survey)
- How to Check the Cylinder Head Height
- How to Check for Plane Surface the Cylinder Head
- Air Mass Meter, 4 Cylinder Petrol
- How to Measure the Valve
- New Rear Engine Damping Block Bracket - Z 12 XEP Petrol Engine, Agila
- How to Check the Inner Diameter of Valve Guide
- Valve Stem Play, Determine
- How to Check the Installation Height of Valves
- How to Check the Installation Height of Valve Guide
- Battery / Starter, Petrol (Current Measurement)
- Battery / Starter (Voltage Measurement)
- How to Overhaul the Cylinder Head
- Cylinder Head, Attach to Assembly Tool Set KM-6215
- Cylinder Head, Disassemble
- Compression 3-cylinder, Unsynchronised
- How to Remove the Valves
- Compression 4-cylinder, Unsynchronised
- Valve Seat, Cut (In Cylinder Head)
- Valve Guide, Ream
- Crankshaft Impulse Sensor, Petrol and Z19DT
- Valve, Grind
- Valve, Grind In
- How to Replace the Valve Stem Seals
- How to Assemble the Cylinder Head
- Cylinder Head Machining Special Tools
- Exhaust Gas Recirculation Valve, Motronic M1.5.5 (MY 2000 and MY 2001)
- Measuring Oil Consumption
- Injector (Multi-Point Fuel Injection), All Except Z22YH
- Engine Identifier
- Knock Sensor
- Lubrication of Radial Shaft Seal Rings No Longer Applicable
- Camshaft Sensor, Motronic M1.5.6
- Cylinder Block - X 10 XE, Z 10 XE, X 12 XE and Z 12 XE Engines
- Crankshaft Guide Bearing, DOHC Gasoline Engines
- Cylinder Head - Z 10 XEP, Z 12 XE and Z 14 XEP Engines
- Engine Timing - Z 10 XEP, Z 12 XE and Z 14 XEP
- Oil Baffle Plate - X 12 XE, Z 12 XE, Z 14 XEP Engines
- Timing Chain Tensioner - Z 10 XEP, Z 12 XE, Z 14 XEP Engines
- Pedal Position Double Signal, Motronic (MY2001)
- Throttle Valve Potentiometer (Double Signal), Motronic (As of MY2001)
- Pedal Position Double Signal, All Petrol (MY 2002, MY 2003 and MY 2004)
- Exhaust Gas Recirculation Valve, Motronic1.5.5 and Motronic 3.11 (MY2002 and MY 2003)
- All OHC and Dohc-Ii Petrol Engines
- New Camshaft Sensor - Z 10 XEP, Z 12 XEP, Z 14 XEP Petrol Engines
- DOHC-0 Engine Z 12 XEP - Agila and Corsa-C
- Elimination of Twinport Sensor - Z 10 XEP, Z 12 XEP and Z 14 XEP Petrol Engines
- Introduction
- Specific Characteristics of the Z 12 XEP Engine
- View of the Engine, Z 12 XEP, Z 14 XEP
- Torque and Power Diagram, Z 12 XEP
- Exhaust Manifold, Z 12 XEP, Z 14 XEP
- DOHC-0-Engines Z 10 XE and Z 12 XE
- Camshaft Control, Z 10 XEP, Z 12 XE, Z 14 XEP (From End MY 2004 to MY 2005)
- Camshaft Control, Z 10 XEP, Z 12 XEP, Z 14 XEP (MY 2005 Onwards)
- Setting the Phase Sensor Disc with KM-954
- Camshaft Sensor
- Wheel Speed Sensor, Except Vectra-C/signum and Astra-H
- Timing Case
- Timing Chain Tensioner
- Bosch Motronic 7.6.2 Engine Control Unit
- Vacuum Hose Connector, Brake Servo
- General: Z 10 XE, Z 12 XE DOHC-0 Petrol Engines
- Fuel Distribution Pipe, Z 12 XE
- View of Engine Z 10 XE - Intake Side
- Crankshaft Guide Bearing, DOHC Engines
- View of Engine Z 10 XE - Exhaust Side
- View of Engine Z 12 XE - Intake Side
- View of Engine Z 12 XE - Exhaust Side
- Torque and Power Curves, Z 10 XE
- Torque and Power Curves, Z 12 XE
- Modifications in Comparison with Conventional DOHC-0 Petrol Engines - Exhaust Manifold Catalytic Converter
- Oxygen Sensors
- Cooling System
- Engine Management System - Motronic Me 1.5.5
- Engine Compartment Survey, Z 10 XE
- Engine Compartment Survey, Z 12 XE
- On-Board Diagnostics (OBD)
- Exhaust Gas Telltale (MIL)
- Engine Electronics Telltale
- Crank Drive Shaft Guide Bearing
- Z 10 XEP DOHC-0 Petrol Engine
- Twinport System
- New Components for DOHC-0 Petrol Engines
- Oil Non-Return Valve - DOHC-0 Petrol Engines
- Ribbed V-Belt Tensioner - DOHC-0 Petrol Engines
- Exhaust Manifold - Z 12 XE and Z 14 XEP Engines
- Spark Plugs - Z 10 XEP and Z 14 XEP Engine
- Starting and Driving Problems Following Re-Installation of Battery, TC P0101
- DOHC O-Petrol Engine (Z 12 XE, Z 12 XEP) (Engine Number)
- Checking Compression (Z 12 XE, Z 12 XEP, Without Air Conditioning, Rhd)
- How to Measure the Oil Temperature
- Checking Engine Oil Pressure (Z 12 XE, Z 12 XEP, Without Air Conditioning, Rhd)
- Checking Engine Oil Pressure (Z 12 XE, Z 12 XEP, with Air Conditioning, Lhd)
- How to Measure the Oil Consumption
- How to Check (Z 12 XE the Timing (Z 12 XEP, Without Air Conditioning, Rhd))
- Air Cleaner Housing, Air Duct (Illustration Z 12 XE)
- Engine Timing Side - Illustration
- How to Replace (Z 12 XE the Ribbed V-Belt (Z 12 XEP, Without Air Conditioning, Rhd))
- How to Replace (Z 12 XE the Ribbed V-Belt (Z 12 XEP, with Air Conditioning, Lhd))
- How to Replace (Z 12 XE the Ribbed V-Belt Tensioner (Z 12 XEP, Without Air Conditioning, Rhd))
- How to Replace (Z 12 XE the Ribbed V-Belt Tensioner (Z 12 XEP, with Air Conditioning, Lhd))
- How to Remove and Install (Z 12 XE the Timing Case (Z 12 XEP, Without Air Conditioning, Rhd))
- How to Remove and Install (Z 12 XE the Timing Case (Z 12 XEP, with Air Conditioning, Lhd))
- Engine - Spark Plugs Wet
- How to Replace (Z 12 XE the Front Crankshaft Seal Ring (Z 12 XEP, Without Air Conditioning, Rhd))
- How to Replace (Z 12 XE the Front Crankshaft Seal Ring (Z 12 XEP, with Air Conditioning, Lhd))
- Cylinder Head - Illustration
- How to Remove and Install (Z 12 XE the Cylinder Head Cover (Z 12 XEP, Without Air Conditioning, Rhd))
- Replace Gasket, Exhaust Manifold (Cylinder Head (Z 12 XE, Without Air Conditioning, Rhd))
- Replace Gasket Exhaust Manifold - Cylinder Head (Z 12 XE, with Air Conditioning, Lhd)
- How to Replace (Z 12 XE the Exhaust Manifold Gasket (Z 12 XEP, Without Air Conditioning, Rhd))
- Crank Drive, Cylinder Block (Illustration)
- How to Remove and Install (Z 12 XE the Flywheel (Z 12 XEP, Without AC, Rhd))
- How to Replace (Z 12 XE the Rear Crankshaft Seal Ring (Z 12 XEP, Without Air Conditioining, Rhd))
- How to Remove and Install (Z 12 XE the Crankshaft (Z 12 XEP, Without Air Conditioning))
- How to Remove and Install (Z 12 XE the Crankshaft (Z 12 XEP, with Air Conditioning))
- Engine Oil Change (Z 12 XE, Z 12 XEP, Without AC, Rhd)
- How to Replace (Z 12 XE the Oil Pressure Switch (Z 12 XEP, Without AC))
- How to Replace (Z 12 XE the Oil Pressure Switch (Z 12 XEP, with AC))
- How to Remove and Install (Z 12 XE the Oil Filter Housing (Without Air Conditioning, Rhd))
- How to Remove and Install (Z 12 XE the Oil Filter Housing (With Air Conditioning, Lhd))
- How to Remove and Install (Z 12 XE the Oil Pump Pressure Regulating Valve (Z 12 XEP, Without AC, Rhd))
- How to Remove and Install (Z 12 XE the Oil Sump (Z 12 XEP, Without Air Conditioning, Rhd))
- How to Remove and Install (Z 12 XE the Oil Intake Pipe (Z 12 XEP, Without Air Conditioning, Rhd))
- How to Remove and Install (Z 12 XE) the Oil Baffle Plate
- How to Remove and Install (Z 12 XE the Oil Pump (Z 12 XEP, Without AC, Rhd))
- How to Remove and Install the Oil Pump ((Z 12 XE, Z 12 XEP, with AC, Lhd))
- How to Remove and Install (Z 12 XE the Oil Dipstick Guide Tube (Without Air Conditioning, Rhd))
- How to Remove and Install (Z 12 XE the Oil Dipstick Guide Tube (With Air Conditioning, Lhd))
- Engine Noises from Engine Compartment Left Hand Silent Block Causes Engine Noises in the Passenger Compartment
- How to Replace (Both Sides) (Z 12 XE the Engine Mounting (Damping Block) (Z 12 XEP, Without AC, Rhd))
- How to Replace (Right-Hand Side) (Z 12 XE the Engine Mounting (Damping Block) (Z 12 XEP, Without AC, Rhd))
- How to Replace (Z12XE) the Engine Mounting (Damping Block)(rear)
- How to Replace (Left-Hand Side) (Z 12 XE the Engine Mounting (Damping Block) (Z 12 XEP, Without AC, Rhd))
- How to Remove and Install (Z 12 XE the Engine (Z 12 XEP, with Air Conditioning, Lhd))
- Engine Compartment Overview - Z 12 XE
- Check Fuel Pressure (Z 12 XE, Z 12 XEP, Without AC, Rhd)
- Special Service Tools
- Sealants, Lubricants and Locking Compounds
- Cylinder Head
- Crank Drive, Cylinder Block
- DOHC 0 Petrol Engines (Z 10 XE, Z 10 XEP) (Engine Number)
- How to Check (Z 10XE the Compression (Z 10 XEP))
- How to Measure (Z 10 XE the Oil Temperature (Z 10 XEP))
- How to Check (Z 10 XE the Engine Oil Pressure (Z 10 XEP Without AC))
- How to Check (Z 10 XE the Engine Oil Pressure (Z 10 XEP with AC))
- How to Check (Z 10 XE the Timing (Z 10 XEP))
- How to Adjust (Z 10 XE the J792900002 Timing (Z 10 XEP))
- Air Cleaner Housing, Air Duct (Illustration (Z 10 XE))
- How to Replace (Z 10 XE the Ribbed V-Belt (Z 10 XEP, Without AC))
- How to Replace (Z 10 XE the Ribbed V-Belt (Z 10 XEP, with AC))
- How to Replace (Z 10 XE the Ribbed V-Belt Tensioner (Z 10 XEP, Without AC))
- How to Replace (Z 10 XE the Ribbed V-Belt Tensioner (Z 10 XEP, with AC))
- How to Remove and Install (Z 10 XE the Timing Case (Z 10 XEP, Without AC))
- Toothed Belt Diagnosis - Possible Causes and Remedys
- How to Remove and Install (Z 10 XE the Timing Case (Z 10 XEP, with AC))
- How to Replace (Z 10 XE the Front Crankshaft Seal Ring (Z 10 XEP))
- How to Replace (Z 10 XE the Front Crankshaft Seal Ring (Z 10 XEP, with AC))
- How to Remove and Install (Z 10 XE the Cylinder Head Cover (Z 10 XEP))
- Replace Exhaust Manifold Gasket (Cast Manifold Version)
- How to Replace (Z 10 XE the Exhaust Manifold Cylinder Head Seal Ring (Z 10 XEP, with AC))
- How to Replace (Z 10 XE the Intake Manifold Gasket (Z 10 XEP))
- How to Remove and Install (Z 10 XE the Cylinder Head (Z 10 XEP, Without AC, Rhd))
- How to Remove and Install (Z 10 XE the Flywheel (Z 10 XEP))
- How to Replace (Z 10 XE the Rear Crankshaft Seal Ring (Z 10 XEP))
- How to Remove and Install (Z 10 XE the All Pistons with Con-Rod (Z 10 XEP, Without AC))
- How to Remove and Install (Z 10 XE the Crankshaft (Z 10 XEP, Without AC))
- Engine Oil Change (Z 10 XE, Z 10 XEP)
- How to Replace (Z 10 XE the Oil Pressure Switch (Z 10 XEP, Without AC))
- How to Replace (Z 10 XE the Oil Pressure Switch (Z 10 XEP, with AC))
- How to Remove and Install (Z 10 XE the Oil Filter Housing (Z 10 XEP, Without AC))
- How to Remove and Install (Z 10 XE the Oil Filter Housing (Z 10 XEP, with AC))
- How to Remove and Install (Z 10 XE the Oil Pump Pressure Regulating Valve (Z 10 XEP))
- How to Remove and Install (Z 10 XE the Oil Pan (Z 10 XEP))
- How to Remove and Install (Z 10 XE the Oil Intake Pipe (Z 10 XEP, Without AC))
- How to Remove and Install (Z 10 XE the Oil Baffle Plate (Z 10 XEP))
- How to Remove and Install (Z 10 XE the Oil Pump (Z 10 XEP, with AC))
- How to Remove and Install (Z 10 XE the Dipstick Guide Tube (Z 10 XEP, with AC, Lhd))
- How to Replace (Both Sides) (Z 10 XE the Engine Mounting (Damping Block) (Z 10 XEP))
- How to Replace (Right Side) (Z 10 XE the Engine Mounting (Damping Block) (Z 10 XEP))
- How to Replace (Rear) (Z 10 XE the Engine Mounting (Damping Block) (Z 10 XEP))
- How to Replace (Left Side) (Z 10 XE the Engine Mounting (Damping Block) (Z 10 XEP))
- How to Remove and Install (Z 10 XE the Engine (Z 10 XEP, Without AC, Rhd))
- Engine Compartment Overview - Z 10 XE
- How to Check (Z 10 XE the Fuel Pressure (Z 10 XEP))
- Toothbelt - Service Intervall Overview
- How to Replace (Z 10 XE the Accelerator Pedal (Z 10 XEP))
- Special Tools
- Sealing, Lubricating and Retaining Agents
- Main Data
- How to Test Values the Adjustment Values
- Ribbed V-Belt - Engine Timing
- Oil Circuit
- Engine Management
- Torque Guide Values
- Recommended Torque Values
- Engine Repair While Using Engine Short Block (Z 10 XE, Z 10 XEP, Without AC)
- How to Remove and Install (Z 12 XE the Engine (Z 12 XEP, Without Air Conditioning, Rhd))
- How to Remove and Install (Z 12 XE the Manual Transmission (Z 12 XEP))
- Manual Transmission, Detach and Reattach from Engine
- How to Check and Inspect the Cylinder Head and Attachments (Overhaul Cylinder Head)
- How to Replace (Z 12 XE the Drive Shaft Guide Bearing (Z 12 XEP))
- How to Replace (Z 10 XE the Drive Shaft Guide Bearing (Z 10 XEP))
- Detach and Attach Manual Transmission From/to Engine
- Replace Piston Rings
- How to Replace (Z 10 XE the One Con-Rod Bearing (Z 10 XEP))
- How to Inspect (Z 10 XE the Crankshaft (Z 10 XEP))
- How to Inspect (Z 12 XE the Crankshaft (Z 12 XEP))
- How to Replace (Z 12 XE the One Con-Rod Bearing (Z 12 XEP))
- How to Check (Z 10 XE the Engine Pressure Loss (Z 10 XEP))
- Air Cleaner Housing, Air Duct (Illustration (Z 10 XEP))
- How to Remove and Install (Z 10 XE the Cylinder Head (Z 10 XEP, with AC))
- How to Remove and Install (Z 10 XE the Both Camshafts (Z 10 XEP))
- How to Remove and Install (Z 10 XE the All Pistons with Con-Rod (Z 10 XEP, with AC))
- Replace Piston
- Air Cleaner Housing, Air Duct (Illustration Z 12 XEP)
- Replace Exhaust Manifold (Z 12 XEP, with Air Conditioning)
- Replace Exhaust Manifold (Z 12 XEP, Without Air Conditioning)
- Replace Oil Dipstick Guide Tube (Z 12 XEP)
- Family-0-Engines (MY98-2004) - Rattling Noise from Timing Chain
- Spark Plug Damages - Possible Causes and Failure Modes
- How to Replace (Z 12 XEP Up to MY 2005.5) the Engine Mounting (Damping Block) (Rear)
- How to Replace (Z 12 XEP from MY 2005.5) the Engine Mounting (Damping Block) (Rear)
- Replace Exhaust Manifold Gasket (Conversion from Cast Manifold to Sheet Metal Manifold)
- Engine Z10/12/14XEP - Loss of Oil Between Oil Filter Modul and Engine Block
- ABS
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Central Door Locking System
- Central Electrics
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Other Accessories
- Paint
- Painting Repair Operations
- Painting Repair System
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seats, Upholstery, Inner Trim Panels
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
