BUZZERS, RELAYS & TIMERS
| Component | Location |
|---|---|
| Back Up Lamp Relay (With A/T) (E45) | Fuse and relay box. (Схема №1) |
| Back-Up Lamp Relay (With M/T) (E226) | Fuse and relay box. (Схема №1) |
| Clutch Interlock Cancel Relay 1 (4.0L M/T) (E171) | Fuse and relay box. (Схема №1) |
| Clutch Interlock Cancel Relay 2 (4.0L M/T) (E166) | Fuse and relay box. (Схема №1) |
| Daytime Light Relay 1 (E103) | Fuse and relay box. (Схема №1) |
| Daytime Light Relay 2 (E104) | Fuse and relay box. (Схема №1) |
| Front Blower Motor Relay (Crew Cab) (E55) | Fuse and relay box. (Схема №1) |
| Front Blower Motor Relay (King Cab) (E54) | Fuse and relay box. (Схема №1) |
| Horn Relay | Left rear of engine compartment. (Схема №16) |
| Stop Lamp Relay (E12) | Fuse and relay box. (Схема №1) |
| Trailer Tow Relay 1 (E227) | Fuse and relay box. (Схема №1) |
| Trailer Tow Relay 2 (E228) | Fuse and relay box. (Схема №1) |
| Trailer Turn Relay LH (E164) | Fuse and relay box. (Схема №1) |
| Trailer Turn Relay RH (E186) | Fuse and relay box. (Схема №1) |
| Transfer High Shift Relay (With 4WD) (E46) | Fuse and relay box. (Схема №1) |
| Transfer Shift Low Relay (With 4WD) (E47) | Fuse and relay box. (Схема №1) |
| Transfer Shut Off Relay 1 (With 4WD) (E156) | Fuse and relay box. (Схема №1) |
| Transfer Shut Off Relay 2 (With 4WD) (E157) | Fuse and relay box. (Схема №1) |
BUZZERS, RELAYS & TIMERS LOCATION
CIRCUIT PROTECTION DEVICES
| Component | Location |
|---|---|
| Fuse And Fusible Link Box | Left rear of engine compartment. (Схема №16) |
| Fuse And Relay Box | Left rear of engine compartment. (Схема №16) |
| Fuse Block J/B (A) | Under right side of dash. (Схема №17) |
CIRCUIT PROTECTION DEVICES LOCATION
CONTROL UNITS
| Component | Location |
|---|---|
| ABS Actuator And Electric Unit (Control Unit) | Right rear of engine compartment. (Схема №16) |
| BCM (Body Control Module) (C) | Right side of steering column under dash. (Схема №17) |
| Electronic Control Module (ECM) | Left rear of engine compartment. (Схема №16) |
| Intelligent Power Distribution Module (IPDM) E/R | Left rear of engine compartment. (Схема №16) |
| Occupant Classification System Control Unit (8) | Under center of floor console. (Схема №15) |
| Transfer Control Unit (With 4WD) (E) | Left side of dash. (Схема №17) |
CONTROL UNITS LOCATION
MOTORS
| Component | Location |
|---|---|
| Electric Throttle Control Actuator (2.5L) (10) | On throttle body, top of engine. (Схема №23) |
| Electric Throttle Control Actuator (4.0L) (10) | On throttle body, top of engine. (Схема №27) |
| Front Wiper Motor | Rear of engine compartment. (Схема №16) |
| Power Valve Actuator | Right front of engine. (Схема №32) |
MOTORS LOCATION
SENDING UNITS & SENSORS
| Component | Location |
|---|---|
| A/F Sensor 1 (Bank 1) (4.0L) | Right rear of engine. (Схема №29) |
| A/F Sensor 1 (Bank 2) (4.0L) | Left rear of engine. (Схема №29) |
| Air Bag Diagnosis Sensor Unit (F) | Below back of floor console. (Схема №17) |
| Air Fuel Ratio (A/F) Sensor 1 (2.5L) | Rear of engine on exhaust system. (Схема №24) |
| Battery Current Sensor | Near battery. (Схема №24) |
| Belt Tension Sensor (5) | Right "B" pillar. (Схема №15) |
| Camshaft Position Sensor (PHASE) (Bank 1) (4.0L) | Right rear of engine. (Схема №25) |
| Camshaft Position Sensor (PHASE) (Bank 2) (4.0L) | Left rear of engine. (Схема №25) |
| Camshaft Position Sensor (2.5L) | Rear of engine. (Схема №21) |
| Crankshaft Position Sensor (2.5L) | Rear of engine. (Схема №24) |
| Crankshaft Position Sensor (4.0L) | Right rear of engine. (Схема №25) |
| Crash Zone Sensor (11) | Center of radiator support. (Схема №15) |
| Engine Coolant Temperature Sensor (2.5L) | Rear of engine. (Схема №21) |
| Engine Coolant Temperature Sensor (4.0L) | Right rear of engine. (Схема №26) |
| EVAP Control System Pressure Sensor (2) | On EVAP canister. (Схема №23) |
| Heated Oxygen Sensor 2 (Bank 1) (2WD) (4.0L) | Right side of transmission. (Схема №30) |
| Heated Oxygen Sensor 2 (Bank 1) (4WD) (4.0L) | Right side of transmission. (Схема №30) |
| Heated Oxygen Sensor 2 (Bank 2) (2WD) (4.0L) | Left side of transmission. (Схема №30) |
| Heated Oxygen Sensor 2 (Bank 2) (4WD) (4.0L) | Left side of transmission. (Схема №30) |
| Heated Oxygen Sensor 2 (2.5L) | After three way converter. (Схема №18) |
| Knock Sensors (Bank 1/Bank 2) (4.0L) | Under intake manifold. (Схема №31) |
| Knock Sensor (2.5L) | Right side of engine. (Схема №22) |
| LH Side Air Bag (Satellite) Sensor (If Equipped) (15) | Below left driver seat. (Схема №15) |
| Mass Air Flow/Intake Air Temperature Sensor (2.5L) | Front of engine. (Схема №24) |
| Mass Air Flow/Intake Air Temperature Sensor (4.0L) | Air intake tube near air filter box. (Схема №32) |
| Occupant Classification System Sensor (7) | Under passenger seat. (Схема №15) |
| Power Steering Pressure Sensor (2.5L) (6) | Front of engine. (Схема №23) |
| Power Steering Pressure Sensor (4.0L) (8) | Front of engine. (Схема №27) |
| Refrigerant Pressure Sensor | Front of engine compartment. (Схема №24) |
| RH Side Air Bag (Satellite) Sensor (If Equipped) (6) | Below right passenger seat. (Схема №15) |
SENDING UNITS & SENSORS LOCATION
SOLENOIDS & SOLENOID VALVES
| Component | Location |
|---|---|
| A/C Compressor Clutch (11) | At lower right front of engine. (Схема №1) |
| EVAP Canister Purge Volume Control Solenoid Valve (2.5L) (1) | Rear of engine compartment. (Схема №24) |
| EVAP Canister Purge Volume Control Solenoid Valve (4.0L) (1) | Left rear of engine compartment. (Схема №27) |
| EVAP Canister Vent Control Valve (1) | Under truck bed. (Схема №23) |
| Intake Valve Timing Control Solenoid Valve (Bank 1) (4.0L) (12) | Top right of engine. (Схема №28) |
| Intake Valve Timing Control Solenoid Valve (Bank 2) (4.0L) (13) | Top left of engine. (Схема №28) |
| Intake Valve Timing Control Solenoid Valve (2.5L) | Front of engine. (Схема №19) |
| VIAS Control Solenoid Valve | Top center of engine. (Схема №32) |
SOLENOIDS & SOLENOID VALVES LOCATION
SWITCHES
| Component | Location |
|---|---|
| Seat Belt Buckle Switch RH (3) | Right seat belt buckle. (Схема №15) |
SWITCHES LOCATION
MISCELLANEOUS
| Component | Location |
|---|---|
| Air Bag Warning Lamp (12) | Instrument cluster. (Схема №15) |
| Combination Meter (M24) (2) | Left side of dash. (Схема №2) |
| Drive Air Bag Module (14) | On steering wheel. (Схема №15) |
| Front LH Seat Belt Pre-Tensioner (16) | Left front "B" pillar. (Схема №15) |
| Front LH Side Air Bag Module (If Equipped) (17) | Driver seat back. (Схема №15) |
| Front Passenger Air Bag Module (10) | Right side of dash. (Схема №15) |
| Front Passenger Air Bag Off Indicator (9) | Center of dash. (Схема №15) |
| Front RH Seat Belt Pre-Tensioner (4) | Right front "B" pillar. (Схема №15) |
| Front RH Side Air Bag Module (If Equipped) (2) | Passenger seat back. (Схема №15) |
| Ignition Coils (With Power Transistors And Spark Plugs) (Bank 1) (4.0L) | Right side of engine. (Схема №32) |
| Ignition Coils (With Power Transistors And Spark Plugs) (Bank 2) (4.0L) | Left side of engine. (Схема №32) |
| Ignition Coils (With Power Transistors And Spark Plugs) (2.5) | Left side of engine. (Схема №24) |
| Immobilizer System Antenna Amplifier (With Immobilizer) (D) | On side of steering column. (Схема №17) |
| Injectors (Bank 1) (4.0L) | Right side of engine. (Схема №32) |
| Injectors (Bank 2) (4.0L) | Left side of engine. (Схема №32) |
| Injectors (2.5) | Left side of engine. (Схема №24) |
| Remote Keyless Entry Receiver (B) | Under upper right side of dash. (Схема №17) |
| Remote Keyless Entry Receiver (M120) (3) | Right side of dash. (Схема №2) |
| Side Curtain Air Bag Modules (If Equipped) (1) | Under headliner on left and right side of passenger compartment. (Схема №15) |
| Spiral Cable (13) | Under steering wheel. (Схема №15) |
| Tire Pressure Warning Check Connector (M123) (4) | Under left side of dash. (Схема №2) |
| TPMS Transmitter (5) | In respective tire. (Схема №2) |
MISCELLANEOUS LOCATION
CONNECTORS
| Component | Location |
|---|---|
| B6 (Crew Cab) (White, 12 Pin) | Under left rear seat. (Схема №41) |
| B16 (King Cab) (White, 8 Pin) | Left rear "C" pillar. (Схема №40) |
| B37 (Crew Cab) (White, 16 Pin) | Left front door sill. (Схема №41) |
| B37 (King Cab) (White, 8 Pin) | Under left front door sill. (Схема №40) |
| B40 (Crew Cab) (White, 8 Pin) | Left front kick panel. (Схема №41) |
| B40 (King Cab) (White, 8 Pin) | Left front kick panel. (Схема №40) |
| B78 (Crew Cab) (Yellow, 2 Pin) | Left front kick panel. (Схема №41) |
| B78 (King Cab) (Yellow, 2 Pin) | Under left front seat. (Схема №40) |
| B102 (Crew Cab) (White, 2 Pin) | Right front kick panel. (Схема №43) |
| B106 (Crew Cab) (White, 12 Pin) | Right "B" pillar. (Схема №43) |
| B107 (King Cab) (White, 8 Pin) | Right "C" pillar. (Схема №42) |
| B154 (Crew Cab) (White, 16 Pin) | Under right front seat. (Схема №43) |
| B157 (Crew Cab) (Yellow, 2 Pin) | Lower "A" pillar near dash. (Схема №43) |
| B162 (Crew Cab) (White, 12 Pin) | Under passenger seat. (Схема №43) |
| B162 (King Cab) (White, 12 Pin) | Right front kick panel. (Схема №42) |
| B163 (Crew Cab) (White, 16 Pin) | Right front kick panel. (Схема №43) |
| B200 (Crew Cab) (White, 16 Pin) | Under left front seat. (Схема №41) |
| B200 (King Cab) (White, 16 Pin) | Left front door sill. (Схема №40) |
| B303 (Crew Cab) (White, 16 Pin) | Under right front seat. (Схема №43) |
| B351 (Crew Cab) (White, 16 Pin) | Under right front seat. (Схема №43) |
| B351 (King Cab) (White, 16 Pin) | Under right front seat. (Схема №42) |
| B356 (Crew Cab) (White, 16 Pin) | Under right front seat. (Схема №43) |
| B1263 (King Cab) (White, 16 Pin) | Right front kick panel. (Схема №42) |
| B1366 (King Cab) (White, 16 Pin) | Right front kick panel. (Схема №42) |
| C14 (Gray, 4 Pin) | Rear of truck frame. (Схема №39) |
| C15 (Gray, 8 Pin) | Below center of truck bed. (Схема №39) |
| C51 (Gray, 8 Pin) | Left rear of truck frame. (Схема №39) |
| C52 (Black, 2 Pin) | Rear of truck frame. (Схема №39) |
| C115 (Gray, 4 Pin) | Rear of truck frame. (Схема №39) |
| C125 (Gray, 8 Pin) | Left rear of truck frame. (Схема №39) |
| C150 (Black, 2 Pin) | Left rear truck frame. (Схема №39) |
| C200 (Gray, 8 Pin) | Left rear of truck frame. (Схема №39) |
| D1 (White, 16 Pin) | Lower left "A" pillar. (Схема №45) |
| D2 (Brown, 12 Pin) | Lower Left "A" pillar. (Схема №45) |
| D101 (White, 12 Pin) | Lower right "A" pillar. (Схема №46) |
| D102 (White, 16 Pin) | Lower right "A" pillar. (Схема №46) |
| D201 (Crew Cab) (White, 12 Pin) | On door, near "B" pillar. (Схема №49) |
| D216 (King Cab) (White, 8 Pin) | Top of door, below window. (Схема №47) |
| D301 (Crew Cab) (White, 12 Pin) | On door, near "B" pillar. (Схема №50) |
| D302 (King Cab) (White, 8 Pin) | Top of door, below window. (Схема №48) |
| E2 (White, 16 Pin) | Right side of engine compartment. (Схема №34) |
| E5 (White, 24 Pin) | Right side of engine compartment. (Схема №34) |
| E10 (White, 6 Pin) | Passenger side of engine compartment. (Схема №35) |
| E19 (White, 16 Pin) | Right side of engine compartment. (Схема №34) |
| E26 (White, 16 Pin) | Passenger side of engine compartment. (Схема №35) |
| E29 (Yellow, 4 Pin) | Passenger side of engine compartment. (Схема №35) |
| E34 (White, 8 Pin) | Left side of engine compartment. (Схема №36) |
| E40 (Gray, 9 Pin) | Right side of engine compartment. (Схема №34) |
| E201 (Gray, 9 Pin) | Right side of engine compartment. (Схема №34) |
| E225 (White, 12 Pin) | Right side of engine compartment. (Схема №34) |
| F14 (2.5L) (White, 14 Pin) | Top of engine. (Схема №37) |
| F14 (4.0L) (White, 24 Pin) | Top of engine. (Схема №38) |
| F32 (2.5L) (White, 16 Pin) | Top of engine. (Схема №37) |
| F32 (4.0L) (White, 16 Pin) | Top of engine. (Схема №38) |
| F33 (2.5L) (White, 6 Pin) | Top of engine. (Схема №37) |
| F33 (4.0L) (White, 16 Pin) | Top of engine. (Схема №38) |
| F44 (2.5L) (Black, 6 Pin) | Top of engine. (Схема №37) |
| F44 (4.0L) (Gray, 4 Pin) | Top of engine. (Схема №38) |
| F201 (Gray, 4 Pin) | Top of engine. (Схема №38) |
| F210 (Black, 6 Pin) | Top of engine. (Схема №37) |
| F225 (Gray, 8 Pin) | Top of engine. (Схема №38) |
| F250 (Light Blue, 4 Pin) | Top of engine. (Схема №38) |
| M1 (White, 24 Pin) | Left side of dash. (Схема №33) |
| M6 (White, 16 Pin) | Left side of dash. (Схема №33) |
| M8 (Brown, 12 Pin) | Left side of dash. (Схема №33) |
| M9 (White, 16 Pin) | Left side of dash. (Схема №33) |
| M10 (Yellow, 4 Pin) | Left side of dash. (Схема №33) |
| M16 (White, 12 Pin) | Right side of dash. (Схема №33) |
| M17 (White, 16 Pin) | Right side of dash. (Схема №33) |
| M63 (White, 6 Pin) | Center console area of dash. (Схема №33) |
| M74 (White, 16 Pin) | Right side of dash. (Схема №33) |
| M75 (White, 12 Pin) | Right side of dash. (Схема №33) |
| M91 (White, 16 Pin) | Left side of dash. (Схема №33) |
| M204 (White, 6 Pin) | Below rear of floor console. (Схема №33) |
| R1 (Crew Cab) (White, 24 Pin) | Lower "A" pillar. (Схема №44) |
| 302 (Crew Cab) (White, 2 Pin) | Under right front seat. (Схема №43) |
CONNECTORS LOCATION
GROUNDS
| Component | Location |
|---|---|
| B7 | Under left seat. (Схема №11) |
| B19 | Left "B" pillar. (Схема №12) |
| B117 | Under right seat. (Схема №13) |
| B132 | Right "B" pillar. (Схема №14) |
| E9 | Left side of engine compartment. (Схема №20) |
| E14 | Left rear of engine compartment. (Схема №7) |
| E15 | Engine compartment. (Схема №20) |
| E24 | Engine compartment. (Схема №6) |
| E126 | Left side of engine compartment. (Схема №5) |
| E203 | Engine compartment. (Схема №8) |
| F10 (2.5L) | Engine compartment. (Схема №10) |
| F10 (4.0L) | Radiator support. (Схема №9) |
| F16 (2.5L) | Engine compartment. (Схема №10) |
| F16 (4.0L) | Radiator support. (Схема №9) |
| M57 | Above steering column. (Схема №3) |
| M61 | On right side of dash frame. (Схема №4) |
| M79 | On right side of dash frame. (Схема №4) |
GROUNDS LOCATION