| Description | Applications | Catalogue Number | Part number |
|---|---|---|---|
| Adhesive sealing compound (black) | Sealing compound between metallic surfaces, cork-, hard fibre-, and rubber seals | 15 03 295 | 90 485 251 |
| Screw locking compound (red) | Locking compound for adhesion of screw connections | 15 10 181 | 90 542 117 |
| Surface sealant (green) | To seal oil filler bolt/oil drain bolt | 15 03 170 | 90 542 114 |
| Silicone grease (white) | Grease for all temperature-stressed sliding connections and for plastic seal rings | 19 70 206 | 90 167 353 |
| Special grease (black) | To install oxygen sensors | 19 48 569 | 90 513 210 |
| Mo S2-lubricating paste (grey) | Lubricating paste of hydraulic valve lifter and camshaft | 19 48 565 | 90 018 024 |
| Grease (brown) | Multi-purpose grease for alternator, starter, etc. | 19 48 606 | 90 510 336 |
Home/Opel/Corsa/Opel Corsa C (2001-2011)/Repair manual/DOHC Petrol Engine/Technical Data Sealants, Lubricants and Locking Compounds
Contents
Wiring diagrams Section: DOHC Petrol Engine- Air Mass Meter, 4 Cylinder Petrol
- Air Mass Meter, Z18XE, Z20LEL, Y22XE, Z22XE
- Compression 3-cylinder, Unsynchronised
- Exhaust Gas Recirculation Valve, Motronic M1.5.5 (MY 2000 and MY 2001)
- Oil Filter
- Exhaust Gas Recirculation Valve, Multec S (MY 2000 and MY 2001)
- Exhaust Gas Recirculation Valve, Simtec (MY 2000 and MY 2001)
- Exhaust Manifold for the Z 14 XEP - Corsa-C, Combo-C, Tigra-B, Astra-H
- Lubrication of Radial Shaft Seal Rings No Longer Applicable
- Camshaft Sensor, Motronic M1.5.6
- Camshaft Sensor, Multec S/f Except Z14XE MY2004
- Camshaft Sensor, Simtec 70/71/81
- Cylinder Block - X 10 XE, Z 10 XE, X 12 XE and Z 12 XE Engines
- Ignition, Primary, Z14XE, Z16XE, Z16YNG
- Crankshaft Guide Bearing, DOHC Gasoline Engines
- Cylinder Head - Z 10 XEP, Z 12 XE and Z 14 XEP Engines
- Engine Timing - Z 10 XEP, Z 12 XE and Z 14 XEP
- Oil Baffle Plate - X 12 XE, Z 12 XE, Z 14 XEP Engines
- Timing Chain Tensioner - Z 10 XEP, Z 12 XE, Z 14 XEP Engines
- Pedal Position Double Signal, Motronic (MY2001)
- Pedal Position Double Signal, Multec S(f) (MY 2001)
- Pedal Position Double Signa,l Simtec (MY 2001)
- Throttle Valve Potentiometer (Double Signal), Multec/trionic (MY 2001,MY 2002 and MY 2003), Simtec (MY 2001 and MY 2002)
- Throttle Valve Potentiometer (Double Signal), Motronic (As of MY2001)
- Pedal Position Double Signal, All Petrol (MY 2002, MY 2003 and MY 2004)
- Exhaust Gas Recirculation Valve, All Petrol (MY 2002, MY 2003 and MY2004)
- Exhaust Gas Recirculation Valve, Motronic1.5.5 and Motronic 3.11 (MY2002 and MY 2003)
- New Camshaft Sensor - Z 10 XEP, Z 12 XEP, Z 14 XEP Petrol Engines
- DOHC-0 Engine Z 12 XEP - Agila and Corsa-C
- Elimination of Twinport Sensor - Z 10 XEP, Z 12 XEP and Z 14 XEP Petrol Engines
- Specific Characteristics of the Z 12 XEP Engine
- Throttle Valve Potentiometer (Double Signal), Simtec (MY 2003), Simtecand Multec-F (MY 2004)
- View of the Engine, Z 12 XEP, Z 14 XEP
- Torque and Power Diagram, Z 12 XEP
- Exhaust Manifold, Z 12 XEP, Z 14 XEP
- DOHC-0-Engines Z 10 XE and Z 12 XE
- Camshaft Control, Z 10 XEP, Z 12 XE, Z 14 XEP (From End MY 2004 to MY 2005)
- Camshaft Control, Z 10 XEP, Z 12 XEP, Z 14 XEP (MY 2005 Onwards)
- Setting the Phase Sensor Disc with KM-954
- Camshaft Sensor
- Wheel Speed Sensor, Except Vectra-C/signum and Astra-H
- Timing Case
- Z 10 XE, Z 12 XE DOHC-0 Petrol Engines
- Timing Chain Tensioner
- View of Engine Z 10 XE - Intake Side
- Bosch Motronic 7.6.2 Engine Control Unit
- View of Engine Z 10 XE - Exhaust Side
- View of Engine Z 12 XE - Intake Side
- View of Engine Z 12 XE - Exhaust Side
- Fuel Distribution Pipe, Z 12 XE
- Torque and Power Curves, Z 10 XE
- Crankshaft Guide Bearing, DOHC Engines
- Torque and Power Curves, Z 12 XE
- Engine Management System - Motronic Me 1.5.5
- Engine Compartment Survey, Z 10 XE
- Engine Compartment Survey, Z 12 XE
- Block Diagram Engine Z 10 XE and Z 12 XE
- Z 14 XE Dohc-I Petrol Engine
- Torque and Power Curves, Z 14 XE
- Engine Compartment Survey, Z 14 XE
- Block Diagram, Engine Z 14 XE
- Engine/transmission Bearings
- Engine Cooling Module
- Z 10 XEP DOHC-0 Petrol Engine
- Z 14 XEP DOHC-0 Petrol Engine
- Twinport System
- New Components for DOHC-0 Petrol Engines
- Oil Non-Return Valve - DOHC-0 Petrol Engines
- Ribbed V-Belt Tensioner - DOHC-0 Petrol Engines
- Exhaust Manifold - Z 12 XE and Z 14 XEP Engines
- Spark Plugs - Z 10 XEP and Z 14 XEP Engine
- Remove and Install Exhaust Gas Recirculation Valve
- How to Remove and Install the Exhaust Gas Recirculation Pipe
- Engine Number
- Check Compression (Z 10 XE, Z 10 XEP, with Air Conditioning System, Lhd)
- Measure Oil Temperature (Z 10 XE, Z 10 XEP)
- Illustration: Z 10 XE
- Replace Front Crankshaft Seal Ring (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Install Cylinder Head Cover (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Install Both Camshafts (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Install Cylinder Head (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Illustration: Z 10 XE, Z 10 XEP
- Engine Oil Change (Z 10 XE, Z 10 XEP)
- Replace Oil Pressure Switch (Z 10 XE, Z 10 XEP)
- Remove and Install Oil Pump Pressure Control Valve (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Install Oil Pan (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Replace Oil Intake Pipe (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Refit Oil Baffle Plate (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Refit Oil Pan (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Check Cooling System for Leaks (Z 10 XE, Z 10 XEP)
- Check for Engine Leaks (CO Content in Coolant) (Z 10 XE, Z 10 XEP)
- Remove and Refit Engine (Z 10 XE, Z 10 XEP, with Air Conditioning)
- Survey of Engine Compartment, Z 10 XE
- Check Fuel Pressure (Z 10 XE, Z 10 XEP, with Air Conditioning System, Lhd)
- Special Service Tools
- Sealants, Lubricants and Locking Compounds
- Specifications
- Adjustment Value, Checking Values
- Ribbed V-Belt
- Engine Control Unit
- Cooling System
- Oil Circuit
- Cylinder Head
- Crank Drive, Cylinder Block
- Engine Management
- Torque Guide Values (Z 10 XE, Z 10 XEP)
- DOHC O Petrol Engine (Z 12 XE, Z 12 XEP, Z 14 XEP) Engine Number
- Check Compression (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Check Oil Temperature (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Check Timing (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Adjust Timing (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Illustration - Air Cleaner Housing, Air Ducts Z 12 XE
- Illustration Z 12 XE, Z 12 XEP, Z 14 XEP
- Replace Ribbed V-Belt (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Front Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Cylinder Head Cover (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Both Camshafts (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Exhaust Manifold Gasket (Z 12 XE, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Intake Manifold Gasket (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Valve Stem Seal (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Engine Oil with Filter Change (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Oil Pressure Switch (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Removing and Installing Oil Filter Housing (Z 12 XE, Z 14 XEP Up to MY 2004)
- Removing and Installing Oil Pump Pressure Control Valve (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Oil Pan (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Oil Intake Pipe (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Oil Pump (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- How to Remove and Install (Z 12 XE the Oil Baffle Plate (Z 14 XEP))
- Removing and Installing Oil Dipstick Guide Tube (Z 12 XE, Z 14 XEP Up to MY 2004, with Air Conditioning, Lhd)
- Check for Engine Leaks (CO Content in Coolant) (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Mta)
- Engine Compartment Overview (Z 12 XE)
- DOHC I Petrol Engine (Z 14 XE, Z 16 YNG) Engine Number
- Measure Oil Temperature (Z 14 XE, Z 16 YNG)
- Air Cleaner Housing, Air Ducts Illustration Z 14 XE, Z 16 YNG
- Replace Ribbed V-Belt (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- How to Replace (Z 14 XE the Front Toothed Belt Cover (Upper) (16 With AC, Lhd))
- Replace Toothed Belt (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- Replace Toothed Belt Tension Roller (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- Replace Toothed Belt Guide Roller (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- How to Replace (Z 14 XE the Toothed Belt Drive Gear / Crankshaft Pulley (Z 16 YNG with AC, Lhd))
- How to Remove and Install (Z 14 XE the Cylinder Head Cover (Z 16 YNG with AC, Lhd))
- How to Remove and Install (Z 14 XE) the Drive Disc
- J 320720 Replace Rear Crankshaft Seal Ring (Z 14 XE, Z 16 YNG)
- Remove and Install Oil Pan (Z 14 XE, Z 16 YNG with AC, Lhd)
- 009 Replace Intake Pipe for Oil Pump (Z 14 XE, Z 16 YNG with AC, Lhd)
- Check Engine for Leaks (Amount of CO in Coolant) (Z 14 XE, Z 16 YNG)
- Check Cooling System for Leaks (Z 14 XE, Z 16 YNG)
- Torque Guide Values (Z 14 XE, Z 16 YNG)
- Replace Front Crankshaft Seal Ring (Z 10 XE, Z 10 XEP, with Air Conditioning, Lhd)
- Remove and Install Flywheel (Z 10 XE, Z 10 XEP)
- Replace Rear Crankshaft Seal Ring (Z 10 XE, Z 10 XEP)
- Remove and Install Crankshaft (Z 10 XE, Z 10 XEP, with Air Conditioning)
- Remove and Install Oil Pump (Z 10 XE, Z 10 XEP, with Air Conditioning, Lhd)
- Replace Engine Damping Blocks (Both Sides) (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Replace Engine Damping Block (Right Side) (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Replace Engine Damping Block (Left Side) (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Removing and Installing Manual Transmission (Mt) from Engine (Z 10 XE, Z 10 XEP, with Air Conditioning System, Lhd)
- Replace Ribbed V-Belt (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Front Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Exhaust Manifold Gasket (Z 12 XE, Z 14 XEP, Without Air Conditioning, Lhd)
- Remove and Install Flywheel (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Rear Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Crankshaft (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning)
- Remove and Install Oil Pump (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Engine Damping Blocks (Both Sides) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Engine Damping Block (Right Side) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Rear Reaction Member (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Engine Damping Block (Left Side) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Removing and Installing Manual Transmission (Mta) from Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning System, Lhd)
- Check Compression (Z 14 XE, Z 16 YNG with AC, Rhd)
- Adjust Timing (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- How to Check and Correct (Z 14 XE the Toothed Belt Tension (Z 16 YNG with AC, Lhd))
- How to Replace (Z 14 XE the Intake Manifold Gasket (Z 16 YNG with AC, Rhd))
- How to Replace (Z 14 XE the Gasket - Intake Manifold Upper Part (With AC, Rhd))
- How to Remove and Install (Z 14 XE the Cylinder Head (Z 16 YNG with AC))
- How to Replace (Z 14 XE the Engine Vent Flange (With AC, Rhd))
- Engine Oil Change (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- Replace Engine Damping Blocks (Both Sides) (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- How to Replace (Right) (Z 14 XE the Engine Damping Block (Z 16 YNG with AC, Rhd))
- How to Replace (Z 14 XE the Engine Damping Block (Left) (Z 16 YNG with AC, Rhd))
- Z18XE Engine - No Compression Because of a Broken Valve Spring
- Remove and Install Engine (Z 14 XE, Z 16 YNG with AC, Rhd)
- 008 Remove and Install Automatic Transmission with Engine Torque Converter (Z14 XE, AC, Rhd)
- Torque Guide Values (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Engine Z10/Z12/Z14XE/P - Strong Vibration from Poly-V-Belt, Often Together with DTC P0300-P0304 (Misfire)
- Family-0-Engines (MY98-2004) - Rattling Noise from Timing Chain
- Dohc-I Petrol Engine (Z 18 XE)
- How to Check (Z 18 XE the Compression (With Air Conditioning, Lhd))
- How to Measure (Z 18 XE) the Oil Temperature
- Engine Z18XE - DTC P1372(2) Crankshaft Segment Failure
- How to Check (Z 18 XE the Engine Oil Pressure (With Air Conditioning, Lhd))
- How to Check (Z 18 XE the Timing (With Air Conditioning, Lhd))
- How to Check and Correct (Z 18 XE the Toothed Belt Tension (With Air Conditioning, Lhd))
- Air Cleaner Housing, Air Ducts
- How to Replace (Z 18 XE the Ribbed V-Belt (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Ribbed V-Belt Tensioner (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Upper Section (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Lower Section (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt Tension Roller (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt Guide Roller (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Rear (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Cylinder Head Cover (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Camshaft Sprockets (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Camshaft Seal Ring (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Both Camshafts (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Exhaust Manifold Gasket (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Intake Manifold Gasket (With Air Conditioning, Lhd))
- Engine Oil with Filter Change (Z 18 XE, with Air Conditioning, Lhd)
- How to Remove and Install (Z 18 XE the Oil Filter Housing (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Crankshaft Front Seal Ring (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Oil Pan (With Air Conditioning, Lhd))
- 020 Additional Work When Replacing the Oil Pan (Z 18 XE, with Air Conditioning, Lhd) (Oil Pan Removed)
- How to Remove and Install (Z 18 XE the Oil Pump (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Oil Pump Pressure Regulating Valve (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the 009 Oil Intake Pipe (With Air Conditioning, Lhd) (Oil Sump Removed))
- How to Remove and Install (Z 18 XE the Oil Dipstick Guide Tube (With Air Conditioning, Lhd))
- How to Top Up and Bleed (Z 18 XE) the Cooling System
- How to Check for Leaks (Z 18 XE) the Cooling System
- How to Check for Leaks the Engine ((CO Content in Coolant) (Z 18 XE))
- How to Remove and Install (Z 18 XE the Fan Motor (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Radiator (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Thermostat with Coolant Connection (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Coolant Pump (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Coolant Pipe (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Engine Damping Blocks (Both Sides) (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Front Reaction Member (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Rear Reaction Member (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Right Engine Damping Block (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Left Engine Damping Block (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Engine (With Air Conditioning, Lhd))
- Manual Transmission From/to Engine, Detach and Attach (Z 18 XE, with Air Conditioning, Lhd)
- How to Check (Z 18 XE the Fuel Pressure (With Air Conditioning, Lhd))
- Technical Data Sealants, Lubricants and Locking Compounds
- Torque Guide Values (Z 18 XE)
- Remove and Install Adapter, Exhaust Gas Recirculation Valve
- Check Engine Oil Pressure (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Mt)
- Removing and Installing Manual Transmission (Mt) from Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning System, Lhd)
- Repair Engine Using a Short Block (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning)
- Check Engine Oil Pressure (Z 14 XE Without AC, Lhd, Z 16 YNG)
- Check Timing (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Fly Wheel (Z 14 XE Without Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Crankshaft (Z 14 XE Without Air Conditioning, Z 16 YNG)
- Remove and Install Reaction Member (Rear) (Z 14 XE, Z 16 YNG with AC, Rhd)
- How to Remove and Install (Z 14 XE the Engine (Z 16 YNG Without AC, Lhd))
- 007 Remove and Install Engine Manual Transmission (Z 14 XE Without Air Conditioning Lhd, Z 16 YNG)
- Check Fuel Pressure (Z 14 XE Lhd, Z 16 YNG)
- Replace Intake Air Temperature Sensor (Z 14 XE, Z 16 YNG with AC, Rhd)
- How to Remove and Install (Z 18 XE the Coolant Connection (With Air Conditioning, Lhd))
- Check Engine Oil Pressure (Z 10 XE, Z 10 XEP)
- Repair Engine Using a Short Block (Z 10 XE, Z 10 XEP, Without Air Conditioning)
- Replace Valve Stem Seals (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- J 312315 Replace Valve Stem Seal (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- How to Remove and Install the Cylinder Block Ventilation Pipe
- How to Replace (Z 18 XE the J 312315 Valve Stem Seals (With Air Conditioning, Lhd))
- Check Engine Pressure Loss (Z 10 XE, Z 10 XEP)
- How to Replace the Piston Rings
- Replace One Con-Rod Bearing (Z 10 XE, Z 10 XEP, Lhd)
- Measure Crankshaft (Z 10 XE, Z 10 XEP)
- Check Engine Pressure Loss (Z 12 XE, Z12 XEP, Z 14 XEP)
- Replace One Con-Rod Bearing (Z 12 XE, Z 12 XEP, Z 14 XEP, Lhd)
- Check Crankshaft Alignment (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Check Engine Pressure Loss (Z 14 XE, Z 16 YNG)
- Remove and Install Lower Section of Toothed Belt Cover (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Replace Rear Toothed Belt Cover (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Replace Front Camshaft Sealing Ring (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Remove and Install Both Camshafts (Z 14 XE, Z 16 YNG with AC, Rhd)
- Replace Intake Manifold Lower Section (Z 14 XE, with Air Conditioning, Rhd)
- Replace Piston Rings
- Replace One Con-Rod Bearing (Z 14 Without Air Conditioning Lhd, Z 16 YNG)
- Replace Front Crankshaft Seal Ring (Z 14 XE Lhd, Z 16 YNG)
- Remove and Install All Pistons with Con-Rods (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Measure Crankshaft (Z 14 XE, Z 16 YNG)
- Replace Oil Filter Short Circuit Valve (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Additional Work When Replacing Oil Pan (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Oil Pump (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Check Oil Pump (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Oil Pump Pressure Regulator Valve (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Oil Dipstick Guide Tube (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Repair Engine Using a Short Block (Z 14 XE Without AC, Lhd, Z 16 YNG)
- How to Check (Z 18 XE) the Engine Pressure Loss
- How to Replace (Z 18 XE the One Con-Rod Bearing (With Air Conditioning, Lhd))
- How to Check Alignment (Z 18 XE) the Crankshaft
- How to Replace (Z 18 XE the Oil Filter Short-Circuit Valve (With Oil Filter Housing))
- How to Replace (Z 18 XE the Oil Filter Short-Circuit Valve (With Oil Filter Cartridge))
- Check Oil Pump
- Flexible Maintenance Intervals
- How to Remove and Install (Z 14 XEP) the Front Reaction Member
- Chemical Products
- Remove and Install Spark Plugs (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- How to Remove and Install (Z 18 XE the Spark Plugs (With Air Conditioning, Lhd))
- Flexible Service Intervals
- Replace Exhaust Manifold (Z 12 XEP, Z 14 XEP-Combo)
- Remove and Install Exhaust Gas Recirculation Valve (Z 12 XE, Z 12 XEP, Z 14 XEP)
- How to Remove and Install the Attaching Parts to Cylinder Head
- Remove and Install Oil Filter Housing (Z 12 XEP, Z 14 XEP from MY 2005)
- Replace Oil Dipstick Guide Tube (Z 12 XEP, Z 14 XEP from MY 2005)
- How to Replace (From MY 05) the Crankshaft Rear Seal Ring
- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Automatic Transmission Front Wheel Drive
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Cruise Control
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Folding Sunroof
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle Front Wheel Drive
- Rear End
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses