Manual sections

Wiring diagrams

• Abbreviations
• Accessory Drive Belts
• Anti-Lock/traction Control
• Automatic HVAC System
• Automatic Trans
• Axle Shafts
• Basic Trouble Shooting
• Blowers, Superchargers & Turbochargers
• Body and Frame - Dismantling Work Prior to Repair: Removal & Installation
• Body Electrical
• Brakes
• Cabin Air Filter
• Charging System
• Check Lists
• Climate Control System - Removal and Installation
• Clutches Manual & Hydraulic
• Collision/avoidance
• Cooling Fan
• Cooling System (Mechanical)
• Cruise Control Systems
• Diagnostic Connector Locations
• Door Locks & Anti-Theft Systems
• Doors and Lids - Removal and Installation
• Drive Cycles
• Driveline/axles
• Driveshaft & Universal Joints
• DTC Index
• Electrical Component Locations
• Electronic Steering
• Electronics - Design and Function - 1 of 4
• Electronics - Design and Function - 2 of 4
• Electronics - Design and Function - 3 of 4
• Electronics - Design and Function - 4 of 4
• Emission Applications
• Engine
• Engine Block Heater and Fuel-Driven Heater - Installation
• Engine Control Systems
• Engine Performance
• Entertainment Systems
• Exhaust
• Exterior Body Panels
• Exterior Lights
• Exterior/interior Trim
• Frames, Subframes & Crossmembers
• Fuel System
• Fuses & Circuit Breakers
• Gauges & Instrument Panels
• Headlights
• Heated Glass/defoggers
• Heater
• Hoist/jack
• Identification
• Ignition System
• Interior Equipment - Removal and Installation
• Lubrication System
• Manual & Power Steering
• Manual Trans
• Mechanical
• Mechanical - Hydraulic
• Media, Communication, and Navigation - Installation - 1 of 2
• Media, Communication, and Navigation - Installation - 2 of 2
• Metric Conversions
• Mirrors
• Mode 6
• Navigation System
• Oem General Information
• Parking Assistance Sensors - Removal and Installation: Overview
• Parking Brake System
• Passive Restraints
• Procedures
• Reset Procedures
• Seats
• Seats, Interior Trim Panels, and Upholstery - Removal and Installation
• Specifications
• Starter
• Steering
• Steering Column
• Steering Column Switches
• Sun Roof/t-Top/convertible Top
• Suspension Front
• Suspension Rear
• Testing & Diagnostics
• Towing Systems
• Traction Control Disable
• Transmission
• Transmission - Removal and Installation
• Wheel & Tire System
• Wheel Alignment
• Wheel Hubs
• Windows
• Wiper/washer Systems

Repair manual

Climate Control System - Removal and Installation Volvo C70 II

Step-by-step instructions on "Climate Control System - Removal and Installation" for Volvo C70 II (2005–2009). Pick an article — removal, installation, adjustment and diagnostics with illustrations.

139subsections

139articles

100illustrations

DRIVER SIDE REGISTER

1 article

• DRIVER SIDE REGISTER 1

TRANSFERRING COMPONENTS

1 article

• TRANSFERRING COMPONENTS

INSTALLING THE CENTER VENTILATION VENT

1 article

• INSTALLING THE CENTER VENTILATION VENT 1

INSTALLING OUTER VENTILATION VENTS

1 article

• INSTALLING OUTER VENTILATION VENTS

POLLEN FILTER CLIMATE CONTROL SYSTEM

1 article

• POLLEN FILTER CLIMATE CONTROL SYSTEM

REMOVING THE ACCELERATOR PEDAL (AP)

1 article

• REMOVING THE ACCELERATOR PEDAL (AP) 7

VENTILATION DUCT FOOT SPACE REAR

1 article

• VENTILATION DUCT FOOT SPACE REAR 2

INSTALLING THE AIR DISTRIBUTION UNIT IN THE DASHBOARD

1 article

• INSTALLING THE AIR DISTRIBUTION UNIT IN THE DASHBOARD 1

INSTALLING AIR DUCT OUTER VENT

1 article

• INSTALLING AIR DUCT OUTER VENT

REMOVING AIR DUCT FRONT FLOOR

1 article

• REMOVING AIR DUCT FRONT FLOOR

INSTALLING AIR DUCT FRONT FLOOR

1 article

• INSTALLING AIR DUCT FRONT FLOOR 1

INSTALLING CENTER AIR DUCT TO FLOOR REAR PASSENGER COMPARTMENT

1 article

• INSTALLING CENTER AIR DUCT TO FLOOR REAR PASSENGER COMPARTMENT 1

INSTALLING FRONT AIR DUCT TO FLOOR REAR PASSENGER COMPARTMENT

1 article

• INSTALLING FRONT AIR DUCT TO FLOOR REAR PASSENGER COMPARTMENT

COOLANT PIPE FUEL-POWERED PREHEATER

1 article

• COOLANT PIPE FUEL-POWERED PREHEATER

REPLACING PIPE COUPLINGS

1 article

• REPLACING PIPE COUPLINGS 3

FAN MOTOR FUEL-POWERED PREHEATER

1 article

• FAN MOTOR FUEL-POWERED PREHEATER

REMOVING COMPONENTS

1 article

• REMOVING COMPONENTS 4

TRANSFERRING THE GLOW PLUG, PRESSURE EQUALIZER AND FLAME TRAP

1 article

• TRANSFERRING THE GLOW PLUG, PRESSURE EQUALIZER AND FLAME TRAP 1

FLAME SENSOR FUEL-POWERED PREHEATER

1 article

• FLAME SENSOR FUEL-POWERED PREHEATER

REMOVING THE COMBUSTION PREHEATER MODULE (CPM)

1 article

• REMOVING THE COMBUSTION PREHEATER MODULE (CPM)

REMOVING THE FLAME SENSOR

1 article

• REMOVING THE FLAME SENSOR 1

INSTALLING THE FLAME SENSOR

1 article

• INSTALLING THE FLAME SENSOR

FUEL FIRED BOOSTER HEATER

1 article

• FUEL FIRED BOOSTER HEATER 5

TRANSFERRING ENGINE COOLANT HOSES

1 article

• TRANSFERRING ENGINE COOLANT HOSES

INSTALLING THE ENGINE COOLANT HEATER

1 article

• INSTALLING THE ENGINE COOLANT HEATER

FUEL FIRED BOOSTER HEATER CONTROL UNIT

1 article

• FUEL FIRED BOOSTER HEATER CONTROL UNIT

REMOVING THE ENGINE COOLANT HEATER

1 article

• REMOVING THE ENGINE COOLANT HEATER

IMPORTANT INFORMATION

1 article

• IMPORTANT INFORMATION 1

INSTALLING THE COMBUSTION PREHEATER MODULE (CPM)

1 article

• INSTALLING THE COMBUSTION PREHEATER MODULE (CPM)

FINAL CHECK OF THE ENGINE COOLANT HEATER

1 article

• FINAL CHECK OF THE ENGINE COOLANT HEATER

FUEL FIRED BOOSTER HEATER EXHAUST PIPE

1 article

• FUEL FIRED BOOSTER HEATER EXHAUST PIPE 3

INSTALLING THE EXHAUST PIPE FOR THE ENGINE COOLANT HEATER

1 article

• INSTALLING THE EXHAUST PIPE FOR THE ENGINE COOLANT HEATER

FUEL FIRED BOOSTER HEATER WATER-IN-FUEL SENSOR

1 article

• FUEL FIRED BOOSTER HEATER WATER-IN-FUEL SENSOR 1

INSTALLING THE OVERHEAT PROTECTION THERMOSTAT / ENGINE COOLANT TEMPERATURE SENSOR

1 article

• INSTALLING THE OVERHEAT PROTECTION THERMOSTAT / ENGINE COOLANT TEMPERATURE SENSOR

FUEL LINE FUEL-POWERED PREHEATER

1 article

• FUEL LINE FUEL-POWERED PREHEATER

REMOVING THE FRONT FUEL LINE

1 article

• REMOVING THE FRONT FUEL LINE 1

INSTALLING THE FRONT FUEL LINE

1 article

• INSTALLING THE FRONT FUEL LINE

REMOVING THE CENTER FUEL LINE

1 article

• REMOVING THE CENTER FUEL LINE

INSTALLING THE CENTER FUEL LINE

1 article

• INSTALLING THE CENTER FUEL LINE 2

INSTALLING THE SUCTION PIPE

1 article

• INSTALLING THE SUCTION PIPE

FUEL TANK

1 article

• FUEL TANK

PREPARATORY WORK

1 article

• PREPARATORY WORK

REMOVING THE EXHAUST SYSTEM

1 article

• REMOVING THE EXHAUST SYSTEM 4

REMOVING THE FUEL PUMP (FP)

1 article

• REMOVING THE FUEL PUMP (FP)

INSTALLING THE FUEL PUMP (FP)

1 article

• INSTALLING THE FUEL PUMP (FP)

INSTALLING THE FUEL TANK

1 article

• INSTALLING THE FUEL TANK

INSTALLING THE HOSE CONNECTORS

1 article

• INSTALLING THE HOSE CONNECTORS

INSTALLING THE CARBON FILTER CONTAINER

1 article

• INSTALLING THE CARBON FILTER CONTAINER

INSTALLING THE HEAT DEFLECTOR PLATE

1 article

• INSTALLING THE HEAT DEFLECTOR PLATE

INSTALLING THE EXHAUST SYSTEM

1 article

• INSTALLING THE EXHAUST SYSTEM

FINISHING

1 article

• FINISHING

FUEL PUMP AND LEVEL SENSOR UNIT

1 article

• FUEL PUMP AND LEVEL SENSOR UNIT

REMOVING

1 article

• REMOVING 2

INSTALLING

1 article

• INSTALLING 1

FUEL PUMP, FUEL-DRIVEN AUXILIARY HEATER

1 article

• FUEL PUMP, FUEL-DRIVEN AUXILIARY HEATER 2

GLOW PLUG FUEL-POWERED PREHEATER

1 article

• GLOW PLUG FUEL-POWERED PREHEATER

REMOVING THE GLOW PLUG/PRESSURE EQUALIZER

1 article

• REMOVING THE GLOW PLUG/PRESSURE EQUALIZER

INSTALLING THE GLOW PLUG / PRESSURE EQUALIZER

1 article

• INSTALLING THE GLOW PLUG / PRESSURE EQUALIZER

WATER PUMP, FUEL-DRIVEN AUXILIARY HEATER

1 article

• WATER PUMP, FUEL-DRIVEN AUXILIARY HEATER

ADJUSTING AND CHECKING

1 article

• ADJUSTING AND CHECKING

INSTALLING THE COVER

1 article

• INSTALLING THE COVER

ACTUATOR DAMPER, CLIMATE CONTROL SYSTEM DRIVER'S SIDE

1 article

• ACTUATOR DAMPER, CLIMATE CONTROL SYSTEM DRIVER'S SIDE

REMOVING THE DASHBOARD

1 article

• REMOVING THE DASHBOARD 1

INSTALLING THE DAMPER MOTOR MODULE (DMM) FOR TEMPERATURE

1 article

• INSTALLING THE DAMPER MOTOR MODULE (DMM) FOR TEMPERATURE

ACTUATOR, MIXER DAMPER

1 article

• ACTUATOR, MIXER DAMPER 1

INSTALLING THE DAMPER MOTOR MODULE (DMM) FOR AIR DISTRIBUTION

1 article

• INSTALLING THE DAMPER MOTOR MODULE (DMM) FOR AIR DISTRIBUTION

ACTUATOR RECIRCULATION

1 article

• ACTUATOR RECIRCULATION

REMOVING THE GLOVE COMPARTMENT

1 article

• REMOVING THE GLOVE COMPARTMENT 1

INSTALLING THE DAMPER MOTOR MODULE (DMM) FOR RECIRCULATION

1 article

• INSTALLING THE DAMPER MOTOR MODULE (DMM) FOR RECIRCULATION

ACTUATOR REGISTER DUCT FOOTWELL

1 article

• ACTUATOR REGISTER DUCT FOOTWELL 1

INSTALLING THE DAMPER MOTOR MODULE (DMM) FOR THE DEFROSTER

1 article

• INSTALLING THE DAMPER MOTOR MODULE (DMM) FOR THE DEFROSTER

AIR QUALITY SENSOR (2006, 2007)

1 article

• AIR QUALITY SENSOR (2006, 2007) 2

INSTALLING THE AIR QUALITY SENSOR (AQS)

1 article

• INSTALLING THE AIR QUALITY SENSOR (AQS)

AIR QUALITY SENSOR, CHECKING

1 article

• AIR QUALITY SENSOR, CHECKING

CHECK

1 article

• CHECK 3

BLOWER MOTOR PASSENGER COMPARTMENT

1 article

• BLOWER MOTOR PASSENGER COMPARTMENT

IMPORTANT INFORMATION AND REMOVING COMPONENTS

1 article

• IMPORTANT INFORMATION AND REMOVING COMPONENTS 4

INSTALLING THE BLOWER FAN MOTOR

1 article

• INSTALLING THE BLOWER FAN MOTOR

CLIMATE UNITS

1 article

• CLIMATE UNITS

INSTALLING THE CLIMATE CONTROL UNIT

1 article

• INSTALLING THE CLIMATE CONTROL UNIT

INSTALLING COMPONENTS

1 article

• INSTALLING COMPONENTS

ACCUMULATOR

1 article

• ACCUMULATOR 3

ELECTRIC BOOSTER HEATER (2006, 2007)

1 article

• ELECTRIC BOOSTER HEATER (2006, 2007) 2

INSTALLING THE ELECTRICAL PREHEATER

1 article

• INSTALLING THE ELECTRICAL PREHEATER

ELECTRIC BOOSTER HEATER (2008-2012)

1 article

• ELECTRIC BOOSTER HEATER (2008-2012)

REMOVING THE ELECTRICAL PREHEATER

1 article

• REMOVING THE ELECTRICAL PREHEATER

HEAT EXCHANGER

1 article

• HEAT EXCHANGER 7

CHECKING THE FUNCTION AND LEAK TRACING

1 article

• CHECKING THE FUNCTION AND LEAK TRACING

TEMPERATURE SENSOR PASSENGER COMPARTMENT

1 article

• TEMPERATURE SENSOR PASSENGER COMPARTMENT 4

INSTALLING THE BLOWER FAN MOTOR PASSENGER COMPARTMENT TEMPERATURE SENSOR

1 article

• INSTALLING THE BLOWER FAN MOTOR PASSENGER COMPARTMENT TEMPERATURE SENSOR

CLIMATE CONTROL MODULE (CCM)

1 article

• CLIMATE CONTROL MODULE (CCM) 1

REMOVING CENTER CONSOLE

1 article

• REMOVING CENTER CONSOLE 5

INSTALLING THE CLIMATE CONTROL MODULE (CCM)

1 article

• INSTALLING THE CLIMATE CONTROL MODULE (CCM)

INSTALLING CENTER CONSOLE

1 article

• INSTALLING CENTER CONSOLE

ORDERING SOFTWARE

1 article

• ORDERING SOFTWARE

PROGRAMMING CUSTOMER PARAMETERS AND ADJUSTING DAMPER MOTORS

1 article

• PROGRAMMING CUSTOMER PARAMETERS AND ADJUSTING DAMPER MOTORS

REMOVING THE CLIMATE CONTROL MODULE (CCM)

1 article

• REMOVING THE CLIMATE CONTROL MODULE (CCM)

AC COMPRESSOR

1 article

• AC COMPRESSOR

INSTALLING THE COMPRESSOR

1 article

• INSTALLING THE COMPRESSOR

CHECKING THE PERFORMANCE

1 article

• CHECKING THE PERFORMANCE

CONDENSER

1 article

• CONDENSER

ACCUMULATOR (2006-2009)

1 article

• ACCUMULATOR (2006-2009)

REMOVING RECEIVER

1 article

• REMOVING RECEIVER

INSTALLING RECEIVER

1 article

• INSTALLING RECEIVER

INSTALLING COMPONENTS AND CHECKING PERFORMANCE

1 article

• INSTALLING COMPONENTS AND CHECKING PERFORMANCE

ACCUMULATOR (2010-2012)

1 article

• ACCUMULATOR (2010-2012)

CONDENSER (2006, 2011)

1 article

• CONDENSER (2006, 2011)

CONDENSER (2012)

1 article

• CONDENSER (2012)

REMOVING THE AIR CONDITIONING AGGREGATE

1 article

• REMOVING THE AIR CONDITIONING AGGREGATE 2

INSTALLING THE CONDENSER

1 article

• INSTALLING THE CONDENSER

INSTALLING THE COOLER UNIT

1 article

• INSTALLING THE COOLER UNIT

FILLING WITH REFRIGERANT AND LEAK TRACING

1 article

• FILLING WITH REFRIGERANT AND LEAK TRACING

ELECTROMAGNETIC CLUTCH

1 article

• ELECTROMAGNETIC CLUTCH

REFRIGERANT PIPE ACCUMULATOR TO COMPRESSOR

1 article

• REFRIGERANT PIPE ACCUMULATOR TO COMPRESSOR 10

EVAPORATOR

1 article

• EVAPORATOR 1

REMOVING THE EVAPORATOR

1 article

• REMOVING THE EVAPORATOR 2

INSTALLING THE EVAPORATOR

1 article

• INSTALLING THE EVAPORATOR 1

EXPANSION VALVE

1 article

• EXPANSION VALVE

INSTALLING THE EXPANSION VALVE (ORIFICE)

1 article

• INSTALLING THE EXPANSION VALVE (ORIFICE) 1

NEEDLE VALVE (2006-2009)

1 article

• NEEDLE VALVE (2006-2009)

INSTALLING THE NEEDLE VALVE / SERVICE VALVE

1 article

• INSTALLING THE NEEDLE VALVE / SERVICE VALVE

NEEDLE VALVE (2010-2012)

1 article

• NEEDLE VALVE (2010-2012)

REMOVING THE NEEDLE VALVE / SERVICE VALVE

1 article

• REMOVING THE NEEDLE VALVE / SERVICE VALVE

REMOVING THE SHIELD

1 article

• REMOVING THE SHIELD

REMOVING THE PIPE/HOSE BETWEEN THE COMPRESSOR AND THE CONDENSER

1 article

• REMOVING THE PIPE/HOSE BETWEEN THE COMPRESSOR AND THE CONDENSER

INSTALLING THE PIPE/HOSE BETWEEN THE COMPRESSOR AND THE CONDENSER

1 article

• INSTALLING THE PIPE/HOSE BETWEEN THE COMPRESSOR AND THE CONDENSER

REMOVING THE PIPE/HOSE BETWEEN THE COMPRESSOR AND THE RECEIVER

1 article

• REMOVING THE PIPE/HOSE BETWEEN THE COMPRESSOR AND THE RECEIVER

INSTALLING THE PIPE/HOSE BETWEEN THE COMPRESSOR AND THE RECEIVER

1 article

• INSTALLING THE PIPE/HOSE BETWEEN THE COMPRESSOR AND THE RECEIVER

INSTALLING SHIELD AND BUMPER COVER

1 article

• INSTALLING SHIELD AND BUMPER COVER

REFRIGERANT PIPE CONDENSER TO EXPANSION VALVE

1 article

• REFRIGERANT PIPE CONDENSER TO EXPANSION VALVE

REMOVING THE PIPE/HOSE BETWEEN THE EVAPORATOR AND THE RECEIVER

1 article

• REMOVING THE PIPE/HOSE BETWEEN THE EVAPORATOR AND THE RECEIVER

INSTALLING THE PIPE/HOSE BETWEEN THE EVAPORATOR AND THE RECEIVER

1 article

• INSTALLING THE PIPE/HOSE BETWEEN THE EVAPORATOR AND THE RECEIVER

REMOVING THE PIPE / HOSE BETWEEN THE CONDENSER AND THE EXPANSION VALVE

1 article

• REMOVING THE PIPE / HOSE BETWEEN THE CONDENSER AND THE EXPANSION VALVE

INSTALLING THE PIPE / HOSE BETWEEN THE CONDENSER AND THE EXPANSION VALVE

1 article

• INSTALLING THE PIPE / HOSE BETWEEN THE CONDENSER AND THE EXPANSION VALVE

REMOVING THE PIPE BETWEEN THE EXPANSION VALVE AND THE EVAPORATOR

1 article

• REMOVING THE PIPE BETWEEN THE EXPANSION VALVE AND THE EVAPORATOR

INSTALLING THE PIPE BETWEEN THE EXPANSION VALVE AND THE EVAPORATOR

1 article

• INSTALLING THE PIPE BETWEEN THE EXPANSION VALVE AND THE EVAPORATOR 2

TEMPERATURE SENSOR EVAPORATOR

1 article

• TEMPERATURE SENSOR EVAPORATOR

IGNITION OFF

1 article

• IGNITION OFF 1

INSTALLING THE TEMPERATURE SENSOR FOR THE EVAPORATOR

1 article

• INSTALLING THE TEMPERATURE SENSOR FOR THE EVAPORATOR