The engine number (arrow) is located on the transmission side of the cylinder block under the oil filter housing.
Note. When installing an engine short block, the engine number must be stamped on the cylinder block before installation.
Contents
Wiring diagrams Section: DOHC Petrol Engine- Air Mass Meter, 4 Cylinder Petrol
- Air Mass Meter, Z18XE, Z20LEL, Y22XE, Z22XE
- Compression 3-cylinder, Unsynchronised
- Exhaust Gas Recirculation Valve, Motronic M1.5.5 (MY 2000 and MY 2001)
- Oil Filter
- Exhaust Gas Recirculation Valve, Multec S (MY 2000 and MY 2001)
- Exhaust Gas Recirculation Valve, Simtec (MY 2000 and MY 2001)
- Exhaust Manifold for the Z 14 XEP - Corsa-C, Combo-C, Tigra-B, Astra-H
- Lubrication of Radial Shaft Seal Rings No Longer Applicable
- Camshaft Sensor, Motronic M1.5.6
- Camshaft Sensor, Multec S/f Except Z14XE MY2004
- Camshaft Sensor, Simtec 70/71/81
- Cylinder Block - X 10 XE, Z 10 XE, X 12 XE and Z 12 XE Engines
- Ignition, Primary, Z14XE, Z16XE, Z16YNG
- Crankshaft Guide Bearing, DOHC Gasoline Engines
- Cylinder Head - Z 10 XEP, Z 12 XE and Z 14 XEP Engines
- Engine Timing - Z 10 XEP, Z 12 XE and Z 14 XEP
- Oil Baffle Plate - X 12 XE, Z 12 XE, Z 14 XEP Engines
- Timing Chain Tensioner - Z 10 XEP, Z 12 XE, Z 14 XEP Engines
- Pedal Position Double Signal, Motronic (MY2001)
- Pedal Position Double Signal, Multec S(f) (MY 2001)
- Pedal Position Double Signa,l Simtec (MY 2001)
- Throttle Valve Potentiometer (Double Signal), Multec/trionic (MY 2001,MY 2002 and MY 2003), Simtec (MY 2001 and MY 2002)
- Throttle Valve Potentiometer (Double Signal), Motronic (As of MY2001)
- Pedal Position Double Signal, All Petrol (MY 2002, MY 2003 and MY 2004)
- Exhaust Gas Recirculation Valve, All Petrol (MY 2002, MY 2003 and MY2004)
- Exhaust Gas Recirculation Valve, Motronic1.5.5 and Motronic 3.11 (MY2002 and MY 2003)
- New Camshaft Sensor - Z 10 XEP, Z 12 XEP, Z 14 XEP Petrol Engines
- DOHC-0 Engine Z 12 XEP - Agila and Corsa-C
- Elimination of Twinport Sensor - Z 10 XEP, Z 12 XEP and Z 14 XEP Petrol Engines
- Specific Characteristics of the Z 12 XEP Engine
- Throttle Valve Potentiometer (Double Signal), Simtec (MY 2003), Simtecand Multec-F (MY 2004)
- View of the Engine, Z 12 XEP, Z 14 XEP
- Torque and Power Diagram, Z 12 XEP
- Exhaust Manifold, Z 12 XEP, Z 14 XEP
- DOHC-0-Engines Z 10 XE and Z 12 XE
- Camshaft Control, Z 10 XEP, Z 12 XE, Z 14 XEP (From End MY 2004 to MY 2005)
- Camshaft Control, Z 10 XEP, Z 12 XEP, Z 14 XEP (MY 2005 Onwards)
- Setting the Phase Sensor Disc with KM-954
- Camshaft Sensor
- Wheel Speed Sensor, Except Vectra-C/signum and Astra-H
- Timing Case
- Z 10 XE, Z 12 XE DOHC-0 Petrol Engines
- Timing Chain Tensioner
- View of Engine Z 10 XE - Intake Side
- Bosch Motronic 7.6.2 Engine Control Unit
- View of Engine Z 10 XE - Exhaust Side
- View of Engine Z 12 XE - Intake Side
- View of Engine Z 12 XE - Exhaust Side
- Fuel Distribution Pipe, Z 12 XE
- Torque and Power Curves, Z 10 XE
- Crankshaft Guide Bearing, DOHC Engines
- Torque and Power Curves, Z 12 XE
- Engine Management System - Motronic Me 1.5.5
- Engine Compartment Survey, Z 10 XE
- Engine Compartment Survey, Z 12 XE
- Block Diagram Engine Z 10 XE and Z 12 XE
- Z 14 XE Dohc-I Petrol Engine
- Torque and Power Curves, Z 14 XE
- Engine Compartment Survey, Z 14 XE
- Block Diagram, Engine Z 14 XE
- Engine/transmission Bearings
- Engine Cooling Module
- Z 10 XEP DOHC-0 Petrol Engine
- Z 14 XEP DOHC-0 Petrol Engine
- Twinport System
- New Components for DOHC-0 Petrol Engines
- Oil Non-Return Valve - DOHC-0 Petrol Engines
- Ribbed V-Belt Tensioner - DOHC-0 Petrol Engines
- Exhaust Manifold - Z 12 XE and Z 14 XEP Engines
- Spark Plugs - Z 10 XEP and Z 14 XEP Engine
- Remove and Install Exhaust Gas Recirculation Valve
- How to Remove and Install the Exhaust Gas Recirculation Pipe
- Engine Number
- Check Compression (Z 10 XE, Z 10 XEP, with Air Conditioning System, Lhd)
- Measure Oil Temperature (Z 10 XE, Z 10 XEP)
- Illustration: Z 10 XE
- Replace Front Crankshaft Seal Ring (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Install Cylinder Head Cover (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Install Both Camshafts (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Install Cylinder Head (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Illustration: Z 10 XE, Z 10 XEP
- Engine Oil Change (Z 10 XE, Z 10 XEP)
- Replace Oil Pressure Switch (Z 10 XE, Z 10 XEP)
- Remove and Install Oil Pump Pressure Control Valve (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Install Oil Pan (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Replace Oil Intake Pipe (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Refit Oil Baffle Plate (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Remove and Refit Oil Pan (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Check Cooling System for Leaks (Z 10 XE, Z 10 XEP)
- Check for Engine Leaks (CO Content in Coolant) (Z 10 XE, Z 10 XEP)
- Remove and Refit Engine (Z 10 XE, Z 10 XEP, with Air Conditioning)
- Survey of Engine Compartment, Z 10 XE
- Check Fuel Pressure (Z 10 XE, Z 10 XEP, with Air Conditioning System, Lhd)
- Special Service Tools
- Sealants, Lubricants and Locking Compounds
- Specifications
- Adjustment Value, Checking Values
- Ribbed V-Belt
- Engine Control Unit
- Cooling System
- Oil Circuit
- Cylinder Head
- Crank Drive, Cylinder Block
- Engine Management
- Torque Guide Values (Z 10 XE, Z 10 XEP)
- DOHC O Petrol Engine (Z 12 XE, Z 12 XEP, Z 14 XEP) Engine Number
- Check Compression (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Check Oil Temperature (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Check Timing (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Adjust Timing (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Illustration - Air Cleaner Housing, Air Ducts Z 12 XE
- Illustration Z 12 XE, Z 12 XEP, Z 14 XEP
- Replace Ribbed V-Belt (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Front Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Cylinder Head Cover (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Both Camshafts (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Exhaust Manifold Gasket (Z 12 XE, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Intake Manifold Gasket (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Valve Stem Seal (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Engine Oil with Filter Change (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Oil Pressure Switch (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Removing and Installing Oil Filter Housing (Z 12 XE, Z 14 XEP Up to MY 2004)
- Removing and Installing Oil Pump Pressure Control Valve (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Oil Pan (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Oil Intake Pipe (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Remove and Install Oil Pump (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- How to Remove and Install (Z 12 XE the Oil Baffle Plate (Z 14 XEP))
- Removing and Installing Oil Dipstick Guide Tube (Z 12 XE, Z 14 XEP Up to MY 2004, with Air Conditioning, Lhd)
- Check for Engine Leaks (CO Content in Coolant) (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Mta)
- Engine Compartment Overview (Z 12 XE)
- DOHC I Petrol Engine (Z 14 XE, Z 16 YNG) Engine Number
- Measure Oil Temperature (Z 14 XE, Z 16 YNG)
- Air Cleaner Housing, Air Ducts Illustration Z 14 XE, Z 16 YNG
- Replace Ribbed V-Belt (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- How to Replace (Z 14 XE the Front Toothed Belt Cover (Upper) (16 With AC, Lhd))
- Replace Toothed Belt (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- Replace Toothed Belt Tension Roller (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- Replace Toothed Belt Guide Roller (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- How to Replace (Z 14 XE the Toothed Belt Drive Gear / Crankshaft Pulley (Z 16 YNG with AC, Lhd))
- How to Remove and Install (Z 14 XE the Cylinder Head Cover (Z 16 YNG with AC, Lhd))
- How to Remove and Install (Z 14 XE) the Drive Disc
- J 320720 Replace Rear Crankshaft Seal Ring (Z 14 XE, Z 16 YNG)
- Remove and Install Oil Pan (Z 14 XE, Z 16 YNG with AC, Lhd)
- 009 Replace Intake Pipe for Oil Pump (Z 14 XE, Z 16 YNG with AC, Lhd)
- Check Engine for Leaks (Amount of CO in Coolant) (Z 14 XE, Z 16 YNG)
- Check Cooling System for Leaks (Z 14 XE, Z 16 YNG)
- Torque Guide Values (Z 14 XE, Z 16 YNG)
- Replace Front Crankshaft Seal Ring (Z 10 XE, Z 10 XEP, with Air Conditioning, Lhd)
- Remove and Install Flywheel (Z 10 XE, Z 10 XEP)
- Replace Rear Crankshaft Seal Ring (Z 10 XE, Z 10 XEP)
- Remove and Install Crankshaft (Z 10 XE, Z 10 XEP, with Air Conditioning)
- Remove and Install Oil Pump (Z 10 XE, Z 10 XEP, with Air Conditioning, Lhd)
- Replace Engine Damping Blocks (Both Sides) (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Replace Engine Damping Block (Right Side) (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Replace Engine Damping Block (Left Side) (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- Removing and Installing Manual Transmission (Mt) from Engine (Z 10 XE, Z 10 XEP, with Air Conditioning System, Lhd)
- Replace Ribbed V-Belt (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Ribbed V-Belt Tensioner (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Front Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Exhaust Manifold Gasket (Z 12 XE, Z 14 XEP, Without Air Conditioning, Lhd)
- Remove and Install Flywheel (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Rear Crankshaft Seal Ring (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Crankshaft (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning)
- Remove and Install Oil Pump (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Lhd)
- Replace Engine Damping Blocks (Both Sides) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Engine Damping Block (Right Side) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Replace Rear Reaction Member (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Replace Engine Damping Block (Left Side) (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning, Lhd)
- Removing and Installing Manual Transmission (Mta) from Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning System, Lhd)
- Check Compression (Z 14 XE, Z 16 YNG with AC, Rhd)
- Adjust Timing (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- How to Check and Correct (Z 14 XE the Toothed Belt Tension (Z 16 YNG with AC, Lhd))
- How to Replace (Z 14 XE the Intake Manifold Gasket (Z 16 YNG with AC, Rhd))
- How to Replace (Z 14 XE the Gasket - Intake Manifold Upper Part (With AC, Rhd))
- How to Remove and Install (Z 14 XE the Cylinder Head (Z 16 YNG with AC))
- How to Replace (Z 14 XE the Engine Vent Flange (With AC, Rhd))
- Engine Oil Change (Z 14 XE, Z 16 YNG with Air Conditioning, Lhd)
- Replace Engine Damping Blocks (Both Sides) (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- How to Replace (Right) (Z 14 XE the Engine Damping Block (Z 16 YNG with AC, Rhd))
- How to Replace (Z 14 XE the Engine Damping Block (Left) (Z 16 YNG with AC, Rhd))
- Z18XE Engine - No Compression Because of a Broken Valve Spring
- Remove and Install Engine (Z 14 XE, Z 16 YNG with AC, Rhd)
- 008 Remove and Install Automatic Transmission with Engine Torque Converter (Z14 XE, AC, Rhd)
- Torque Guide Values (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Engine Z10/Z12/Z14XE/P - Strong Vibration from Poly-V-Belt, Often Together with DTC P0300-P0304 (Misfire)
- Family-0-Engines (MY98-2004) - Rattling Noise from Timing Chain
- Dohc-I Petrol Engine (Z 18 XE)
- How to Check (Z 18 XE the Compression (With Air Conditioning, Lhd))
- How to Measure (Z 18 XE) the Oil Temperature
- Engine Z18XE - DTC P1372(2) Crankshaft Segment Failure
- How to Check (Z 18 XE the Engine Oil Pressure (With Air Conditioning, Lhd))
- How to Check (Z 18 XE the Timing (With Air Conditioning, Lhd))
- How to Check and Correct (Z 18 XE the Toothed Belt Tension (With Air Conditioning, Lhd))
- Air Cleaner Housing, Air Ducts
- How to Replace (Z 18 XE the Ribbed V-Belt (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Ribbed V-Belt Tensioner (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Upper Section (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Lower Section (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt Tension Roller (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Toothed Belt Guide Roller (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Toothed Belt Cover - Rear (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Cylinder Head Cover (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Camshaft Sprockets (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Camshaft Seal Ring (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Both Camshafts (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Exhaust Manifold Gasket (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Intake Manifold Gasket (With Air Conditioning, Lhd))
- Engine Oil with Filter Change (Z 18 XE, with Air Conditioning, Lhd)
- How to Remove and Install (Z 18 XE the Oil Filter Housing (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Crankshaft Front Seal Ring (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Oil Pan (With Air Conditioning, Lhd))
- 020 Additional Work When Replacing the Oil Pan (Z 18 XE, with Air Conditioning, Lhd) (Oil Pan Removed)
- How to Remove and Install (Z 18 XE the Oil Pump (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Oil Pump Pressure Regulating Valve (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the 009 Oil Intake Pipe (With Air Conditioning, Lhd) (Oil Sump Removed))
- How to Remove and Install (Z 18 XE the Oil Dipstick Guide Tube (With Air Conditioning, Lhd))
- How to Top Up and Bleed (Z 18 XE) the Cooling System
- How to Check for Leaks (Z 18 XE) the Cooling System
- How to Check for Leaks the Engine ((CO Content in Coolant) (Z 18 XE))
- How to Remove and Install (Z 18 XE the Fan Motor (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Radiator (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Thermostat with Coolant Connection (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Coolant Pump (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Coolant Pipe (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Engine Damping Blocks (Both Sides) (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Front Reaction Member (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Rear Reaction Member (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Right Engine Damping Block (With Air Conditioning, Lhd))
- How to Replace (Z 18 XE the Left Engine Damping Block (With Air Conditioning, Lhd))
- How to Remove and Install (Z 18 XE the Engine (With Air Conditioning, Lhd))
- Manual Transmission From/to Engine, Detach and Attach (Z 18 XE, with Air Conditioning, Lhd)
- How to Check (Z 18 XE the Fuel Pressure (With Air Conditioning, Lhd))
- Technical Data Sealants, Lubricants and Locking Compounds
- Torque Guide Values (Z 18 XE)
- Remove and Install Adapter, Exhaust Gas Recirculation Valve
- Check Engine Oil Pressure (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Remove and Install Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, Without Air Conditioning, Mt)
- Removing and Installing Manual Transmission (Mt) from Engine (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning System, Lhd)
- Repair Engine Using a Short Block (Z 12 XE, Z 12 XEP, Z 14 XEP, with Air Conditioning)
- Check Engine Oil Pressure (Z 14 XE Without AC, Lhd, Z 16 YNG)
- Check Timing (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Fly Wheel (Z 14 XE Without Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Crankshaft (Z 14 XE Without Air Conditioning, Z 16 YNG)
- Remove and Install Reaction Member (Rear) (Z 14 XE, Z 16 YNG with AC, Rhd)
- How to Remove and Install (Z 14 XE the Engine (Z 16 YNG Without AC, Lhd))
- 007 Remove and Install Engine Manual Transmission (Z 14 XE Without Air Conditioning Lhd, Z 16 YNG)
- Check Fuel Pressure (Z 14 XE Lhd, Z 16 YNG)
- Replace Intake Air Temperature Sensor (Z 14 XE, Z 16 YNG with AC, Rhd)
- How to Remove and Install (Z 18 XE the Coolant Connection (With Air Conditioning, Lhd))
- Check Engine Oil Pressure (Z 10 XE, Z 10 XEP)
- Repair Engine Using a Short Block (Z 10 XE, Z 10 XEP, Without Air Conditioning)
- Replace Valve Stem Seals (Z 10 XE, Z 10 XEP, Without Air Conditioning, Lhd)
- J 312315 Replace Valve Stem Seal (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- How to Remove and Install the Cylinder Block Ventilation Pipe
- How to Replace (Z 18 XE the J 312315 Valve Stem Seals (With Air Conditioning, Lhd))
- Check Engine Pressure Loss (Z 10 XE, Z 10 XEP)
- How to Replace the Piston Rings
- Replace One Con-Rod Bearing (Z 10 XE, Z 10 XEP, Lhd)
- Measure Crankshaft (Z 10 XE, Z 10 XEP)
- Check Engine Pressure Loss (Z 12 XE, Z12 XEP, Z 14 XEP)
- Replace One Con-Rod Bearing (Z 12 XE, Z 12 XEP, Z 14 XEP, Lhd)
- Check Crankshaft Alignment (Z 12 XE, Z 12 XEP, Z 14 XEP)
- Check Engine Pressure Loss (Z 14 XE, Z 16 YNG)
- Remove and Install Lower Section of Toothed Belt Cover (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Replace Rear Toothed Belt Cover (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Replace Front Camshaft Sealing Ring (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Remove and Install Both Camshafts (Z 14 XE, Z 16 YNG with AC, Rhd)
- Replace Intake Manifold Lower Section (Z 14 XE, with Air Conditioning, Rhd)
- Replace Piston Rings
- Replace One Con-Rod Bearing (Z 14 Without Air Conditioning Lhd, Z 16 YNG)
- Replace Front Crankshaft Seal Ring (Z 14 XE Lhd, Z 16 YNG)
- Remove and Install All Pistons with Con-Rods (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Measure Crankshaft (Z 14 XE, Z 16 YNG)
- Replace Oil Filter Short Circuit Valve (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Additional Work When Replacing Oil Pan (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Oil Pump (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Check Oil Pump (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Oil Pump Pressure Regulator Valve (Z 14 XE with Air Conditioning Lhd, Z 16 YNG)
- Remove and Install Oil Dipstick Guide Tube (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- Repair Engine Using a Short Block (Z 14 XE Without AC, Lhd, Z 16 YNG)
- How to Check (Z 18 XE) the Engine Pressure Loss
- How to Replace (Z 18 XE the One Con-Rod Bearing (With Air Conditioning, Lhd))
- How to Check Alignment (Z 18 XE) the Crankshaft
- How to Replace (Z 18 XE the Oil Filter Short-Circuit Valve (With Oil Filter Housing))
- How to Replace (Z 18 XE the Oil Filter Short-Circuit Valve (With Oil Filter Cartridge))
- Check Oil Pump
- Flexible Maintenance Intervals
- How to Remove and Install (Z 14 XEP) the Front Reaction Member
- Chemical Products
- Remove and Install Spark Plugs (Z 14 XE, Z 16 YNG with Air Conditioning, Rhd)
- How to Remove and Install (Z 18 XE the Spark Plugs (With Air Conditioning, Lhd))
- Flexible Service Intervals
- Replace Exhaust Manifold (Z 12 XEP, Z 14 XEP-Combo)
- Remove and Install Exhaust Gas Recirculation Valve (Z 12 XE, Z 12 XEP, Z 14 XEP)
- How to Remove and Install the Attaching Parts to Cylinder Head
- Remove and Install Oil Filter Housing (Z 12 XEP, Z 14 XEP from MY 2005)
- Replace Oil Dipstick Guide Tube (Z 12 XEP, Z 14 XEP from MY 2005)
- How to Replace (From MY 05) the Crankshaft Rear Seal Ring
- ABS
- ABS 5.3
- ABS 5.3/TC/ESP
- ABS 5/TC, ABS 5.3/TC
- ABS 8
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Automatic Transmission Front Wheel Drive
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Communication / Navigation
- Cooling System
- Corrosion Protection
- DOHC Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Cruise Control
- Electronic Module
- Engine and Engine Aggregates
- Engine Electrics
- Eps Electrical Power Steering
- Exhaust System
- Fittings, Hinges, Locks
- Folding Roof
- Folding Sunroof
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle Front Wheel Drive
- Rear End
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Sensors
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
