Home ReviewsRefund
Home/RAM/Pickup 2500/RAM Pickup 2500 (2011-2012)/Repair manual/Fuses & Circuit Breakers/Vehicle Quick Reference: Maintenance
Contents Wiring diagrams Section: Fuses & Circuit Breakers All sections

Vehicle Quick Reference: Maintenance RAM Pickup 2500

Fuses & Circuit Breakers ~1411 words

FLUID ADDITIVES

Chrysler strongly recommends against the addition of any fluids to the transmission, other than those automatic transmission fluids listed above. Exceptions to this policy are the use of special dyes to aid in detecting fluid leaks.

Various "special" additives and supplements exist that claim to improve shift feel and/or quality. These additives and others also claim to improve converter clutch operation and inhibit overheating, oxidation, varnish, and sludge. These claims have not been supported to the satisfaction of Chrysler and these additives must not be used. The use of transmission "sealers" should also be avoided, since they may adversely affect the integrity of transmission seals.

BRAKE FLUID

The brake fluid used in this vehicle must conform to DOT 3 specifications and SAE J1703 standards. No other type of brake fluid is recommended or approved for usage in the vehicle brake system. Use only Mopar brake fluid or an equivalent from a tightly sealed container.

CAUTIONNever use reclaimed brake fluid or fluid from a container which has been left open. An open container of brake fluid will absorb moisture from the air and contaminate the fluid.
CAUTIONNever use any type of a petroleum-based fluid in the brake hydraulic system. Use of such type fluids will result in seal damage of the vehicle brake hydraulic system causing a failure of the vehicle brake system. Petroleum based fluids would be items such as engine oil, transmission fluid, power steering fluid, etc.

FLUID TYPES

When service is required, Chrysler Group LLC recommends that only Mopar® brand parts, lubricants and chemicals be used. Mopar® provides the best engineered products for servicing Chrysler Group LLC vehicles.

POWER STEERING FLUID

Mopar® ATF +4, Automatic Transmission Fluid is required in the power steering system. Substitute fluids can induce power steering system failure.

Mopar® ATF +4, Automatic Transmission Fluid when new is red in color. The ATF is dyed red so it can be identified from other fluids used in the vehicle such as engine oil or antifreeze. The red color is not permanent and is not an indicator of fluid condition. As the vehicle is driven, the ATF will begin to look darker in color and may eventually become brown. This is normal. ATF+4 also has a unique odor that may change with age. Consequently, odor and color cannot be used to indicate the fluid condition or the need for a fluid change.

Oil Change Indicator- Reset

The vehicle is equipped with an engine oil change indicator system. The "Oil Change Required" message flashes in the EVIC display for approximately ten seconds after a single chime has sounded, to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate depending upon your personal driving style.

Unless reset, this message continues to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure

  1. Turn the ignition switch to the "ON" position. Do not start the engine.
  2. Fully press the accelerator pedal slowly three times within ten seconds.
  3. Turn the ignition switch to the "LOCK" position.

Note. If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary, repeat this procedure.

At Each Stop for Fuel

  1. Check the engine oil level about five minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
  2. Check the windshield washer solvent and add if required.

Once a Month

  1. Check tire pressure and look for unusual wear or damage.
  2. Inspect the battery and clean and tighten the terminals as required.
  3. Check the fluid levels of the coolant reservoir, brake master cylinder, and transmission and add as needed.
  4. Check all lights and other electrical items for correct operation.

At Each Oil Change

  1. Change the engine oil filter.
  2. Inspect the brake hoses and lines.
CAUTIONFailure to perform the required maintenance items may result in damage to the vehicle. Proper operation of four-wheel drive vehicles depends on tires of equal size, type and circumference on each wheel. Any difference in tire size can cause damage to the transfer case. Tire rotation schedule should be followed to balance tire wear.

Required Maintenance Intervals

Note. ** Vehicle's built with the 4.7L engine are equipped with sixteen spark plugs. One set is located on the top of the engine under the coils and the second set is located on the side of the engine. The spark plugs located under the coils are a standard plug and must be changed every 48,000 miles (80 000 km). The spark plugs located on the side of the engine are a premium plug and must be changed every 96,000 miles (160 000 km).

Perform Maintenance EveryMaintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
MilesKilometersMonths
8000130006Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 8,000 miles (13 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only).
160002600012Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 16,000 miles (26 000 km). If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary. Lube the front drive shaft fitting (2500/3500 (4x4) models only). Inspect the brake linings, replace if necessary. Inspect the CV joints. Perform the first inspection at 16,000 miles (26 000 km) or 12 months. Inspect exhaust system. Perform the first inspection at 16,000 miles (26 000 km) or 12 months. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
240003900018Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 24,000 miles (39 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only). Inspect the CV joints. Inspect exhaust system. Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
320005200024Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 32,000 miles (52 000 km). Replace the engine air cleaner filter. Replace the spark plugs (3.7L and 5.7L Engines). Lube the front drive shaft fitting (2500/3500 (4x4) models only). Adjust parking brake on vehicles equipped with four-wheel disc brakes. Inspect the transfer case fluid. Inspect the brake linings, replace if necessary. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
400006500030Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 40,000 miles (65 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only).
480007800036Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 48,000 miles (78 000 km). If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary. Replace the top row of spark plugs (4.7L Engine). ** Lube the front drive shaft fitting (2500/3500 (4x4) models only). Inspect the brake linings, replace if necessary. Inspect the CV joints. Inspect exhaust system. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
560009100042Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 56,000 miles (91 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only).
6400010400048Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 64,000 miles (104 000 km). Replace the engine air cleaner filter. Replace the ignition cables (3.7L Engine). Replace the spark plugs (3.7L and 5.7L Engines). Lube the front drive shaft fitting (2500/3500 (4x4) models only). Inspect the brake linings; replace if necessary. Adjust parking brake on vehicles equipped with four-wheel disc brakes. Change the automatic transmission fluid and filter(s) if using your vehicle for any of the following: police, taxi, fleet, or frequent trailer towing. Change the transfer case fluid if using your vehicle for any of the following: police, taxi, fleet, or frequent trailer towing. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
7200011700054Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 72,000 miles (117 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only). Inspect the CV joints. Inspect exhaust system. Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
8000013000060Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 80,000 miles (130 000 km). If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary. Lube the front drive shaft fitting (2500/3500 (4x4) models only). Flush and replace the engine coolant if not done at 104,000 miles (169 000 km). Inspect the brake linings, replace if necessary. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
8800014300066Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 88,000 miles (143 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only).
9600015600072Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 96,000 miles (156 000 km). Replace the engine air cleaner filter. Replace the ignition cables (4.7L Engine). Replace the top row and side row of spark plugs (4.7L Engine). ** Replace the spark plugs (3.7L and 5.7L Engines). Inspect and replace PCV valve if necessary. α - Lube the front drive shaft fitting (2500/3500 (4x4) models only). Adjust parking brake on vehicles equipped with four-wheel disc brakes. Inspect the transfer case fluid. Inspect the brake linings, replace if necessary. Inspect the CV joints. Inspect exhaust system. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
10400016900078Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 104,000 miles (169 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only). Flush and replace the engine coolant if not done at 60 months.
11200018200084Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 112,000 miles (182 000 km). If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary. Lube the front drive shaft fitting (2500/3500 (4x4) models only). Inspect the brake linings, replace if necessary. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
12000019500090Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 120,000 miles (195 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only). Inspect the CV joints. Inspect exhaust system. Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Change the automatic transmission fluid and filter(s). Replace the accessory drive belt(s).
12800020800096Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 128,000 miles (208 000 km). Replace the engine air cleaner filter. Replace the ignition cables (3.7L Engine). Replace the spark plugs (3.7L and 5.7L Engines). Lube the front drive shaft fitting (2500/3500 (4x4) models only). Adjust parking brake on vehicles equipped with four-wheel disc brakes. Change the transfer case fluid. Inspect the brake linings, replace if necessary. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary.
136000221000102Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 136,000 miles (221 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only).
144000234000108Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 144,000 miles (234 000 km). If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter; replace if necessary. Replace the top row of spark plugs (4.7L Engine). ** Lube the front drive shaft fitting (2500/3500 (4x4) models only). Inspect the brake linings, replace if necessary. Inspect the CV joints. Inspect exhaust system. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect the front and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
152000247000114Change the engine oil and engine oil filter. Rotate the tires, rotate at the first sign of irregular wear, even if it occurs before 152,000 miles (247 000 km). Lube the front drive shaft fitting (2500/3500 (4x4) models only).

α - This maintenance is recommended by the manufacturer to the owner, but is not required to maintain emissions warranty.

WARNINGYou can be badly injured working on or around a motor vehicle. Do only service work for which you have the knowledge and the right equipment. If you have any doubt about your ability to perform a service job, take your vehicle to a competent mechanic. Failure to properly inspect and maintain your vehicle could result in a component malfunction and effect vehicle handling and performance. This could cause an accident Failure to follow these instructions may result in possible serious or fatal injury.

The vehicle is equipped with an engine oil change indicator system. The "Oil Change Required" message flashes in the EVIC display for approximately ten seconds after a single chime has sounded, to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate depending upon personal driving style.

Unless reset, this message continues to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure

  1. Turn the ignition switch to the "ON" position. Do not start the engine.
  2. Fully press the accelerator pedal slowly three times within ten seconds.
  3. Turn the ignition switch to the "LOCK" position.

Note. If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary, repeat this procedure.

At Each Stop for Fuel

  1. Check the engine oil level about 30 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.

Once a Month

  1. Inspect the batteries, and clean and tighten the terminals as required.
  2. Check the fluid levels of the coolant reservoir, brake master cylinder, and transmission and transfer case (if equipped), add as needed.

At Each Oil Change

  1. Change the engine oil filter.
  2. Inspect the exhaust system.
  3. Check the automatic transmission fluid level.
  4. Check the manual transmission fluid level.
  5. Check the coolant level, hoses, and clamps.
  6. Lubricate outer tie rod ends.
CAUTIONFailure to perform the required maintenance items may result in damage to the vehicle. Proper operation of four-wheel drive vehicles depends on tires of equal size, type and circumference on each wheel. Any difference in tire size can cause damage to the transfer case. Tire rotation schedule should be followed to balance tire wear.

Refer to the Maintenance Schedules on the following Service Information for the required maintenance intervals.

Perform Maintenance EveryMaintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
MilesKilometersMonths
7500120006When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends.
150002400012When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
225003600018When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Inspect drive belt, replace if necessary. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect brake linings. Inspect and adjust parking brake if necessary.
300004800024When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the wheel bearings. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Check the transfer case fluid (4x4). Change automatic transmission fluid (Chassis Cab Only).
375006000030When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends.
450007200036When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Inspect drive belt, replace as necessary. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect brake linings. Inspect and adjust parking brake if necessary. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
525008400042When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends.
600009600048When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the wheel bearings. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Change automatic transmission fluid and sump filter (Chassis Cab Only). Change automatic transmission fluid and filter(s) if using your vehicle for any of the following: police, fleet, or frequent trailer towing (Ram Truck Only). Inspect the manual transmission fluid, add if necessary. Change the transfer case fluid (4x4).
6750010800054When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect brake linings. Inspect and adjust parking brake if necessary. Replace Crankcase Ventilation Filter (CCV). Clean EGR Valve (Ram Truck - California, Maine, Vermont, Massachusetts, New York, Connecticut, Rhode Island, and Oregon Only). Clean EGR Cooler (Ram Truck Only)**.
7500012000060When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Flush and replace engine coolant at 60 months, if not replaced at 97,500 miles (157 000 km). Inspect drive belt, replace as necessary. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
8250013200066When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends.
9000014400072When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Inspect drive belt, replace as required. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the wheel bearings. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect brake linings. Inspect and adjust parking brake if necessary. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Check the transfer case fluid (4x4). Change automatic transmission fluid (Chassis Cab Only).
9750015600078When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Flush and replace engine coolant, if not replaced at 60 months. Flush and replace power steering fluid (3500 Ram Truck Only).
10500016800084When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Inspect drive belt, replace as required. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Flush and replace power steering fluid. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
11250018000090When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect brake linings. Inspect and adjust parking brake if necessary.
12000019200096When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Inspect drive belt, replace as required. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the wheel bearings. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Change automatic transmission fluid and sump filter (Chassis Cab Only). Change automatic transmission fluid and filter(s) (Ram Truck Only). Change the manual transmission fluid if using your vehicle for any of the following: police, fleet, or frequent trailer towing. Change the transfer case fluid (4x4).
127500204000102When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends.
135000216000108When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Inspect drive belt, replace as required. Replace fuel filter element. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Inspect brake linings. Inspect and adjust parking brake if necessary. Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Replace Crankcase Ventilation Filter (CCV). Clean EGR Valve (Ram Truck Only). Clean EGR Cooler (Ram Truck Only).
142500228000114When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends.
150000240000120When prompted by the Engine Oil Indicator System, the engine oil and filter must be changed. If not prompted by the Engine Oil Indicator System within 7,500 miles (12 000 km) or six months since the last oil and filter change, change the engine oil and engine oil filter. Under no circumstances should oil change intervals exceed 7,500 miles (12 000 km) or six months, whichever comes first. Rotate tires. Replace fuel filter element. Inspect drive belt, replace as required. Adjust valve lash clearance. Lubricate front drive shaft fitting (4x4). Lubricate outer tie rod ends. Inspect the wheel bearings. Inspect the front suspension, tie rod ends and boot seals for cracks or leaks and all parts for damage, wear, improper looseness or end play; replace if necessary. Flush and replace engine coolant at 120 months, if not replaced at 97,500 miles (157 000 km). Inspect the front (4x4) and rear axle fluid, change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing. Check the transfer case fluid (4x4). Change automatic transmission fluid (Chassis Cab Only).

Inspection and service should also be performed anytime a malfunction is observed or suspected. Retain all receipts.

* This maintenance is not required if belt was previously replaced.

**The EGR Valve and EGR Cooler maintenance will be covered by the manufacturer only at this maintenance interval, for vehicles in California, Maine, Massachusetts, New York, Vermont, Connecticut, Oregon, Rhode Island.

CAUTION***The manufacturer highly recommends that all cooling system service, maintenance, and repairs be performed by a local authorized dealer.
WARNINGYou can be badly injured working on or around a motor vehicle. Do only service work for which you have the knowledge and the right equipment. If you have any doubt about your ability to perform a service job, take the vehicle to a competent mechanic. Failure to properly inspect and maintain the vehicle could result in a component malfunction and effect vehicle handling and performance. This could cause an accident Failure to follow these instructions may result in possible serious or fatal injury.

The vehicle is equipped with an engine oil change indicator system. The "Oil Change Required" message flashes in the EVIC display for approximately ten seconds after a single chime has sounded, to indicate the next scheduled oil change interval. The engine oil change indicator system is duty cycle based, which means the engine oil change interval may fluctuate depending upon your personal driving style.

Unless reset, this message continues to display each time you turn the ignition switch to the ON/RUN position. To turn off the message temporarily, press and release the Menu button. To reset the oil change indicator system (after performing the scheduled maintenance) perform the following procedure

  1. Turn the ignition switch to the "ON" position. Do not start the engine.
  2. Fully press the accelerator pedal slowly three times within ten seconds.
  3. Turn the ignition switch to the "LOCK" position.

Note. If the indicator message illuminates when you start the vehicle, the oil change indicator system did not reset. If necessary, repeat this procedure.

At Each Stop for Fuel

  1. Check the engine oil level about five minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accuracy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
  2. Check the windshield washer solvent and add if required.

Once a Month

  1. Check tire pressure and look for unusual wear or damage.
  2. Inspect the battery and clean and tighten the terminals as required.
  3. Check the fluid levels of the coolant reservoir, brake master cylinder, power steering and transmission and add as needed.
  4. Check all lights and other electrical items for correct operation.

At Each Oil Change

  1. Change the engine oil filter.
  2. Inspect the brake hoses and lines.
CAUTIONFailure to perform the required maintenance items may result in damage to the vehicle. Proper operation of four-wheel drive vehicles depends on tires of equal size, type and circumference on each wheel. Any difference in tire size can cause damage to the transfer case. Tire rotation schedule should be followed to balance tire wear.
Perform Maintenance EveryMaintenance Items
(Where time and mileage are listed, follow the interval that occurs first.)
MilesKilometersMonths
8000130006Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends.
160002600012Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Inspect the CV joints. Perform the first inspection at 12,000 miles (20 000 km) or 12 months. Inspect exhaust system. Perform the first inspection at 12,000 miles (20 000 km) or 12 months.
240003900018Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front & rear axle fluid. Change if using your vehicle for fleet, off-road or frequent trailer towing.
320005200024Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Lube front drive shaft fitting (4x4 only). Inspect the CV joints. Inspect exhaust system.
400006500030Change the engine oil and engine oil filter. Rotate tires. Replace the engine air cleaner filter. Replace the spark plugs. Adjust parking brake on vehicles equipped with four wheel disc brakes. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the transfer case fluid.
480007800036Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Inspect the front & rear axle fluid. Change if using your vehicle for fleet, off-road or frequent trailer towing.
560009100042Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends.
6400010400048Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Lube front drive shaft fitting (4x4 only). Inspect the CV Joints. Inspect exhaust system.
7200011700054Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front & rear axle fluid. Change if using your vehicle for fleet, off-road or frequent trailer towing.
800001300060Change the engine oil and engine oil filter. Rotate tires. Replace the engine air cleaner filter. Replace the spark plugs. Adjust parking brake on vehicles equipped with four wheel disc brakes. Inspect the brake linings, replace if necessary. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Change the automatic transmission fluid & filter(s) if using your vehicle for any of the following: fleet, snow plowing, or frequent trailer towing. Inspect the transfer case fluid, add if necessary. Flush and replace the engine coolant at 60 months if not done at 102,000 miles (170 000 km).
8800014300066Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends.
9600015600072Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Lube front drive shaft fitting (4x4 only). Inspect the front & rear axle fluid. Change if using your vehicle for fleet, off-road or frequent trailer towing. Inspect the CV Joints. Inspect exhaust system.
10400016900078Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends.
11200018200084Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary.
12000019500090Change the engine oil and engine oil filter. Rotate tires. Replace the engine air cleaner filter. Replace the spark plugs. Inspect and replace PCV valve if necessary. α - Adjust parking brake on vehicles equipped with four wheel disc brakes. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front & rear axle fluid. Change if using your vehicle for fleet, off-road or frequent trailer towing. Inspect the transfer case fluid.
12800020800096Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Lube front drive shaft fitting (4x4 only). Inspect the CV Joints. Inspect exhaust system.
136000221000102Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Flush and replace the engine coolant if not done at 60 months. Flush and replace power steering fluid.
144000234000108Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Inspect the front & rear axle fluid. Change if using your vehicle for taxi, fleet, off-road or frequent trailer towing.
152000247000114Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends.
120000200000120Change the engine oil and engine oil filter. Rotate tires. Replace the engine air cleaner filter. Replace the spark plugs. Adjust parking brake on vehicles equipped with four wheel disc brakes. Inspect the brake linings, replace if necessary. Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Lube front drive shaft fitting (4x4 only). Inspect the CV Joints. Inspect exhaust system. Inspect the transfer case fluid, change if using your vehicle for any of the following: fleet, off-road, or frequent trailer towing. Change the automatic transmission fluid & filter(s). Replace accessory drive belt(s).
126000210000126Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front & rear axle fluid. Change if using your vehicle for fleet, off-road or frequent trailer towing.
132000220000132Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary.
138000230000138Change the engine oil and engine oil filter. Rotate tires. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends.
144000240000144Change the engine oil and engine oil filter. Rotate tires. If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary. Inspect the brake linings, replace if necessary. Lubricate outer tie rod ends. Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. Lube front drive shaft fitting (4x4 only). Inspect the front & rear axle fluid. Change if using your vehicle for fleet, off-road or frequent trailer towing. Inspect the CV Joints. Inspect exhaust system.
150000250000150Change the engine oil and engine oil filter. Rotate tires. Replace the engine air cleaner filter. Replace the spark plugs. Adjust parking brake on vehicles equipped with four wheel disc brakes. Lube front drive shaft fitting (4x4 only). Lubricate outer tie rod ends. Inspect the transfer case fluid.

α - This maintenance is recommended by the manufacturer to the owner, but is not required to maintain emissions warranty.

WARNINGYou can be badly injured working on or around a motor vehicle. Do only service work for which you have the knowledge and the right equipment. If you have any doubt about your ability to perform a service job, take your vehicle to a competent mechanic. Failure to properly inspect and maintain your vehicle could result in a component malfunction and effect vehicle handling and performance. This could cause an accident Failure to follow these instructions may result in possible serious or fatal injury.

More articles — Vehicle Quick Reference