Home/Volvo/C70/Volvo C70 I (1997-2005)/Repair manual/Transmission - Adaptation (Coupe)/Dashboard, Replacing

Contents

Wiring diagrams Section: Transmission - Adaptation (Coupe)

Adaptation of throttle module

Adaptation of Transmission control module (TCM)

Adjusting the gear cable

Check

Activating Components

Shift Solenoid S1, S2, S3, S4, S5

Line Pressure Solenoid SLU, SLS, SLT

General

Shifting Program According To Gear-Shift Position Sensor

Gear-Shift Position Sensor Position

Gear-Shift Position Sensor Signal A

Gear-Shift Position Sensor Signal B

Gear-Shift Position Sensor Signal C

Gear-shift position sensor signal PA

Winter mode status

Current Gear (According To Gear Ratio)

New Gear (According To Solenoids)

Status, Shift Solenoid S1, S2, S3, S4, S5

Stop (Brake) Lamp Switch

Kickdown

Engine Speed (RPM)

Transmission Speed Sensor, Input Speed

TCM Speed Sensor, Calculated Speed

Vehicle Speed ABS

Throttle, Position

Battery Voltage

Oil Temperature Sensor Signal

Oil Temperature

Lock-Up Solenoid SLU, Amperage

Line Pressure Solenoid SLS, Amperage

Line Pressure Solenoid SLTH, Amperage

Engine Control Module (ECM) Engine Coolant Temperature (ECT)

Text Transmitted To the Driver Information Module

Downloading Software And Replacing the Control Module

Drive Shaft Left, Replacing

Installing the Drive Shaft And Control Arm

Align the Drive Shaft In the Hub And the Spring Strut In the Wheel Spindle

Installing Brake Components On the Wheel Spindle

Connecting the Breakout Box

Checking For Open-Circuits, Contact Resistance And Oxidation

Verification

Fault-Tracing Information

Installing the Units

6-Pin Connector

Removing the gear selector knob

Installing a new boot

Installing the top panel

Installing the gear selector knob

Brake Control Module (BCM), Replacing

Preparation

Installing the integrated relay/fusebox

Installing the air cleaner (ACL) housing

Finishing

Brake Disc Rear, Replacing

Adjusting the Parking Brake

Removing the brake disc

Cleaning and checking

Installing the brake disc

Carrier Plate, Replacing

Preparatory Work

Removing the Carrier Plate

Center Console Compartment Middle, Replacing

Installing Center Console Compartment

Checking And/Or Replacing the Clutch And Clutch Driven Plate

Installing the Tools On the Clutch

Checking For Coolant In the Oil

Replacing the Clutch Plate And Pressure Plate

Conditions

Procedure

Gaiter CV Joint, Replacing

Removing the Gaiter From the Top Panel

Installing the Gaiter

Gear Selector Cables, Replacing

Removing the Air Cleaner (ACL) Housing

Feeding In the Gear Selector Cable From the Inside

Removing the Center Console

Removing the Cable At the Firewall

Installing the Mechanical Cable

Installing the center console

Installing the front wheels

Removing the Panel

Removing the Top Panel

Installing the Lock Bracket On the Gear Selector Knob

Other Information

Courtesy Lamp And Bulb

Cover Control System, Replacing

Removing the Sub-Frame

Cleaning Cover

Installing Cover

Installing the Sub-Frame

Filling Of Oil

Cover/Armrest Tunnel, Replacing

Installing the Cover/Armrest

Plenum Chamber

Gutter

The gutter

Dashboard, Replacing

Removing the Dashboard

Installing the Dashboard

Soundproofing Panel Driver's Side, Replacing

Data Link Connector (DLC) With Bracket

Data Link Connector (DLC) Without Bracket

Decals For Safety Equipment

All sections

Dashboard, Replacing Volvo C70 I

Transmission - Adaptation (Coupe)

Dashboard, Replacing

Note. As the illustrations in this service information are used for different model years and / or models, some variation may occur. However, the essential information is always correct.