Checking Equipment
· TECH 1 Case
· Program Module "OPEL/VAUXHALL 89-90 ECU"
· Electronic-Kit l KM-609
· Multimeter MKM-587-A
· Diagnostic Switch KM -640
· Checking spark plug
| .P. F0374_G.tif | 18 | 18 | tiff;; |
Contents
Section: Carburettor- Selection of Fuel, Octane Number Coding with Octane Number Plugs
- Octane Number Plug (Octane Number Coding), Selection of Fuel
- Introduction
- General Instructions/safety Measures
- Checking Equipment
- Features Specific to This System
- Diagnostic Switch KM-640
- Checking with Tech 1
- Abbreviations, Definitions
- F0: Data List - Test Step 01 CO Coding
- F0: Data List - Test Step 02 Ron Coding
- F0: Data List - Test Step 03 Check Light
- F0: Data List - Test Step 04 Preheating Relay
- F0: Data List - Test Step 05 Spark Advance
- F0: Data List - Test Step 06 Engine Speed
- F0: Data List - Test Step 07 Battery Voltage
- F0: Data List - Test Step 08 Coolant Temperature
- F0: Data List - Test Step 09 Thr. Valve Reg.
- F0: Data List - Test Step 10 TPS Signal
- F0: Data List - Test Step 11 Ventilat. Valve
- F0: Data List - Test Step 12 Evacuating Valve
- F0: Data List - Test Step 13 Accelerat. Phase
- F0: Data List - Test Step 14 Pre-Throttle
- F0: Data List - Test Step 15 Sim. Idle Pos. Sw
- F0: Data List - Test Step 16 Transm. Coding
- F0: Data List - Test Step 17 Torque Control
- Explanation of Tables
- Table 1 Tech 1 Checking
- Table 1 Tech 1 Checking. Possible Cause of Fault / Trouble-Shooting
- Table 2 - Trouble Code Table: Trouble Code 14 Coolant Temperature Voltage Low
- Table 2 - Trouble Code Table: Trouble Code 15 Coolant Temperature Voltage High
- Table 2 - Trouble Code Table: Trouble Code 19 Invalid TC Please Ignore!
- Table 2 - Trouble Code Table: Trouble Code 21 Throttle Posit. Sensor Voltage High
- Table 2 - Trouble Code Table: Trouble Code 22 Throttle Posit. Sensor Voltage Low
- Table 2 - Trouble Code Table: Trouble Code 36 Ron Coding Circuit
- Table 2 - Trouble Code Table: Trouble Code 42 Primary Ignition Current Too High
- Table 2 - Trouble Code Table: Trouble Code 48 Battery Voltage Low
- Table 2 - Trouble Code Table: Trouble Code 49 Battery Voltage High
- Table 2 - Trouble Code Table: Trouble Code 53 Thr. Valve Reg. Pot. Voltage Low
- Table 2 - Trouble Code Table: Trouble Code 54 Thr. Valve Reg. Pot. Voltage High
- Table 2 - Trouble Code Table: Trouble Code 55 Replace ECU
- Table 2 - Trouble Code Table: Trouble Code 56 Pre-Throttle Current High
- Table 2 - Trouble Code Table: Trouble Code 57 Pre-Throttle Current Low
- Table 2 - Trouble Code Table: Trouble Code 58 CO Coding Voltage Low
- Table 2 - Trouble Code Table: Trouble Code 59 Thr. Valve Reg. Extens. Time Too Long
- Table 2 - Trouble Code Table: Trouble Code 61 Thr. Valve Reg. Closing Time Too Long
- Table 2 - Trouble Code Table: Trouble Code 62 Thr. Valve Reg. Vent. Time Too Long
- Table 2 - Trouble Code Table: Trouble Code 63 Thr. Valve Reg. Evacuat. Time Too Long
- Table 2 - Trouble Code Table: Trouble Code 64 Primary Ignition Current Too Low
- Table 2 - Trouble Code Table: Trouble Code 75 Torque Control Voltage Low
- Table 2 - Trouble Code Table: Trouble Code 76 Continuous Torque Control
- Table 3 System Components
- Wiring Harness Coding
- Table 4 Emergency Operation Properties. Notes on "Engine Does Not Start"
- Table 5 - Test Step 01 Check Intake Manif. Preheating Relay and Ptc? (Yes/ No)
- Table 5 - Test Step 02 Check Throttle Valve Regulator Ventilat. Valve? (Yes/ No)
- Table 5 - Test Step 03 Check Pre-Throttle Function? (Yes/no)
- Table 5 - Test Step 04 Check Engine Stop/start Function? (Yes/no)
- Table 5 - Test Step 05 Check Engine Start Function? (Yes/no)
- Complaints Chart
- Air Cleaner Housing, Air Ducts
- How to Remove and Install the Air Cleaner Housing
- How to Check the Intake Air Pre-Heating
- How to Adjust the Idle Speed and CO Content in Exhaust
- How to Adjust (2 E 3 Carburettor with Idle Speed Load Compensation) the Idle Speed and CO Content in Exhaust
- How to Check and Adjust the Fast Idling
- How to Check the Pulldown Unit
- How to Remove and Install the Thermo Time Valve
- How to Check and Adjust the Choke Valve Gap
- How to Adjust the Choke Valve Forced Opening
- How to Check and Adjust the Position of Stepped Plate
- How to Check the Choke Cover Position
- How to Check and Adjust the Cold Start Adjustment, Throttle Valve Gap
- How to Check the Basic Adjustment of Throttle Valve - Ii. Stage
- How to Check and Adjust the Injection Quantity
- How to Check the Idle Speed Increase Valve and Throttle Valve Adjuster
- How to Remove and Install the Accelerator Pump
- How to Check and Adjust the Release and Forced Return Ii. Stage
- How to Check the Pull Rod for Ii. Stage
- How to Check for Leaks the Vacuum Unit Ii. Stage
- How to Remove and Install the Vacuum Unit Ii. Stage
- How to Remove and Install the Enrichment Valve
- How to Remove and Install the Idle Speed Load Compensation Bracket
- How to Remove and Install the Starter Body
- How to Remove and Install the Pulldown Unit
- How to Remove and Install the Idle Speed Increase Valve
- How to Remove and Install the Throttle Valve Adjuster
- How to Remove and Install the Throttle Valve Potentiometer
- How to Remove and Install the 2 E 3 Carburettor
- How to Remove and Install (Carburettor Removed) the Carburettor Cover
- How to Remove and Install the Float
- How to Remove and Install the Main Nozzles
- How to Remove and Install the Idler Nozzle
- How to Remove and Install the Preatomizer
- How to Remove and Install the Accelerator Pipe
- How to Remove and Install (Only for 18 Sv) the Idle Cut-Off Valve
- How to Check the Float Level
- How to Adjust the Carburettor Actuation
- How to Remove and Install Remove and Install the Filter in Fuel Supply
- How to Adjust the Throttle Valve Dashpot
- How to Check and Adjust the Enrichment Pipe
- Trouble-Shooting Table (2 E 3 Carburettor) Complaints
- Engine Management System - Ecotronic (2 E- E Carburettor ) (E 18 NVR)
- General Repair Instructions
- How to Check the Vacuum Unit Ii. Stage
- How to Adjust the Throttle Valve, I. and Ii. Stages
- How to Adjust the Release and Forced Return, Ii. Stage
- How to Adjust the Idle Speed and Idle Speed CO Value
- How to Adjust the Throttle Valve Adjuster Control Range
- How to Remove and Install the Filter in Fuel Supply
- How to Remove and Install the Main Nozzle and Idler Nozzle
- How to Remove and Install the Non-Return Valve on Throttle Valve Adjuster
- How to Check for Leaks the Non-Return Valve
- How to Remove and Install the Mixture Pre-Heater Element
- How to Remove and Install the Filter on Throttle Valve Adjuster
- How to Remove and Install the Timing Relay and Relay for Mixture Pre-Heating
- How to Remove and Install the 2 E-E Carburettor
- How to Remove and Install the Carburettor Cover
- How to Remove and Install the Prethrottle Adjuster
- Trouble-Shooting Table (Ecotronic) Complaints
- How to Remove and Install the Coolant Temperature Sensor
- How to Remove and Install the Control Unit
- How to Remove and Install the High Tension Distributor
- How to Remove and Install the Ignition Coil
- How to Remove and Install the Inductive Pulse Pick-Up
- Octane Number Plug, Set Code
- Technical Data Carburettor 2 E 3, Characteristic Data/ Calibration
- Technical Data Carburettor 2 E 3, Characteristic Data/calibration
- Technical Data Ecotronic, Characteristic Data/ Calibration
- ABS
- Accessories
- Additional Lighting
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Brake Hydraulics, Brake Lines
- Car Level Control
- Carburettor
- Central Door Locking System
- Clutch
- Clutch and Transmission
- Cooling System
- Did (Dual Info Display)
- Diesel Engine
- Distributor Transmission Four Wheel Drive
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Traction Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Ignition System
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- OHC Petrol Engine
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Power Steering
- Radiator Grille
- Radio
- Radio Interference Suppression
- Rear Axle and Rear Wheel Suspension
- Rear Axle Four Wheel Drive
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering Damper
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses