Volkswagen Routan I (2008-2012) computer data lines system Wiring diagrams

16 15 19 CAN INT BUS (+) CAN INT BUS (-) LIN BUS A/C HEATER CONTROL BLK WIRE CAN INT BUS (-) (+) CLUSTER COMPUTER DATA LINES SYSTEM DK BLU WIRE FUSE HEATED SEATS MODULE (UNDER DRIVER'S SEAT) HOT W/ RUN RELAY ENERGIZED HTR B(+) DRV RUN RLY OUT HTR B(+) DRV HTR B(+) DRV RUN RLY OUT GROUND LEFT SEAT BACK HEATER LEFT SEAT CUSHION HEATER LIN BUS HTR B(+) DRV LT GRN/BRN WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE MANUAL A/C 3 ZONE AUTOMATIC A/C MANUAL A/C EXCEPT 3 ZONE PNK/YEL WIRE REAR HEATED SEATS CIRCUIT RIGHT BACK CUSHION HEATER RIGHT SEAT BACK HEATER TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/ORG WIRE WHT/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 FUSED B(+) BLK WIRE BRN WIRE CAN INTERIOR BUS (-) MICROPHONE 2 IN (+) CAN INTERIOR BUS + COMMON AUDIO OUT COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/YEL WIRE FUSE GRY/WHT WIRE HANDS FREE MODULE (BEHIND LEFT END OF DASH) HOT AT ALL TIMES INSIDE REARVIEW MIRROR LEFT AUDIO OUT LEFT AUDIO OUTPUT RIGHT AUDIO OUTPUT COMMON AUDIO OUTPUT LT BLU/WHT WIRE LT GRN/DK BLU WIRE LT GRN/DK GRN WIRE MEDIA PORT (UCI) MICROPHONE 1 IN (+) MICROPHONE 1 IN (+) MICROPHONE IN (-) MICROPHONE 2 IN (+) MICROPHONE FEED MICROPHONE FEED SENSOR GROUND GROUND MICROPHONE IN (-) NCA WIRE ORG/GRY WIRE RADIO (BASE) RED WIRE RIGHT AUDIO OUT SENSOR GROUND TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) UCI AUDIO LH IN UCI AUDIO REF UCI AUDIO RH IN UCI DEVICE DETECT UCI EXIT TRANSMIT UCI EXT RECEIVE UCI ID UCI PWR FEED UCI SHLD WHT/GRY WIRE WHT/ORG WIRE YEL WIRE

BLK WIRE BLK/LT GRN WIRE BRN WIRE COMPUTER DATA LINES SYSTEM FUSE GRY WIRE HOT AT ALL TIMES IGN SW OUT (RUN-ACC) GROUND LT BLU WIRE LT GRN WIRE ORG/ WIRE ORG/LT BLU WIRE ORG/TAN WIRE ORG/YEL WIRE PNK CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) WIRE RED WIRE SUNROOF CLOSE SWITCH SENSE SUNROOF MOTOR/MODULE (SUNROOF ASSEMBLY) SUNROOF OPEN SWITCH SENSE SUNROOF SUNROOF SW VENT RTN SWITCH SENSE SUNROOF SW RTN SUNROOF SWITCH TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE YEL WIRE

1 2 CAN BUS(-) CAN BUS(+) 1 4 5 6 2 GND FUSED B (+) FUSED B (+) REAR VENT WIND CLOSE REAR VENT WIND OPEN 14 12 1 8 RF MASTER WIND SW (DN) RF MASTER WIND SW (UP) FUSED B(+) FUSED B(+) 4 3 9 6 DOOR LOCK SW MUX DOOR LOCK SW MUX FUSED B(+) DRIVER FRONT DOOR LIN B(+) BLK WIRE BREAKOUT) DOOR LOCKS SYSTEM CIRCUIT BREAKER 1 COMPUTER DATA LINES SYSTEM DK BLU/PNK WIRE DK GRN/RED WIRE DRIVER DOOR MODULE (DRIVER FRONT DOOR) DRIVER FRONT DOOR LIN DRIVER RIGHT REAR WINDOW MOTOR VENT MOTOR (LEFT (RIGHT "D" PILLAR) FRONT DOOR) DRIVER WINDOW/DOOR LOCK SWITCH DRV DOOR SW LOCK SW MUX RETURN ELECTRONICS EXCEPT REAR WINDOW VENT FRONT PASSENGER WINDOW MOTOR (FRONT PASSENGER'S DOOR) FUSE HOT AT ALL TIMES LEFT REAR POWER WINDOW SWITCH (MEMORY W/O POWER SLIDING DOORS) LEFT REAR VENT MOTOR (LEFT "D" PILLAR) LEFT REAR WINDOW MOTOR (LEFT REAR DOOR) LT GRN/LT BLU WIRE LT GRN/TAN WIRE ORG/BRN WIRE ORG/DK BLU WIRE ORG/GRY WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/TAN WIRE ORG/VIO WIRE ORG/WHT WIRE PASSENGER WINDOW/DOOR LOCK SWITCH PNK/YEL WIRE REAR WINDOW VENT REAR WINDOW VENT SWITCH RIGHT DOOR LOCK SW MUX RIGHT REAR POWER WINDOW SWITCH (MEMORY W/O POWER SLIDING DOORS) RIGHT REAR WINDOW MOTOR (RIGHT REAR DOOR) RUN/ ACCESSORY RELAY RUN/ ACCESSORY RELAY CTRL TAN/LT BLU WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/DK GRN WIRE VIO/LT GRN WIRE WHT/GRY WIRE WHT/ORG WIRE

1 2 10 DRIVER FRONT DOOR LIN WIND SW SNS RTN DRIVE DOOR COURTESY LAMP 2 1 5 4 CAN INT BUS (+) CAN INT BUS (-) FUSE B(+) GND 2 1 LR WINDOW DRIVER (DN) LR WINDOW DRIVER (UP) 2 1 RR WINDOW DRIVER (DN) RR WINDOW DRIVER (UP) 2 3 1 PWR SLID DOOR MUX RTN PWR WINDOW SW FEED SW ILLUMINATION 2 3 1 WIND SW SNS RTN DRIVE LIN BUS FUSED B(+) 4 5 1 6 2 FUSED B (+) FUSED B (+) GND REAR VENT WIND CLOSE REAR VENT WIND OPEN 5 1 2 4 FUSED B (+) CAN BUS (+) CAN BUS (-) GND 5 8 GND FUSED B(+) 8 5 9 10 FUSED B(+) GND LR WINDOW DRIVER (UP) LR WINDOW DRIVER (DN) 9 10 LR WINDOW DRIVER (UP) LR WINDOW DRIVER (DN) BLK WIRE BLK/LT GRN WIRE BLK/ORG WIRE CIRCUIT BREAKER 1 COMPUTER DATA LINES SYSTEM DK BLU/PNK WIRE DK GRN/RED WIRE DOOR COURTESY LAMP DOOR LOCKS SYSTEM DRIVER DOOR MODULE (DRIVER FRONT DOOR) DRIVER WINDOW MOTOR (LEFT FRONT DOOR) DRIVER WINDOW/ DOOR LOCK SWITCH FRONT PASSENGER WINDOW MOTOR (FRONT PASSENGER'S DOOR) FUSE FUSE FUSE HOT AT ALL TIMES LEFT COURTESY LAMP LEFT REAR DOOR MODULE (LEFT REAR DOOR) LEFT REAR POWER WINDOW SWITCH LEFT REAR VENT MOTOR (LEFT "D" PILLAR) LEFT REAR WINDOW MOTOR (LEFT REAR DOOR) LT GRN/LT BLU WIRE LT GRN/WHT WIRE ORG/ WIRE ORG/BRN WIRE ORG/DK BLU WIRE ORG/GRY WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/TAN WIRE ORG/VIO WIRE ORG/WHT WIRE PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PASSENGER WINDOW/DOOR LOCK SWITCH PNK/YEL WIRE REAR WINDOW VENT SWITCH RED/LT BLU WIRE RED/LT GRN WIRE RED/ORG WIRE RIGHT COURTESY LAMP RIGHT REAR DOOR MODULE (RIGHT REAR DOOR) RIGHT REAR POWER WINDOW SWITCH RIGHT REAR VENT MOTOR (RIGHT "D" PILLAR) RIGHT REAR WINDOW MOTOR (RIGHT REAR DOOR) RUN/ ACCESSORY RELAY RUN/ ACCESSORY RELAY CTRL ELECTRONICS TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/ORG WIRE WHT/GRY WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE

1 2 3 4 5 6 7 8 9 10 LEFT AUDIO OUTPUT RIGHT AUDIO OUTPUT 1 2 ANT SIG ANT SHLD 1 2 SATELLITE ANT SIG 1 SATELLITE ANT SHLD 1 AUDIO SATELLITE ANTENNA BLK WIRE COMMON AUDIO OUT COMPUTER DATA LINES SYSTEM DK GRN WIRE DK GRN/BRN WIRE DK GRN/GRY WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/YEL WIRE FUSE GRY/VIO WIRE GRY/YEL WIRE HANDS FREE MODULE CIRCUIT HOT AT ALL TIMES LEFT FRONT DOOR SPEAKER LEFT INSTRUMENT PANEL SPEAKER LEFT REAR SPEAKER LR SPKR (+) LR SPKR (-) RR SPKR (+) RR SPKR (-) GROUND CAN INTERIOR BUS (+) RADIO RADIO ANTENNA RF SPKR (+) RF SPKR (-) LF SPKR (+) LF SPKR (-) RIGHT FRONT DOOR SPEAKER RIGHT INSTRUMENT PANEL SPEAKER RIGHT REAR SPEAKER SHLD SHLD 1 SIG SIG (1) TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/GRY WIRE YEL/RED WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 VDO-AUDIO RETURN 3 1 2 3 4 5 6 7 8 9 10 MICROPHONE 2 IN (+) MICROPHONE 1 IN (+) 1 2 ANT SIG ANT SHLD 2 1 SATELLITE ANT SHLD 1 SATELLITE ANT SIG 1 BLK WIRE BLK/LT GRN WIRE CAN INTERIOR BUS + COMPUTER DATA LINES SYSTEM DK GRN/BRN WIRE DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/TAN WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE EXCEPT 3 ZONE EXCEPT HANDS FREE FUSE FUSED B (+) GROUND GRY/BRN WIRE GRY/DK BLU WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/WHT WIRE GRY/YEL WIRE HANDS FREE HOT AT ALL TIMES LT BLU/DK GRN WIRE LT BLU/WHT WIRE LT GRN/DK BLU WIRE MICROPHONE FEED MICROPHONE IN (-) SENS GND NAVIGATION SYSTEM NCA WIRE ORG/GRY WIRE POWER DISTRIBUTION SYSTEM RADIO RADIO ANTENNA RED WIRE SATELLITE ANT SHLD 2 SATELLITE ANT SIG 2 SATELLITE ANTENNA 1 SATELLITE ANTENNA 2 SHLD SIG TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VDO-AUDIO LEFT 1 VDO-AUDIO LEFT 1 VDO-AUDIO RETURN 1 VDO-AUDIO RIGHT 1 VDO-AUDIO LEFT 2 VDO-AUDIO LEFT 2 VDO-AUDIO LEFT 3 VDO-AUDIO RETURN 1 VDO-AUDIO RETURN 2 VDO-AUDIO RETURN 3 VDO-AUDIO RIGHT 1 VDO-AUDIO RIGHT 2 VDO-AUDIO RIGHT 3 VDO-VIDEO COMMON 1 VDO-VIDEO COMMON 2 VDO-VIDEO SHIELD 1 VDO-VIDEO SHIELD 2 VDO-VIDEO SIGNAL 1 VDO-VIDEO SIGNAL 2 VIDEO SCREEN 1 MODULE W/ SATELLITE VIDEO W/ W/O SUNROOF SUNROOF W/O SATELLITE VIDEO W/O SUNROOF WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/RED WIRE

BLK WIRE CAN INTERIOR BUS + COMPUTER DATA LINES SYSTEM DK GRN/DK BLU WIRE DK GRN/LT BLU WIRE DK GRN/ORG WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DK GRN/YEL WIRE FUSED B (+) GROUND GRY WIRE GRY/BRN WIRE GRY/DK BLU WIRE GRY/LT BLU WIRE GRY/ORG WIRE GRY/VIO WIRE GRY/WHT WIRE GRY/YEL WIRE MONITOR/DVD MEDIA SYSTEM NCA WIRE RED WIRE SATELLITE ANT SHLD 1 SATELLITE ANT SHLD 2 SATELLITE ANT SIG 1 SATELLITE ANT SIG 2 SATELLITE AUDIO ANTENNA SATELLITE VIDEO MODULE SDARS AUDIO SIG COM SDARS LH AUDIO SIG SDARS RH AUDIO SIG SDARS VIDEO SHIELD SDARS VIDEO SIG SDARS VIDEO SIG COM SHLD 1 SIG (1) VDO-AUDIO LEFT 4 VDO-AUDIO RETURN 4 VDO-AUDIO RIGHT 4 VDO-VIDEO COMMON 4 VDO-VIDEO SHIELD 4 VDO-VIDEO SIGNAL 4 VIDEO SCREEN 1 MODULE VIDEO SCREEN 3 MODULE W/ SATELLITE RADIO W/ SUNROOF W/O SUNROOF WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/TAN WIRE YEL/RED WIRE

7 8 9 10 11 12 13 14 CAN INT BUS (+) FUSED B (+) BLK WIRE BRN WIRE COMPUTER DATA LINES SYSTEM DK BLU WIRE DK BLU/GRY WIRE DK BLU/ORG WIRE DK GRN WIRE FUSE GROUND R SEAT LATCH SW SNS SEAT LATCH SW RTN L SEAT LATCH SW SNS GRY WIRE GRY/BLK WIRE GRY/DK BLU WIRE GRY/LT GRN WIRE GRY/ORG WIRE GRY/RED WIRE GRY/WHT WIRE HOT AT ALL TIMES L DRV UNLATCH R DRV UNLATCH CAN INT BUS (-) DRV SEAT LATCH L SEAT BACK MTR FRWD L SEAT BACK MTR RRWD L SEAT MTR UPSTOW DRV L SEAT MTR STOW DRV R SEAT MTR UPSTOW DRV R SEAT DRV MTR LEFT POWER REAR FOLDING SEAT BACK MOTOR LEFT POWER REAR FOLDING SEAT LATCH (REAR OF LEFT LEFT POWER REAR FOLDING SEAT LATCH SWITCH 1 (LEFT SEAT ASSEMBLY) LEFT POWER REAR FOLDING SEAT LATCH SWITCH 2 (LEFT SEAT ASSEMBLY) LEFT POWER REAR FOLDING SEAT RECLINER SWITCH LEFT POWER REAR FOLDING SEAT STOW MOTOR LT BLU WIRE LT GRN WIRE LT GRN/BRN WIRE LT GRN/DK BLU WIRE LT GRN/GRY WIRE LT GRN/ORG WIRE LT GRN/TAN WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MTR FRWD MTR RRWD ORG/ WIRE PNK 2 1 3 SW RTN SW MUX SW SPLY WIRE PNK 3 1 2 SW RTN SW MUX SW SPLY WIRE POSI SENS POWER FOLDING SEAT SWITCH POWER REAR FOLDING SEAT MODULE RED WIRE RIGHT POWER REAR FOLDING SEAT BACK MOTOR RIGHT POWER REAR FOLDING SEAT LATCH (REAR OF RIGHT RIGHT POWER REAR FOLDING SEAT LATCH SWITCH 1 (RIGHT SEAT ASSEMBLY) RIGHT POWER REAR FOLDING SEAT LATCH SWITCH 2 (RIGHT SEAT ASSEMBLY) RIGHT POWER REAR FOLDING SEAT RECLINER SWITCH RIGHT POWER REAR FOLDING SEAT STOW MOTOR ROW SEAT) RRWD DRV FRWD DRV BACK POSI SENS RTN SENS RTN SENS SPLY UNSTOW DRV MTR DRV STOW DRV SW MUX SW RTN SW RTN SW RTN SW RTN SW SNS SW SIG SW SNS SW RTN TAN WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) UNSTOW DRV VIO WIRE VIO/PNK WIRE WHT WIRE WHT/BLK WIRE YEL WIRE YEL/BLK WIRE YEL/LT BLU WIRE

16 15 19 CAN INT BUS (+) CAN INT BUS (-) LIN BUS BLK WIRE BLK/YEL WIRE CAN INT BUS (-) (+) CLUSTER COMPUTER DATA LINES SYSTEM DK BLU WIRE DRV HI IND DRV LO IND FUSE FUSE FUSE FUSED B (+) GROUND HEATED SEATS MODULE (UNDER DRIVER'S SEAT) HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED LEFT REAR DOOR MODULE (LEFT REAR DOOR) LEFT REAR HEATED SEAT SWITCH LIN BUS RUN RLY OUT RUN RLY OUT HTR B(+) DRV HTR B(+) DRV GROUND LT GRN WIRE LT GRN/GRY WIRE LT GRN/LT BLU WIRE LT GRN/ORG WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE PANEL LAMP DRV PILLAR) PNK/YEL WIRE RIGHT REAR DOOR MODULE (RIGHT REAR DOOR) RIGHT REAR HEATED SEAT SWITCH SEAT BACK HEATER SEAT CUSHION HEATER SW IND FEED SW SNS TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/ORG WIRE WHT/RED WIRE