SERVICE DATA
| Fuel pressure regulator | Fuel pressure at no vacuum | 265 - 304 kPa (2.7 - 3.1 kgf/cm 2 , 38 - 44 psi) |
|---|---|---|
| Fuel pump | Resistance at 20°C (68°F) | 0.2 - 3.0ohm |
| Injector | Resistance at 20°C (68°F) | 13.4 - 14.2 ohm |
| Injection volume | 56 - 69 cm 3 (3.4 - 4.2 cu in.) per 15 seconds | |
| Difference between each cylinder | 13 cm 3 (0.8 cu in.) or less | |
| Fuel leakage | 1 drop or less per 12 minutes | |
| MAF meter | Resistance (THA - E2) at -20°C (-4°F) | 12.5 - 16.9 kohm |
| Resistance (THA - E2) at 20°C (68°F) | 2.19 - 2.67 kohm | |
| Resistance (THA - E2) at 60°C (140°F) | 0.50 - 0.68 kohm | |
| Throttle body | Throttle body fully closed angle | 5.5° |
| Accelerator pedal position sensor | Standard throttle valve opening percentage Sensor lever full-open position | 60 % or more |
| Throttle control motor | Motor resistance at 20°C (68°F) | 0.3 - 100 ohm |
| VSV for EVAP | Resistance at 20°C (68°F) | 30 - 34 ohm |
| VSV for vapor pressure sensor | Resistance at 20°C (68°F) | 30 - 36 ohm |
| ECT sensor | Resistance at -20°C (-4°F) | 10 - 20 kohm |
| Resistance 0°C (32°F) | 4 - 7 kohm | |
| Resistance 20°C (68°F) | 2 - 3 kohm | |
| Resistance 40°C (104°F) | 0.9 - 1.3 kohm | |
| Resistance 60°C (140°F) | 0.4 - 0.7 kohm | |
| Resistance 80°C (176°F) | 0.2 - 0.4 kohm | |
| Vapor pressure sensor | Power source voltage | 4.5 - 5.5 V |
| Heated oxygen sensor | Heater coil resistance at 20°C (68°F) | 11 - 16 ohm |
| Fuel cut rpm | Fuel return rpm | 1,000 rpm |
| Fuel pump resister | Resistance at 20°C (68°F) | 0.70 - 0.76 ohm |
| VSV for CCV | Resistance at 20°C (68°F) | 24 - 30 ohm |
SFI SERVICE DATA
TORQUE SPECIFICATION
| Part tightened | N.m | Kgf.cm | Ft.lbf |
|---|---|---|---|
| Fuel line Union bolt type | 39 | 400 | 29 |
| Fuel line Flare nut type for use with SST | 34 | 345 | 25 |
| Fuel line Flare nut type | 38 | 380 | 28 |
| Fuel pressure pulsation damper x Delivery pipe for use with SST | 33 | 340 | 24 |
| Fuel pressure pulsation damper x Delivery pipe | 39 | 400 | 29 |
| Fuel pressure regulator x RH delivery pipe | 7.5 | 80 | 66 in.lbf |
| Fuel tank vent tube set plate x Fuel tank | 3.5 | 35 | 31 in.lbf |
| Front fuel pipe x Delivery pipe | 39 | 400 | 29 |
| Front fuel pipe x Lower intake manifold | 7.5 | 80 | 66 in.lbf |
| Fuel return pipe x LH delivery pipe | 7.5 | 80 | 66 in.lbf |
| Delivery pipe x Lower intake manifold | 18 | 185 | 13 |
| Fuel sender gauge x Fuel tank | 1.5 | 15 | 13 in.lbf |
| Fuel tank x Body | 39 | 400 | 29 |
| Drain plug x Fuel tank | 6.5 | 65 | 58 in.lbf |
| Fuel tank filler pipe x Fuel tank | 3.5 | 35 | 31 in.lbf |
| Cutoff valve cover x Fuel tank | 1.5 | 15 | 13 in.lbf |
| Accelerator pedal position sensor x Body | 5.0 | 51 | 44 in.lbf |
| Throttle body x Upper intake manifold, Lower intake manifold | 18 | 185 | 13 |
| Upper intake manifold, Accelerator cable bracket x Lower intake manifold | 18 | 185 | 13 |
| ECT sensor x Front water bypass joint | 20.4 | 208 | 15 |
| Knock sensor x Cylinder block | 45 | 450 | 33 |
| Heated oxygen sensor x Exhaust manifold | 44 | 450 | 32 |
| Heated oxygen sensor x Front exhaust pipe | 20 | 200 | 14 |
| No.1 rear seat x Body | 41 | 420 | 30 |
| MAF meter x Air cleaner | 1.68 | 17 | 15 in.lbf |
| Fuel pump resistor x Body | 12 | 122 | 8.8 |
SFI TORQUE SPECIFICATION