Repair manual
Wiring diagrams
Volkswagen Eos I Repair Manual
Step-by-step repair and maintenance instructions for the Volkswagen Eos I (2006–2011): removal, installation, adjustment, diagnostics and parameter checks with illustrations.
78sections
1143articles
ENManual language
- VALVE TIMING, CHECKING
- SETTING THE ENGINE TO TDC USING THE DIAL GAUGE -VAS 6079
- CAMSHAFT AXIAL CLEARANCE, CHECKING
- VALVE GUIDE, CHECKING
- ENGINE COVER
- VACUUM PUMP
- CAMSHAFTS
- VALVE STEM SEALS
- UPPER TIMING CHAIN COVER
- LOWER TIMING CHAIN COVER
- CAMSHAFT TIMING CHAIN
- Removing
- Installing
- INTAKE CAMSHAFT BALANCE SHAFT
- EXHAUST CAMSHAFT BALANCE SHAFT
- SAFETY PRECAUTIONS
- HIGH SIDE FUEL PRESSURE, RELEASING
- CLEAN WORKING CONDITIONS
- WITH FUEL DELIVERY UNIT INSTALLED
- WITH TANK MORE THAN 3/4 FULL
- WITH TANK LESS THAN 3/4 FULL
- ELECTRONIC POWER CONTROL SYSTEM FUNCTION
- EVAP SYSTEM COMPONENTS
- FUEL PUMP, CHECKING
- FUNCTION AND VOLTAGE SUPPLY, CHECKING
- FUEL PRESSURE, CHECKING
- RESIDUAL PRESSURE, CHECKING
- FUEL DELIVERY, CHECKING
- CURRENT DRAW, CHECKING
- FUEL SYSTEM, CHECKING FOR LEAKS
- LEAK DETECTION PUMP, CHECKING VACUUM SUPPLY
- ACCELERATOR PEDAL MODULE
- FUEL SYSTEM COMPONENTS
- FUEL DELIVERY UNIT
- Removing
- Installing
- Fuel Level Sensor -G
- FUEL TANK
- EVAP CANISTER
- Leak Detection Pump -V144
- FUEL INJECTION SYSTEM
- THROTTLE VALVE CONTROL MODULE, CLEANING
- TECHNICAL DATA
- FUEL RAIL, PIPES AND HIGH PRESSURE PUMP, THROUGH 05.06
- FUEL RAIL, PIPES AND HIGH PRESSURE PUMP, FROM 06.06
- FUEL PRESSURE SENSOR -G247-, CHECKING
- DOUBLE CHECK-VALVE, CHECKING
- ENGINE COVER/UPPER AIR FILTER HOUSING
- AIR FILTER ELEMENT
- INTAKE MANIFOLD
- Intake Flap Motor -V157- With Intake Manifold Runner Position Sensor -G336
- FUEL RAIL
- Throttle Valve Control Module -J338
- HIGH PRESSURE PUMP
- Fuel Pressure Sensor -G247
- FUEL INJECTORS
- FUEL INJECTOR TEFLON SEAL
- WITHOUT A ANTI-THEFT IMMOBILIZER
- WITH A ANTI-THEFT IMMOBILIZER
- A/C SYSTEM REPAIRING AND HANDLING REFRIGERANTS
- A/C SYSTEM WITH MANUAL CONTROLS, FROM 08 NOVEMBER 2010
- CLIMATRONIC A/C SYSTEM WITH AUTOMATIC CONTROLS
- ODORS IN VEHICLES WITH A/C
- REFRIGERANT OIL
- SPECIALIZED REFRIGERANT CIRCUIT REPAIRS
- PASSENGER COMPARTMENT A/C AND HEATING SYSTEM
- HEATER AND A/C CONTROLS FUNCTION, THROUGH 18 MAY 2008
- MULTI-PIN CONNECTOR ASSIGNMENT ON REAR OF HEATER AND A/C CONTROLS, THROUGH 18 MAY 2008
- MULTI-PIN CONNECTOR ASSIGNMENT ON REAR OF HEATER AND A/C CONTROLS, FROM 25 MAY 2008
- FRONT A/C DISPLAY CONTROL HEAD FUNCTION
- MULTI-PIN CONNECTOR ASSIGNMENT ON REAR OF FRONT A/C DISPLAY CONTROL HEAD
- AIR QUALITY SENSOR -G238
- CLIMATRONIC CONTROL MODULE, THROUGH 23 MAY 2008
- MULTI-PIN CONNECTOR ASSIGNMENT ON REAR OF CLIMATRONIC CONTROL MODULE, THROUGH 18 MAY 2008
- CLIMATRONIC CONTROL MODULE, FROM 18 MAY 2008 THROUGH 05 NOVEMBER 2010
- MULTI-PIN CONNECTOR ASSIGNMENT ON REAR OF CLIMATRONIC CONTROL MODULE, FROM 18 MAY 2008 THROUGH 05 NOVEMBER 2010
- CLIMATRONIC CONTROL MODULE, FROM 08 NOVEMBER 2010
- MULTI-PIN CONNECTOR ASSIGNMENT ON REAR OF CLIMATRONIC CONTROL MODULE, FROM 08 NOVEMBER 2010
- PASSENGER COMPARTMENT CLIMATRONIC
- A/C COMPRESSOR PRESSURE RELIEVE VALVE, CHECKING
- CHECKING AND ADJUSTING COMPONENTS
- A/C COMPRESSOR
- A/C COMPRESSOR AUXILIARY COMPONENT BRACKET
- SECURING A/C COMPRESSOR TO BODY
- AIR DISTRIBUTION DOOR MOTOR -V428-, FROM 25 MAY 2008
- CENTER VENT TEMPERATURE SENSOR -G191
- FLEXIBLE SHAFT, THROUGH 18 MAY 2008
- FOOTWELL VENT TEMPERATURE SENSOR -G192
- GLOVE COMPARTMENT COOLING
- HEATER AND A/C SYSTEM CONTROLS
- HIGH PRESSURE SENSOR -G65
- RECIRCULATION DOOR MOTOR -V113
- TEMPERATURE REGULATOR DOOR MOTOR -V68
- AIR DISTRIBUTION DOOR MOTOR -V428
- EVAPORATOR VENT OR EVAPORATOR TEMPERATURE SENSOR -G263- / -G308
- AIR FLOW DOOR MOTOR -V71- WITH BACK PRESSURE DOOR MOTOR POSITION SENSOR -G113
- AIR QUALITY SENSOR -G238-, FROM 25 MAY 2008
- CENTRAL AIR DOOR MOTOR -V70
- DEFROSTER DOOR MOTOR -V107
- FRONT A/C DISPLAY CONTROL HEAD -E87- / -J255
- FRESH AIR BLOWER -V2- / FRESH AIR BLOWER CONTROL MODULE -J126
- LEFT FOOTWELL VENT TEMPERATURE SENSOR -G261
- LEFT TEMPERATURE DOOR MOTOR -V158
- LEFT VENT TEMPERATURE SENSOR -G150
- RIGHT FOOTWELL VENT TEMPERATURE SENSOR -G262
- RIGHT TEMPERATURE DOOR MOTOR -V159
- RIGHT VENT TEMPERATURE SENSOR -G151
- SUNLIGHT PHOTO SENSORS -G107- / -G134
- CONDENSER
- EXPANSION VALVE
- EVAPORATOR
- EVACUATING AND CHARGING VALVE, LOW AND HIGH PRESSURE SIDES
- HEATING AND A/C UNIT
- REFRIGERANT CIRCUIT COMPONENTS
- EVAPORATOR HOUSING
- BATTERY TYPES
- BATTERY, CHARGING [For engine(s): BPY, CCTA, CBFA]
- BATTERY, CHARGING [For engine(s): BUB, CBRA]
- BATTERY POST/TERMINAL
- BATTERY INTERRUPT IGNITER -N253- USAGE AND SAFETY INFORMATION
- BATTERY INTERRUPT IGNITER -N253-, DISPOSAL
- B+ CABLE MOUNT ON GENERATOR
- CRUISE CONTROL SYSTEM
- STARTER [For transmission(s): 02Q]
- STARTER [For transmission(s): 02E]
- 6 VOLT BATTERY PRECAUTIONS
- WARNINGS AND SAFETY PRECAUTIONS
- BATTERY INTERRUPT IGNITER -N253
- CHECKING 6 VOLT ABSORBED GLASS MAT (AGM) BATTERIES
- BATTERY TESTER, CONNECTING TO 6 VOLT BATTERIES
- GENERATOR, CHECKING
- RIBBED BELT, CHECKING
- STARTER, CHECKING
- DISCONNECTING
- CONNECTING
- BATTERY [For engine(s): BPY, CCTA, CBFA]
- BATTERY [For engine(s): BUB, CBRA]
- B+ WIRE CONNECTION ON GENERATOR
- JUMP START POINT WITH SUPPRESSOR -C24
- GENERATOR [For engine(s): BPY, CCTA, CBFA]
- GENERATOR [For engine(s): BUB, CBRA]
- RIBBED BELT PULLEY WITHOUT FREEWHEEL
- RIBBED BELT PULLEY WITH FREEWHEEL, BOSCH
- RIBBED BELT PULLEY WITH FREEWHEEL, VALEO
- STARTER WIRE (B+ WIRE)
- STARTER [For engine(s): BUB, CBRA]
- VOLTAGE REGULATOR, BOSCH
- VOLTAGE REGULATOR, VALEO
- 2.0L - Turbocharger, Supercharger - Engine Code(s): Bpy 2
- 2.0L - Fuel Supply - Engine Code(s): Bpy 4
- 3.2L - Fuel Supply Servicing - Engine Code(s): Bub 3
- 3.2L - Fuel Supply - Engine Code(s): Bub & Cbra 6
- 2.0L - Fuel Supply Servicing - Engine Code(s): Bpy 2
- 2.0L - Turbocharger, G-Charger - General Information - Engine Code(s): Bpy 2
- AMPLIFIER -R12
- ANTENNA SYSTEMS
- COMPASS
- DIGITAL SATELLITE RADIO TUNER -R190
- EXTERNAL AUDIO SOURCE CONNECTION -R199
- EXTERNAL MULTIMEDIA DEVICE INTERFACE -R215
- INTERFERENCE SUPPRESSION MEASURES
- MULTIFUNCTION STEERING WHEEL, UP TO 11.10
- MULTIFUNCTION STEERING WHEEL, FROM 11.10
- RCD 510 SOUND SYSTEM
- RCD 510 CD TRANSPORT PROTECTION, ACTIVATING/DEACTIVATING
- SPEAKER SYSTEMS
- TELEPHONE SYSTEM
- AMPLIFIER CONNECTORS, TERMINAL ASSIGNMENTS
- 8-PIN CONNECTOR 2, VOLTAGE SUPPLY, CAN-BUS, TELEPHONE MUTING
- 12-PIN CONNECTOR 3, TELEPHONE SIGNAL INPUT
- 12-PIN CONNECTOR 4, DIGITAL SATELLITE RADIO TUNER
- 12-PIN CONNECTOR 3, AUX AUDIO OUTPUT, TELEPHONE SIGNAL INPUT
- 12-PIN CONNECTOR 4, AUX AUDIO INPUT, CD CHANGER CONTROL AND CD AUDIO INPUT SIGNALS
- 8-PIN CONNECTOR 2, VOLTAGE SUPPLY WIRES AND CAN-BUS
- 12-PIN CONNECTOR 3 FOR TELEPHONE AND MICROPHONE SIGNALS
- 12-PIN CONNECTOR 4, CD CHANGER CONTROL AND AUDIO INPUT SIGNALS
- 26-PIN CONNECTOR, AUDIO AND VIDEO
- 8-PIN CONNECTOR 4, VOLTAGE SUPPLY WIRES AND CAN-BUS
- 12-PIN CONNECTOR 5, TELEPHONE SIGNALS AND PRE-AMPLIFIER OUTPUT SIGNALS
- 12-PIN CONNECTOR 6, CD CHANGER CONTROL AND AUDIO INPUT SIGNALS, DIGITAL SATELLITE RADIO TUNER
- ANTENNA CONNECTORS 7 AND 8
- MULTIFUNCTION STEERING WHEEL, ADAPTING
- RADIO COMPONENTS, ADAPTING
- RADIO NAVIGATION SYSTEM COMPONENTS, ADAPTING
- PREMIUM 7 ANTI-THEFT CODING, DEACTIVATING
- RCD 510 ANTI-THEFT CODING, DEACTIVATING
- RNS 315 ELECTRONIC ANTI-THEFT SYSTEM, DEACTIVATING
- RNS 510 ANTI-THEFT CODING, DEACTIVATING
- RNS MFD 2 DVD ANTI-THEFT CODING, DEACTIVATING
- ANTENNA AMPLIFIER -R24
- ANTENNA MODULE
- ANTENNA MODULE CARRIER PLATE
- ANTENNA WIRES
- CD CHANGER
- COMPASS MAGNETIC FIELD SENSOR -G197
- LEFT AND RIGHT MULTIFUNCTION BUTTONS ON STEERING WHEEL -E440- / -E441-, UP TO 11.10
- LEFT AND RIGHT MULTIFUNCTION BUTTONS ON STEERING WHEEL -E440- / -E441-, FROM 11.10
- MULTIFUNCTION STEERING WHEEL CONTROL MODULE -J453-, UP TO 11.10
- RADIOS
- FRONT BASS SPEAKERS
- FRONT MID-RANGE SPEAKERS
- REAR BASS SPEAKER
- FRONT TREBLE SPEAKER
- REAR TREBLE SPEAKER
- TELEPHONE BASEPLATE, UP TO 06.06
- TELEPHONE ELECTRONICS CONTROL MODULE, UP TO 06.06
- TELEPHONE ELECTRONICS CONTROL MODULE, FROM 06.06
- TELEPHONE MICROPHONE
- USB CONNECTOR
- MODIFYING THE ADAPTER FOR OIL FILLING -VAS 6262 A
- TRANSMISSION OIL LEVEL, CHECKING AND FILLING
- SELECTOR LEVER, MANUAL RELEASE
- SELECTOR LEVER CABLE, ADJUSTING
- SELECTOR LEVER CABLE, CHECKING
- SELECTOR MECHANISM, CHECKING
- SELECTOR LEVER HANDLE
- HANDLE BUTTON, MOVING INTO THE INSTALLED POSITION
- SELECTOR LEVER CABLE, THROUGH 02.09
- SELECTOR LEVER AND SELECTOR MECHANISM WITH SELECTOR LEVER CABLE, FROM 03.09
- TRANSMISSION OIL COOLER
- OIL PUMP
- SELECTOR SHAFT LEVER SEAL, TRANSMISSION REMOVED
- DSG Transmission Mechatronic -J743-, TRANSMISSION INSTALLED
- DSG Transmission Mechatronic -J743-, TRANSMISSION REMOVED
- Transmission Input Speed Sensor -G182- AND Clutch Oil Temperature Sensor -G509
- OIL FILTER
- TRANSMISSION, REMOVING [For engine(s): BPY, CCTA, CBFA]
- TRANSMISSION, REMOVING [For engine(s): BUB, CBRA]
- TRANSMISSION, INSTALLING
- SELECTOR LEVER CABLE ADJUSTING, THROUGH 02.2009
- OIL FILTER, CHANGING AND OIL LEVEL, ADJUSTING
- SELECTOR LEVER MANUAL RELEASE
- SELECTOR LEVER CABLE CHECKING, THROUGH 02.2009
- SELECTOR MECHANISM CHECKING, THROUGH 02.2009
- SHIFT HANDLE WITH COVER
- MECHATRONIC UNIT, TRANSMISSION INSTALLED
- MECHATRONIC UNIT, TRANSMISSION REMOVED
- TRANSMISSION INPUT SPEED SENSOR AND CLUTCH OIL TEMPERATURE SENSOR
- TRANSMISSION OIL COOLER
- OIL PUMP
- SELECTOR SHAFT LEVER SEAL
- SELECTOR LEVER CABLE, THROUGH 02.2009
- SELECTOR LEVER AND MECHANISM WITH CABLE, FROM 03.2009
- TRANSMISSION, REMOVING
- TRANSMISSION, INSTALLING
- SHIFT AND SELECTOR CABLES, INSTALLED POSITION
- SHIFT MECHANISM OVERVIEWS
- SHIFT LEVER AND HOUSING, THROUGH 10.06
- SHIFT LEVER AND HOUSING, FROM 11.06
- SHIFT AND SELECTOR CABLES
- SHIFT MECHANISM, ADJUSTING
- FUNCTION
- SHIFT MECHANISM
- PLASTIC RELAY LEVER
- SELECTOR SHAFT SEAL
- REMOVING
- INSTALLING
- TRANSMISSION, TRANSPORTING
- SELECTOR MECHANISM, FROM 11.06
- TRANSMISSION, WITHOUT A SEALING CAP CIRCLIP
- TRANSMISSION HOUSING
- CLUTCH HOUSING
- SHIFT FORKS
- CSC ROOF SAFETY PRECAUTIONS
- REAR LID SERVICE POSITION
- CSC ROOF, OPENING WITHOUT ELECTRO-HYDRAULIC ASSISTANCE
- CSC ROOF, CLOSING WITHOUT ELECTRO-HYDRAULIC ASSISTANCE
- SEALS WITH SIPIOL COATING, REPAIRING
- GLASS PANEL, REMOVING
- GLASS PANEL, INSTALLING
- GLASS PANEL, ADJUSTING
- GLASS PANEL GAP DIMENSIONS
- GLASS PANEL CABLES, REMOVING
- GLASS PANEL CABLES, INSTALLING
- SUNROOF MOTOR, REMOVING
- SUNROOF MOTOR, INSTALLING
- GLASS PANEL SEAL, FROM JULY 2007
- GUIDE RAILS, REMOVING
- GUIDE RAILS, INSTALLING
- GUIDE RAIL, ADJUSTING
- ROOF CENTER SECTION, REMOVING
- ROOF CENTER SECTION, INSTALLING
- ROOF CENTER SECTION, ADJUSTING
- ROOF CENTER PIECE GAP DIMENSIONS
- REAR WINDOW FRAME, REMOVING
- REAR WINDOW FRAME, INSTALLING
- REAR WINDOW FRAME, ADJUSTING
- REAR WINDOW FRAME GAP DIMENSIONS
- REAR WINDOW FRAME SEAL
- ROOF PILLAR, REMOVING
- ROOF PILLAR, INSTALLING
- ROOF PILLAR, ADJUSTING
- ROOF PILLAR GAP DIMENSIONS
- ROOF PILLAR SEAL, REMOVING
- ROOF PILLAR LATCH, REMOVING
- ROOF PILLAR LATCH, INSTALLING
- CONVERTING SENSORS WHEN REPLACING ROOF
- CSC ROOF, REMOVING
- CSC ROOF, SUPPORTING
- NEW CSC ROOF, REMOVING FROM SHIPPING CONTAINER
- CSC ROOF, INSTALLING
- BASIC SETTING FOR NEWLY INSTALLED CSC ROOF
- SUN SHADE, REMOVING
- SUN SHADE, INSTALLING
- SUN SHADE CABLES, REMOVING
- SUN SHADE CABLES, INSTALLING
- TENSIONED HEADLINER TENSIONING BANDS
- ROUTING TENSION BAND 1
- ROUTING TENSIONING BANDS 2 AND 3
- ROUTING TENSIONING BANDS 4 AND 5
- TENSIONED HEADLINER RAIL, INSTALLING
- ROOF PILLAR TRIM
- NEW ROOF PILLAR TRIM, PREPARING
- ROUTING TENSION BAND 2
- REAR WINDOW FRAME UPPER TRIM
- ROOF PILLAR FLAP, REMOVING
- ROOF PILLAR FLAP, INSTALLING
- COVER FLAPS, INSTALLING
- REAR SHELF PROTECTIVE STRIP
- WINDSHIELD SEAL
- ROOF PILLAR FRONT POSITION SENSORS
- ROOF PILLAR LOCK SENSORS
- REAR WINDOW FRAME LOCK SENSORS
- REAR WINDOW FRAME OPENING SENSOR
- ROOF PILLAR FLAP OPENING SENSORS
- REAR SHELF LOCK SENSORS
- LUGGAGE COVER CONTACT SWITCH
- HYDRAULIC SYSTEM
- CLEAN WORKING CONDITIONS
- HYDRAULIC SYSTEM, FILLING AND BLEEDING
- HYDRAULIC PUMP CONNECTOR ASSIGNMENT
- HYDRAULIC LINE ON HYDRAULIC CYLINDER
- HYDRAULIC CYLINDER IN ROOF PILLAR
- HYDRAULIC CYLINDER IN MOUNTING FRAME
- HYDRAULIC CYLINDER ON HINGE
- HYDRAULIC CYLINDER IN MAIN HINGE
- VALVE SEAT, REFACING
- MAXIMUM PERMITTED REFACING DIMENSION IS CALCULATED AS FOLLOWS
- REFACING THE EXHAUST VALVE SEAT
- VALVE TIMING, CHECKING
- THROUGH 11.08
- FROM 12.08
- COMPRESSION, CHECKING
- VALVE GUIDE, CHECKING
- CYLINDER HEAD COVER
- CAMSHAFT ADJUSTERS
- VEHICLES THROUGH 11.08
- VEHICLES FROM 12.08
- CAMSHAFT AND OIL PUMP TIMING CHAINS
- CAMSHAFTS
- VALVE STEM SEALS
- Engine Performance Diagnostic Routine Outline - General Information
- Engine Performance Safety Precautions
- Parasitic Load Explanation & Test Procedures - General Information 2
- Waveforms - Injector Pattern Tutorial - General Information 2
- Electrostatic Discharge Warning - General Information
- State Emission Standards - Diesel
- 3.2L - Exhaust System, Emission Controls - Engine Code(s): Bub & Cbra 5
- 2.0L - Exhaust System, Servicing - Engine Code(s): Bpy
- 3.2L - Exhaust System, Servicing - Engine Code(s): Bub 2
- 2.0L - Exhaust System, Emission Controls - Engine Code(s): Bpy 3
- General, Technical Data - Engine - Engine Code(s): Bpy
- General, Technical Data - Engine - Engine Code(s): Bub & Cbra
- FOG LAMPS
- HALOGEN HEADLAMPS
- HALOGEN HEADLAMP BULBS, REPLACING
- HEADLAMP MOUNTING TABS, REPAIRING
- HID DYNAMIC CORNERING LAMP MOTOR
- HID HEADLAMPS, USAGE AND SAFETY PRECAUTIONS
- NOTES ON HAZARDOUS HIGH VOLTAGE / CURRENTS
- NOTES ON PRESSURE, TEMPERATURE AND RADIATION/GLARE
- DISPOSAL REGULATIONS FOR HID LAMPS
- HID HEADLAMPS AND CORNERING LAMP (AFS LIGHT SYSTEM), SERVICE INFORMATION
- HID LOW BEAM REFLECTOR MOTOR
- HID LEVEL CONTROL SYSTEM SENSOR
- HID SWIVEL MODULE POSITION SENSOR
- BONDING THE SENSOR BRACKET IN THE EVENT OF REPAIRS
- BONDING SENSOR BRACKET IN BUMPER COVER
- PAINTING SENSOR BRACKETS AND SENSORS
- STEERING COLUMN SWITCH, TO 10.09
- STEERING COLUMN SWITCH, FROM 11.09
- STEERING COLUMN ELECTRONIC SYSTEMS CONTROL MODULE -J527-, FROM 11.09
- STEERING COLUMN COMBINATION SWITCH -E595-, FROM 11.09
- TAIL LAMPS
- HID HEADLAMPS AND CORNERING LAMP (AFS)
- EXTERIOR MIRROR TURN SIGNAL AND ENTRY LAMP BULBS
- PARKING AID SYSTEM (PDC) / REAR LID ASSISTANT (HDA)
- TAIL LAMPS IN SIDE PANEL
- DYNAMIC CORNERING LAMP MOTOR, CHECKING
- FOG LAMPS, ADJUSTING
- HEADLAMP RANGE CONTROL POSITIONING MOTOR, CHECKING
- ADAPTING
- CODING
- HEADLAMP POWER OUTPUT STAGES, CODING
- LEVEL CONTROL SYSTEM SENSOR, CHECKING
- LOW BEAM REFLECTOR MOTOR, CHECKING
- IGNITION SWITCH, FROM 11.09, CHECKING
- STEERING COLUMN ELECTRONIC SYSTEMS CONTROL MODULE -J527-, FROM 11.09, CODING
- STEERING ANGLE SENSOR -G85- TO 10.09, BASIC SETTING
- EXTERIOR MIRROR TURN SIGNAL LAMPS
- EXTERIOR MIRROR ENTRY LAMPS
- FOG LAMP
- FOG LAMP BULBS -L22/L23
- FRONT SIDE MARKER LAMP
- FRONT SIDE MARKER BULB -M33/M34
- FRONT TURN SIGNAL BULBS
- HEADLAMP BEAM ADJUSTING MOTORS
- HIGH BEAM BULBS
- LOW BEAM BULBS
- PARKING LAMP BULBS
- HEADLAMP HOUSING
- LOWER MOUNTING TAB, REPAIRING
- SIDE MOUNTING TAB, REPAIRING
- UPPER MOUNTING TAB, REPAIRING
- CORNERING LIGHT BULB
- CORNERING LAMP AND HEADLAMP RANGE CONTROL MODULE -J745
- GAS DISCHARGE LAMPS
- HEADLAMP RANGE CONTROL POSITIONING MOTOR
- HEADLAMP POWER OUTPUT STAGES
- HEADLAMP CONTROL MODULE
- LEFT FRONT LEVEL CONTROL SYSTEM SENSOR -G78
- LEFT REAR LEVEL CONTROL SYSTEM SENSOR -G76
- LOW BEAM REFLECTOR MOTOR
- PARKING LAMPS BULBS
- HIGH-MOUNTED BRAKE LAMP -M25
- STEERING LOCK HOUSING
- LOCK CYLINDER
- IGNITION SWITCH
- IGNITION SWITCH KEY LOCK SOLENOID -N376
- LICENSE PLATE LAMP ATTACHED BY SCREWS
- BULB, LICENSE PLATE LAMP ATTACHED BY SCREWS
- LICENSE PLATE LAMP ATTACHED BY CLIPS
- BULB, LICENSE PLATE LAMP ATTACHED BY CLIPS
- PARKING AID CONTROL MODULE -J446
- REAR PARKING AID SENSOR, THROUGH 05.07
- REAR PARKING AID SENSOR, FROM 06.07
- REAR PARKING AID WARNING BUZZER -H15
- STEERING COLUMN ELECTRONIC SYSTEMS CONTROL MODULE -J527-, VALEO
- STEERING COLUMN ELECTRONIC SYSTEMS CONTROL MODULE -J527-, KOSTAL
- STEERING COLUMN COMBINATION SWITCH -E595-, VALEO
- STEERING COLUMN COMBINATION SWITCH -E595-, KOSTAL
- STEERING COLUMN SWITCH BASE CARRIER, VALEO
- STEERING COLUMN SWITCH BASE CARRIER, KOSTAL
- STEERING COLUMN ELECTRONIC SYSTEMS CONTROL MODULE -J527
- AIRBAG SPIRAL SPRING/RETURN SPRING WITH SLIP RING -F138
- STEERING ANGLE SENSOR -G85
- TURN SIGNAL SWITCH -E2
- WINDSHIELD WIPER SWITCH -E
- STEERING COLUMN SWITCH BASE PLATE
- REAR LID TAIL LAMPS
- REAR LID TAIL LAMP BULB HOLDER
- DIODE CIRCUIT BOARD FOR SIDE PANEL TAIL LAMP
- LONGITUDINAL MEMBER THREADS, SERVICING
- WHEEL BEARING, LIFTING TO CURB WEIGHT POSITION
- SUBFRAME AND CONSOLES, SECURING
- SUBFRAME, LOWERING
- BALL JOINT, CHECKING
- INNER CV JOINT, CHECKING, WITH CV JOINT VL100
- CV JOINT, CHECKING FOR FUNCTION
- OUTER CV JOINT, CHECKING, WITH CV JOINT VL100
- OUTER CV JOINT, CHECKING, WITH MOUNTED CV JOINT VL107
- FRONT LEFT LEVEL CONTROL SYSTEM SENSOR
- SUBFRAME, WITHOUT STEERING GEAR
- INSTALLING
- SUBFRAME, WITH STEERING GEAR
- SUBFRAME BONDED RUBBER BUSHINGS
- BALL JOINT
- CONTROL ARM WITH MOUNTING BRACKET
- CONTROL ARM WITH MOUNTING BRACKET, LEFT SIDE FOR VEHICLES WITH DSG OR AUTOMATIC TRANSMISSION
- CONTROL ARM WITH MOUNTING BRACKET, RIGHT SIDE ON VEHICLES WITH 6-CYLINDER ENGINE
- CONTROL ARM BONDED RUBBER BUSHING
- MOUNTING BRACKET WITH CONTROL ARM BEARING
- STABILIZER BAR
- WHEEL BEARING UNIT
- WHEEL BEARING HOUSING
- SUSPENSION STRUT
- REMOVING
- DRIVE AXLE WITH CV JOINT
- LEFT DRIVE AXLE WITH MOUNTED CV JOINT
- RIGHT DRIVE AXLE WITH MOUNTED CV JOINT
- DRIVE AXLE WITH TRIPOD JOINT AAR2600I
- DRIVE AXLE WITH TRIPOD JOINT AAR3300I
- COIL SPRING, REMOVING
- COIL SPRING, INSTALLING
- DRIVE AXLE WITH CV JOINT VL100
- REMOVING OUTER CONSTANT VELOCITY JOINT
- DRIVE AXLE WITH MOUNTED CV JOINT VL107
- TENSIONING CLAMP ON SMALL DIAMETER
- DRIVE AXLE WITH ATTACHED CV JOINT VL107
- REMOVING THE INNER CV JOINT
- INSTALLING THE INNER CV JOINT
- DRIVE AXLE WITH TRIPLE ROLLER JOINT AAR2600I
- DRIVE AXLE WITH TRIPLE ROLLER JOINT AAR3300I
- ALARM HORN -H12
- ANTI-THEFT ALARM SYSTEM, ACTIVATING AND DEACTIVATING
- ANTI-THEFT IMMOBILIZER CONTROL MODULE -J362
- ANTI-THEFT IMMOBILIZER READING COIL -D2
- CENTRAL LOCKING AND ANTI-THEFT ALARM SYSTEM ANTENNA -R47
- DOOR LOCK COMPONENTS
- IGNITION KEY
- IGNITION KEY, VARIABLE CODE TRANSPONDER
- ANTI-THEFT ALARM SYSTEM
- ANTI-THEFT IMMOBILIZER
- CENTRAL LOCKING -SAFE- INDICATOR LAMP -K133-, CHECKING
- ALARM HORN -H12-, CHECKING
- IGNITION KEY, ADAPTING TO IMMOBILIZER
- IGNITION KEY, ADAPTING TO COMFORT SYSTEM
- ALARM HORN
- INTERIOR MONITORING DEACTIVATION SWITCH AND DEACTIVATE VEHICLE INCLINATION SENSOR BUTTON
- INTERIOR MONITORING TRANSCEIVER MODULE 1 -G303
- INTERIOR MONITORING TRANSCEIVER MODULE 2 -G305
- VEHICLE INCLINATION SENSOR -G384
- ANTI-SLIP REGULATION/ELECTRONIC STABILIZATION PROGRAM BUTTON
- SUNROOF BUTTON -E325
- FRONT HOOD SWITCH -F266
- HORNS
- EMERGENCY FLASHER SWITCH -E229
- FOOTWELL LIGHTS
- FRONT PASSENGER AIRBAG DISABLED INDICATOR LAMP
- FRONT PASSENGER AIRBAG DEACTIVATION KEY SWITCH -E224
- GLOVE COMPARTMENT LAMP
- GLOVE COMPARTMENT LAMP SWITCH -E26
- HEADLAMP ADJUSTER -E102- AND INSTRUMENT PANEL ILLUMINATION DIMMER SWITCH -E20
- LIGHT SWITCH -E1
- CENTRAL LOCKING -SAFE- INDICATOR LAMP -K133
- DRIVER INTERIOR LOCKING BUTTON -E308
- DRIVER WINDOW REGULATOR SWITCH
- FUEL TANK LID UNLOCK BUTTON -E319
- PASSENGER DOOR WINDOW REGULATOR SWITCH -E107
- REAR LID REMOTE CONTROL LOCK SWITCH -E233
- LUGGAGE COMPARTMENT LAMP
- LUGGAGE COMPARTMENT LAMP SWITCH -F5
- LUGGAGE COVER CONTACT SWITCH -F364
- GARAGE DOOR OPENER
- INTERIOR LAMP
- LEFT INTERIOR LAMP -W16- AND RIGHT INTERIOR LAMP -W17-, BULBS
- ILLUMINATED VANITY MIRROR LAMPS
- LIFTING VEHICLE ON A HOIST OR WORKSHOP HOIST
- LABELS
- VIN
- VEHICLE DATA LABEL
- ENGINE CODE AND ENGINE NUMBER
- SEVERE OPERATING CONDITIONS
- TYPE PLATE
- TIME OR DISTANCE DEPENDENT SERVICE INFORMATION
- SERVICE TABLES
- ROOF PILLAR COMPARTMENTS, REAR LONGITUDINAL MEMBER FELT AND HYDRAULIC PUMP SOUND ENCLOSURE, CHECKING FOR MOISTURE
- BALL JOINTS, CHECKING
- AUTOMATIC HEADLAMP CONTROL AND STATIC CORNERING LAMP, CHECKING FUNCTION
- PRECAUTIONS AND WARNINGS
- CSC ROOF, CLOSING
- GLASS PANEL, OPENING AND CLOSING
- BATTERY IN ENGINE COMPARTMENT
- BATTERY IN LUGGAGE COMPARTMENT
- BATTERY, CHECKING WITH BATTERY TESTER
- TIRES, CHECKING CONDITION
- TIRES, CHECKING WEAR PATTERN
- TIRE PRESSURES, EOS FROM MY 06
- BRAKE SYSTEM AND SHOCK ABSORBERS, CHECKING FOR LEAKS AND DAMAGE
- FRONT DISC BRAKE PADS
- REAR DISC BRAKE PADS
- BRAKE DISCS
- ROOF PILLAR AND CENTER ROOF SECTION SIDE SEALS, CLEANING AND APPLYING LUBRICANT
- CENTER ROOF SECTION FRONT SEALS, CLEANING AND APPLYING LUBRICANT
- CENTER ROOF SECTION REAR SEALS, CLEANING AND APPLYING LUBRICANT
- WINDSHIELD FRAME FRONT SEALS, CLEANING AND APPLYING LUBRICANT
- REAR WINDOW FRAME SEAL, CLEANING
- WIND DEFLECTOR, CLEANING
- CSC ROOF, OPENING
- OIL AND FILTER, 6-SPEED DSG 02E, REMOVING AND INSTALLING
- POWER WINDOWS, SETTING ONE-TOUCH UP/DOWN FUNCTION
- INNER AND OUTER BODY, CHECKING FOR CORROSION
- RIBBED BELT, CHECKING CONDITION
- FREEZE PROTECTION, CHECKING AND ADDING COOLANT ADDITIVE
- COOLANT LEVEL, CHECKING AND FILLING
- MIXTURE RATIO
- AIR FILTER, 2.0L TFSI, REMOVING AND INSTALLING
- AIR FILTER, 3.2L, REMOVING AND INSTALLING
- ENGINE COVER, 2.0L TFSI, REMOVING AND INSTALLING
- Vehicles up to Model Year 2005
- Vehicles from Model Year 2006
- LOWER ENGINE COMPARTMENT COVER, REMOVING AND INSTALLING
- ENGINE AND ENGINE COMPARTMENT COMPONENTS, CHECKING FOR LEAKS AND DAMAGE
- ENGINE OIL, CHECKING LEVEL
- ENGINE OIL, FILLING
- OIL FILTER, 2.0L TFSI, REMOVING AND INSTALLING
- OIL FILTER, 3.2L, REMOVING AND INSTALLING
- RADIO AND RADIO NAVIGATION SYSTEM, ENTERING ANTI-THEFT CODE PIN AND STORING STATIONS
- TIRE PRESSURE MONITORING SYSTEM, PERFORMING BASIC SETTING
- DUST AND POLLEN FILTER, CLEANING HOUSING AND REMOVING AND INSTALLING FILTER ELEMENT
- HID HEADLAMPS, ADJUSTING
- HALOGEN HEADLAMPS, ADJUSTING
- FOG LAMPS AND OTHER AUXILIARY LAMPS, ADJUSTING
- EOS
- EOS Facelift
- Other Auxiliary Lamps
- WINDSHIELD WASHER SYSTEM, CHECKING AND ADJUSTING SPRAY NOZZLES
- Windshield Washer System Spray Nozzles
- HEADLAMP WASHER SYSTEM, CHECKING SPRAY NOZZLE SETTING
- WINDSHIELD WIPER BLADES, CHECKING PARK POSITION
- WINDSHIELD WIPER PROTECTORS, VERSION 1, REMOVING
- WINDSHIELD WIPER PROTECTORS, VERSION 2, REMOVING
- WIPER BLADE PROTECTOR, TYPE 3, TRANSPORT WIPER BLADE, CHANGING
- TIE ROD ENDS, CHECKING PLAY, SECURITY AND JOINT BOOTS
- TRANSPORT MODE, DEACTIVATING
- TRANSPORT PROTECTION, REMOVING LOCKING PIECES FROM FRONT AXLE STRUTS
- UNDERBODY COMPONENTS, CHECKING FOR DAMAGE
- CLOCK, SETTING
- CAMSHAFT DRIVE TOOTHED BELT, 2.0L FSI AND TFSI, REMOVING AND INSTALLING
- SPARK PLUGS, 2.0L TFSI, REMOVING AND INSTALLING
- SPARK PLUGS, 3.2L SRE, REMOVING AND INSTALLING
- ROOF COMPARTMENT BUFFER, INSTALLING ON CONVERTIBLE TOP COMPARTMENT COVER
- LIFTING VEHICLE ON A HOIST OR WORKSHOP HOIST
- LABELS
- VIN
- VEHICLE DATA LABEL
- ENGINE CODE AND ENGINE NUMBER
- SEVERE OPERATING CONDITIONS
- TYPE PLATE
- TIME OR DISTANCE DEPENDENT SERVICE INFORMATION
- SERVICE TABLES
- GLOSSARY
- ROOF PILLAR COMPARTMENTS, REAR LONGITUDINAL MEMBER FELT AND HYDRAULIC PUMP SOUND ENCLOSURE, CHECKING FOR MOISTURE
- BALL JOINTS, CHECKING
- AUTOMATIC HEADLAMP CONTROL AND STATIC CORNERING LAMP, CHECKING
- PRECAUTIONS AND WARNINGS
- CSC ROOF, CLOSING
- GLASS PANEL, OPENING AND CLOSING
- BATTERY TERMINALS, BATTERY IN ENGINE COMPARTMENT, CHECKING
- BATTERY TERMINALS, BATTERY IN LUGGAGE COMPARTMENT, CHECKING
- BATTERY, CHECKING WITH BATTERY TESTER
- TIRES, CHECKING CONDITION
- TIRES, CHECKING WEAR PATTERN
- TIRE PRESSURES, EOS FROM MY 06
- BRAKE SYSTEM AND SHOCK ABSORBERS, CHECKING FOR LEAKS AND DAMAGE
- FRONT DISC BRAKE PADS
- REAR DISC BRAKE PADS
- BRAKE ROTORS, CHECKING CONDITION
- CSC ROOF, CHECKING FOR DAMAGE AND FUNCTIONALITY
- ROOF PILLAR AND CENTER ROOF SECTION SIDE SEALS, CLEANING AND APPLYING LUBRICANT
- CENTER ROOF SECTION FRONT SEALS, CLEANING AND APPLYING LUBRICANT
- CENTER ROOF SECTION REAR SEALS, CLEANING AND APPLYING LUBRICANT
- WINDSHIELD FRAME FRONT SEALS, CLEANING AND APPLYING LUBRICANT
- REAR WINDOW FRAME SEAL, CLEANING
- WIND DEFLECTOR, CLEANING
- CSC ROOF, OPENING
- OIL AND FILTER, 6-SPEED DSG 02E, REMOVING AND INSTALLING
- POWER WINDOWS, SETTING ONE-TOUCH UP/DOWN FUNCTION
- INNER AND OUTER BODY, CHECKING FOR CORROSION
- RIBBED BELT, CHECKING CONDITION
- FREEZE PROTECTION, CHECKING AND ADDING COOLANT ADDITIVE
- COOLANT LEVEL, CHECKING AND FILLING
- MIXTURE RATIO
- 2.0L TFSI
- 3.2L
- ENGINE COVER, 2.0L TFSI, REMOVING AND INSTALLING
- VEHICLES UP TO MODEL YEAR 2005
- VEHICLES FROM MODEL YEAR 2006
- LOWER ENGINE COMPARTMENT COVER, REMOVING AND INSTALLING
- ENGINE AND ENGINE COMPARTMENT COMPONENTS, CHECKING FOR LEAKS AND DAMAGE
- ENGINE OIL, CHECKING LEVEL
- OIL FILTER, 2.0L TFSI, REMOVING AND INSTALLING
- OIL FILTER, 3.2L, REMOVING AND INSTALLING
- ENGINE OIL, FILLING
- RADIO AND RADIO NAVIGATION SYSTEM, ENTERING ANTI-THEFT CODE PIN AND STORING STATIONS
- TIRE PRESSURE MONITORING SYSTEM, PERFORMING BASIC SETTING
- DUST AND POLLEN FILTER, CLEANING HOUSING AND REMOVING AND INSTALLING FILTER ELEMENT
- HID HEADLAMPS, ADJUSTING
- HALOGEN HEADLAMPS, ADJUSTING
- FOG LAMPS, ADJUSTING
- EOS
- EOS FACELIFT
- WINDSHIELD WASHER SYSTEM, CHECKING AND ADJUSTING SPRAY NOZZLES
- WINDSHIELD WASHER SYSTEM SPRAY NOZZLES
- HEADLAMP WASHER SYSTEM, CHECKING SPRAY NOZZLE SETTING
- WINDSHIELD WIPER BLADES, CHECKING PARK POSITION
- WINDSHIELD WIPER PROTECTORS, VERSION 1, REMOVING
- WINDSHIELD WIPER PROTECTORS, VERSION 2, REMOVING
- WIPER BLADE PROTECTOR, TYPE 3, TRANSPORT WIPER BLADE, CHANGING
- TIE ROD ENDS, CHECKING PLAY, SECURITY AND JOINT BOOTS
- TRANSPORT MODE, DEACTIVATING
- TRANSPORT PROTECTION, REMOVING LOCKING PIECES FROM FRONT AXLE STRUTS
- UNDERBODY COMPONENTS, CHECKING FOR DAMAGE
- CLOCK, SETTING
- CAMSHAFT DRIVE TOOTHED BELT, 2.0L TFSI, REMOVING AND INSTALLING
- SPARK PLUGS, 3.2L, REMOVING AND INSTALLING
- ROOF COMPARTMENT BUFFER ON CONVERTIBLE TOP COMPARTMENT COVER, INSTALLING
- 3.2L - Crankshaft, Cylinder Block - Engine Code(s): Bub & Cbra 5
- 2.0L - Crankshaft, Cylinder Block - Engine Code(s): Bpy 4
- 2.0L - Engine Assembly - Engine Code(s): Bpy 2
- 2.0L - Cylinder Head, Valvetrain - Engine Code(s): Bpy 4
- 2.0L - Cylinder Head, Valvetrain - Engine Code(s): Cbfa & Ccta 5
- Cylinder Head, Valvetrain 5
- 3.2L - Engine Assembly - Engine Code(s): Bub & Cbra 3
- Controls, Housing - Automatic Transmission 02E (As of 09.2011) 5
- Controls, Housing - Manual Transmission 02Q 6
- Controls, Housing - Automatic Transmission 02E (As of 11.2009) 4
- 3.2L - Electrical Components for Regulating Transmission 02E 2
- 2.0L - Electrical Components for Regulating Transmission 02E 2
- AIRBAG AND BELT TENSIONER WIRE REPAIR INFORMATION
- CONTACT HOUSINGS AND CONNECTORS, REPAIR INFORMATION
- FIBER-OPTIC CABLE
- PROTECTING CONNECTIONS
- Procedure
- VEHICLE ELECTRICAL SYSTEM, GENERAL REPAIR INFORMATION
- CONTACT RELEASE TOOLS
- CONTACT SURFACE CLEANING SET VAS6410A
- CRIMPING PLIERS VAS 1978/1A
- CRIMPING PLIERS WITH INSERT
- UPGRADE KIT FOR VAS 1978 VAS 1978/50
- RELEASE TOOL SET VAS 1978/35
- WIRE STRIPPER VAS 1978/3
- BATTERY TERMINAL CLAMP AND BATTERY TERMINAL, CLEANING
- CONTACTS IN CONTACT HOUSING, REPAIRING
- CONTACT HOUSINGS, REPAIRING WIRE TERMINALS
- SINGLE WIRE SEALS, INSTALLING
- THREADED CONNECTIONS, REPAIRING
- WIRE BREAK WITH SINGLE REPAIR POINT
- WIRE BREAK WITH DUAL REPAIR POINT
- WIRES WITH DIAMETER UP TO 0.35 MM 2, REPAIRING
- 4-PIN HEATED OXYGEN SENSOR
- 6-PIN UNIVERSAL OXYGEN SENSOR
- PRIMARY LOCK
- SECONDARY LOCK
- ROUND CONNECTOR SYSTEMS
- FLAT CONNECTOR SYSTEMS
- SPECIAL CONNECTOR SYSTEMS