Compressor (4JB1 - T)
Type DKS - 17CH
Displacement 168 cc / rev.
Construction Swash plate
Magnetic clutch:
Rated voltage 12 volts DC
Current consumption 3.7A
Stalling torque 48 Nm / min.
Home/Opel/Frontera/Opel Frontera A (1992-1998)/Repair manual/Air Conditioning/Technical Data Compressor (4JB1-T Engine)
Contents
Section: Air Conditioning- Introduction Air Conditioning
- Survey - Frontera
- The Opel/vauxhall Checking System
- Checking Equipment Air Conditioning System
- General Instructions Air Conditioning
- Air Conditioning
- Rated Fuse Current of the Fused Jumper Wire
- Safety Measures Air Conditioning
- Safety Measures
- Block Diagram 25 Tds
- Exchange AC Compressor
- Checking Equipment Air Conditioning
- Refrigerant Circuit
- Block Diagram X 20 SE, X 22 XE
- Function and Mechanical Check Air Conditioning
- Component Location
- Air Conditioning General
- Function Check Air Conditioning
- Compressor
- Receiver-Dryer
- A, Diagnostic System Check
- Refrigerant Leaks from Evaporator
- Performance Test Air Conditioning
- Accumulator
- Compressor, 4JB1T Turbodiesel Engine
- B-01, Refrigerant Circuit Check
- Performance Data for X20SE/X22XE Engines Air Conditioning
- Evaporator
- Location of Components, X20SE and X22XE Petrol Engines
- B-02, Electrical Function Check
- Performance Data for 4JB1-TC Engines: Air Conditioning
- Thermostatically Controlled Expansion Valve
- Location of Components, 4JB1T Turbodiesel Engine
- B-03, Mechanical Function Check
- Trouble-Shooting Tables for Mechanical Defects - Trouble-Shooting Table,general
- Service Connections
- C-01, Blower Heating Circuit
- Trouble-Shooting Tables for Mechanical Defects - High Pressure Unusually Low
- Pressure Switch Assembly
- C-02, Air Conditioning System Information Switch Circuit
- Trouble-Shooting Tables for Mechanical Defects - High Pressure Unusually High
- Thermostat
- C-03, Air Conditioning System Cutoff Relay Circuit
- Trouble-Shooting Tables for Mechanical Defects - Low Pressure Unusually Low
- Cutoff Relay (Diesel Models)
- C-04, Blower Radiator Motors Circuit
- Trouble-Shooting Tables for Mechanical Defects - Low Pressure Unusually High
- Circuit Diagram, Air Conditioning (Petrol Models)
- C-05, Function-Group Ripped V-Belt
- Trouble-Shooting Tables for Mechanical Defects-High/low Pressure Unusually High
- Circuit Diagram, Air Conditioning (Diesel Models)
- C-06, Function-Group Refrigerant Lines
- System Survey-Installation Position of Components,frontera with X20SE/X22XE Eng
- Technical Data
- C-07, Function-Group Condenser
- System Survey-Installation Position of Components,frontera with 4JB1-TC Engines
- C-08, Function-Group Air Distribution
- C-09, Function-Group Compressor, Expansion Valve, Control Valve
- Survey of System - Block Diagram for Frontera with 4JB1-TC Engines
- C-10, Function-Group Refrigerant Circuit, High Pressure Side
- Survey of System - Fuse Box Engine Compartment
- C-11, Function-Group Refrigerant Circuit, Low Pressure Side
- Function Description for X20SE and X22XE Engines
- C-12, Function-Group Refrigerant Circuit, High and Low Pressure Side
- Function Description for 4JB1-TC Engines
- Air Conditioning, New Turbodiesel Engine General
- Terminal Assignment
- Trouble-Shooting Table for Electrical Faults
- Location of Components (Air Conditioning)
- Parts Location
- Test Program - AC Front. MY '95.5 Checking Instructions
- Circuit Diagram (Air Conditioning)
- Wiring Schematic Diagram 25 Tds
- Test Program - AC Front. MY '95.5 Voltage Supply
- Wiring Schematic Diagram X 20 SE, X 22 XE
- Test Program - AC Front. MY '95.5 Air Conditioning Switch S101
- Test Program - AC Front. MY '95.5 Pressure Switch S20 (4JB1-TC Only)
- Test Program - AC Front. MY '95.5 Electrical Thermostat K128 (X20SE/X22XE)
- Test Program - AC Front. MY '95.5 Electrical Thermostat K128 (4JB1-TC Only)
- Test Program - AC Front. MY '95.5 Compr. Clutch Y1 (X22XE/X20SE Only)
- Test Program - AC Front. MY '95.5 Compressor Clutch (4JB1-TC Only)
- Test Program - AC Front. MY '95.5 Auxiliary Fan Motor M11
- Test Program - AC Front. MY '95.5 Fan Switch S3
- Test Program - AC Front. MY '95.5 Fan Motor M3
- Test Program - AC Front. MY '95.5 Fast Idle Solenoid Valve Y57(4JB1-TC)
- Terminal Assignment, 5-pin Relay Base of Fan Relay K7
- Terminal Assignment, 5-pin Relay Base of Fan Relay K6
- Terminal Assignment,3-pin Wiring Harness Plug of AC Switch S101
- Terminal Assignment, Wiring Harness Plug for Fan Switch S3
- Terminal Assignment,4-pin Wiring Harness Plug for Pressure Switch S20
- Terminal Assignment,3-pin Wiring Harness Plug for Electrical Thermostat K128
- Terminal Assignment, 9-pin Relay Base of Cutoff Relay K60
- Terminal Assignment, 9-pin Relay Base of Auxiliary Fan Relay K52
- Terminal Assignment,2-pin Wiring Harness Plug for Auxiliary Fan Motor M11
- Terminal Assignment,2-pin Wiring Harness Plug of Fan Motor M3
- Terminal Assignment,6-pin Wiring Harness Plug, Resistor for Fan Motor R30
- Terminal Assignment,2-pin Wiring Harness Plug, Fast Idle Solenoid Valve Y57
- Circuit Diagram - Air Conditioning (Excerpt from Main Circuit Diagram)
- Frontera MY '94 - Survey of System Installation Position of Components
- Block Diagram for Frontera C24NE Engines
- Block Diagram for Frontera with 23DTR Engines
- Fuse Box, Engine Compartment Frontera MY '94
- Function Description Frontera MY '94
- Trouble-Shooting Table for Electricalfaults Frontera MY '94
- Test Program - AC Front. MY '94 Test Instructions
- Test Program - AC Front. MY '94 Voltage Supply
- Test Program - AC Front. MY '94 Air Conditioning Switch S101
- Test Program - AC Front. MY '94 Pressure Switch S27/28
- Test Program - AC Front. MY '94 Electronic Thermostat P41
- Air Conditioning Compressor Drive
- Test Program - AC Front. MY '94 Compressor Clutch Y1 (C24NE Only)
- Test Program - AC Front. MY '94 Compressor Clutch Y1 (23DTR Only)
- Test Program - AC Front. MY '94 Auxiliary Fan Motors M11 AND M35*
- Test Program - AC Front. MY '94 Fan Switch S24
- Test Program - AC Front. MY '94 Fan Motor M10
- Terminal Assignment, 6-pin Relay Base for Fan Relay K7
- Terminal Assignment, 9-pin Relay Base for Compressor Relay K6
- Terminal Assignment,3-pin Wiring Harness Plug, Air Conditioning Switch S101
- Terminal Assignment,8-pin Wiring Harness Plug, Fan Switch S24
- Terminal Assignment,2-pin Wiring Harness Plug, Pressure Switch S27/S28
- Terminal Assignment,3-pin Wiring Harness Plug, Electronic Thermostat P41
- Terminal Assignment, 9-pin Relay Base for Auxiliary Fan Relays K51 AND K87*
- Terminal Assignment,2-pin Wiring Harness Plugs, Auxiliary Fan Motors M11 AND M35*
- Terminal Assignment, 6-pin Relay Base for Cutoff Relay K60
- Terminal Assignment,2-pin Wiring Harness Plug, Fan Motor M10
- Time Allowance - Air Conditioning Frontera MY '95.5
- How to Repair and Storage of Air Conditioning Components the General Instructions
- Safety Regulations for Handling Refrigerant
- Refrigerant R134A
- Handling Refrigerant Containers
- Assembly Diagram - Air Conditioning
- Circulation Plan - Air Conditioning
- Air Conditioning Diagnosis, General
- Discharge Pressure Abnormally High, Checking Diagnosis
- Discharge Pressure Abnormally Low, Checking Diagnosis
- Suction Pressure Abnormally High, Checking Diagnosis
- Suction Pressure Abnormally Low, Checking Diagnosis
- Suction and Discharge Pressure Abnormally High, Checking Diagnosis
- Air Conditioning Checking, Refrigerant System with Manifold Gauge
- How to Drain and Recover Refrigerant the Air Conditioning System
- Air Conditioning System, Evacuate
- Air Conditioning System, Charge
- How to Remove and Install the Pipe and Hose Lines
- How to Remove and Install the Compressor
- How to Remove and Install (VM41B Engine) the Compressor Drive Shaft
- How to Remove and Install the Condenser Assembly
- How to Remove and Install the Receiver/dryer
- How to Remove and Install the Pressure Switch
- How to Remove and Install the Evaporator Assembly
- How to Remove and Install the Electronic Thermostat
- How to Remove and Install the Evaporator Core And/or Expansion Valve
- How to Replace the Air Conditioning Switch
- Special Service Tools Heating, Ventilation, Air Conditioning
- Technical Data Refrigerant
- Technical Data Evaporator
- Technical Data Condenser
- Technical Data Expansion Valve
- Technical Data Thermoswitch
- Technical Data Pressure Switch
- Technical Data Compressor (Up to MY'95.5)
- Technical Data Compressor (4JB1-T Engine)
- Air Con. Inoperative Resulting from Insufficient Refrigerant
- How to Check and Adjust the V-Belt Tension, Power Steering Pump And/ or AC Compressor
- How to Remove and Install the AC Compressor
- How to Remove and Install the Power Steering Pump, Version with AC
- Illustration - Ribbed V-Belt Routing with Power Steering and AC
- How to Check and Adjust the V-Belt Tension, Power Steering Pump And/or AC Compressor
- How to Check and Adjust the V-Belt Tension, Power Steering Pump and AC
- ABS
- ABS 415
- Accessories
- Additional Lighting
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Cih Petrol Engine
- Clutch
- Clutch and Transmission
- Cooling System
- Diesel Engine
- Distributor Transmission Four Wheel Drive
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Four Wheel Drive
- OHC Petrol Engine
- Other Accessories
- Paint
- Painting Repair Operations
- Painting Repair System
- Power Steering
- Radiator Grille
- Radio
- Radio Interference Suppression
- Rear Axle and Rear Wheel Suspension
- Rear Axle Four Wheel Drive
- Rear Axle Rear Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses