Manual sections
Wiring diagrams- Battery
- Body
- Bodywork
- Braking
- Comfort and convenience
- Confort
- Current generation
- Dashboard
- Driver information
- Electrical harnesses
- Engine
- Front anti -roll bar
- Front axle
- Front doors
- Front seats
- Front section
- Front shock absorbers
- Front springs
- Gearbox assembly
- General points
- General points about the vehicle
- Instrument panel
- Instruments and controls
- Lighting - signalling
- Mechanical
- Other
- Power unit
- Pre-heating
- Protections and doors
- Re-assembling
- Rear axle
- Rear door trim
- Rear door windows
- Rear doors
- Rear seats
- Rear section
- Rear shock absorbers
- Rear springs
- Roof bow
- Roof panel
- Side structure
- Starting
- Steering
- Suspension
- Transmission
- Washing and wiping
Repair manual
Gearbox assembly Citroen Berlingo I facelift
Step-by-step instructions on "Gearbox assembly" for Citroen Berlingo I facelift (2002–2012). Pick an article — removal, installation, adjustment and diagnostics with illustrations.
Gearbox
- Presentation: tooling
- Presentation: recommended tools
- Tightening torques: BE4 manual gearbox
- Tightening torques: MA manual gearbox
- Tightening torques: engine/gearbox coupling
- Identification - data: BE4 manual gearbox
- Identification - specification: MA5 manual gearbox
- Checking and adjusting values: MA manual gearbox
- Checking and adjusting values: BE manual gearbox
- Data: Gearbox of the MA5 type
- Data: Gearbox of the BE4/5 type
- Data: BE4/5 gearbox with reinforced transmission ®
- Identification - tightening torques: gearbox
- Check: efficiency of the enhanced traction differential ®
- Check - adjustment: set of primary shaft bearings
- Adjustment: reinforced transmission differential housing ®
- Stripping - re-assembling: components internal to the gearbox
- Refitting: manual gearbox
- Dismantling: manual gearbox
- Dismantling: manual gearbox — variant 2
- Refitting: manual gearbox — variant 2
- Removing - refitting: the gear lever acquisition card (MOTEUR ELECTRIQUE VENTURI)
- Removing - refitting: gearbox (DV6DTED M, DV6ETED M)
- Removing - refitting: refitting MA gearbox
- Removing - refitting: MA gearbox
- Removing - refitting: gearbox (DV6ATED4)
- Drain - refill: BE gearbox
- Draining - filling - level: MA gearbox
- Overhaul: BE4 manual gearbox (Summary)
- Overhaul: manual gearbox - type MA/MAP (Summary)
- Cleaning and refitting conditions: gearbox
- Cleaning and refitting conditions: gearbox — variant 2
- Greasing: splines of the primary shaft
- Stripping - re-assembling: components internal to the gearbox — variant 2
- Stripping - re-assembling: reinforced transmission differential housing ®
- Modification: MA5 gearbox secondary shaft
- Modification: MA5 gearbox
- Modification: BE4/5 gearbox secondary shaft
- Help in diagnosis: Manual gearbox (technical note)
- Tightening torques: coupling of engine on reduction box (MOTEUR ELECTRIQUE VENTURI)
- Draining - refilling: reduction gear (MOTEUR ELECTRIQUE VENTURI)
- Removing - refitting: motor (MOTEUR ELECTRIQUE VENTURI)
- Removing - refitting: reduction gear driveshaft seals (MOTEUR ELECTRIQUE VENTURI)
- Tightening torques: components of the electric drive train
- Removing - refitting: electric coolant pump (drive train) (MOTEUR ELECTRIQUE VENTURI)
- Removing - refitting: engine emulation board (MOTEUR ELECTRIQUE VENTURI)
- Removing - refitting: inertial sensor (or inertia sensor) (MOTEUR ELECTRIQUE VENTURI)
Clutch
- Removing - refitting: clutch mechanism
- Removing - refitting: clutch cable
- Help in diagnosis: clutch (technical note)
- Aid to mechanical diagnosis: difficult/impossible to change gear (cable operated clutch control)
- Removing - refitting: Accelerator pedal sensor (MOTEUR ELECTRIQUE VENTURI)
- Help in diagnosis: difficult/impossible to change gear (hydraulic clutch control)
Gearbox controls
- Identification - specification: MA5 type gear controls
- Identification - specification: BE4 type gear controls
- Data: selection control (SA18)
- Data: MA type gear controls
- Data: BE type gear controls
- Removing - refitting: gearbox controls (MOTEUR ELECTRIQUE VENTURI)
- Removing - refitting: gearbox controls (DV6ETED M, DV6DTED M)
- Removing - refitting: selection control (SA18)