Manual sections
Wiring diagrams- ABS 5.3
- ABS 5.3/TC/ESP
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-S
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Electrics
- Central Locking with Atws (Electronic)
- Check Control
- Clutch
- Clutch and Transmission
- Cng
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Ehps - Electrical Hydraulic Power Steering
- Electrical Equipment and Instruments
- Electrical Socket Front/ Rear
- Electrical Window Winders
- Electronic Cruise Control
- Electronic Traction Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bolted)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Info Display Ccrt 700
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- Multitimer
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Xenon Control Unit (Headlamp Range Control)
Repair manual
Fuel Injection Systems Opel Zafira A
Step-by-step instructions on "Fuel Injection Systems" for Opel Zafira A (1999–2005). Pick an article — removal, installation, adjustment and diagnostics with illustrations.
86articles
154illustrations
Articles in this section
86 articles- How to Remove and Install (Up to MY 03) the Cng Pressure Reducer 2
- How to Remove and Install the Cng Injectors 1
- How to Remove and Install (Up to MY 03) the Cng Low Pressure Line 2
- Engine Management System GMPT-E15 1
- Engine Management System GMPT-E15, Engine Compartment Overview 3
- Engine Management System GMPT-E15, Engine Control Unit 1
- Engine Management System GMPT-E15, Intake Pipe Pressure Sensor 1
- How to Remove and Install the Voltage Transformer - Cng Engine Control Unit 1
- Engine Management System GMPT-E15, Electronic Accelerator Pedal
- How to Remove and Install the Switch for Gas/petrol Operation 1
- Engine Management System GMPT-E15, Throttle Valve Module (Electronic Accelerator Pedal) 1
- Engine Management System GMPT-E15, Accelerator Pedal Module (Electronic Accelerator Pedal) 1
- Engine Management System GMPT-E15, Emergency Operation Modes (Electronic Accelerator Pedal)
- Engine Management System GMPT-E15, Injectors 1
- How to Remove and Install (From MY 04) the Cng Pressure Reducer 1
- Engine Management System GMPT-E15, Crankshaft Pulse Pick-Up 1
- How to Remove and Install (From MY 04) the Cng Low Pressure Line 2
- Engine Management System GMPT-E15, Oxygen Sensor 1
- Engine Management System GMPT-E15, Multec Block Diagram 2
- Install Cng Pressure Reduction Conversion Kit (Landi Renzo). 26
- Throttle Valve Module (Electronic Accelerator Pedal) - All Vehicle Types 2
- Accelerator Pedal Module (Electronic Accelerator Pedal) - All Vehicle Types 1
- Emergency Operation Modes (Electronic Accelerator Pedal) - All Vehicle Types
- Engine Runs Poorly, Vibrates or Stalls When Driving Off
- Engine - Stalling
- Coolant Temperature Sensor - Wiring Harness Connector Poor Contact 6
- Engine - Lack of Power, Misfire, MIL On, Trouble Codes P035X And/or P030X Stored in ECU
- Rear Crankshaft Seal Ring - Oil Leakage
- Wiring Harness Connector Air Mass Meter - Marten Bite Attacks 2
- Engine - Power Decrease Under Load
- Cylinder Head - Programming Option "Old" and "New" Cylinder Head
- Throttle Body - Idle Fluctuations Due to Dirt Contamination 4
- Engine ECU for Z20LET-Engine as of MY 03 1/2
- Z18XE Engine - Jerking at Partial Load and P1555 (All Symptom Bytes) Stored in ECU
- Z18XE EOBD Exhaust Emission Test - Not Passed
- Magnetic Coil Cng Bottle Valve - Electrical Resistance to Low / Short Circuit
- Cng Injection Nozzles - Leakage Rate Too High
- Magnetic Coil Cng Bottle Valve - Electrical Resistance Too High
- Engine Z22SE, Z22YH (High Oil Consumption)
- Engine Control Unit - Failure Code P1600 Is Set
- Engine Control Unit - Failure Code P1679 Is Set (Extended Operation in Cng Mode)
- Engine Z16XE - P0120(8) Throttle Position Sensor Failure
- Engine Z16XE - P0335(0) Crankshaft Sensor Failure
- Engine Y20DTH / Y22DTR - Electrical EGR Valve Malfunction, DTC P400(C) And/or P0400(9) Is Set
- Engine Z22SE - High Oil Consumption
- Engine Z20LET - Turbocharger Wastgate Regulation Valve Defekt
- Engine Y20DTH Turbo Charger, Waste Gate (Trouble Code P0234, Positive Deviation Set)
- Engine Z16YNG, Cng Injector (Failure Code P300, P301-P304 (Multible Misfire / Misfire Cylinder 1-4))
- How to Replace (Z 22 SE) the Knock Sensor 4
- How to Replace (Z 22 SE) the Crankshaft Pulse Pick-Up 4
- How to Replace (Z 22 SE) the Throttle Body 4
- How to Replace (Z 22 SE) the Intake Pipe Pressure Sensor 5
- How to Replace (1 or All Injectors) (Z 22 SE) the Injectors 11
- How to Check (Z 22 SE) the Fuel Pressure 2
- How to Replace (Z 22 SE) the Fuel Pressure Regulator 3
- How to Remove and Install (Z 22 SE) the Fuel Pump Relay 2
- How to Replace (Pre-Converter Oxygen Sensor) (Z 22 SE) the Mixture Regulating Oxygen Sensor 4
- How to Replace (Post-Converter Oxygen Sensor) (Z 22 SE) the Catalytic Converter Control Oxygen Sensor 4
- How to Replace (Z 22 SE) the Dis Ignition Module 2
- How to Replace (Z 22 SE) the Intake Air Temperature Sensor 2
- How to Replace (Z 22 SE) the Coolant Temperature Sensor 4
- How to Remove and Install (Z 22 SE) the Engine Control Unit 3
- How to Replace (Z 22 SE) the Tank Vent Valve 1
- How to Replace (Z 22 SE) the Accelerator Pedal 2
- Engine Z20LET - Trouble Code P1106 Stored in ECU 2
- Engine X18XE1 - Engine Stalls, Trouble Code P0100 And/or P0110 Set 6
- How to Remove and Install the Ignition Module 1
- How to Remove and Install the Intake Manifold Pressure Sensor 1
- How to Remove and Install the Throttle Body 1
- How to Remove and Install the Hot Film Mass Air Flow Meter 1
- How to Remove and Install the Injectors 2
- Engine Z22SE, ECU (Trouble Code P1614 (Wrong Transponder Key) Stored in ECU)
- How to Check the Fuel Pressure 1
- How to Remove and Install the Fuel Pressure Regulator 1
- How to Remove and Install the Fuel Pump Relay 1
- How to Remove and Install the Crankshaft Pulse Pick-Up 1
- How to Remove and Install the Camshaft Sensor 1
- How to Remove and Install the Knock Sensor 1
- How to Remove and Install the Coolant Temperature Sensor 1
- How to Remove and Install the Engine Control Unit 1
- How to Remove and Install the Tank Vent Valve 1
- Replace Charge Pressure Control Solenoid Valve 1
- How to Replace the Control Unit, Dis Ignition Module 2
- How to Remove and Install (Y 20 DTH from MY 2003 the Atmospheric Pressure Sensor (Y 22 DTR from MY 2003)) 2
- Replace Solenoid Valve - Throttle Valve 1
- Replace Throttle Valve Potentiometer 4