Chevrolet Cutaway G3500 (1997-2012) hot at all times Wiring diagrams

BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CHIME MODULE (BEHIND CENTER OF DASH) DATA CLSS 2 DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE GRY WIRE HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER LT BLU WIRE LT GRN WIRE LTR FUSE 30 PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL RADIO RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) SPLICE UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) VEHICLE COMMUNICATIONS INTERFACE MODULE (VCIM) (BELOW STEERING COLUMN) W/O ACTIVE HANDLING W/ ACTIVE HANDLING W/O RADIO WHT WIRE YEL WIRE

BLK WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CLASS 2 CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE IND DK BLU WIRE DK BLU/WHT WIRE DK GRN WIRE GRN WIRE GROUND GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF ORG/BLK WIRE PCM IGN 1 FUSE 38 PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SET/ COAST STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) THROTTLE ACTUATOR CONTROL (TAC) MODULE (AT LEFT REAR OF ENGINE COMPARTMENT) TURN SIGNAL/ MULTIFUNCTION SWITCH UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA UART SERIAL DATA SERIAL DATA 14 58 UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSS HIGH WHT WIRE YEL WIRE

BLK WIRE BLU WIRE BODY FUSE BLOCK (BELOW LEFT FRONT SEAT) CARGO/ PASSENGER CLASS 2 CRUISE IND CLASS 2 (PCM) DATA COMPUTER DATA LINES SYSTEM CRUISE CONTROL MODULE (NEAR BRAKE FLUID RESERVOIR) CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE GRN WIRE GRY WIRE GRY/BLK WIRE HOT AT ALL TIMES HOT IN RUN, START IGN IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LT BLU WIRE LT BLU/BLK WIRE NCA WIRE ON CRUISE CONTROL ON/OFF SWITCH OFF ON OFF PCM IGN 1 FUSE 38 PNK 17 (OR 1320) WIRE PNK WIRE POWERTRAIN CONTROL MODULE (PCM) (IN ENGINE COMPT, ON LEFT INNER FENDER) PPL PPL VSS LOW RED/WHT WIRE RESUME/ ACCEL RESUME/ACCEL SERIAL DATA SET/ COAST SPEED SIGNAL AUTO CRUISE INHIBIT SIG VSS HIGH 13 37 STOP LP FUSE 7 STOP/ CHMSL FUSE 8 STOPLAMP SWITCH (ABOVE BRAKE PEDAL) TURN SIGNAL/ MULTIFUNCTION SWITCH UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) WHT (OR LT BLU) WIRE WHT WIRE YEL WIRE

BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) CHIME MODULE (BEHIND CENTER OF DASH) COOLANT HEATER (ATTACHED TO LEFT INNER FRAME RAIL) DATA CLSS 2 DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (IN ENGINE COMPT, ON LEFT INNER FENDER) ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) GLOW PLUG CONTROL MODULE (GPCM) (LEFT REAR OF ENGINE) GRY WIRE HI SPD GMLAN SERIAL DATA HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER LT BLU WIRE LT GRN WIRE LTR FUSE 30 NCA WIRE PNK DATA CLSS 2 WIRE POWER DISTRIBUTION SYSTEM PPL RADIO RED/WHT WIRE REMOTE CONTROL DOOR LOCK RECEIVER (BEHIND CENTER OF DASH) SPLICE TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TRANSMISSION CONTROL MODULE (TCM) (ON RIGHT FRAME RAIL) UNDERHOOD FUSE BLOCK (LEFT SIDE OF ENGINE COMPT) UNDERHOOD PASS- THROUGH GROMMET BREAKOUT) VEHICLE COMMUNICATIONS INTERFACE MODULE (VCIM) (BELOW STEERING COLUMN) W/ AUXILIARY HEATER W/O ACTIVE HANDLING W/ ACTIVE HANDLING W/O AUXILIARY HEATER W/O RADIO WHT WIRE YEL WIRE

54 49 22 33 (DIESEL) (GASOLINE) ABS PUMP ABS/TCC SW ABS/VSES FUSE 48 ANTI-LOCK IND BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE FLUID LEVEL SW IN LEFT FRONT SENSOR (+) RIGHT FRONT SENSOR (-) VSS INPUT BRAKE FLUID LEVEL SWITCH (HEAVY DUTY) (ON BRAKE MASTER CYLINDER RESERVOIR) BRAKE IND BRKS FUSE 11 BRN WIRE CRUISE CONTROL SYSTEM DIESEL DK GRN WIRE GAS GRY WIRE HOT AT ALL TIMES HOT IN RUN HOT IN RUN OR START IGN E FUSE 22 INSTRUMENT PANEL CLUSTER LEFT FRONT SENSOR (-) RIGHT FRONT SENSOR (+) BRAKE INPUT LEFT FRONT WHEEL SPEED SENSOR (ON INSIDE OF LEFT FRONT WHEEL) LOGIC LT BLU WIRE PNK WIRE PPL PPL DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) RED/BLK WIRE RIGHT FRONT WHEEL SPEED SENSOR (ON INSIDE OF RIGHT FRONT WHEEL) SERIAL DATA IGNITION STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TCC BRAKE SW TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENG COMPT) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENG COMPT) VEHICLE SPEED SENSOR (VSS) VSS HIGH VSS LOW VSS OUTPUT YEL WIRE YEL/BLK WIRE

ABS/TCC SWITCH ABS/TCS CLASS 2 SERIAL DATA YAW RATE SENSOR LO REF WHEEL POS SENS LOW REF ABS/VSES FUSE 48 AUXILIARY 1 FUSE 32 BLK WIRE BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRAKE IN BRKS FUSE 11 BRN WIRE DEL TORQUE DK BLU WIRE DK GRN WIRE ELECTRONIC BRAKE CONTROL MODULE (EBCM) GRY WIRE HOT AT ALL TIMES HOT IN HOT IN RUN OR START IGN E FUSE 22 IGNITION 3 VOLT LATERAL ACCELEROMETER SIG LEFT FRONT WHEEL SPEED SENSOR (ON INSIDE OF LEFT FRONT WHEEL) LEFT REAR WHEEL SPEED SENSOR (AT LEFT REAR OF WHEEL HUB) LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE NCA WIRE ORG/BLK WIRE PNK 1 2 WIRE PNK WIRE POWER DISTRIBUTION SYSTEM POWERTRAIN CONTROL MODULE (PCM) (IN ENG COMPT, ON LEFT INNER FENDER) PPL PPL UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) PPL/WHT WIRE PRECHARGE MOTOR LO BATTERY (+) GND PRECHARGE MOTOR HI PRECHARGE PUMP (AT LEFT FRONT OF FRAME RAIL) RED WIRE REQ TORQUE REQUEST TORQUE SIGNAL DELIVERED TORQUE SIGNAL RIGHT FRONT WHEEL SPEED SENSOR (ON INSIDE OF RIGHT FRONT WHEEL) RIGHT REAR WHEEL SPEED SENSOR (AT RIGHT REAR OF WHEEL HUB) RUN WIRE STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VEHICLE SPEED SENSOR (VSS) (ON RIGHT SIDE OF TRANSMISSION) VSES MOTOR VSS HIGH VSS LOW VSS OUTPUT WHT WIRE YEL WIRE YEL/BLK WIRE

12 13 34 28 27 25 8 65 43 44 59 36 63 66 46 PRESS SENS LOW REF 19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 21 22 58 4 24 40 SENS SIG LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C CMPRSR RELAY 40 A/C COMPRESSOR CLUTCH A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN/WHT WIRE CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE 63 GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF SIDE OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER WHT (OR RED) WIRE WHT/BLK WIRE YEL WIRE

BLK WIRE BLOWER MOTOR (ON RIGHT REAR OF ENGINE COMPT, ON EVAPORATOR CASE) BLOWER MOTOR RELAY BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BREAKOUT) BRN WIRE BRN/WHT WIRE DEFOGGER SWITCH DEFOGGER IND DEFOGGER SYSTEM DK BLU WIRE DK GRN/WHT WIRE FLOOR MIX BLEND DEF MAX A/C OFF A/C BI-LEV FRONT AUXILIARY HVAC CONTROL ASSEMBLY FRT BLWR FUSE 74 GND IGN GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ HVAC 1 FUSE 14 HVAC 2 FUSE 13 HVAC CNTRL FUSE 25 HVAC CONTROL ASSEMBLY INTERIOR LEFT REAR OF ENGINE) (4.3L: RIGHT REAR OF ENGINE) LIGHTS SYSTEM LOGIC 2 1 LT BLU WIRE LT GRN WIRE MAX A/C OFF A/C BI-LEV VENT MED OFF ORG/ WIRE PNK/BLK WIRE PPL PPL/WHT WIRE REAR REAR AUXILIARY HVAC CONTROL ASSEMBLY REAR BLWR FUSE 29 REAR DUAL SIG CTRL REAR DUAL CTRL RED WIRE RED/BLK WIRE RED/WHT WIRE SPLICE BLOCK TAN WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VACUUM PUMP (6.6L) (RIGHT FRONT OF ENGINE COMPT, UNDER BATTERY) VENT FLOOR DEF MIX BLEND W/ ELECTRIC REAR WINDOW DEFOGGER, POWER MIRRORS W/ RV UPFITTER W/O RV (ATTACHED TO LOWER RIGHT "B" PILLAR PART OF UPFITTER W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL WIRE

2501 2500 2501 2500 COMPUTER DATA LINES SYSTEM A/C LOW PRESSURE SWITCH (ON SIDE OF ACCUMULATOR) AUXILIARY AIR TEMPERATURE ACTUATOR AUXILIARY BLOWER MOTOR (ON AUXILIARY HVAC) AUXILIARY BLOWER MOTOR MEDIUM SPEED RELAY AUXILIARY BLOWER MOTOR RESISTOR ASSEMBLY (ON AUXILIARY AUXILIARY HVAC MODULE) AUXILIARY MODE ACTUATOR BATT GND BLK WIRE BLK/WHT WIRE BLOWER MOTOR BREAKOUT) BREAKOUT) BRN WIRE COMPUTER DATA LINES SYSTEM COOLANT HEATER BLOWER MOTOR COOLANT HEATER COMBUSTION SENSOR COOLANT HEATER CONTROL MODULE COOLANT HEATER GLOW PLUG COOLANT HEATER OVERHEAT TEMPERATURE SENSOR COOLANT HEATER AIR TEMPERATURE SENSOR COOLANT HEATER TEMPERATURE SENSOR DK BLU WIRE DK BLU/LT GRN WIRE DK GRN WIRE DRIVER INFORMATION CENTER (DIC) DISPLAY ENGINE COOLANT LEVEL SWITCH ENGINE COOLANT TEMPERATURE GAUGE FOH MDL FUSE 35 FROM AUXILIARY BLOWER MOTOR CONNECTOR BREAKOUT) FUEL PUMP GND SERIAL - SERIAL + SERIAL - SERIAL + GRN/RED WIRE GRY WIRE HEATER MOTOR HOT AT ALL TIMES INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOGIC COOLANT LEVEL SW SIG LOW REF LOW SPD GMLAN SERIAL DATA LT BLU WIRE LT GRN WIRE ORG/ WIRE PROVISIONAL RED/WHT WIRE SERIAL DATA TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VOLT WHT WIRE YEL WIRE

19 21 69 14 71 CTRL SPD SIG CTRL SPD SIG SPEED SIG 24 40 58 4 21 22 SENS SIG LOW REF 59 36 63 66 46 25 8 65 43 44 12 13 34 28 27 PRESS SENS LOW REF 6.6L 4.3L 4.8L, 5.3L, 6.0L A/C CMPRSR FUSE 18 A/C CMPRSR RELAY 40 A/C COMPRESSOR CLUTCH A/C REFRIGERANT PRESSURE SENSOR A/C SERIAL REQUEST DATA SIG BLK WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BRN/WHT WIRE CLUTCH RLY CTRL COMPUTER DATA LINES SYSTEM COOLING FAN ASSEMBLY (6.6L) (BEHIND RADIATOR) DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ENGINE CONTROL MODULE (ECM) ENGINE COOLANT TEMPERATURE (ECT) SENSOR FAN CLTCH (EV) FUSE 63 GMLAN - GMLAN + GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ PWR/TRN RELAY 49 ENERGIZED LOW REF LT BLU WIRE LT GRN WIRE OF ENGINE) ORG/BLK WIRE PNK WIRE REF SIDE OF ENGINE COMPT) TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT W/ AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/O AUXILIARY FUEL FIRED HEATER W/ AUXILIARY FUEL FIRED HEATER WHT/BLK WIRE YEL WIRE