Manual sections

Wiring diagrams

• A/c Compressor
• Abbreviations
• Accessories Control Systems
• Accessory Drive Belts
• Accessory Electronic Module (Aem), Alarm, Parking Assistance - Installation Instructions, Accessories
• Airbag
• Antenna Systems
• Anti-Lock/traction Control
• Application
• Automatic HVAC System
• Automatic Trans
• Auxiliary Emission Control Systems
• Axle Shafts
• Basic Trouble Shooting
• Blowers, Superchargers & Turbochargers
• Body Electrical
• Brakes
• Cabin Air Filter
• Cables and Fuses - Removal, Replacement and Installation
• Charging System
• Check Lists
• Climate Units - Removal, Replacement and Installation
• Clutches Manual & Hydraulic
• Collision/avoidance
• Computer Relearn
• Control Modules - Design and Function - 1 of 4
• Control Modules - Design and Function - 2 of 4
• Control Modules - Design and Function - 4 of 4
• Cooling Fan
• Cooling System (Mechanical)
• Cruise Control Systems
• Cruise Control, Cargo, Storage & Towing - Accessory Installation Instructions
• Diagnostic Connector Locations
• Differentials & Drive Axles
• Door Locks & Anti-Theft Systems
• Drive Cycles
• Driveline/axles
• DTC Index
• Electrical Component Locations
• Electrical Motors, Sensors & Switches - Removal, Replacement and Installation
• Emission Applications
• Engine
• Engine - Removal, Replacement and Installation
• Engine Control Systems
• Engine Heater, Parking Heater - Installation Instructions, Accessories
• Engine Performance
• Entertainment Systems
• Exhaust
• Exterior Body Panels
• Exterior Lights
• Exterior/interior Trim
• Frames, Subframes & Crossmembers
• Fuel System
• Fuel, Injectors & Sensors - Removal & Installation
• Fuses & Circuit Breakers
• Gauges & Instrument Panels
• Gearbox, Gear Shift Position Sensor - Adjustment, Removal & Installation
• Headlights
• Heated Glass/defoggers
• Identification
• Ignition System
• Interior Equipment - Installation Instructions, Accessories
• Interior/illumination Lights
• Lubrication System
• Manual & Power Steering
• Manual Trans
• Mechanical
• Mechanical - Hydraulic
• Media, Communication and Navigation - Installation Instructions, Accessories - 1 of 2
• Media, Communication and Navigation - Installation Instructions, Accessories - 2 of 2
• Metric Conversions
• Mirrors
• Mode 6
• Navigation System
• Oem General Information
• Paint/coatings
• Panel Repair - Removal, Replacement and Installation
• Parking Brake System
• Passive Restraints
• Rear Axle, Drive Shafts - Removal, Replacement and Installation
• Rear Wheel Suspension - Removal, Replacement and Installation
• Removal & Installation
• Reset Procedures
• Restraints
• Seats
• Seats, Interior Components - Removal, Replacement and Installation
• Solenoid Control, Gear Selector & Line Pressure - Removal & Installation
• Specifications
• Starter
• Steering
• Steering Column
• Steering Column Switches
• Steering Gear
• Sun Roof/t-Top/convertible Top
• Suspension Control Systems
• Suspension Front
• Suspension Rear
• System
• Testing & Diagnostics
• Timing Belt
• Traction Control Disable
• Transmission
• Transmission - Removal, Replacement and Installation - 1 of 2
• Transmission - Removal, Replacement and Installation - 2 of 2
• Transmission - Replacing
• Wheel & Tire System
• Wheel Alignment
• Wheel Hubs
• Windows
• Wiper/washer Systems

Repair manual

Gearbox, Gear Shift Position Sensor - Adjustment, Removal & Installation Volvo S60 I

Step-by-step instructions on "Gearbox, Gear Shift Position Sensor - Adjustment, Removal & Installation" for Volvo S60 I (2000–2004). Pick an article — removal, installation, adjustment and diagnostics with illustrations.

52subsections

52articles

107illustrations

Gear selector cables, adjusting

1 article

• Gear selector cables, adjusting

Preparatory work

1 article

• Preparatory work

Preparations and adjusting gear selector cable

1 article

• Preparations and adjusting gear selector cable 2

Installing components

1 article

• Installing components

Gearbox input speed sensor, replacing

1 article

• Gearbox input speed sensor, replacing 1

Gearbox, installing

1 article

• Gearbox, installing

Gearbox, removing (D5252 M56 2000-)

1 article

• Gearbox, removing (D5252 M56 2000-)

Disconnecting the battery lead

1 article

• Disconnecting the battery lead 7

Removing the mounting screws for the gearbox and starter motor

1 article

• Removing the mounting screws for the gearbox and starter motor 4

Removing the air baffle and splash guard under the engine

1 article

• Removing the air baffle and splash guard under the engine

Removing the control arms and track rod (both sides)

1 article

• Removing the control arms and track rod (both sides)

Removing the nut from the ball joint (both sides)

1 article

• Removing the nut from the ball joint (both sides)

Removing the screws from the sub-frame support plates (both sides)

1 article

• Removing the screws from the sub-frame support plates (both sides)

Removing the stub axle from the control arm

1 article

• Removing the stub axle from the control arm

Removing the drive shaft from the stub axle (right-hand side)

1 article

• Removing the drive shaft from the stub axle (right-hand side)

Removing the sealing ring for the CV joint housing

1 article

• Removing the sealing ring for the CV joint housing

Removing the cap for the drive shaft support bearing

1 article

• Removing the cap for the drive shaft support bearing

Removing the drive shaft

1 article

• Removing the drive shaft

Pressing up the sub-frame on the right-hand side

1 article

• Pressing up the sub-frame on the right-hand side 5

Preparatory work for removing the stub axle on the left-hand side

1 article

• Preparatory work for removing the stub axle on the left-hand side 1

Lowering the sub-frame

1 article

• Lowering the sub-frame

Lowering the engine and gearbox

1 article

• Lowering the engine and gearbox

Removing the collision protection system over the steering gear

1 article

• Removing the collision protection system over the steering gear

Installing the fixture on the mobile jack

1 article

• Installing the fixture on the mobile jack 1

Gearbox, removing (AW50/51 AWD; AW55-50/51SN; 2003-2009)

1 article

• Gearbox, removing (AW50/51 AWD; AW55-50/51SN; 2003-2009) 4

Removing the coolant hose from the passenger compartment heater

1 article

• Removing the coolant hose from the passenger compartment heater 22

Gearbox, removing (B5254T4, M66 AWD; 2004-2007)

1 article

• Gearbox, removing (B5254T4, M66 AWD; 2004-2007) 15

Preparations when removing gearbox

1 article

• Preparations when removing gearbox 1

Preparations for lowering the sub-frame

1 article

• Preparations for lowering the sub-frame 12

Gearbox, removing (gasoline M66 AWD 2004-)

1 article

• Gearbox, removing (gasoline M66 AWD 2004-) 9

Removing the screws and nuts for the engine pad, engine stabilizer brace and steering gear

1 article

• Removing the screws and nuts for the engine pad, engine stabilizer brace and steering gear

Measuring position of the tie rod in steering gear

1 article

• Measuring position of the tie rod in steering gear

Disconnecting the steering gear

1 article

• Disconnecting the steering gear

Removing front suspension components (both sides)

1 article

• Removing front suspension components (both sides)

Disconnecting the ball joint pinion from the control arm (both sides)

1 article

• Disconnecting the ball joint pinion from the control arm (both sides) 1

Removing the right drive shaft

1 article

• Removing the right drive shaft 2

Removing the drive shaft from the gearbox

1 article

• Removing the drive shaft from the gearbox

Removing the lower charge air pipe

1 article

• Removing the lower charge air pipe

Removing bevel gear

1 article

• Removing bevel gear 2

Installing the fixture on the mobile jack and gearbox

1 article

• Installing the fixture on the mobile jack and gearbox 1

Removing the gearbox

1 article

• Removing the gearbox

Gearbox, removing (AW50/51 AWD; 2002-2009)

1 article

• Gearbox, removing (AW50/51 AWD; 2002-2009)

Gearbox, removing (B5204T5, M56; 2004-2007)

1 article

• Gearbox, removing (B5204T5, M56; 2004-2007)

Installing the lifting beam and lifting hook on the engine lifting eyelet

1 article

• Installing the lifting beam and lifting hook on the engine lifting eyelet

Removing the air baffles and splash guard under the engine

1 article

• Removing the air baffles and splash guard under the engine

Removing the screw for the cable duct

1 article

• Removing the screw for the cable duct 1

Measuring the position of the tie rod in the steering gear

1 article

• Measuring the position of the tie rod in the steering gear

Exposing the steering shaft joint

1 article

• Exposing the steering shaft joint 11

Gear-shift position sensor, checking/adjusting (AW50/51 AWD; AW55-50/51SN; 2003-2009)

1 article

• Gear-shift position sensor, checking/adjusting (AW50/51 AWD; AW55-50/51SN; 2003-2009)

Gear-shift position sensor, checking/adjusting (AW50/51 AWD; 2002)

1 article

• Gear-shift position sensor, checking/adjusting (AW50/51 AWD; 2002) 5

Installing the gear selector cable

1 article

• Installing the gear selector cable

Installing engine compartment components

1 article

• Installing engine compartment components