Check piston rings end gap and side clearance. Check ring bore by depressing ring into cylinder with an inverted piston. See PISTONS, PINS & RINGS table under ENGINE SPECIFICATIONS. Lubricate pistons and rings with clean oil. Install rings onto pistons. Stagger ring gaps. (Схема №40)
Contents
Wiring diagrams Section: Mechanical- Engine Identification
- Valve Clearance Adjustment
- Trouble Shooting
- Removal & Installation
- Fuel Pressure Release
- Removal & Installation (Left Exhaust Manifold)
- Removal & Installation (Right Exhaust Manifold)
- Timing Belt
- Tools Required
- Timing Belt Adjustment Checking
- Marks on Camshaft Gears 3 and 4 Align to the Left of J 42069-20
- Marks on Camshaft Gears 3 and 4 Align to the Right of J 42069-20
- Marks on Camshaft Gears 1 and 2 Align to the Left of J 42069-20
- Marks on Camshaft Gears 1 and 2 Align to the Right of J 42069-20
- Timing Belt Tensioner Adjustment
- Overhaul
- Cylinder Head
- Valve Springs
- Installed Spring Height
- Valve Stem Oil Seals
- Valve Guides
- Valve Seat
- Valves
- Valve Seat Correction Angles
- Piston & Rod Assembly
- Fitting Pistons
- Piston Rings
- Rod Bearings
- Crankshaft & Main Bearings
- Thrust Bearing
- Cylinder Block
- Engine Lubrication System
- Crankcase Capacity
- Oil Pressure
- Torque Specifications
- Engine Specifications
- A/c Compressor
- Abbreviations
- Accessory Drive Belts
- Adjustments
- Airbag
- Anti-Lock/traction Control
- Application
- Automatic HVAC System
- Automatic Trans
- Auxiliary Emission Control Systems
- Axle Shafts
- Basic Trouble Shooting
- Body Electrical
- Body, Cab Control Systems
- Brakes
- Cabin Air Filter
- Charging System
- Check Lists
- Computer Relearn
- Cooling Fan
- Cruise Control Systems
- Diagnostic Connector Locations
- Differentials & Drive Axles
- Door Locks & Anti-Theft Systems
- Drive Cycles
- Driveline/axles
- Driveshaft & Universal Joints
- DTC Index
- Electrical
- Electrical Component Locations
- Electronic Steering
- Electronic Suspension
- Emission Applications
- Engine
- Engine Performance
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing - All Makes
- Headlights
- Heated Glass/defoggers
- Identification
- Manual & Power Steering
- Manual HVAC System
- MAP Guidelines
- Mechanical
- Mechanical - Hydraulic
- Metric Conversions
- Mirrors
- Mode 6
- Procedures
- Removal & Installation
- Reset Procedures
- Restraints
- Rpo Codes
- Seats
- Sensor Range Charts
- Specifications
- Starter
- Steering
- Steering Column
- Steering Column Switches
- Sun Roof/t-Top/convertible Top
- Suspension Front
- Suspension Rear
- Testing & Diagnostics
- Theory & Operation
- Timing Belt
- Traction Control Disable
- Transmission
- Wheel Alignment
- Windows
- Wiper/washer Systems
- Wiring Diagrams - Engine Performance