Manual sections

Wiring diagrams

• Abbreviations
• Accessory Drive Belts
• Adjustments
• Airbag
• Application
• Audio, Navigation, Anti-Theft and Restraints (Repair)
• Automatic HVAC System
• Automatic Trans
• Axle Shafts
• Basic Trouble Shooting
• Body Electrical
• Body Equipment - Repair
• Brakes
• Brakes - Repair
• Breakout Boxes & Connectors - Overview
• Cabin Air Filter
• Charging System
• Check Lists
• Clutch - Repair
• Clutches Manual & Hydraulic
• Coding and Programming - Overview
• Coding and Programming - Overview - All Models
• Communication Devices
• Computer Relearn
• Convertible Top & Hardtop - Repair
• Cooling Fan
• Cooling System (Mechanical)
• Diagnostic Connector Locations
• Diagnostic Equipment - Overview - All
• Door Locks & Anti-Theft Systems
• Drive Cycles
• Driveline/axles
• Driveshaft & Universal Joints
• DTC Index
• Electrical Component Locations
• Electronic Suspension
• Electronic Transmission Control - Overview
• Emission Applications
• Engine
• Engine - Repair (m54)
• Engine Controls - System & Component Testing
• Engine Electrical System - Repair
• Engine Management - Overview
• Engine Performance
• Entertainment Systems
• Exhaust
• Exterior Body Panels
• Exterior Lights
• Exterior/interior Trim
• Fuel System
• Fuses & Circuit Breakers
• Gauges & Instrument Panels
• General Electrical System - Repair
• Heating and Air Conditioning - Repair
• Horns
• Identification
• Lights - Repair
• Manual & Power Steering
• Manual Trans
• MAP Guidelines
• Mechanical
• Mechanical - Hydraulic
• Metric Conversions
• Mode 6
• Oem General Information
• On Board Monitor and Navigation Systems - Overview - e38, ee39, e46, e52, e65 & e85
• On-Vehicle Servicing - (a5s 360r/390r)
• Pin Voltage Charts
• Reset Procedures
• Restraints
• Seats
• Seats - Repair
• Specifications
• Starter
• Steering
• Steering Column
• Steering Gear
• Steering Linkage
• Sun Roof/t-Top/convertible Top
• Suspension - Front
• Suspension - Rear
• Suspension Front
• Testing & Diagnostics
• Traction Control Disable
• Transmission
• Wheel & Tire System
• Wheel Alignment

Repair manual

Body Equipment - Repair BMW Z4 E85/E86

Step-by-step instructions on "Body Equipment - Repair" for BMW Z4 E85/E86 (2002–2005). Pick an article — removal, installation, adjustment and diagnostics with illustrations.

111subsections

111articles

299illustrations

51 00... Safety instructions for working on cars with airbag systems

1 article

• 51 00... Safety instructions for working on cars with airbag systems

51 00... Service position of engine hood

1 article

• 51 00... Service position of engine hood 2

51 23 265 Removing and installing/replacing left or right gas strut for engine bonnet/hood

1 article

• 51 23 265 Removing and installing/replacing left or right gas strut for engine bonnet/hood 2

51 11 050 Removing and installing/replacing carrier for front bumper trim

1 article

• 51 11 050 Removing and installing/replacing carrier for front bumper trim 2

51 11 156 Removing and installing front bumper trim

1 article

• 51 11 156 Removing and installing front bumper trim 4

51 11 157 Replacing Front Bumper Trim

1 article

• 51 11 157 Replacing Front Bumper Trim 1

51 11 158 Replacing baseplate for licence plate

1 article

• 51 11 158 Replacing baseplate for licence plate 2

51 12 050 Removing and installing/replacing carrier for rear bumper trim

1 article

• 51 12 050 Removing and installing/replacing carrier for rear bumper trim 2

51 12 156 Removing and installing rear bumper trim

1 article

• 51 12 156 Removing and installing rear bumper trim 3

51 12 157 Replacing rear bumper trim

1 article

• 51 12 157 Replacing rear bumper trim 1

51 12 158 Removing and installing/replacing license plate holder

1 article

• 51 12 158 Removing and installing/replacing license plate holder

51 12 742 Replacing an impact absorber for rear bumper

1 article

• 51 12 742 Replacing an impact absorber for rear bumper

51 12 801 Replacing bracket for rear bumper at left or right

1 article

• 51 12 801 Replacing bracket for rear bumper at left or right 1

51 12 825 Removing and installing/replacing guide for rear Center bumper

1 article

• 51 12 825 Removing and installing/replacing guide for rear Center bumper 1

51 13... Replacing front radiator grill, middle left or right

1 article

• 51 13... Replacing front radiator grill, middle left or right 4

51 13 001 Removing and installing/replacing front radiator grill, middle left or right

1 article

• 51 13 001 Removing and installing/replacing front radiator grill, middle left or right 2

51 13 115 Removing and installing/replacing cowl panel cover

1 article

• 51 13 115 Removing and installing/replacing cowl panel cover 4

51 13 425 Removing and installing/replacing trim on left or right rear light

1 article

• 51 13 425 Removing and installing/replacing trim on left or right rear light 2

51 14... Instructions for attaching number/letter designation combination

1 article

• 51 14... Instructions for attaching number/letter designation combination 2

51 14 001 Replacing front BMW badge (removing and replacing)

1 article

• 51 14 001 Replacing front BMW badge (removing and replacing) 1

51 14 008 Replacing (removing and installing) number/letter combination on front left or right side panel

1 article

• 51 14 008 Replacing (removing and installing) number/letter combination on front left or right side panel 1

51 14 110 Removing and installing/replacing rear model emblem

1 article

• 51 14 110 Removing and installing/replacing rear model emblem 2

51 16... Cementing of mirror base

1 article

• 51 16... Cementing of mirror base

51 16... Removing and installing cover on panel for rear storage box

1 article

• 51 16... Removing and installing cover on panel for rear storage box 2

51 16... Removing and installing/replacing cover

1 article

• 51 16... Removing and installing/replacing cover 1

51 16... Removing and installing/replacing handbrake lever cover

1 article

• 51 16... Removing and installing/replacing handbrake lever cover 4

51 16... Replacing finisher on left instrument panel trim

1 article

• 51 16... Replacing finisher on left instrument panel trim 1

51 16 000 Removing and installing/replacing mirror on left or right front door

1 article

• 51 16 000 Removing and installing/replacing mirror on left or right front door 3

51 16 026 Replacing mirror glass

1 article

• 51 16 026 Replacing mirror glass 3

51 16 040 Replacing left or right outside mirror housing

1 article

• 51 16 040 Replacing left or right outside mirror housing 5

51 16 060 Removing and installing/replacing interior rearview mirror (overview)

1 article

• 51 16 060 Removing and installing/replacing interior rearview mirror (overview) 6

51 16 060 Removing and installing/replacing interior rearview mirror (with Japanese toll mirror)

1 article

• 51 16 060 Removing and installing/replacing interior rearview mirror (with Japanese toll mirror) 6

51 16 060 Removing and installing/replacing interior rearview mirror (with mirror arm end caps)

1 article

• 51 16 060 Removing and installing/replacing interior rearview mirror (with mirror arm end caps) 6

51 16 060 Removing and installing/replacing interior rearview mirror (with rain sensor)

1 article

• 51 16 060 Removing and installing/replacing interior rearview mirror (with rain sensor) 6

51 16 080 Removing and installing or replacing sun visor and left or right counter support

1 article

• 51 16 080 Removing and installing or replacing sun visor and left or right counter support 1

51 16 200 Removing and installing storage tray

1 article

• 51 16 200 Removing and installing storage tray 4

51 16 202 Removing and installing/replacing front cup holder

1 article

• 51 16 202 Removing and installing/replacing front cup holder

51 16 210 Removing and installing/replacing trim for preselector lever (gearshift lever)

1 article

• 51 16 210 Removing and installing/replacing trim for preselector lever (gearshift lever) 2

51 16 222 Replacing finisher on right instrument panel trim

1 article

• 51 16 222 Replacing finisher on right instrument panel trim 4

51 16 235 Removing and installing panel for rear storage box

1 article

• 51 16 235 Removing and installing panel for rear storage box 5

51 16 239 Removing and installing/replacing lid on rear storage box

1 article

• 51 16 239 Removing and installing/replacing lid on rear storage box 3

51 16 240 Removing and installing rear storage compartment

1 article

• 51 16 240 Removing and installing rear storage compartment 5

51 16 248 Removing and installing/replacing lock on rear storage box

1 article

• 51 16 248 Removing and installing/replacing lock on rear storage box 4

51 16 340 Removing and installing/replacing fastener for right glovebox (without active knee protection)

1 article

• 51 16 340 Removing and installing/replacing fastener for right glovebox (without active knee protection) 1

51 16 360 Removing and installing right glovebox (with active knee protection)

1 article

• 51 16 360 Removing and installing right glovebox (with active knee protection) 1

51 16 367 Removing and installing right glovebox with housing (with active knee protection)

1 article

• 51 16 367 Removing and installing right glovebox with housing (with active knee protection) 2

51 23 130 Adjusting/replacing striker on hood/bonnet

1 article

• 51 23 130 Adjusting/replacing striker on hood/bonnet

51 23 160 Removing and installing/replacing arrester hook on engine hood

1 article

• 51 23 160 Removing and installing/replacing arrester hook on engine hood 1

51 21 003 Replacing door detent (lock striker), front left or right

1 article

• 51 21 003 Replacing door detent (lock striker), front left or right 1

51 21 004 Adjusting front left or right door detent (lock wedge)

1 article

• 51 21 004 Adjusting front left or right door detent (lock wedge)

51 21 090 Removing and installing/replacing door lock in left or right front door

1 article

• 51 21 090 Removing and installing/replacing door lock in left or right front door 6

51 21 140 Removing and installing/replacing complete lock cylinder in left or right front door

1 article

• 51 21 140 Removing and installing/replacing complete lock cylinder in left or right front door 5

51 21 170 Removing and installing or replacing outside handle from left or right front door

1 article

• 51 21 170 Removing and installing or replacing outside handle from left or right front door 6

51 21 200 Removing and installing/replacing outside handle and lock actuation of left or right front door

1 article

• 51 21 200 Removing and installing/replacing outside handle and lock actuation of left or right front door 3

51 21 225 Removing and installing or replacing inside door opener in left or right front door

1 article

• 51 21 225 Removing and installing or replacing inside door opener in left or right front door 4

51 21 280 Removing and installing or replacing door retainer on left or right front door

1 article

• 51 21 280 Removing and installing or replacing door retainer on left or right front door 3

51 21 310 Removing and installing/replacing window cavity cover strip on front door

1 article

• 51 21 310 Removing and installing/replacing window cavity cover strip on front door 3

51 23... Adjusting/replacing bump stops

1 article

• 51 23... Adjusting/replacing bump stops 4

51 24 004 Adjusting rear lid lock (lower section of rear lid lock)

1 article

• 51 24 004 Adjusting rear lid lock (lower section of rear lid lock) 7

51 24 050 Removing and installing/replacing lock (lock cylinder) for rear lid

1 article

• 51 24 050 Removing and installing/replacing lock (lock cylinder) for rear lid 4

51 24 100 Removing and installing/replacing rear lid lock (upper section)

1 article

• 51 24 100 Removing and installing/replacing rear lid lock (upper section) 2

51 24 130 Removing and installing/replacing locking bracket for trunk lid lock

1 article

• 51 24 130 Removing and installing/replacing locking bracket for trunk lid lock 2

51 24 300 Removing and installing or replacing left or right gas strut for trunk lid

1 article

• 51 24 300 Removing and installing or replacing left or right gas strut for trunk lid 1

51 24 391 Replacing rubber mount on trunk lid support

1 article

• 51 24 391 Replacing rubber mount on trunk lid support 1

51 31... Instructions on gluing windshield

1 article

• 51 31... Instructions on gluing windshield

51 31... Removing windshield with "Roll Out 2000"

1 article

• 51 31... Removing windshield with "Roll Out 2000" 11

51 31 000 Removing and installing/replacing windshield

1 article

• 51 31 000 Removing and installing/replacing windshield

51 31 015 Repairing damage to windshields caused by pitting (stone chips) (clear and tinted laminated safety glass)

1 article

• 51 31 015 Repairing damage to windshields caused by pitting (stone chips) (clear and tinted laminated safety glass) 1

51 31 021 Removing and installing/replacing rubber frame for windshield

1 article

• 51 31 021 Removing and installing/replacing rubber frame for windshield 2

51 32 154 Adjusting left or right front door window glass

1 article

• 51 32 154 Adjusting left or right front door window glass 7

51 32 170 Removing and installing/replacing door window glass, front left or right

1 article

• 51 32 170 Removing and installing/replacing door window glass, front left or right 6

51 33 000 Removing and installing power window regulator in left or right front door

1 article

• 51 33 000 Removing and installing power window regulator in left or right front door 6

51 41... Replacing speaker cover on left or right door trim panel

1 article

• 51 41... Replacing speaker cover on left or right door trim panel 2

51 41 000 Removing and installing left or right front door trim panel

1 article

• 51 41 000 Removing and installing left or right front door trim panel 5

51 41 001 Replacing front left or right door trim

1 article

• 51 41 001 Replacing front left or right door trim 2

51 41 017 Removing and installing/replacing cover on door handle, front left or right

1 article

• 51 41 017 Removing and installing/replacing cover on door handle, front left or right 2

51 41 019 Removing and installing/replacing door handle on door trim panel, front left or right

1 article

• 51 41 019 Removing and installing/replacing door handle on door trim panel, front left or right 3

51 48... Removing and installing/replacing sound insulation in front door, left or right

1 article

• 51 48... Removing and installing/replacing sound insulation in front door, left or right 5

51 43... Removing and installing/replacing trim behind rollover bar on left or right

1 article

• 51 43... Removing and installing/replacing trim behind rollover bar on left or right 2

51 43 010 Removing and installing/replacing rear left or right upper side trim section

1 article

• 51 43 010 Removing and installing/replacing rear left or right upper side trim section 4

51 43 015 Removing and installing/replacing rear left or right lower side trim section

1 article

• 51 43 015 Removing and installing/replacing rear left or right lower side trim section 2

51 43 030 Removing and installing/replacing cover on front left or right rollover protection bar

1 article

• 51 43 030 Removing and installing/replacing cover on front left or right rollover protection bar 3

51 43 031 Removing and installing/replacing cover on rear left or right rollover protection bar

1 article

• 51 43 031 Removing and installing/replacing cover on rear left or right rollover protection bar 2

51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left

1 article

• 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left 3

51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right

1 article

• 51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right 2

51 43 080 Removing and installing/replacing deflector for roofliner

1 article

• 51 43 080 Removing and installing/replacing deflector for roofliner 1

51 43 201 Removing and installing or replacing trim for front left or right roof pillar

1 article

• 51 43 201 Removing and installing or replacing trim for front left or right roof pillar 1

51 44 150 Replacing trim for front roofliner

1 article

• 51 44 150 Replacing trim for front roofliner 2

51 45... Removing and installing/replacing radio cutout trim

1 article

• 51 45... Removing and installing/replacing radio cutout trim 1

51 45 030 Removing and installing instrument panel trim

1 article

• 51 45 030 Removing and installing instrument panel trim 9

51 45 031 Replacing instrument panel trim

1 article

• 51 45 031 Replacing instrument panel trim 8

51 45 181 Removing and installing/replacing trim for instrument panel, bottom right

1 article

• 51 45 181 Removing and installing/replacing trim for instrument panel, bottom right 1

51 45 185 Removing and installing/replacing trim for pedal assembly

1 article

• 51 45 185 Removing and installing/replacing trim for pedal assembly 1

51 46 050 Removing and installing/replacing top trim on tail panel

1 article

• 51 46 050 Removing and installing/replacing top trim on tail panel 3

51 47 000 Removing and installing/replacing front (inside) left or right entrance cover strip

1 article

• 51 47 000 Removing and installing/replacing front (inside) left or right entrance cover strip 2

51 47 065 Removing and installing/replacing finishing strip at front left or right entrance

1 article

• 51 47 065 Removing and installing/replacing finishing strip at front left or right entrance 2

51 47 101 Removing and installing/replacing luggage compartment floor trim(s)

1 article

• 51 47 101 Removing and installing/replacing luggage compartment floor trim(s) 1

51 47 131 Replacing front trim for luggage compartment floor

1 article

• 51 47 131 Replacing front trim for luggage compartment floor 2

51 47 140 Removing and installing/replacing panel for luggage compartment partition

1 article

• 51 47 140 Removing and installing/replacing panel for luggage compartment partition 2

51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim

1 article

• 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim 2

51 47 161 Removing and installing/replacing right trunk wheel arch trim

1 article

• 51 47 161 Removing and installing/replacing right trunk wheel arch trim 1

51 47 490 Removing and installing/replacing front underbody protection

1 article

• 51 47 490 Removing and installing/replacing front underbody protection 6

51 49... Removing and installing/replacing rear lid recessed handle

1 article

• 51 49... Removing and installing/replacing rear lid recessed handle 5

51 71... Removing and installing/replacing rear left or right wheel arch splash guard

1 article

• 51 71... Removing and installing/replacing rear left or right wheel arch splash guard 1

51 71 038 Removing and installing/replacing front left or right wheel arch cover

1 article

• 51 71 038 Removing and installing/replacing front left or right wheel arch cover 1

51 71 041 Removing and installing/replacing rear left or right wheel arch cover

1 article

• 51 71 041 Removing and installing/replacing rear left or right wheel arch cover 2

51 71 371 Removing and installing/replacing tension strut on left or right spring strut dome

1 article

• 51 71 371 Removing and installing/replacing tension strut on left or right spring strut dome 1

51 71 374 Removing and installing/replacing reinforcement plate on front axle support

1 article

• 51 71 374 Removing and installing/replacing reinforcement plate on front axle support 1

51 71 390 Removing and installing/replacing reinforcement plate on rear axle

1 article

• 51 71 390 Removing and installing/replacing reinforcement plate on rear axle 2

51 71 447 Removing and installing or replacing panel for cover on left or right side member

1 article

• 51 71 447 Removing and installing or replacing panel for cover on left or right side member 3

51 71 482 Removing and installing/replacing left or right tension strut (on rear axle)

1 article

• 51 71 482 Removing and installing/replacing left or right tension strut (on rear axle) 1