BUZZERS, RELAYS & TIMERS
| Component | Location |
|---|---|
| A/C Clutch Relay | In battery junction box. |
| Accessory Delay Relay | In central junction box. |
| Accessory Relay | In central junction box. |
| Blower Motor Relay | Behind lower left center of dash. |
| Brake Shift Interlock Relay | Behind left side of dash, near steering column. |
| Daytime Running Lights (DRL) Relay | Behind lower left end of dash. (Схема №6) |
| Foglight Relay | In battery junction box. |
| Four Wheel Drive Relay | On left side of cargo compartment, behind trim. |
| Fuel Pump Relay | In battery junction box. |
| Headlight Relay | In battery junction box. |
| High Speed Fan Control Relay 1 | In battery junction box. |
| High Speed Fan Control Relay 2 | In battery junction box. |
| Horn Relay | In central junction box. |
| Ignition Relay | In central junction box. |
| Low Speed Fan Control Relay | In battery junction box. |
| Medium Speed Fan Control Relay (2.0L) | In battery junction box. |
| Medium Speed Fan Control Relay (3.0L) | On lower left front of engine compartment, near headlight. (Схема №4) |
| Park Light Relay | In central junction box. |
| PCM Power Relay | In battery junction box. |
| Rear Window Defrost Relay | In battery junction box. |
| Rear Wiper Relay | In central junction box. |
| Starter Relay | In battery junction box. |
BUZZERS, RELAYS & TIMERS LOCATION
CIRCUIT PROTECTION DEVICES
| Component | Location |
|---|---|
| A/C Compressor Clutch Diode | In battery junction box. |
| Battery Junction Box (BJB) | On left front corner of engine compartment. (Схема №4) |
| Brake Shift Interlock Diode | Behind left side of dash, near steering column. |
| Central Junction Box (CJB) | Below left end of dash. (Схема №6) |
| PCM Power Diode | In central junction box. |
| Starter Relay Diode | In battery junction box. |
CIRCUIT PROTECTION DEVICES LOCATION
CONTROL UNITS
| Component | Location |
|---|---|
| ABS Control Module | On left rear side of engine compartment. (Схема №3) |
| Daytime Running Lights (DRL) Module | Behind lower left end of dash. (Схема №6) |
| Electronic Flasher Module | Behind lower left end of dash. |
| Generic Electronic Module (GEM) | Behind lower center of dash. |
| Passive Anti-Theft Transceiver | Behind lower left side of dash, near steering column. |
| Powertrain Control Module (PCM) | In recess on upper center of firewall. |
| Restraints Control Module (RCM) | Beneath lower center of dash, on transmission tunnel. (Схема №5) |
CONTROL UNITS LOCATION
MOTORS
| Component | Location |
|---|---|
| Engine Cooling Fan Motor 1 | On left side of engine compartment, behind radiator. |
| Engine Cooling Fan Motor 2 | On right side of engine compartment, behind radiator. |
| Front Blower Motor | Behind right side of dash. |
| Fuel Tank Unit | Beneath left rear of vehicle, in fuel tank. |
| Rear Window Washer Pump Motor | On right front of engine compartment, below reservoir. |
| Rear Wiper Motor Assembly | On center of liftgate. |
| Roof Opening Panel Motor Assembly | At front center of roof, behind trim. |
| Speed Control Servo | On right side of engine compartment. |
| Windshield Washer Pump Motor | On right front of engine compartment, below reservoir. |
| Windshield Wiper Motor | On left rear of engine compartment, beneath windshield. |
MOTORS LOCATION
SENDING UNITS & SENSORS
| Component | Location |
|---|---|
| Camshaft Position (CMP) Sensor (2.0L) | On right rear of cylinder head. (Схема №1) |
| Camshaft Position (CMP) Sensor (3.0L) | On front of left cylinder head. |
| Crankshaft Position (CKP) Sensor (2.0L) | On lower left side of engine block. |
| Crankshaft Position (CKP) Sensor (3.0L) | On front of engine block. |
| Cylinder Head Temperature (CHT) Sensor | On right front of cylinder head. |
| Differential Pressure Feedback EGR (DPFE) Sensor (2.0L) | On rear of engine. |
| Differential Pressure Feedback EGR (DPFE) Sensor (3.0L) | On right rear of engine. |
| Engine Coolant Temperature (ECT) Sensor (2.0L) | On right front of cylinder head. (Схема №1) |
| Engine Coolant Temperature (ECT) Sensor (3.0L) | On rear of right cylinder head. (Схема №2) |
| Fuel Tank Pressure Transducer Sensor | Beneath left rear of vehicle. |
| Fuel Tank Unit | Beneath left rear of vehicle, in fuel tank. |
| Knock Sensor (2.0L) | On right side of engine block, behind intake manifold. (Схема №1) |
| Knock Sensor (3.0L) | On right side of engine. |
| Mass Airflow (MAF) Sensor (2.0L) | Near rear of cylinder head, in air intake duct. |
| Mass Airflow (MAF) Sensor (3.0L) | On left side of engine compartment, in air intake duct. |
| Output Shaft Speed Sensor (OSS) | On right rear of transmission, near left axle flange. |
| Side Air Bag Sensor (2) | At base of respective "B" pillar. |
| Throttle Position (TP) Sensor (2.0L) | On throttle body. (Схема №1) |
| Throttle Position (TP) Sensor (3.0L) | On throttle body. (Схема №2) |
| Transmission Range (TR) Sensor | On left side of transmission. |
| Turbine Shaft Speed (TSS) Sensor | On right rear of transmission. |
| Vehicle Speed Sensor (VSS) (M/T) | On right side of transmission. |
| Wheel Speed Sensor (4) | On respective wheel hub assembly. |
SENDING UNITS & SENSORS LOCATION
SOLENOIDS & SOLENOID VALVES
| Component | Location |
|---|---|
| Brake Shift Interlock | Behind left side of dash, near steering column. |
| Differential Lock Solenoid | Under center rear of vehicle. |
| EGR Vacuum Regulator Solenoid Valve (2.0L) | On right side of engine, near throttle body. (Схема №1) |
| EGR Vacuum Regulator Solenoid Valve (3.0L) | On right rear of intake manifold. |
| EVAP Canister Purge Valve | On left side of engine compartment. (Схема №3) |
| EVAP Canister Vent Control Solenoid | Beneath left rear of vehicle. |
| Idle Air Control (IAC) Valve (2.0L) | On right side of engine, attached to intake manifold. |
| Idle Air Control (IAC) Valve (3.0L) | Below throttle body, on center of engine. (Схема №2) |
SOLENOIDS & SOLENOID VALVES LOCATION
SWITCHES
| Component | Location |
|---|---|
| A/C Clutch Cycling Pressure Switch | On right side of engine compartment, near strut tower. |
| Anti-Theft Hood Switch | On right end of radiator support. |
| Brake Fluid Level Switch | On brake master cylinder fluid reservoir. (Схема №3) |
| Brake Pedal Position Switch | On bracket, above brake pedal. (Схема №6) |
| Clutch Cut-Off Switch | On bracket, above clutch pedal. (Схема №6) |
| Clutch Switch | On bracket, above clutch pedal. (Схема №6) |
| Deactivator Switch | On bracket, above brake pedal. (Схема №6) |
| Dual Pressure Switch | On lower right front of engine compartment. |
| Inertia Fuel Shutoff (IFS) Switch | At base of right door pillar, near kick panel. (Схема №5) |
| Liftgate Ajar Switch | On top center of liftgate. |
| Low Coolant Level Switch | On right side of engine compartment, on coolant reservoir. |
| Oil Pressure Switch (2.0L) | On lower right front of engine block. (Схема №1) |
| Oil Pressure Switch (3.0L) | On left front of engine. |
| Park Brake Switch | At base of park brake lever. |
| Power Steering Pressure Switch | On left front of engine. |
| Reversing Lights Switch (M/T) | On top of transmission. |
| Safety Belt Switch | At base of left "B" pillar. |
SWITCHES LOCATION
MISCELLANEOUS
| Component | Location |
|---|---|
| ABS Test Connector | On left side of engine compartment, near strut tower. (Схема №3) |
| Data Link Connector (DLC) | On lower left side of dash. |
| Engine Cooling Fan Resistor | On lower left side of engine compartment. (Схема №4) |
| Front Blower Motor Resistor Assembly | Behind right side of dash. |
| Ignition Transformer Capacitor 1 (2.0L) | On rear of cylinder head. (Схема №1) |
| Ignition Transformer Capacitor 1 (3.0L) | On right front of engine. (Схема №2) |
| Ignition Transformer Capacitor 2 (3.0L) | On left front of engine. |
| Power Point (Front) | Behind center of dash. |
| Power Point (Rear) | On left side of cargo compartment. |
| Seat Belt Tensioner (2) | Beneath respective front seat, near transmission tunnel. |
| Subwoofer Amplifier | On right side of cargo compartment, behind trim. |
| Transmission Hardware Unit | Inside of left side of transmission. |
MISCELLANEOUS LOCATION
CONNECTORS
| Component | Location |
|---|---|
| C110 (Duratec) (16 Pin) | Right rear side of engine. (Схема №2) |
| C110 (ZETEC) (16 Pin) | Center rear of engine. |
| C133 (Duratec) (16 Pin) | Rear of engine. (Схема №2) |
| C134 (42 Pin) | Left front of engine compartment. (Схема №4) |
| C139 (1 Pin) | Left front of engine compartment. |
| C140 (2 Pin) | Right front of engine compartment. |
| C210 (22 Pin) | Behind center of dash. |
| C211 (20 Pin) | Left front of vehicle on floor. (Схема №5) |
| C212 (12 Pin) | Left rocker panel. (Схема №6) |
| C239 (4 Pin) | Right front of vehicle on floor. (Схема №5) |
| C248 (4 Pin) | Left rocker panel. (Схема №6) |
| C260 (34 Pin) | Left rocker panel. (Схема №6) |
| C263 (20 Pin) | Left rocker panel. (Схема №6) |
| C311 (14 Pin) | In front of right rear door. |
| C312 (28 Pin) | In front passenger's door. |
| C313 (14 Pin) | In front of left rear door. |
| C314 (28 Pin) | In driver's door. |
| C316 (2 Pin) | Left front of vehicle on floor. |
| C405 (4 Pin) | In right top of liftgate. |
| C406 (14 Pin) | In right center of liftgate. |
| C408 (14 Pin) | Rear center of vehicle. |
| C410 (4 Pin) | Left rear of vehicle. |
| C421 (2 Pin) | Left rear of vehicle on floor. |
| C423 (4 Pin) | Rear center of vehicle. |
| C919 (2 Pin) (W/Roof Opening Panel) | Front center of roof. |
CONNECTORS LOCATION
GROUNDS
| Component | Location |
|---|---|
| G100 | Center rear of engine compartment. |
| G101 (Duratec) | Top center of transmission. |
| G101 (ZETEC) | Top center of transmission. |
| G102 | Right front of engine compartment. |
| G103 | Right front of engine compartment. |
| G104 | Left front of engine compartment. (Схема №4) |
| G105 | Left front of engine compartment. (Схема №4) |
| G106 (Duratec) | Right front of engine. |
| G106 (ZETEC) | Right front of engine. |
| G107 (Duratec) | Right front of engine. |
| G107 (ZETEC) | Right front of engine. |
| G108 (Duratec) | Left rear of engine. (Схема №2) |
| G108 (ZETEC) | Left rear of engine. |
| G200 | Behind center of dash. |
| G201 | Behind center of dash. |
| G202 | Behind left side of dash. |
| G203 | Behind left side of dash. |
| G205 | Behind center of dash. |
| G300 | Left front floor. |
| G301 | Left front floor. |
| G400 | In liftgate. |
| G401 | In liftgate. |
| G402 | Left rear end of vehicle. |
| G403 | Left rear end of vehicle. |
| G404 | Right rear floor. |
GROUNDS LOCATION