Chevrolet Cutaway G3500 (1997-2012) hot at all times Wiring diagrams

A/T ISS LO SIG ACC WAKEUP DATA BLK/WHT WIRE BRK SW FUSE 32 BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/WHT WIRE GMLAN DATA (-) 2-3 SHIFT SOL GMLAN DATA (-) VSS LOW SIG PC SOL LOW CTRL GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRANK RELAY 69 ENERGIZED HOT W/ RUN/ CRANK RELAY ENERGIZED LT BLU/WHT WIRE LT GRN WIRE LT GRN/BLK WIRE ORG/ WIRE ORG/BLK WIRE P/N PARK/NEUTRAL POSITION (PNP) SWITCH PNK WIRE POWER DISTRIBUTION SYSTEM PPL/WHT WIRE RED/WHT WIRE REPLICATED TOS SIG GMLAN DATA (+) GMLAN DATA (-) STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCM BATT FUSE 44 TCM IGN FUSE 47 TFP SW B SIG TFT SENS SIG TR SW A SIG LOW REF IGN VOLT BATT POS VOLT TFP SW C SIG TR SW B SIG TR SW C SIG TFP SW A SIG PNK WIRE TRANS FUSE 51 TRANSMISSION CONTROL MODULE (TCM) (LEFT FRONT CORNER OF ENGINE COMPT) UNDERHOOD FUSE BLOCK WHT WIRE YEL WIRE YEL/BLK WIRE

2 3 11 13 DATA BUS (-) DATA BUS (+) 2 3 DATA BUS (+) DATA BUS (-) 2 3 SERIAL DATA SERIAL DATA 5 4 6 7 157 147 167 177 DATA BUS (+) DATA BUS (-) DATA BUS (-) DATA BUS (+) 6 5 DATA BUS (-) DATA BUS (+) 6.6L 4.8L, 5.3L, 6.0L 4.3L ACC WAKE UP SERIAL DATA DATA BUS (+) DATA BUS (-) BLK/WHT WIRE CHIME MODULE (BEHIND LEFT CENTER OF DASH) CUTAWAY DATA LINK CONNECTOR (DLC) (UNDER LEFT SIDE OF DASH) DATA LINK RESISTOR DIGITAL RADIO RECEIVER (S-BAND DIGITAL AUDIO SYSTEM) (LEFT SIDE OF DASH) DK BLU WIRE DK GRN WIRE ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) HOT AT ALL TIMES INFLATABLE RESTRAINT SENSING, DIAGNOSTIC MODULE (SDM) (UNDER LEFT FRONT SEAT) INSTRUMENT PANEL CLUSTER (IPC) LIGHT DUTY W/O RECREATIONAL VEHICLE, UPFITTER SALES PACKAGE LT GRN WIRE LTR/DLC FUSE 73 NITROGEN OXIDES SENSOR 1 (TOP LEFT REAR SIDE OF ENGINE) NITROGEN OXIDES SENSOR 2 (MIDDLE OF DIESEL PARTICULATE FILTER) RADIO RED WIRE RED/WHT WIRE REDUCTANT SENSOR MODULE (ABOVE REDUCTANT TANK) REMOTE CONTROL DOOR LOCK RECEIVER (RCDLR) (IF EQUIPPED) (BEHIND CENTER OF DASH) SERIAL DATA SPLICE PACK TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/O RADIO WHT WIRE

11 12 LPS DIMMER SW SIG DIMMING VOLT REF 2 15 HEAD 8 17 PARK LAMPS SIG HEADLAMPS OFF SIG AUXILIARY BLOWER MOTOR SWITCH BATTERY POS VOLT BCM 3 FUSE 26 BLK WIRE BLK/WHT WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) BRN WIRE BRN/WHT WIRE CONNECTOR CONTROL DIMMING CTRL DK GRN WIRE DRIVER DOOR LOCK SWITCH DRIVER INFORMATION CENTER (DIC) SWITCH DRIVER WINDOW SWITCH FRONT AUXILIARY HVAC CONTROL ASSEMBLY HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES HVAC CONTROL ASSEMBLY IN FRONT HEADLINER HARNESS, 21 CM INFLATABLE RESTRAINT I/P MODULE DISABLE SWITCH (W/ MANUAL SUPPRESSION) LEFT STEERING WHEEL CONTROL SWITCH LPS DIMMING CTRL LT BLU WIRE OFF AUTO PARK ORG/ WIRE ORG/WHT WIRE PASSENGER DOOR LOCK (W/ POWER SWITCH MIRRORS, POWER WINDOWS) PASSENGER WINDOW SWITCH PNK CONTROL PNK WIRE PNK PNK W/O REDUNDANT RADIO STEERING WHEEL WIRE PNK WIRE RADIO RED WIRE RED/WHT WIRE RIGHT STEERING WHEEL CONTROL SWITCH STR WHL SNSR FUSE 17 TRACTION CONTROL SWITCH (TCS) (W/ ACTIVE BRAKE CONTROL) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) W/ AUTOMATIC CRUISE CONTROL, REDUNDANT RADIO STEERING WHEEL CONTROL W/ AUTOMATIC ELECTRONIC CRUISE CONTROL W/ AUXILIARY HEATER W/O REAR A/C W/ ELECTRIC SIDE DOOR LOCK W/ ELECTRIC TOW/HAUL SWITCH SIDE DOOR LOCK W/ POWER OPERATED WINDOW W/ REAR W/O REAR AUXILIARY AUXILIARY CONTROLS CONTROLS W/ REDUNDANT RADIO STEERING WHEEL W/ RV UPFITTER W/O RADIO PROVISIONS W/O RV UPFITTER WHT WIRE YEL WIRE

1 18 25 COURTESY LP CTRL COURTESY LP CTRL DEFEAT SW SIG 149 (OR 690) 20 CM FROM RIGHT SUNSHADE BREAKOUT) BLK WIRE BLK/WHT WIRE BLU WIRE BODY CONTROL MODULE (BCM) (BEHIND LOWER RIGHT SIDE OF DASH) BODY FUSE BLOCK (UNDER LEFT FRONT SEAT) CARGO CARGO DOOR LATCH ASSEMBLY (IN RIGHT REAR CARGO DOOR) CARGO/PASSENGER COURTESY LP CTRL CTSY LP CTRL DK BLU WIRE DK BLU/WHT WIRE DOME DOME READING FL DOME RLY CTRL FRONT DOME/ READING LAMPS GRY WIRE GRY/BLK WIRE HEADLAMP, PANEL DIMMER SWITCH HOT AT ALL TIMES LEFT SUNSHADE LIFTGATE AJAR SW SIG MIDDLE DOME/ READING LAMPS ORG/ WIRE PASSENGER PASSENGER/CARGO W/O RV UPFITTER PNK/BLK WIRE PPL PROVISIONAL READING REAR DOME/ READING LAMPS (PASSENGER) DOME LAMP (CARGO) RED WIRE RIGHT SUNSHADE (ON UPPER RIGHT OF HEADLINER) TAN/WHT WIRE THE ENGINE BLOCK) UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) UNDERHOOD LAMP UPFTR AUX 1 FUSE 36 (W/ CUTAWAY, AMBULANCE, RV UPFITTERS) UPFTR CTSY LAMPS FUSE 4 UPFTR CTSY LAMPS PCB RELAY (W/ AMBULANCE, RV UPFITTER) W/ COMMERCIAL TRADESMAN SALES PACKAGE, CARGO LAMP W/ CUTAWAY W/ CUTAWAY, CARGO W/O RV UPFITTER W/ LEFT, RIGHT SUNSHADE MIRROR W/ RV UPFITTER W/ RV UPFITTER, LEFT, RIGHT SUNSHADE MIRROR W/O RV UPFITTER W/O RV W/ RV UPFITTER UPFITTER WHT WIRE YEL/BLK WIRE

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 56 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 79 FUEL PUMP RELAY 38 (4.8L/6.0L) GAS FUEL PUMP FUSE 24 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 64 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 65 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL BLK WIRE BRN WIRE COMPUTER DATA COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 36 FSCM IGN FUSE 6 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LINES SYSTEM LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK WIRE PPL PPL/WHT WIRE PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)

5.3L 5.3L EXCEPT 5.3L A/C REFRIGERANT PRESSURE SENSOR ACC SER DATA IGN VOLT BATT POS VOLT PNK WIRE ACCELERATOR PEDAL POSITION (APP) SENSOR (UNDER LEFT SIDE OF DASH) ANTI-LOCK BRAKES SYSTEM BANK 1 SENSOR 2 BANK 2 SENSOR 2 BLK LT BLU/ WIRE BLK WIRE BLK/WHT WIRE BRAKE PEDAL POSITION (BPP) SENSOR (TOP OF BRAKE PEDAL ASSEMBLY) BREAKOUT) BRK SENS SPLY BRK SW FUSE 13 BRN WIRE COMPUTER DATA LINES SYSTEM CUTAWAY DK BLU WIRE DK GRN WIRE DK GRN/WHT WIRE ECM BATT FUSE 19 ECM IGN/ GLOW PLUG MDL IGN FUSE 30 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) ENGINE COOLANT RADIATOR TEMPERATURE SENSORS FUEL PUMP, SENDER ASSEMBLY (ON FUEL TANK) FUEL TANK PRESSURE (FTP) SENSOR (ON FUEL TANK) GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IAT SENS SIG LOW REF ECT SENS SIG LOW REF LOW REF PRESS SENS SIG PPL LT BLU WIRE LT BLU/ BLK WIRE LT BLU/BLK WIRE LT BLU/WHT WIRE LT GRN WIRE MAF SENS SIG LOW REF ORG/BLK WIRE ORG/WHT WIRE PNK (OR PNK) 5 6 7 WIRE PNK IGN VOLT WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL FUEL LEVEL SENS PPL/WHT WIRE PRESS SENS SIG LOW REF PWR/TRN RLY CTRL RED/WHT WIRE RELAY CTRL START RLY CTRL STARTING/ CHARGING SYSTEM STOP LAMP SWITCH (BEHIND LEFT SIDE OF DASH, ABOVE BRAKE PEDAL) TAN WIRE TAN/BLK WIRE TAN/WHT WIRE TCC BRAKE SIG TOWARDS INSTRUMENT PANEL CLUSTER) TRANSMISSIONS SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT) VSS WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE

4.8L/6.0L 5.3L BLK WIRE BLK/WHT WIRE BRN WIRE BRN/WHT WIRE CLUTCH RLY CTRL CNSTR VENT SOL FUSE 56 COMPT) COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE ECM PWR/TRN FUSE 78 ENGINE CONTROL MODULE (ECM) (LEFT SIDE OF ENGINE COMPT) EVAP SOL CTRL EVAPORATIVE EMISSION (EVAP) CANISTER VENT SOLENOID (NEAR FRONT OF FUEL TANK) EVEN IGN/ INJ FUSE 79 FUEL PUMP RELAY 38 (4.8L/6.0L) GAS FUEL PUMP FUSE 24 GRY WIRE GRY/WHT WIRE HOT AT ALL TIMES IC 1 CTRL IC 2 CTRL IC 3 CTRL IC 4 CTRL IC 5 CTRL IC 6 CTRL IC 7 CTRL IC 8 CTRL IGN INSTRUMENT PANEL CLUSTER (IPC) LOGIC LOW ENGINE OIL PRESSURE IND LOW REF LT BLU WIRE LT BLU/WHT WIRE MAF/ CNSTR VENT FUSE 64 MALFUNCTION INDICATOR LAMP MIL CTRL ODD IGN/INJ FUSE 65 ORG/ WIRE ORG/BLK WIRE ORG/WHT WIRE PNK 5 6 7 (OR PNK) WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK PPL 2 3 4 WIRE PNK WIRE PPL PPL/WHT WIRE PWR/TRN RELAY 49 RED/WHT WIRE SNSR 1 (PRE)/CLS FUSE 77 SNSR 2 (POST) FUSE 62 TOS SIG TRANSMISSIONS SYSTEM AIR CONDITIONING SYSTEM UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE WHT WIRE YEL WIRE

& IGNITION COIL/MODULE 7) 1 2 3 PNK WIRE 1 2 3 PPL BLK WIRE BRN WIRE COMPUTER DATA COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/WHT WIRE FCSM BATT FUSE 36 FSCM IGN FUSE 6 GMLAN DATA GRY WIRE HOT AT ALL TIMES HOT W/ RUN/ CRNK RELAY 15 ENERGIZED IGN VOLT IGNITION COIL/MODULE 1 IGNITION COIL/MODULE 3 IGNITION COIL/MODULE 5 LINES SYSTEM LOW REF LT BLU WIRE LT BLU/WHT WIRE NCA WIRE ORG/ WIRE ORG/WHT WIRE PNK PNK PNK PNK PNK PNK PNK PNK PNK 4 5 6 7 8 9 10 11 12 WIRE PNK PNK PPL 15 16 17 18 19 20 21 22 23 24 WIRE PNK WIRE PPL PPL/WHT WIRE PUMP CTRL RED WIRE RED/WHT WIRE RELAY CTRL SENS SIG SERIAL DATA SPARK PLUG TAN WIRE TAN/BLK WIRE UNDERHOOD FUSE BLOCK (ON LEFT SIDE OF ENGINE COMPT)