Chevrolet Cutaway G3500 (1997-2012) hot at all times Wiring diagrams

2 6 3 1 CAN BUS HI LO REF CAN BUS LO 32 33 34 35 36 37 38 VEHICLE SPD SIG CAN BUS HI DATA 5.3L, 4.8L, 6.0L 4.3L ABS MDL FUSE 2 ABS MTR FUSE 1 BLK WIRE BLK/PPL WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE COMPUTER DATA LINES SYSTEM DIESEL DIESEL GASOLINE DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) FUSE 29 GASOLINE GRY WIRE GRY/BLK WIRE HI SPD GMLAN DATA + HI SPD GMLAN DATA + B+ HI SPD GMLAN DATA- HI SPD GMLAN DATA- GND HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED IPC FUSE 10 LEFT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (WSS) (AT LEFT REAR WHEEL HUB) LF WHEEL SPD SENS LOW REF LOW REF LOW REF RF WHEEL SPD SENS LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE ORG/ WIRE ORG/BLK WIRE PNK WIRE RED WIRE RED/BLK WIRE RED/WHT WIRE RIGHT FRONT WHEEL SPEED SENSOR (WSS) (ON INSIDE OF RIGHT FRONT WHEEL) SERIAL DATA ENABLE B+ STEERING ANGLE SENS CAN BUS LO DATA STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) STR/WHL/ SNSR TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SIGNAL WHT WIRE WHT/BLK WIRE YAW, LATERAL ACCELERATION SENSOR (UNDER FRONT PASSENGER SEAT) YEL WIRE YEL/BLK WIRE

ABS IND. AIR BAG IND BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IND BRN WIRE BRN/WHT WIRE CHARGE IND CMPS FUSE 19 COMPUTER DATA LINES SYSTEM CRUISE IND DIESEL DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COMPT) ENGINE CONTROLS SYSTEM SUPPLEMENTAL RESTRAINTS SYSTEM ENGINE COOLANT TEMPERATURE GAUGE FRONT SEAT) FUEL GAUGE GMLAN SERIAL GRY/BLK WIRE HIGH BEAM IND HOT AT ALL TIMES HOT W/ RUN RELAY HOT W/ RUN/CRNK RELAY 15 ENERGIZED I/P CLUSTER FUSE 23 IGN VOLT IND CTRL IND LAMP (MIL) INSTRUMENT PANEL CLUSTER (IPC) IPC FUSE 10 LEFT TURN IND LIFTGATE AJAR SW SIG LF DOOR AJAR SW RR DOOR OPEN SW LR DOOR OPEN SW LOGIC LOW ENGINE OIL PRESSURE GAUGE LOW FUEL IND LOW OIL LOW STABILITY IND LT BLU WIRE LT GRN WIRE MALFUNCTION MIL CTRL NETWORK 3 ODOMETER PARK BRAKE SWITCH (UNDER LEFT SIDE OF DASH) PASS SEAT BELT PASSENGER SEAT BELT IND PNK WIRE PNK/BLK WIRE PPL PPL PNK WIRE PRESSURE IND PRND 321 RED/WHT WIRE RF DOOR AJAR SW RIGHT TURN IND SEAT BELT IND SECURITY IND SEO FUSE 27 SPEEDOMETER SUPPLEMENTAL RESTRAINTS SYSTEM SW SIG SWITCH SIG TAN/WHT WIRE TIRE PRESSURE IND TOW/HAUL IND TRACTION CONTROL IND UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF VOLTS GAUGE W/ BRAKE WARNING INDICATOR SYSTEM W/ ODOMETER SECURITY WIRING PROVISION (SEO) W/O ODOMETER SECURITY WIRING PROVISION (SEO) WAIT TO START IND WHT WIRE YEL WIRE YEL/BLK WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 LH AUDIO SIG (+) RH AUDIO SIG (+) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 B+ LF MID OUT (+) RF MID OUT (+) 1959 1955 LR MID OUT (-) RR MID OUT (-) 2 1 8 LO REF 658 1782 VOICE SIG DRAIN WIRE HI SPD GMLAN ANTENNA IN BATT POSITIVE VOLT BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BREAKOUT) BRN/WHT WIRE CELLULAR, DIGITAL RADIO ANTENNA CELLULAR/ NAVIGATION ANTENNA COAX COMPUTER DATA LINES SYSTEM CRUISE CONTROL SYSTEM CUTAWAY UPFITTER DIGITAL RADIO RECEIVER (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE DRAIN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT STEERING WHEEL MODULE COIL (AT TOP OF STEERING COLUMN) INFO LED DIMMING CTRL GND LF MID OUT (-) RF MID OUT (-) LEFT CARGO DOOR SPEAKER (IF EQUIPPED) LEFT FRONT SPEAKER LEFT REAR SPEAKER LH AUDIO SIG + RH AUDIO SIG + LO GMLAN SERIAL DATA LO REF LO SERIAL DATA LR MID OUT (+) RR MID OUT (+) LT BLU WIRE LT BLU/BLK WIRE LT GRN WIRE MUTE NCA WIRE ORG/ WIRE PASSENGER/ CARGO PNK WIRE RADIO RADIO ANTENNA RDO/ CHIME FUSE 20 RED/WHT WIRE RIGHT CARGO DOOR SPEAKER (IF EQUIPPED) RIGHT FRONT SPEAKER RIGHT REAR SPEAKER RIGHT STEERING WHEEL CONTROL SWITCH SEEK DOWN SEEK UP SOURCE STEERING WHEEL CTRL TAN WIRE TAN/BLK WIRE TAN/WHT WIRE USB CABLE USB CHARGE USB RECEPTACLE VEHICLE COMMUNICATION INTERFACE MODULE (VICM) (BELOW STEERING COLUMN) VOICE SIG VOL DOWN VOL UP W/ VEHICLE COMMUNICATION SYSTEM W/O VEHICLE COMMUNICATION SYSTEM WHT WIRE YEL WIRE

1 2 B+ GND 6 7 8 9 10 11 12 BRAKE SW SIG AUTOMATIC TRANSMISSION AUTOMATIC TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR BLK/WHT WIRE BRK SW FUSE 13 BRN/WHT WIRE COMPUTER DATA LINES SYSTEM CONTROL SOLENOID VALVE ASSEMBLY DK BLU WIRE DK GRN WIRE DRIVER INFORMATION CENTER DISPLAY (DIC) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EXCEPT 6.6L 6.6L EXTERIOR LIGHTS SYSTEM 1786 2501 2500 6399 GMLAN HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED IGN IGN VOLTAGE INSTRUMENT PANEL CLUSTER INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW REFERENCE LT BLU WIRE LT BLU/WHT WIRE ORG/BLK WIRE PC SOLENOID 1 CONTROL PC SOLENOID 2 CONTROL PC SOLENOID 3 CONTROL PC SOLENOID 4 CONTROL PC SOLENOID 5 CONTROL PNK WIRE PRESSURE CONTROL (PC) SOLENOID VALVE 1 PRESSURE CONTROL (PC) SOLENOID VALVE 2 PRESSURE CONTROL (PC) SOLENOID VALVE 3 PRESSURE CONTROL (PC) SOLENOID VALVE 4 PRESSURE CONTROL (PC) SOLENOID VALVE 5 RED/WHT WIRE SHIFT SOLENOID (SS) 1 CONTROL SHIFT SOLENOID (SS) 2 CONTROL SHIFT SOLENOID (SS) VALVE 1 SHIFT SOLENOID (SS) VALVE 2 STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TCM BATT FUSE 32 TCM IGN FUSE 31 TO AUTOMATIC TRANSMISSION (DIAGRAM 2 OF 2) TORQUE CONVERTER CLUTCH (TCC) PRESSURE CONTROL (PC) SOLENOID VALVE TORQUE CONVERTER CLUTCH PRESSURE CONTROL SOLENOID CONTROL TOW/HAUL IND TOW/HAUL SWITCH TRANSMISSION CONTROL MODULE (TCM) TRANSMISSION FLUID TEMPERATURE (TFT) SENSOR SIGNAL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 56 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 79 FUEL PUMP RELAY 38 (4.8L/6.0L) GAS FUEL PUMP FUSE 24 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 64 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 65 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL BLK WIRE BRN WIRE COMPUTER DATA COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 36 FSCM IGN FUSE 6 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LINES SYSTEM LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK WIRE PPL PPL/WHT WIRE PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

BLK WIRE BLK/WHT WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION (CKP) SENSOR (NEXT TO CRANKSHAFT PULLEY) DIESEL FUEL PUMP FUSE 24 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/GLOW PLUG MDL IGN FUSE 30 ECM PWR/ TRN FUSE 45 EXHAUST GAS RECIRCULATION (EGR) TEMPERATURE SENSOR 2 EXHAUST GAS RECIRCULATION (EGR) VALVE (RIGHT SIDE OF ENGINE ABOVE 1 CYLINDER) FUEL FILTER PRESSURE SWITCH FUEL HTR FUSE 71 FUEL INJECTOR 2 (ON LEFT SIDE OF ENGINE) FUEL INJECTOR 3 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 5 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 8 (ON LEFT SIDE OF ENGINE) FUEL PUMP RELAY GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAF/ CNSTR FUSE 71 NCA WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL/WHT WIRE PWR/ TRN RELAY 49 RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE

BLK WIRE BLK/WHT WIRE BRK SW FUSE 13 BRN WIRE BRN/WHT WIRE CRANKSHAFT POSITION (CKP) SENSOR (NEXT TO CRANKSHAFT PULLEY) DIESEL FUEL PUMP FUSE 24 DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/GLOW PLUG MDL IGN FUSE 30 ECM PWR/ TRN FUSE 45 EXHAUST GAS RECIRCULATION (EGR) TEMPERATURE SENSOR 2 EXHAUST GAS RECIRCULATION (EGR) VALVE (RIGHT SIDE OF ENGINE ABOVE 1 CYLINDER) FUEL FILTER PRESSURE SWITCH (TOP LEFT REAR SIDE OF ENGINE) FUEL HTR FUSE 71 FUEL INJECTOR 2 (ON LEFT SIDE OF ENGINE) FUEL INJECTOR 3 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 5 (ON RIGHT SIDE OF ENGINE) FUEL INJECTOR 8 (ON LEFT SIDE OF ENGINE) FUEL PUMP RELAY GRY WIRE GRY/BLK WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/CRNK RELAY 15 ENERGIZED LOWER RIGHT FRONT OF ENGINE) LT BLU WIRE LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/WHT WIRE MAF/ CNSTR FUSE 64 NCA WIRE ORG/BLK WIRE PNK PNK WIRE PNK WIRE PNK/BLK WIRE PPL/WHT WIRE PWR/ TRN RELAY 49 RED/WHT WIRE TAN WIRE TAN/WHT WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) WHT/BLK WIRE YEL WIRE