Volkswagen Routan I (2008-2012) computer data lines system Wiring diagrams

ADJUSTABLE PEDALS MOTOR (UNDER LEFT SIDE OF DASH) ADJUSTABLE PEDALS SWITCH BLK WIRE CAN C BUS (+) COMPUTER DATA LINES SYSTEM ELECTRONICS FRWD MTR FUSED B (+) GROUND HOT AT ALL TIMES LT GRN/LT BLU WIRE LT GRN/WHT WIRE RED/ORG WIRE RRWD MTR TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) WHT/BRN WIRE WHT/LT BLU WIRE

AUTO DAY/ NIGHT MIRR (+) AUTO DAY/NIGHT MIRR (-) BACKUP LAMP RELAY BACKUP LAMP SW OUT BLK WIRE BLK/YEL WIRE CAN INTR BUS (+) COMPUTER DATA LINES SYSTEM DK GRN/LT BLU WIRE DK GRN/YEL WIRE DRIVER DOOR MODULE (IN DRIVER DOOR) EXCEPT BASE FUSE FUSED IGN SW OUT HANDS FREE MODULE (BEHIND LEFT END OF DASH) HOT W/ RUN/ START RELAY ENERGIZED INSIDE REARVIEW MIRROR LT BLU/WHT WIRE LT GRN/DK BLU WIRE LT GRN/DK GRN WIRE MICROPHONE 1 IN (+) MICROPHONE 2 IN (+) MICROPHONE FEED MICROPHONE IN (-) NIGHT MIRR (-) AUTO DAY/ ORG/GRY WIRE PNK/LT GRN WIRE RADIO SENS GND SENSOR GROUND TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) W/ NAVIGATION W/ RAIN SENSE W/O NAVIGATION WHT/GRY WIRE WHT/LT GRN WIRE WHT/ORG WIRE

1 8 FUSED B(+) GND 2 1 GND LIFTGATE AJAR SW SNS 3 4 DRV DR AJAR SW SNS GND 3 4 PASS DR AJAR SW SEN GND 4 3 GND LH SLIDING DR AJAR SW SNS 4 3 GND RH SLIDING DR AJAR SW SNS B(+) BLK WIRE BLK/ORG WIRE BUS - CAN INTERIOR CLUSTER COMPASS COMPUTER DATA LINES SYSTEM DRIVER 1 OVERHEAD HALO LAMP DRIVER 2 OVERHEAD HALO LAMP DRIVER DOOR LATCH (REAR OF DRIVER'S DOOR) DRV DR AJAR ELECTRONICS FRONT PASSENGER DOOR LATCH (REAR OF FRONT PASSENGER'S DOOR) FUSE GRY WIRE HEADLAMP SWITCH HOT AT ALL TIMES INTERIOR LAMPS DRV LEFT REAR DOOR LATCH (LEFT REAR DOOR) LEFT REAR DOOR MODULE (LEFT REAR DOORS) LH SLIDING DR AJAR SW SNS LIFTGATE AJAR LIFTGATE AJAR SW SNS LIFTGATE DOOR LATCH (LOWER CENTER OF LIFTGATE) ORG/BRN WIRE PANEL LAMPS DIMMER SIGNAL PASS DR AJAR PASSENGER 1 OVERHEAD HALO LAMP PASSENGER 2 OVERHEAD HALO LAMP POWER LIFTGATE MODULE (MOUNTED ON LEFT "D" PILLAR) RED WIRE RH SLIDING DR AJAR SW SNS RIGHT REAR DOOR LATCH RIGHT REAR DOOR MODULE (RIGHT REAR DOOR) SW SNS TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ SUNROOF W/O POWER LIFTGATE W/O SUNROOF WHT/GRY WIRE WHT/ORG WIRE YEL/BLU WIRE YEL/LT BLU WIRE YEL/TAN WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 FUSED B(+) PANEL LAMPS DRIVER 12 11 1 RH SLIDING DR AJAR SW SNS CAN INT BUS - CAN INT BUS + 2 1 GND LIFTGATE AJAR SW SNS 21 17 18 LIFTGATE AJAR SW SNS CAN INT BUS - CAN INT BUS + 3 4 ESP ON/OFF SNS GND 4 3 GND LH SLIDING DR AJAR SW SNS 4 3 GND RH SLIDING DR AJAR SW SNS ANALOG CLOCK MODULE B(+) BANK 1 SWITCH BLK WIRE BLK/ORG WIRE BREAKOUT) BUS (-) CAN C BUS - CAN C BUS (+) CAN INTERIOR CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) CLUSTER COMPUTER DATA LINES SYSTEM COURTESY LAMPS DRIVER DK BLU/WHT WIRE DK GRN/VIO WIRE DK GRN/WHT WIRE DOOR LOCKS SYSTEM DRIVER DOOR LATCH (REAR OF DRIVER'S DOOR) DRV DR AJAR DRV DR AJAR SW SNS ELECTRONICS EOP SIG ESP ON/OFF SNS FRONT PASSENGER DOOR LATCH (REAR OF FRONT PASSENGER'S DOOR) FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) FUSED IGN SW OUT (RUN-START) FUSED B(+) GROUND GROUND GROUND GRY WIRE GRY/ORG WIRE GRY/WHT WIRE HEADLAMP SW MUX PANEL LAMPS DIMMER SIG HEADLAMP SW MUX RTN HEADLIGHTS SYSTEM INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM HOT AT ALL TIMES HOT W/ RUN RELAY ENERGIZED HOT W/ RUN/ START RELAY ENERGIZED INTERIOR LAMPS DRIVER HEADLAMP SW SIG INTERIOR LIGHTS SYSTEM COMPUTER DATA INTERIOR LIGHTS SYSTEM HEADLIGHTS SYSTEM LEFT REAR DOOR LATCH (LEFT REAR DOOR) LEFT REAR DOOR MODULE (LEFT REAR DOORS) LH SLIDING DR AJAR SW SNS LH SLIDING DR AJAR SW SNS CAN INT BUS - CAN INT BUS + 12 11 1 LIFTGATE AJAR LIFTGATE AJAR SW SNS LIFTGATE DOOR LATCH (LOWER CENTER OF LIFTGATE) LIN BUS GND SW OUT (RUN) LINES SYSTEM LT GRN/TAN WIRE MODULE (LEFT SIDE OF ENGINE COMPT) OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/GRY WIRE ORG/VIO WIRE PANEL LAMPS DRV PARK BRAKE PARKING BRAKE SWITCH (BEHIND LEFT SIDE OF DASH) PASS DR AJAR PASS DR AJAR SW SNS PNK/LT GRN WIRE PNK/YEL WIRE POWER LIFTGATE MODULE (MOUNTED ON LEFT "D" PILLAR) POWER SLIDING DOOR LOCKOUT SNS PARK BRAKE SW SNS POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RADIO CONTROL MUX HORN SW SNS RADIO CONTROL MUX RTN RED WIRE RH SLIDING DR AJAR SW SNS RIGHT REAR DOOR LATCH (RIGHT REAR DOOR) RIGHT REAR DOOR MODULE (RIGHT REAR DOORS) SENS RTN SENS SIG FUEL LVL SOUND SYSTEMS SOUND SYSTEMS HORNS SYSTEM SW SNS TOTALLY INTEGRATED POWER TRUNK, TAILGATE, FUEL DOORS SYSTEM TRUNK, TAILGATE, FUEL DOORS SYSTEM INTERIOR LIGHTS SYSTEM UGDO ENABLE CONTROL LIN BUS VIO WIRE VIO/DK BLU WIRE VIO/GRY WIRE VIO/WHT WIRE VIO/YEL WIRE W/ COMPASS W/O POWER LIFTGATE WHT WIRE WHT/BLK WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE WHT/YEL WIRE YEL/LT BLU WIRE YEL/TAN WIRE YEL/VIO WIRE YEL/WHT WIRE

1 6 2 8 FUSED B(+) FUSED B(+) PANEL LAMPS DRV GND 15 16 10 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) PANEL LAMPS DIMMER SIG 2 1 PANEL LAMPS DRV GND 2 4 5 PANEL LAMPS DIMMER SIG PANEL LAMPS DRV GND 3 2 PANEL LAMPS DRV GND 3 ZONE MANUAL A/C 4 3 PANEL LAMPS DRV GND 4 5 PANEL LAMPS DRV GND 7 4 PANEL LAMPS DRV GND 7 9 17 9 PANEL LAMPS DRV GND A/C HEATER CONTROL ANALOG CLOCK MODULE B(+) BANK 1 SWITCH BANK 2 SWITCH BLK WIRE BUS - CAN INTERIOR CAN INTERIOR BUS + CENTER CONSOLE LAMP CLUSTER COMPASS COMPUTER DATA LINES SYSTEM ELECTRONICS FUSE HEADLAMP SWITCH HOT AT ALL TIMES INVERTER SWITCH MANUAL A/C AUTOMATIC A/C OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/GRY WIRE PANEL LAMPS DRV REAR BLOWER CONTROL SWITCH RED WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) W/ CENTER CONSOLE LAMP W/O CENTER CONSOLE LAMP WHT/GRY WIRE WHT/ORG WIRE

1 2 3 4 5 6 7 8 9 10 11 12 13 FORWARD MOTOR REARWARD MOTOR 1 2 3 4 5 6 RECLINER SENS GND RECLINER UP DRV 1 2 3 4 5 6 SW MUX RTN VER/HORIZ SW MUX VER/RECLINER SW MUX 1 3 5 FORWARD SW REARWARD SW GROUND 1 4 11 SW MUX RTN VER/HORIZ SW MUX VER/RECLINER SW MUX 8 9 10 11 12 13 14 HORIZ FORWARD DRV HORIZ REARWARD DRV R VER DN DRV ADJUSTABLE PEDALS MOTOR (UNDER LEFT SIDE OF DASH) BLK WIRE BLK/ORG WIRE CAN INT BUS (+) FUSED B (+) SENS SPLY GROUND CAN INT BUS (-) (+) CIRCUIT BREAKER COMPUTER DATA LINES SYSTEM DRIVER SEAT FRONT VERTICAL ADJUSTER MOTOR (DRIVER'S SEAT) DRIVER SEAT HORIZONTAL ADJUSTER MOTOR (DRIVER'S SEAT) DRIVER SEAT REAR VERTICAL ADJUSTER MOTOR (DRIVER'S SEAT) DRIVER SEAT RECLINER ADJUSTER MOTOR (DRIVER'S SEAT) DRIVER SEAT SWITCH FUSE HOT AT ALL TIMES LT BLU WIRE LT GRN WIRE LT GRN/BLK WIRE LT GRN/BRN WIRE LT GRN/DK GRN WIRE LT GRN/LT BLU WIRE LT GRN/VIO WIRE LT GRN/WHT WIRE LT GRN/YEL WIRE MEMORY PEDALS SWITCH MEMORY SEAT MODULE (UNDER DRIVER'S SEAT) MEMORY SET SWITCH ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/RED WIRE ORG/VIO WIRE PNK/YEL WIRE R VER UP DRV F VER DN DRV F VER UP DRV RECLINER DN DRV RECLINER POSITION SENS RED WIRE SENS RTN SENS SIG SW FORWARD SW REARWARD SW MUX SW RTN SW SPLY TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO/BRN WIRE VIO/DK BLU WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/GRY WIRE WHT/ORG WIRE YEL/VIO WIRE

1 2 3 4 5 6 7 8 9 10 11 12 FUSED IGN SW OUT (RUN) PARK ASSIST DISPLAY SPLY 1 2 3 DISPLAY SPLY DISPLAY GND DISPLAY SIG BLK/RED WIRE CAN INTERIOR BUS + COMPUTER DATA LINES SYSTEM DK GRN/GRY WIRE FUSE GRY/DK GRN WIRE GRY/LT BLU WIRE GRY/ORG WIRE HOT W/ RUN RELAY ENERGIZED PARK ASSIST DISPLAY PARK ASSIST DISPLAY GND GND CAN INTERIOR BUS (-) PARK ASSIST DISPLAY SIG PARK ASSIST MODULE (BEHIND RIGHT QUARTERPANEL) PARK SENSOR 10 (W/ MEMORY) (REAR FASCIA) PARK SENSOR 11 (W/ MEMORY) (REAR FASCIA) PARK SENSOR 8 (W/ MEMORY) (REAR FASCIA) PARK SENSOR 9 (W/ MEMORY) (REAR FASCIA) PNK/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) WHT WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/ORG WIRE YEL PNK/ WIRE

1 2 3 4 DRV DR UNLCK DRV DRV DR LCK DRV DRV DR AJAR SW SNS GND 1 2 3 4 LR DR UNLCK DRV LR DR LCK DRV LH SLIDING DR AJAR SW SNS GND 1 2 3 4 LR DR UNLCK DRV LR DR LCK DRV LR DR LCK SNS LH PWR SLIDING DR MUX RTN 1 2 3 4 PASS DR UNLCK DRV PASS DR LCK DRV PASS DR AJAR SW SEN GND 1 2 3 LIFTGATE LCK DRV 1 2 LH CINCH/RELEASE MTR UNLATCH DRV LH CINCH/RELEASE MTR LATCH DRV 18 15 SW ILLUMINATION DRV LH PWR SLIDING DR MUX RTN 2 1 GND LIFTGATE AJAR SW SNS 2 1 LH PWR SLIDING DR MUX RTN SW ILLUMINATION DRV 21 18 17 LIFTGATE AJAR SW SNS CAN INTERIOR BUS (+) CAN INTERIOR BUS (-) 7 3 16 LH PWR SLIDING DR MUX RTN LH DR IN/OUT HANDLE SW SNS LH DR SECTOR SW SNS 7 6 LH CINCH/RELEASE MTR UNLATCH DRV LH CINCH/RELEASE MTR LATCH DRV AMBIENT AIR TEMPERATURE SENSOR (BEHIND CENTER OF FRONT FASCIA) BLK WIRE COMPUTER DATA LINES SYSTEM DOOR LOCK RELAY DOOR UNLOCK 1 RELAY DOOR UNLOCK 2 RELAY DR UNLK RLY 2 CTRL DRIVER DOOR LATCH (REAR OF DRIVER'S DOOR) DRV DR DR LOCK AJAR SW RLY SNS CTRL ELECTRONICS DR UNLK RLY 1 CTRL EXPRESS FRONT PASSENGER DOOR LATCH (REAR OF FRONT PASSENGER'S DOOR) FRONT WASHER FLUID LEVEL SENSOR (IN WASHER FLUID RESERVOIR) FUSE FUSE FUSE FUSED B (+) GRY/LT BLU WIRE GRY/YEL WIRE HOOD AJAR HOOD AJAR SWITCH (LEFT SIDE OF ENGINE COMPT) HORN RELAY HORN SW RLY SNS CTRL HORNS SYSTEM HOT AT ALL TIMES LEFT AJAR SW SNS LEFT REAR DOOR LATCH (W/ POWER SLIDING DOOR) (LEFT REAR DOOR) LEFT REAR DOOR LATCH (W/O POWER SLIDING DOOR) LEFT REAR DOOR MODULE (W/ POWER SLIDING DOOR) (LEFT REAR DOORS) LEFT REAR POWER WINDOW SWITCH (W/ POWER SLIDING DOOR) LEFT SLIDING DR AJAR SW SENS SNS LIFTGATE AJAR SW SNS LIFTGATE DOOR LATCH (LOWER CENTER OF LIFTGATE) LIFTGATE UNLCK DRV LT GRN/DK BLU WIRE LT GRN/GRY WIRE LT GRN/LT BLU WIRE ORG/BRN WIRE ORG/GRY WIRE ORG/LT BLU WIRE ORG/LT GRN WIRE ORG/YEL WIRE PASS DR AJAR SW SNS POWER LIFTGATE MODULE (MOUNTED ON LEFT "D" PILLAR) POWER MODULE (LEFT SIDE OF ENGINE COMPT) SENS GND TAN/BRN WIRE TAN/DK BLU WIRE TAN/GRY WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TOTALLY INTEGRATED VIO WIRE VIO/BRN WIRE VIO/GRY WIRE VIO/LT BLU WIRE VIO/WHT WIRE W/ POWER LIFTGATE W/O POWER LIFTGATE WHT WIRE WHT/GRY WIRE WHT/ORG WIRE WHT/RED WIRE

1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RH SLIDING DR AJAR SW SNS GND 1 2 3 4 RR DR LCK DRV RR DR UNLCK DRV RR DR LCK SNS RH PWR SLIDING DR MUX RTN 1 2 CAN INTERIOR BUS (-) CAN INTERIOR BUS (+) 1 2 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV 1 4 LH SLIDING DR PILLAR SW MUX SW RTN 1 4 RH SLIDING DR PILLAR SW MUX SW RTN 2 1 RH PWR SLIDING DR MUX RTN SW ILLUMINATION DRV 7 3 16 RH PWR SLIDING DR MUX RTN RH DR IN/OUT HANDLE SW SNS RH DR SECTOR SW SNS 7 4 PASS SW RTN PASS DR LCK SW MUX 7 6 RH CINCH/RELEASE MTR UNLATCH DRV RH CINCH/RELEASE MTR LATCH DRV B(+) BASE BASE EXCEPT BASE BLK WIRE BRAKE FLUID LEVEL SENSOR (BRAKE FLUID RESERVOIR) BRAKE LP SW BRAKE SIG 1 BRN/YEL WIRE CAN INTERIOR BUS + COMPUTER DATA LINES SYSTEM DK GRN WIRE DRIVER DOOR MODULE (IN DRIVER FRONT DOOR) DRIVER WINDOW/ DOOR LOCK SWITCH DRV DR LCK SW MUX DRV DR LCK SW MUX LIN BUS ELECTRONICS FUEL PUMP MODULE (UNDER REAR OF VEHICLE) FUSE FUSED B (+) HOT AT ALL TIMES IGN SW, RUN/ START LEFT B-PILLAR SWITCH (LEFT "B" PILLAR) LEFT FRONT TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT FRONT OF ENGINE COMPT) LEFT REAR TIRE PRESSURE TRANSPONDER (IF EQUIPPED) (LEFT REAR WHEELWELL) LF TURN SIG CTRL LH SLIDING DR LIN BUS LR TURN SIG CTRL LT BLU/RED WIRE LT GRN/LT BLU WIRE LT GRN/TAN WIRE LT GRN/WHT WIRE MONITOR LAN OCCUPANT RESTRAINT CONTROLLER MODULE ORG/BRN WIRE ORG/DK GRN WIRE ORG/GRY WIRE ORG/YEL WIRE PASS DR LCK SW MUX PASS SW RTN PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PASSENGER WINDOW/ DOOR LOCK SWITCH PILLAR SW MUX PNK/WHT WIRE POWERTRAIN CONTROL MODULE (LEFT SIDE OF ENGINE COMPT) RED/ORG WIRE RF TURN SIG CTRL RH SLIDING DR RIGHT B-PILLAR SWITCH (RIGHT "B" PILLAR) RIGHT REAR DOOR LATCH (W/ POWER SLIDING DOOR) (RIGHT REAR DOOR) RIGHT REAR DOOR LATCH (W/O POWER SLIDING DOOR) RIGHT REAR DOOR MODULE (W/ POWER SLIDING DOOR) (RIGHT REAR DOORS) RIGHT REAR POWER WINDOW SWITCH (W/ POWER SLIDING DOOR) RR SLIDING DR AJ SW RR TURN SIG CTRL SHIFTER LEVER ASSEMBLY (BEHIND LEFT CENTER OF DASH) SOL UNLOCK TRS PRK SIG STOP LAMP SWITCH (AT TOP OF BRAKE PEDAL) SW RTN SW RTN PASS DR LCK SW MUX TAN/DK BLU WIRE TAN/GRY WIRE TAN/LT BLU WIRE TAN/ORG WIRE TAN/WHT WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VIO WIRE VIO/DK GRN WIRE VIO/LT GRN WIRE VIO/ORG WIRE VIO/YEL WIRE WHT/BRN WIRE WHT/DK GRN WIRE WHT/GRY WIRE WHT/LT BLU WIRE WHT/LT GRN WIRE WHT/ORG WIRE WHT/RED WIRE WHT/TAN WIRE WHT/YEL WIRE YEL/DK BLU WIRE

5 4 2 1 FUSED B (+) GROUND CAN BUS (+) CAN BUS (-) BLK WIRE COMM DRV COMPUTER DATA LINES SYSTEM DK BLU WIRE DK GRN/RED WIRE DRIVER DOOR MODULE (DRIVER FRONT DOOR) DRIVER OUTSIDE REARVIEW MIRROR (DRIVER DOOR MIRROR) FUSE GRY/LT GRN WIRE GRY/TAN WIRE HORI DRV HORI POSI SIG HORI POSI SIG SENS GND VER POSI SIG HORI POSI SIG SENS GND VER POSI SIG MIRR RTN MIRR (+) HOT AT ALL TIMES HTR DRV HTR RTN HTR SIG LT BLU/GRY WIRE LT BLU/WHT WIRE LT GRN/DK GRN WIRE LT GRN/GRY WIRE LT GRN/LT BLU WIRE LT GRN/YEL WIRE MIRR MIRR DRV MIRR RTN MIRR SIG PASSENGER DOOR MODULE (PASSENGER FRONT DOOR) PASSENGER OUTSIDE REARVIEW MIRROR (PASSENGER DOOR MIRROR) RED/LT BLU WIRE RED/LT GRN WIRE SENS GND SIG DRV SIG RTN TAN WIRE TAN/DK GRN WIRE TAN/GRY WIRE TAN/LT BLU WIRE TAN/LT GRN WIRE TAN/ORG WIRE TAN/VIO WIRE TAN/WHT WIRE TAN/YEL WIRE TOTALLY INTEGRATED POWER MODULE (LEFT SIDE OF ENGINE COMPT) VER DRV VER POSI SIG WHT/GRY WIRE WHT/ORG WIRE