- Place throttle body on Holding Fixture (J-9789-118 or BT-30-15) to prevent damage to throttle valve. Remove fuel meter body cover screws and remove fuel meter body cover. (Схема №5) If fuel pres sure regulator cover is removed, regulator diaphragm must be replaced to prevent fuel leaks.
- Remove fuel injectors. Note location of fuel inlet and outlet nuts and remove. Discard gaskets and "O" rings. Remove fuel meter body assembly-to-throttle body screws. (Схема №5) Remove fuel meter body assembly. Remove and discard fuel meter body assembly gasket.
- Remove TP sensor, IAC valve, fuel pressure regulator, governor drive motor and governor throttle drive assembly, lever and bearing assembly, rubber components, gaskets and diaphragms. Clean all remaining (metal) parts in a cold immersion-type cleaner such as Carbon X (X-55). Blow dry with compressed air. Inspect mating surfaces for damage which may prevent gasket sealing. Repair or replace faulty components.
Home/Chevrolet/Astro/Chevrolet Astro I (1985-2005)/Repair manual/Removal & Installation/Disassembly (Fuel Meter Assembly Model 295)
Contents
Wiring diagrams Section: Removal & Installation- Introduction
- On-Vehicle Adjustments
- Powertrain Control Module (PCM)
- Control Module
- Fuel System Pressure Relief (Cpi)
- Fuel System Pressure Relief (Tbi)
- In-Tank Filter
- Fuel Pump
- Removal & Installation (All Models)
- Removal (Cpi)
- Removal (Tbi)
- Removal & Installation
- Throttle Body (Cpi)
- Throttle Body (Tbi)
- Identification
- Disassembly (Fuel Meter Assembly Model 220)
- Disassembly (Fuel Meter Assembly Model 295)
- Reassembly (Fuel Meter Assembly)
- Upper Intake Manifold & Cpi Assembly
- Disassembly & Reassembly
- Distributor (Hvi - High Value Ignition System)
- Oxygen Sensor
- Torque Specifications
- A/c Compressor
- Abbreviations
- Accessory Drive Belts
- Adjustments
- Airbag
- Anti-Lock/traction Control
- Application
- Automatic Trans
- Auxiliary Emission Control Systems
- Basic Trouble Shooting
- Brakes
- Charging System
- Check Lists
- Computer Relearn
- Cooling System (Mechanical)
- Cruise Control Systems
- Diagnostic Connector Locations
- Differentials & Drive Axles
- Door Locks & Anti-Theft Systems
- Driveline/axles
- Driveshaft & Universal Joints
- DTC Index
- Electrical
- Electrical Component Locations
- Emission Applications
- Engine
- Engine Performance
- Fuses & Circuit Breakers
- Gauges & Instrument Panels
- General Servicing - All Makes
- Heated Glass/defoggers
- Heater
- Identification
- Manual & Power Steering
- Manual HVAC System
- MAP Guidelines
- Mechanical
- Mechanical - Hydraulic
- Metric Conversions
- Mirrors
- Passive Restraints
- Pin Voltage Charts
- Procedures
- Removal & Installation
- Reset Procedures
- Restraints
- Rpo Codes
- Seats
- Sensor Range Charts
- Specifications
- Starter
- Steering
- Steering Column
- Steering Column Switches
- Suspension Front
- Suspension Rear
- Testing & Diagnostics
- Theory & Operation
- Traction Control Disable
- Transfer Case
- Transmission
- Wheel Alignment
- Windows
- Wiper/washer Systems
- Wiring Diagrams - Engine Performance