Manual sections

• Abbreviations
• Accessories Control Systems
• Accessory Drive Belts
• Airbag
• Alarm System, Control Modules, Engine Management Systems - Design and Function
• Antenna Systems
• Anti-Lock/traction Control
• Anti-Theft- Installation Instructions, Accessories
• Automatic HVAC System
• Automatic Trans
• Auxiliary Emission Control Systems
• Axle Shafts
• Basic Trouble Shooting
• Blowers, Superchargers & Turbochargers
• Body and Interior Systems - Removal, Replacement, Specifications
• Body Electrical
• Brake System Components - Removal and Installation
• Brakes
• Bulbs, Control Modules, Charging - Design and Function
• Cabin Air Filter
• Cables and Fuses - Removal, Replacement and Installation
• Center Differential, Drive Shaft, Half Shaft- Removal, Replacement and Installation
• Charging System
• Check Lists
• Climate Units - Installation Instructions, Accessories
• Climate Units - Removal, Replacement and Installation
• Clutches Manual & Hydraulic
• Collision/avoidance
• Connectors, Modules, Switches, Sensors - Removal, Replacement and Installation
• Control Modules, Restraint System, Starter, Sun Roof, Tire Pressure Monitoring, Transmission - Design and Function
• Cooling System (Mechanical)
• Cruise Control Systems
• Diagnostic Connector Locations
• Differentials & Drive Axles
• Door Locks & Anti-Theft Systems
• Drive Cycles
• Driveline/axles
• Driveshaft & Universal Joints
• DTC Index
• Electrical Component Locations
• Electronic Steering
• Electronic Suspension
• Emission Applications
• Engine
• Engine - Removal, Replacement and Installation
• Engine Control - Specifications, Removal & Installation
• Engine Control Systems
• Engine Performance
• Entertainment Systems
• Exhaust
• Exterior Body Panels
• Exterior Lights
• Exterior/interior Trim
• Frames, Subframes & Crossmembers
• Fuel System
• Fuel, Ignition & Engine Control Systems - Removal, Installation & Specifications
• Fuses & Circuit Breakers
• Gauges & Instrument Panels
• Gearbox, Input/output Speed Sensor - Removal & Installation
• Gearbox, Selector Cable, Selector Knob - Removal & Installation
• Heated Glass/defoggers
• Hoist/jack
• Identification
• Ignition System
• Interior - Installation Instructions, Accessories
• Interior - Removal, Replacement and Installation
• Interior Equipment - Installation Instructions, Accessories
• Interior Equipment - Removal, Replacement and Installation
• Lubrication System
• Manual & Power Steering
• Mechanical
• Mechanical - Hydraulic
• Media, Communication and Navigation - Installation Instructions, Accessories - 1 of 2
• Media, Communication and Navigation - Installation Instructions, Accessories - 2 of 2
• Metric Conversions
• Mirrors
• Mode 6
• Navigation System
• Oem General Information
• Paint/coatings
• Parking Brake System
• Passive Restraints
• Procedures
• Radiator, Transmission Components - Removal & Installation
• Reset Procedures
• Restraints, Seats, Windows - Removal & Installation
• Seats
• Specifications
• Starter
• Steering
• Steering Column
• Sun Roof/t-Top/convertible Top
• Suspension Control Systems
• Suspension Front
• Suspension Rear
• Testing & Diagnostics
• Timing Belt
• Towing and Auxiliary Storage - Installation Instructions, Accessories
• Towing Systems
• Traction Control Disable
• Transmission
• Transmission - Removal & Installation
• Transmission - Removal, Replacement and Installation - Part 1
• Transmission - Removal, Replacement and Installation - Part 2
• Transmission, Transmission Control Module (TCM), Fluid, Speed Sensor - Removal & Replacement
• Warning System
• Wheel & Tire System
• Wheel Alignment
• Wheel Hubs
• Wiper/washer Systems

Repair manual

Engine - Removal, Replacement and Installation Volvo V70 II рестайлинг

Step-by-step instructions on "Engine - Removal, Replacement and Installation" for Volvo V70 II рестайлинг (2004–2007). Pick an article — removal, installation, adjustment and diagnostics with illustrations.

160subsections

160articles

198illustrations

Crankshaft seal rear, replacing

1 article

• Crankshaft seal rear, replacing 3

Installing the sealing ring

1 article

• Installing the sealing ring 2

Installing the gearbox

1 article

• Installing the gearbox

Checking the engine

1 article

• Checking the engine

Crankshaft seal, front, replacing

1 article

• Crankshaft seal, front, replacing

Replacing the carrier plate

1 article

• Replacing the carrier plate

Preparatory work

1 article

• Preparatory work

Removing the carrier plate

1 article

• Removing the carrier plate 3

Finishing

1 article

• Finishing

Flywheel

1 article

• Flywheel

Removing the flywheel

1 article

• Removing the flywheel

Checking the crankshaft seal

1 article

• Checking the crankshaft seal

Installing the flywheel

1 article

• Installing the flywheel

Replacing the flywheel (Gasoline)

1 article

• Replacing the flywheel (Gasoline)

Preparations

1 article

• Preparations

Removing the flywheel and carrier plate

1 article

• Removing the flywheel and carrier plate

Removing the seal

1 article

• Removing the seal

Installing flywheel and carrier plate

1 article

• Installing flywheel and carrier plate

Replacing the flywheel

1 article

• Replacing the flywheel 1

Flywheel, replacing

1 article

• Flywheel, replacing

Removing transmission and clutch

1 article

• Removing transmission and clutch

Replacing flywheel

1 article

• Replacing flywheel

Carrier plate, replacing

1 article

• Carrier plate, replacing

Installing the carrier plate

1 article

• Installing the carrier plate

Transmission, removing (AW55-50)

1 article

• Transmission, removing (AW55-50) 29

Transmission, installing (AW55-50)

1 article

• Transmission, installing (AW55-50) 7

Transmission, installing (AW50 AWD)

1 article

• Transmission, installing (AW50 AWD) 5

Transmission, removing (AW50 AWD)

1 article

• Transmission, removing (AW50 AWD) 2

Checking crankshaft seal

1 article

• Checking crankshaft seal

Cylinder head/gasket, replacing

1 article

• Cylinder head/gasket, replacing 3

When replacing or working on the cylinder head

1 article

• When replacing or working on the cylinder head 1

Variable valve timing unit, checking and adjusting

1 article

• Variable valve timing unit, checking and adjusting 5

Installing components

1 article

• Installing components

Check

1 article

• Check

Preparation

1 article

• Preparation

Removing components

1 article

• Removing components

Depressurizing the fuel system

1 article

• Depressurizing the fuel system 1

Removing ignition coils

1 article

• Removing ignition coils

Removing intake manifold

1 article

• Removing intake manifold

Setting up the engine

1 article

• Setting up the engine

Removing the timing belt

1 article

• Removing the timing belt

Removing the timing gear pulley

1 article

• Removing the timing gear pulley

Removing components from turbocharger (TC)

1 article

• Removing components from turbocharger (TC)

Releasing the inlet pipe for the coolant pump

1 article

• Releasing the inlet pipe for the coolant pump

Removing the camshaft cover and cylinder head

1 article

• Removing the camshaft cover and cylinder head

Cleaning

1 article

• Cleaning

Installing the cylinder head

1 article

• Installing the cylinder head

Installing valve lifters and camshafts

1 article

• Installing valve lifters and camshafts

Applying liquid gasket

1 article

• Applying liquid gasket

Installing the camshaft cover

1 article

• Installing the camshaft cover

Installing the manifold and turbocharger (TC)

1 article

• Installing the manifold and turbocharger (TC)

Installing the rear camshaft seal

1 article

• Installing the rear camshaft seal

Installing the front camshaft seals

1 article

• Installing the front camshaft seals

Checking and adjusting the variable valve timing unit

1 article

• Checking and adjusting the variable valve timing unit

Installing intake manifold

1 article

• Installing intake manifold

Installing the fuel rail

1 article

• Installing the fuel rail 4

Cleaning the gasket faces

1 article

• Cleaning the gasket faces 2

Installing the intake pipe for the coolant pump

1 article

• Installing the intake pipe for the coolant pump 4

Installing the intake manifold and gasket

1 article

• Installing the intake manifold and gasket

Installing the fuel and air distribution pipe

1 article

• Installing the fuel and air distribution pipe 3

Aligning the crankshaft

1 article

• Aligning the crankshaft

Installing the camshaft covers

1 article

• Installing the camshaft covers

Installing the front camshaft seal

1 article

• Installing the front camshaft seal 1

Checking and adjusting

1 article

• Checking and adjusting 1

Installing the exhaust manifold

1 article

• Installing the exhaust manifold 4

Releasing the coolant pump inlet pipe

1 article

• Releasing the coolant pump inlet pipe

When replacing/machining the cylinder head

1 article

• When replacing/machining the cylinder head 1

Checking crankshaft setting

1 article

• Checking crankshaft setting

Installing VVT-unit/timing gear pulley on exhaust camshaft

1 article

• Installing VVT-unit/timing gear pulley on exhaust camshaft 7

Engine mount, right, replacing

1 article

• Engine mount, right, replacing 6

Sub-frame front, replacing

1 article

• Sub-frame front, replacing 18

Installing the sub-frame

1 article

• Installing the sub-frame 3

Engine mount, front, replacing

1 article

• Engine mount, front, replacing

Bushing sub-frame, replacing

1 article

• Bushing sub-frame, replacing 2

Removing the front engine pad lower screw

1 article

• Removing the front engine pad lower screw

Folding out the fender liner

1 article

• Folding out the fender liner 1

Removing the nuts and screw for the steering gear

1 article

• Removing the nuts and screw for the steering gear

Removing the delivery line for the steering gear

1 article

• Removing the delivery line for the steering gear 3

Installing the bracket for the heated oxygen sensor (HO2S)

1 article

• Installing the bracket for the heated oxygen sensor (HO2S) 2

Marking the left-hand rear bushing

1 article

• Marking the left-hand rear bushing 2

Lifting the sub-frame

1 article

• Lifting the sub-frame

Installing the nuts and screw for the steering gear

1 article

• Installing the nuts and screw for the steering gear

Installing the delivery line from the steering gear

1 article

• Installing the delivery line from the steering gear

Installing the screws for the engine mounting to the engine

1 article

• Installing the screws for the engine mounting to the engine

Installing the protective plate

1 article

• Installing the protective plate

Installing the screw for the front engine pad

1 article

• Installing the screw for the front engine pad

Installing the air intake cover

1 article

• Installing the air intake cover

Installing the protective cover

1 article

• Installing the protective cover

Removing the lifting tools

1 article

• Removing the lifting tools

Removing the rear engine pad

1 article

• Removing the rear engine pad 2

Installing the rear engine pad

1 article

• Installing the rear engine pad 1

Engine mount rear, replacing

1 article

• Engine mount rear, replacing

Replacing the rear engine pad

1 article

• Replacing the rear engine pad

Engine/transmission, installing

1 article

• Engine/transmission, installing 2

Installing the propeller shaft (all-wheel drive (AWD) only)

1 article

• Installing the propeller shaft (all-wheel drive (AWD) only)

Installing the three-way catalytic converter (TWC) (all-wheel drive (AWD) only)

1 article

• Installing the three-way catalytic converter (TWC) (all-wheel drive (AWD) only)

Installing the front exhaust pipe

1 article

• Installing the front exhaust pipe 7

Installing the transmission cable

1 article

• Installing the transmission cable 4

Final check

1 article

• Final check

Engine/transmission, removing

1 article

• Engine/transmission, removing 2

Removing the transmission cable

1 article

• Removing the transmission cable 1

Cars with engine block heaters (option)

1 article

• Cars with engine block heaters (option)

Separating the fuel line

1 article

• Separating the fuel line 1

Removing the air conditioning aggregate

1 article

• Removing the air conditioning aggregate

Exposing the air conditioning (A/C) compressor

1 article

• Exposing the air conditioning (A/C) compressor

Separating the steering shaft

1 article

• Separating the steering shaft

Removing the three-way catalytic converter (TWC) (all-wheel drive (AWD) only)

1 article

• Removing the three-way catalytic converter (TWC) (all-wheel drive (AWD) only)

Removing the propeller shaft from the transmission and drive distribution box (all-wheel drive (AWD) only)

1 article

• Removing the propeller shaft from the transmission and drive distribution box (all-wheel drive (AWD) only) 1

Engine/transmission, removing/installing

1 article

• Engine/transmission, removing/installing 10

Reinstalling the engine and transmission

1 article

• Reinstalling the engine and transmission 4

Installing the engine and transmission unit

1 article

• Installing the engine and transmission unit

Connecting fuel lines

1 article

• Connecting fuel lines

Installing the propeller shaft

1 article

• Installing the propeller shaft

Installing the three-way catalytic converter (TWC)

1 article

• Installing the three-way catalytic converter (TWC) 1

Installing the air conditioning (A/C) compressor

1 article

• Installing the air conditioning (A/C) compressor

Installing the connector

1 article

• Installing the connector 3

Removing the three-way catalytic converter (TWC)

1 article

• Removing the three-way catalytic converter (TWC)

Removing the propeller shaft

1 article

• Removing the propeller shaft

Lowering the engine and transmission

1 article

• Lowering the engine and transmission 1

Removing the engine coolant heater (option)

1 article

• Removing the engine coolant heater (option)

Engine block, installing components

1 article

• Engine block, installing components

Installing the components for the engine pad

1 article

• Installing the components for the engine pad 1

Installing the flywheel and carrier plate

1 article

• Installing the flywheel and carrier plate

Oil pan, replacing

1 article

• Oil pan, replacing 1

Removing the oil pan

1 article

• Removing the oil pan 2

Removing the oil sump

1 article

• Removing the oil sump

Installing the oil pan

1 article

• Installing the oil pan

Auxiliaries belt / belt tensioner, replacing

1 article

• Auxiliaries belt / belt tensioner, replacing 2

Installing the auxiliaries belt

1 article

• Installing the auxiliaries belt

Camshaft seal/variable valve timing (VVT) unit, replacing

1 article

• Camshaft seal/variable valve timing (VVT) unit, replacing

Disconnecting the battery lead

1 article

• Disconnecting the battery lead 1

Aligning the engine according to the marking

1 article

• Aligning the engine according to the marking

Removing the timing gear pulley with the variable valve timing unit

1 article

• Removing the timing gear pulley with the variable valve timing unit 1

Installing the battery lead

1 article

• Installing the battery lead 1

Timing belt, replacing

1 article

• Timing belt, replacing

Position the engine according to the marking

1 article

• Position the engine according to the marking 2

Installing the timing belt

1 article

• Installing the timing belt

Tighten the timing belt

1 article

• Tighten the timing belt

For engine serial no. up to 3188688

1 article

• For engine serial no. up to 3188688

For engine serial no. from 3188689

1 article

• For engine serial no. from 3188689

Reinstall

1 article

• Reinstall

Checking work

1 article

• Checking work 2

Applies to B5244Sx model years 1999-2001

1 article

• Applies to B5244Sx model years 1999-2001 5

Applies to all: Installing VVT-control valve

1 article

• Applies to all: Installing VVT-control valve 3

Replacing the rear camshaft seal

1 article

• Replacing the rear camshaft seal

Removing the variable valve timing (VVT) control valve

1 article

• Removing the variable valve timing (VVT) control valve

Variable valve timing solenoid, replacing

1 article

• Variable valve timing solenoid, replacing

Removing the camshaft seal

1 article

• Removing the camshaft seal

Replacing the camshaft seal

1 article

• Replacing the camshaft seal 3

Rear camshaft seal

1 article

• Rear camshaft seal

Removing the camshaft belt

1 article

• Removing the camshaft belt

Checking the tension pulley and idler pulley

1 article

• Checking the tension pulley and idler pulley

Installing the camshaft belt

1 article

• Installing the camshaft belt 3

Replacing the belt tensioner

1 article

• Replacing the belt tensioner 2

Replacing the rear seal

1 article

• Replacing the rear seal 1

Removing the front camshaft seal

1 article

• Removing the front camshaft seal 1

Installing the variable valve timing (VVT) unit on the exhaust camshaft

1 article

• Installing the variable valve timing (VVT) unit on the exhaust camshaft

Installing the variable valve timing (VVT) unit on the intake camshaft

1 article

• Installing the variable valve timing (VVT) unit on the intake camshaft

Adjusting the timing belt

1 article

• Adjusting the timing belt 1

Removing the rear camshaft seal

1 article

• Removing the rear camshaft seal