Manual sections
Repair manual

Electrical Equipment Audi TT 8N рестайлинг

Step-by-step instructions on "Electrical Equipment" for Audi TT 8N рестайлинг (2003–2006). Pick an article — removal, installation, adjustment and diagnostics with illustrations.

176subsections
176articles
224illustrations

General Information

1 article

Application notes

1 article

Instrument cluster On Board Diagnostic (OBD), initiating

1 article

Scan Tool (ST) and test equipment safety precautions

1 article

Test requirements

1 article

Address word for instrument cluster: 17

1 article

On Board Diagnostic (OBD) functions

1 article

Diagnostic Trouble Code (DTC) Memory, checking (function 02)

1 article

Diagnostic Trouble Code (DTC) table

1 article

Output Diagnostic Test Mode (DTM) (function 03)

1 article

Diagnostic Trouble Code (DTC) Memory, erasing

1 article

End Output (function 06)

1 article

Code Control Module (function 07)

1 article

Read Measuring Value Block (function 08)

1 article

Read Measuring Value Blocks, interpreting

1 article

Adaptation (function 10)

1 article

Adaptation, initiating

1 article

Service Interval Display (SID), resetting after service

1 article

Fuel consumption display, adapting

1 article

Language versions for multi-function display, adapting

1 article

Odometer, adaptation

1 article

Adaptation

1 article

SID: distance remaining until next Inspection Service (after replacing instrument cluster)

1 article

SID: time remaining until next Inspection Service (after replacing instrument cluster)

1 article

Fuel level sender, adaptation

1 article

Replacement instrument cluster input values, adapting

1 article

Service interval display, resetting after a service without using VAG 1551/1552

1 article

Fixed service interval values, SID adaptation values

1 article

Message "dEF" on trip recorder display

1 article

Notes on replacing instrument cluster

1 article

Display groups, summary

1 article

Engine speed threshold, adaptation

1 article

SID: Distance remaining until next Inspection Service (adaptation after replacing instrument cluster)

1 article

SID: time remaining until next Inspection Service (adaptation after replacing instrument cluster)

1 article

SID: Minimum distance, adaptation

1 article

SID: Maximum distance, adaptation

1 article

SID: Maximum time interval, adaptation

1 article

Oil grade, adaptation (where applicable)

1 article

Total consumption, adaptation

1 article

Powertrain CAN-Bus, adaptation

1 article

Information CAN-Bus, adaptation

1 article

Data exchange between control modules, checking

1 article

Anti-theft immobilizer On Board Diagnostic (OBD), initiating

1 article

Diagnostic Trouble Code (DTC) Memory, erasing (function 05)

1 article

Display group overview

1 article

Adaptation of vehicle keys

1 article

Lost key procedure

1 article

Determining the secret number (7-digit PIN)

1 article

Adaptation after replacing instrument cluster

1 article

Adaptation after replacing Engine Control Module (ECM)

1 article

Login Procedure (function 11)

1 article

Login Procedure, instrument cluster

1 article

Login Procedure, Engine Control Module (ECM)

1 article

Additional information

1 article

"Read Measuring Value Block", performing

1 article

Cruise control system, activating/deactivating

1 article

Wiring and component check using test box VAG 1598/31

1 article

Automatic vertical headlight aim control On Board Diagnostic (OBD), initiating

1 article

Control Module Versions, checking (function 01)

1 article

Basic Setting (function 04)

1 article

VAG 1551/1552 Scan Tool (ST), VAS 5051 Vehicle Diagnostic Testing and Information System or VAS 5052 Vehicle Diagnostic and Service System, connecting and selecting functions

1 article

Warnings and safety measures for lead-acid batteries

1 article

Battery handling instructions

1 article

Absorbed Glass Mat (AGM) Battery

1 article

Battery, disconnecting and reconnecting

1 article

Battery, disconnecting

1 article

Battery, reconnecting (all)

1 article

Battery, removing and installing

1 article

Special tools, testers and auxiliary items needed

1 article

Removing

1 article

Installing

1 article

Battery with central gas venting

1 article

Visual check

1 article

No-load voltage, checking

1 article

Electrolyte level - battery with charge indicator (magic eye), checking

1 article

Electrolyte level - battery with cell caps, checking

1 article

Specific gravity, checking

1 article

Battery, testing

1 article

Battery, charging

1 article

Quick charging/boost starting

1 article

Generator (GEN) - 4-cylinder 132kW (180 bhp) engine, removing and installing

1 article

Generator (GEN) - 4-cylinder 165kW (225 bhp) engine, removing and installing

1 article

Generator (GEN) - 6-cylinder 184kW (250 bhp) engine, removing and installing

1 article

Ribbed belt pulley, removing and installing

1 article

Ribbed belt pulley with free-wheel, removing and installing

1 article

Starter - 4-cylinder engine with manual transmission, removing and installing

1 article

Starter - 4-cylinder engine with automatic transmission, removing and installing

1 article

Starter - 6-cylinder engine, removing and installing

1 article

On Board Diagnostic (OBD), function

1 article

OBD program application notes

1 article

Preparation

1 article

VAS 5051/5052

1 article

VAG 1551/1552

1 article

Instrument cluster, rear view

1 article

Speedometer Vehicle Speed Sensor (VSS) -G22-, checking

1 article

Sender for Fuel Gauge -G-, checking

1 article

Sender for Fuel Gauge -G-, multi-pin connector assignments

1 article

Fuel consumption signal, testing

1 article

Engine Coolant Temperature (ECT) Sensor -G2-, checking

1 article

Engine Coolant Temperature (ECT) Sensor -G2-, multi-pin connector assignments

1 article

Instrument cluster multi-pin connector assignments

1 article

Garage Door Opener Control Module -J530-, removing and installing

1 article

Windshield wiper system, removing and installing

1 article

Wiper blade park position, setting

1 article

Wiper blade contact angle, adjusting

1 article

Washer fluid reservoir, removing and installing

1 article

Spray jets, removing and installing

1 article

Headlight washer spray jets, removing and installing

1 article

Headlight washer spray jets, adjusting

1 article

Headlight washer fluid reservoir, removing and installing

1 article

Headlight housing, removing and installing

1 article

Halogen headlights, adjusting

1 article

Halogen low beam bulb, replacing

1 article

Halogen high beam bulb, replacing

1 article

Parking/side marker light bulb, replacing

1 article

Turn signal bulb, replacing

1 article

Headlight securing lugs, servicing

1 article

HID headlights, adjusting

1 article

HID bulb, replacing

1 article

Headlight Beam Adjusting Motors -V48- and -V49-, removing and installing

1 article

High Intensity Gas Discharge Lamp Control Modules -J343- and -J344- through approx. 03.00, removing and installing

1 article

High Intensity Gas Discharge Lamp Control Modules -J343- and -J344- from approx. 04.00, removing and installing

1 article

Fog lights, removing and installing

1 article

Fog light bulbs, replacing

1 article

Fog lights, adjusting

1 article

Side mounted turn signals, removing and installing

1 article

Rear light housing and bulb holder, removing and installing

1 article

Rear light housing, alignment

1 article

High mount brake light - Coupe, removing and installing

1 article

High mount brake light - Roadster, removing and installing

1 article

License plate light, removing and installing

1 article

Steering column switches, removing and installing

1 article

Terminal assignments at multi-pin connectors

1 article

Lock cylinder, removing and installing

1 article

Ignition/starter switch, removing and installing

1 article

Headlight Range Control Module -J431- - Coupe, removing and installing

1 article

Headlight Range Control Module -J431- - Roadster, removing and installing

1 article

Left Front Level Control System Sensor -G78-, removing and installing

1 article

Removing (front-wheel drive)

1 article

Removing (all-wheel drive)

1 article

Switches in instrument panel, removing and installing

1 article

Light Switch -E1-, removing and installing

1 article

Glove compartment light (switch) -W6-, removing and installing

1 article

Switches in front center console, removing and installing

1 article

Switch mount in rear center console, removing and installing

1 article

Driver's Interior Locking Switch -E150-, removing and installing

1 article

Function Selector Switch 2 (Navigation), removing and installing

1 article

Wind Deflector Switch, -E278-, removing and installing

1 article

Convertible Top Operation Switch -E137-, removing and installing

1 article

Mirror Adjustment Switch -E43-, removing and installing

1 article

Window lifter switches, removing and installing

1 article

Door contact switches, removing and installing

1 article

Garage Door Opener Control Head -E284-, removing and installing

1 article

Rear lid contact switch, removing and installing

1 article

Font interior/reading light - Coupe, removing and installing

1 article

Front interior/reading light bulbs - Coupe, replacing

1 article

Front interior/reading light - Roadster, removing and installing

1 article

Special tools and equipment required

1 article

Front interior/reading light bulbs - Roadster, replacing

1 article

Luggage compartment lights - Coupe, removing and installing

1 article

Luggage compartment light - Roadster, removing and installing

1 article

Glove compartment light, removing and installing

1 article

Removing and installing make-up mirror light - Coupe

1 article

Horn, removing and installing

1 article

Malfunctioning transponder and/or loss of key

1 article

Reader coil, replacing

1 article

Lock set or instrument cluster, procedure for replacing

1 article

System test

1 article

Main fuse panel, removing and installing

1 article

Fuse panel, removing and installing

1 article

Micro central electric and 13-position relay panel, removing and installing

1 article

Auxiliary relay panel in left rear engine compartment, removing and installing

1 article

Wiring harnesses and connectors, repairing

1 article

0.22 mm2 or 0.35 mm2 wiring, repairing

1 article

Safety precautions for repairing wiring and plug connectors

1 article

Antenna connector cable, replacing

1 article