BUZZERS, RELAYS & TIMERS
| Component | Component Location |
|---|---|
| Coolant Preheating Relay (High Heat Output) (1.9L) | Left rear corner of engine compartment. |
| Coolant Preheating Relay (Low Heat Output) (1.9L) | Left rear corner of engine compartment. |
| Daytime Running Lights Changeover Relay (2) | On thirteenfold auxiliary relay panel. (Схема №4) |
| Dual Horn Relay | On relay panel. (Схема №4) |
| Foglight Relay | On thirteenfold auxiliary relay panel. (Схема №4) |
| Fuel Pump (FP) Relay | On relay panel. (Схема №4) |
| Glow Plug Relay | On thirteenfold auxiliary relay panel. (Схема №4) |
| Load Reduction Relay | On relay panel. (Схема №4) |
| Park/Neutral Position (PNP) Relay | On thirteenfold auxiliary relay panel. (Схема №4) |
| Power Supply Relay | On thirteenfold auxiliary relay panel. (Схема №4) |
| Rear Lid Motor Remote Unlock Relay | On thirteenfold auxiliary relay panel. (Схема №4) |
| Secondary Air Injection (AIR) Pump Relay | At left side of engine compartment, behind air cleaner housing. |
| Starter Locking Relay (Clutch Pedal Switch) | On thirteenfold auxiliary relay panel. (Схема №4) |
| Wiper Washer Intermittent Relay (2) | On relay panel. (Схема №4) |
BUZZERS, RELAYS & TIMERS LOCATION
CIRCUIT PROTECTION DEVICES
| Component | Component Location |
|---|---|
| Fuse/Bracket Battery | Behind battery. |
| Fuse Panel | Behind left side of dash. |
| Relay Panel | Under left side of dash. |
| Thirteenfold Auxiliary Relay Panel | Under left side of dash. |
CIRCUIT PROTECTION DEVICES LOCATION
CONTROL UNITS
| Component | Component Location |
|---|---|
| ABS Control Module | At left side of engine compartment. |
| Air Bag Control Module | Beneath center of dash, on central tunnel. |
| Comfort System Central Control Module | Behind left side of dash. |
| Coolant Fan Control Module | On left front of engine compartment. |
| Diesel Direct Fuel Injection (DFI) Engine Control Module (ECM) (1.9L) | At base of windshield, in center of plenum. (Схема №1) |
| Door Control Module (2-Door) (2) | Integral with window regulator motor, in respective door. |
| Door Control Module (4-Door) (4) | Integral with window regulator motor, in respective door. |
| Motronic Engine Control Module (ECM) (1.8L) | At base of windshield, in center of plenum. |
| Motronic Engine Control Module (ECM) (2.0L) | At base of windshield, in center of plenum. (Схема №2) |
| Motronic Engine Control Module (ECM) (2.8L) | At base of windshield, in center of plenum. (Схема №3) |
| Power Sun Roof Control Module | Behind front interior light. |
| Throttle Valve Control Module (1.8L) | On throttle body. (Схема №5) |
| Throttle Valve Control Module (2.0L) | On throttle body. (Схема №2) |
| Throttle Valve Control Module (2.8L) | On throttle body. (Схема №3) |
| Transmission Control Module (TCM) (1.8L) | At base of windshield, in right side of plenum. (Схема №6) |
| Transmission Control Module (TCM) (1.9L) | At base of windshield, in right side of plenum. (Схема №1) |
| Transmission Control Module (TCM) (2.0L) | At base of windshield, in right side of plenum. (Схема №2) |
| Transmission Control Module (TCM) (2.8L) | At base of windshield, in right side of plenum. (Схема №3) |
CONTROL UNITS LOCATION
MOTORS
| Component | Component Location |
|---|---|
| ABS Hydraulic Pump | Integral with ABS control module. |
| After-Run Coolant Pump (2.8L) | On right rear of cylinder head. (Схема №3) |
| Fresh Air Blower | Behind right side of dash, on HVAC housing. |
| Fresh/Recirculating Air Door Motor | On right corner of HVAC housing. |
| Fuel Pump (FP) | In fuel tank, under rear seat. |
| Fuel Tank Lid Unlock Motor | On right side of luggage compartment, behind carpet. |
| Leak Detection Pump | In right rear wheelhouse, near fuel filler tube. |
| Secondary Air Injection (AIR) Pump Motor (2.0L) | On left rear side of engine. |
| Secondary Air Injection (AIR) Pump Motor (2.8L) | On left side of engine, near generator. |
| Throttle Drive (1.8L) | Integral with throttle valve control module. |
| Throttle Position (TP) Actuator (2.0L) | Integral with throttle valve control module, on throttle body. |
| Throttle Position (TP) Actuator (2.8L) | Integral with throttle valve control module, on throttle body. |
MOTORS LOCATION
SENDING UNITS & SENSORS
| Component | Component Location |
|---|---|
| ABS Wheel Speed Sensor (4) | On respective hub/spindle assembly. |
| Accelerator Pedal Position Sensors 1 & 2 (Late Production 2.0L) | In pedal assembly. |
| Accelerator Pedal Position Sensors 1 & 2 (1.8L) | In pedal assembly. (Схема №15) |
| Accelerator Pedal Position Sensors 1 & 2 (2.8L) | In pedal assembly. |
| Barometric Pressure (BARO) Sensor (1.8L) | In control module housing, in left rear corner of engine compartment. |
| Camshaft Position (CMP) Sensor (1.8L) | On front of cylinder head, behind camshaft timing belt cover. (Схема №7) |
| Camshaft Position (CMP) Sensor (2.0L) | On cylinder head, behind camshaft sprocket. (Схема №2) |
| Camshaft Position (CMP) Sensor (2.8L) | On rear of cylinder head, behind ignition coil. (Схема №3) |
| Engine Coolant Level (ECL) Sensor | On engine coolant reservoir. |
| Engine Coolant Temperature (ECT) Sensor (1.8L) | On rear of cylinder head. (Схема №8) |
| Engine Coolant Temperature (ECT) Sensor (1.9L) | On cylinder head, in coolant flange. (Схема №1) |
| Engine Coolant Temperature (ECT) Sensor (2.0L) | On cylinder head, in coolant flange. (Схема №2) |
| Engine Coolant Temperature (ECT) Sensor (2.8L) | On left rear of cylinder head, on coolant flange. (Схема №3) |
| Engine Oil Temperature Sensor (1.8L) | On left side of engine, on oil filter housing. |
| Engine Speed (RPM) Sensor (1.8L) | On left rear of cylinder block, behind oil filter. (Схема №9) |
| Engine Speed (RPM) Sensor (1.9L) | On left side of engine block, near transmission flange. (Схема №1) |
| Engine Speed (RPM) Sensor (2.0L) | On left side of engine block, near transmission flange. (Схема №2) |
| Engine Speed (RPM) Sensor (2.8L) | On lower left rear of engine, near transmission flange. (Схема №3) |
| Fuel Gauge Sender | In fuel tank. |
| Fuel Temperature Sensor (1.9L) | At left side of engine, on front of diesel DFI pump. (Схема №1) |
| Heated Oxygen Sensor (HO2S) (1.8L) | In catalytic converter inlet, near turbocharger. (Схема №10) |
| Heated Oxygen Sensor (HO2S) (2.0L) | Ahead of three-way catalytic converter. |
| Heated Oxygen Sensor (HO2S) (2.0L) | Behind three-way catalytic converter. |
| Heated Oxygen Sensor (HO2S) (2.8L) | Ahead of three-way catalytic converter. |
| Intake Air Temperature (IAT) Sensor (1.8L) | On intake manifold, behind throttle body. (Схема №11) |
| Intake Air Temperature (IAT) Sensor (1.9L) | Integral to manifold absolute pressure sensor. |
| Intake Air Temperature (IAT) Sensor (2.0L) | Integral to mass airflow sensor. |
| Knock Sensor (KS) No. 1 (1.8L) | On left front of engine block. (Схема №12) |
| Knock Sensor (KS) No. 1 (2.0L) | On left front side of engine block. (Схема №2) |
| Knock Sensor (KS) No. 1 (2.8L) | On lower right side of engine, below exhaust manifold. |
| Knock Sensor (KS) No. 2 (1.8L) | On left rear of engine block. (Схема №13) |
| Knock Sensor (KS) No. 2 (2.0L) | On left side of engine block, behind ignition coil. |
| Knock Sensor (KS) No. 2 (2.8L) | On lower left side of engine, above oil cooler. |
| Manifold Absolute Pressure (MAP) Sensor (1.9L) | Between charge air cooler and intake manifold, in intake air duct. (Схема №1) |
| Mass Airflow (MAF) Sensor (1.8L) | Inside air cleaner housing. |
| Mass Airflow (MAF) Sensor (1.9L) | At right of air cleaner housing, in intake air duct. (Схема №1) |
| Mass Airflow (MAF) Sensor (2.0L) | At right of air cleaner housing, in intake air duct. (Схема №2) |
| Mass Airflow (MAF) Sensor (2.8L) | Between air cleaner housing and throttle body. (Схема №3) |
| Modulating Piston Displacement Sensor (1.9L) | Integral with fuel temperature sensor, on injection pump. |
| Needle Lift Sensor (1.9L) | On left side of cylinder head. (Схема №1) |
| Oxygen Sensor (O2S) (Behind TWC) (1.8L) | Behind catalytic converter. |
| Oxygen Sensor (O2S) Behind TWC (2.0L) | At back of three-way catalytic converter. |
| Oxygen Sensor (O2S) Behind TWC (2.8L) | At back of three-way catalytic converter. |
| Side Air Bag Crash Sensor (Left) | Under driver's seat, beneath carpet. |
| Side Air Bag Crash Sensor (Right) | Under passenger's seat, beneath carpet. |
| Speedometer Vehicle Speed Sensor (VSS) | On right side of transmission, above differential housing. |
| Throttle Drive Angle Sensor 1 (1.8L) | Integral with throttle valve control module. |
| Throttle Drive Angle Sensor 2 (1.8L) | Integral with throttle valve control module. |
| Throttle Position (TP) Sensor (1.9L) | Above accelerator pedal. |
| Throttle Position (TP) Sensor (2) (2.0L) | Integral to throttle valve control module, on throttle body. |
| Throttle Position (TP) Sensor (2) (2.8L) | Integral to throttle valve control module, on throttle body. |
| Transmission Vehicle Speed Sensor (VSS) (A/T) | On top of transmission, near transmission cooler. |
| Vehicle Speed Sensor (A/T) | On top of transmission. |
| Windshield Washer Fluid Level Sensor | On washer fluid reservoir. |
SENDING UNITS & SENSORS LOCATION
SOLENOID & SOLENOID VALVES
| Component | Component Location |
|---|---|
| Cold Start Injector (1.9L) | At left side of engine, on bottom of diesel direct fuel injection pump. |
| EGR Vacuum Regulator Solenoid Valve (1.9L) | On center of firewall. (Схема №1) |
| Evaporative Emission (EVAP) Canister Purge Regulator Valve (1.8L) | Next to engine coolant reservoir. |
| Evaporative Emission (EVAP) Canister Purge Regulator Valve (2.0L) | Next to engine coolant reservoir. (Схема №2) |
| Evaporative Emission (EVAP) Canister Purge Regulator Valve (2.8L) | Next to engine coolant reservoir. (Схема №3) |
| Fuel Cut-Off Valve (1.9L) | At left side of engine, on top of diesel direct fuel injection pump. |
| Intake Manifold Changeover Valve (2.8L) | On left side of engine, above oil filter housing. |
| Intake Manifold Flap Changeover Valve (1.9L) | On intake manifold. |
| Secondary Air Injection (AIR) Solenoid Valve (2.0L) | Above brake fluid reservoir. (Схема №2) |
| Secondary Air Injection (AIR) Solenoid Valve (2.8L) | On left side of engine, above oil cooler housing. |
| Shift Lock Solenoid (A/T) | At base of gear selector, under trim panel. |
| Turbocharger Recirculating Valve (1.8L) | Beneath intake manifold, on bracket. |
| Wastegate By-Pass Regulator Valve (1.8L) | On right front of engine compartment, near camshaft drive belt cover. |
| Wastegate By-Pass Regulator Valve (1.9L) | At left rear side of engine compartment. |
SOLENOID & SOLENOID VALVES LOCATION
SWITCHES
| Component | Component Location |
|---|---|
| A/C Cut-Out Thermal Switch | On main radiator hose "T" fitting, near radiator. |
| A/C Pressure Switch | In right rear corner of engine compartment. |
| Ambient Temperature Switch | On left side of plenum, at base of windshield. |
| Back-Up Light Switch (M/T) | On top of transmission, near starter solenoid. |
| Brake Fluid Level Warning Switch | Integral with brake fluid reservoir cap. |
| Brakelight Switch | Above brake pedal. |
| Brake Vacuum Vent Valve Switch | Integral with brakelight switch, above brake pedal. |
| Closed Throttle Position (CTP) Switch (Early Production 2.0L) | Integral to throttle valve control module, on throttle body. |
| Closed Throttle Position (CTP) Switch (1.9L) | Integral to throttle position sensor, above accelerator pedal. |
| Clutch Pedal Position (CPP) Switch | Above clutch pedal. |
| Clutch Vacuum Vent Valve Switch | Above clutch pedal. |
| Coolant Fan Control (FC) Switch | On bottom left rear of radiator. |
| Kickdown Switch (1.9L) | Integral to throttle position sensor, above accelerator pedal. |
| Kickdown Switch (2.0L) | On left side of firewall, in throttle cable. |
| Luggage Compartment Light Switch | On trunk/liftgate latch mechanism. |
| Multifunction Transmission Range Switch (A/T) | On right side of transmission. |
| Oil Pressure Switch (1.8L) | On oil cooler/oil filter housing. |
| Oil Pressure Switch (1.9L) | On oil filter flange. (Схема №1) |
| Oil Pressure Switch (2.0L) | On oil filter flange. (Схема №2) |
| Oil Pressure Switch (2.8L) | On oil filter flange. |
| Trunk Lock Alarm/Central Locking Switch | On liftgate/trunk lock cylinder. |
SWITCHES LOCATION
MISCELLANEOUS
| Component | Component Location |
|---|---|
| Alarm Horn | On left side of plenum, at base of windshield. |
| Data Link Connector (DLC) | Under left side of dash. |
| Fresh Air Blower Series Resistance (W/Fuse) | Behind right side of dash, on fresh air blower. |
| Ignition Coil (1.8L) | Mounted on top of cylinder head, above each respective cylinder. (Схема №14) |
| Ignition Coil (2.0L) | On lower left rear of engine. |
| Ignition Coil (2.8L) | On rear of cylinder head. |
| Positive Crankcase Ventilation (PCV) Heating Element (1.9L) | Between cylinder head cover and intake air duct, in PCV hose. |
| Positive Crankcase Ventilation (PCV) Heating Element (2.0L) | Between cylinder head cover and intake air duct, in PCV hose. (Схема №2) |
| Positive Crankcase Ventilation (PCV) Heating Element (2.8L) | Between cylinder head cover and intake air duct, in PCV hose. (Схема №3) |
| Power Output Stage (1.8L) | On right side of engine compartment, on top of air cleaner housing. |
| Quantity Adjuster (1.9L) | Integral with fuel temperature sensor, on injection pump. |
| Seat Belt Tensioner Ignitor (Left) | At base of left "B" pillar, behind trim panel. |
| Seat Belt Tensioner Ignitor (Right) | At base of right "B" pillar, behind trim panel. |
| Side Air Bag Ignitor (Left) | On left side of left front seat back, behind upholstery. |
| Side Air Bag Ignitor (Right) | On right side of right front seat back, behind upholstery. |
MISCELLANEOUS LOCATION
CONNECTORS
| Component | Component Location |
|---|---|
| T1 (1 Pin) | At rear of roof, above headliner. |
| T2A (2 Pin) | At left side of engine compartment, in left wiring duct. |
| T2B (2 Pin) | At left side of engine compartment, in left wiring duct. |
| T2C (2 Pin) | At left side of engine compartment, in left wiring duct. |
| T2 (2 Pin) | At rear of deck lid. |
| T3A (3 Pin) | At lower left front of engine compartment. |
| T3A (3 Pin) | On right front of engine. |
| T3B (3 Pin) | At lower left front of engine compartment. |
| T3B (3 Pin) | On left side of engine. |
| T3 (3 Pin) | On battery cover. |
| T3 (3 Pin) | On left side of engine. |
| T4A (4 Pin) | At lower right rear of engine compartment. |
| T4B (Black, 4 Pin) | At lower right rear of engine compartment. |
| T4C (Brown, 4 Pin) | At lower right rear of engine compartment. |
| T4 (4 Pin) | Near starter motor. |
| T5 (Black, 5 Pin) | At left front of luggage compartment. |
| T5D (Brown, 5 Pin) | At left front of luggage compartment. |
| T6 (Brown, 6 Pin) | At left rear of engine compartment, in protective housing. |
| T6C (6 Pin) | At lower right rear of engine compartment. |
| T10A (10 Pin) | At left side of engine compartment, in left wiring duct. |
| T10D (Green, 10 Pin) | At left rear of engine compartment, in protective housing. |
| T10E (Black, 10 Pin) | At left rear of engine compartment, in protective housing. |
| T10F (10 Pin) | On left side of engine. |
| T10G (Gray, 10 Pin) | At left rear of engine compartment, in protective housing. |
| T10H (Blue, 10 Pin) | At left rear of engine compartment, in protective housing. |
| T10I (Black, 10 Pin) | Behind left kick panel. |
| T10K (Black, 10 Pin) | Behind right kick panel. |
| T10L (Black, 10 Pin) | At left "B" pillar. |
| T10M (Black, 10 Pin) | At right "B" pillar. |
| T10N (Brown, 10 Pin) | Behind left kick panel. |
| T10 (Orange, 10 Pin) | At left rear of engine compartment, in protective housing. |
| T10P (Brown, 10 Pin) | Behind right kick panel. |
| T10Q (Blue, 10 Pin) | Behind left kick panel. |
| T10R (Blue, 10 Pin) | Behind right kick panel. |
| T12 (12 Pin) | At left side of luggage compartment. |
| T12 (12 Pin) | On top of transmission. |
CONNECTORS LOCATION
GROUNDS
| Component | Component Location |
|---|---|
| G12 (1.9L) | On left front of engine compartment. (Схема №1) |
| G12 (2.0L) | On left front of engine compartment. (Схема №2) |
| G12 (2.8L) | On left front of engine compartment. (Схема №3) |
| G42 | Below left side of dash. |
| G43 | Behind right kick panel. |
| G44 | Behind left kick panel. |
| G49 | On top right of steering column. |
| G50 | At left front of luggage compartment. |
| G65 (1.9L) | On left front of engine compartment. (Схема №1) |
| G65 (2.0L) | On left front of engine compartment. (Схема №2) |
| G65 (2.8L) | On left front of engine compartment. (Схема №3) |
| G77 | On base of left "B" pillar. |
| G78 | On base of right "B" pillar. |
| G608 (1.9L) | On left rear of engine compartment. (Схема №1) |
| G608 (2.0L) | On left rear of engine compartment. (Схема №2) |
| G608 (2.8L) | On left rear of engine compartment. (Схема №3) |
| G609 (1.9L) | On right rear of engine compartment. (Схема №1) |
| G609 (2.0L) | On right rear of engine compartment. (Схема №2) |
| G609 (2.8L) | On right rear of engine compartment. (Схема №3) |
GROUNDS LOCATION