Technical Data
Piston Pins
| Diameter (mm) | Interference fit | |||
|---|---|---|---|---|
| in con-rod (mm) | Clearance in piston (mm) | |||
| Standard | Limit | Standard | Limit | |
| 21.997-22.005 | 21.97 | 0.02-0.041 | 0.007 to 0.02 | 0.039 |
Installation Heat con-rod small end cool piston pin
Home/Opel/Monterey/Opel Monterey A (1992-1999)/Repair manual/OHC Petrol Engine/Technical Data Piston Pin - 6VD1
Contents
Section: OHC Petrol Engine- Oil Change Interval (All Monterey with 6DV1 Petrol Engine)
- Crankshaft Operations
- Toothed Belt Replacement Intervals Reference Guide from 1991 MY to 1998 MY
- Camshaft Pulley 6VD1 Petrol Engine
- Petrol Engine - General
- Engine Management
- Special Service Tools Petrol Engine 6VD1
- Introduction
- Toothed Belt Diagnosis - Possible Causes and Remedys
- Toothbelt - Service Intervall Overview
- Illustration of - SOHC Petrol Engine 6VD1, Cross-Section, Rear View
- Illustration of - SOHC Petrol Engine 6VD1, Longitudinal View
- Illustration of - SOHC Petrol Engine 6VD1, Top View
- General Instructions, Safety Instructions (6VD1)
- How to Adjust the Drive Belt Tension, Alternator, Check And (6VD1)
- How to Check the Compression (6VD1)
- How to Check the Loss of Compression (6VD1)
- How to Measure the Engine Oil Temperature (6VD1)
- How to Check the Engine Oil Pressure (6VD1)
- How to Check and Adjust the Timing (6VD1)
- How to Check and Adjust the Toothed Belt Tension (6VD1)
- How to Remove and Install the Toothed Belt Covers (6VD1)
- How to Remove and Install the Toothed Belt (6VD1)
- How to Remove and Install the Seal Ring, Camshaft Housing, Front (6VD1)
- How to Remove and Install the Exhaust Manifold Seal at Cylinder Head (6VD1)
- How to Remove and Install the Intake Manifold Seal at Cylinder Head (6VD1)
- How to Remove and Install the Rocker Arm Shafts and Rocker Arm (6VD1)
- How to Check the Rocker Arm Shaft (6VD1)
- Rocker Arm .Check - 6VD1
- How to Remove and Install the Camshaft (6VD1)
- Camshaft Check - 6VD1
- How to Repair the Spark Plug Thread (6VD1)
- How to Remove and Install the Cylinder Head (6VD1)
- Cylinder Head, Disassemble and Assemble (6VD1)
- How to Overhaul the Cylinder Head (6VD1)
- How to Replace the Valve Guide (6VD1)
- How to Replace the Valve Seat (6VD1)
- How to Check for Plane Surface the Cylinder Head (6VD1)
- How to Replace the Crankshaft Guide Bearing (6VD1)
- How to Remove and Install the Flywheel (6VD1)
- How to Replace the Starter Ring Gear (6VD1)
- How to Remove and Install the Seal, Oil Pan (6VD1)
- How to Remove and Install the Piston with Con-Rod (6VD1)
- How to Remove and Install the Piston Rings (6VD1)
- How to Remove and Install the Con-Rod Bearing (6VD1)
- How to Replace the Con-Rod or Piston (6VD1)
- How to Remove and Install the Crankshaft Gear (6VD1)
- How to Remove and Install the Crankshaft (6VD1)
- Crankshaft Check - 6VD1
- How to Remove and Install the Oil Seal Ring, Crankshaft (Oil Pump Housing) (6VD1)
- How to Remove and Install the Oil Seal Ring, Crankshaft, Rear (6VD1)
- How to Remove and Install the Oil Filter (6VD1)
- How to Remove and Install the Oil Pump Safety Valve (6VD1)
- How to Remove and Install the Oil Pump (6VD1)
- How to Overhaul the Oil Pump (6VD1)
- How to Remove and Install the Oil Cooler (6VD1)
- How to Remove and Install the Engine Damping Blocks (6VD1)
- How to Remove and Install the Engine Without Transmission (6VD1)
- How to Repair with Short Block the Engine (6VD1)
- Spark Plug Damages - Possible Causes and Failure Modes
- How to Remove and Install the Crankshaft Angle Sensor (6VD1)
- Special Service Tools SOHC Petrol Engine 6VD1
- Technical Data Engine Oil Viscosity - 6VD1
- Technical Data Engine Oil Quality - 6VD1
- Technical Data Disposal - 6VD1
- Technical Data Engine Oil Quantities - 6VD1
- Technical Data Drive Belts - 6VD1
- Technical Data Adjustment Values/checking Values - 6VD1
- Technical Data Cylinder Head Dimensions - 6VD1
- Technical Data Dimensions of Valve to Cylinder Head - 6VD1
- Technical Data Valve Dimensions - 6VD1
- Technical Data Valve Springs - 6VD1
- Technical Data Valve Train - 6VD1
- Technical Data Camshaft - 6VD1
- Technical Data Cylinder and Piston Dimensions - 6VD1
- Technical Data Piston Rings - 6VD1
- Technical Data Piston Pin - 6VD1
- Technical Data Crankshaft Main Bearing - 6VD1
- Technical Data Con-Rod Bearing - 6VD1
- Technical Data Flywheel - 6VD1
- Tightening Torques - 6VD1
- ABS
- ABS 5.3
- Accessories
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-M
- Automatic Transmission Rear Wheel Drive
- Battery
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Locking with Atws (Electronic)
- Clutch
- Clutch and Transmission
- Cooling System
- Diesel Engine
- Distributor Transmission Four Wheel Drive
- DOHC Petrol Engine
- Electrical Equipment and Instruments
- Electrical Window Winders
- Electronic Cruise Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Four Wheel Drive
- Manual Transmission Rear Wheel Drive
- OHC Petrol Engine
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Power Steering
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Rear Wheel Drive
- Rear Wheel Brake
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses