Manual sections
Wiring diagrams- Battery
- Body
- Bodywork
- Braking
- Comfort and convenience
- Confort
- Connector pinouts
- Current generation
- Dashboard
- Driver information
- Driving assistance
- Electrical harnesses
- Engine
- Front anti -roll bar
- Front axle
- Front doors
- Front seats
- Front section
- Front shock absorbers
- Gearbox assembly
- General points
- General points about the vehicle
- Instrument panel
- Instruments and controls
- Lighting - signalling
- Mechanical
- Other
- Power unit
- Pre-heating
- Protections and doors
- Rear axle
- Rear door windows
- Rear doors
- Rear seats
- Rear section
- Rear shock absorbers
- Roof panel
- Side structure
- Starting
- Steering
- Suspension
- Transmission
- Washing and wiping
Repair manual
Engine Peugeot 2008 I
Step-by-step instructions on "Engine" for Peugeot 2008 I (2013–2016). Pick an article — removal, installation, adjustment and diagnostics with illustrations.
Crankshaft
- Identification - data: under engine - EP engine (indirect injection) (EP6C)
- Removing-refitting: ancillary drive belt (with and without air conditioning compressor) (EP6C)
- Removing-refitting: engine ring seals (EP6C)
- Removing - refitting: engine ring seals (DV6C, DV4C, DV6DTED)
- Removing - refitting: ancillary drive belt (DV4C)
- Removing - refitting: ancillary drive belt (STOP AND START version) (DV6C, DV6DTED)
- Dismantling - re-assembly: ancillary drive belt (vehicle with air conditioning) (EB2)
- Dismantling - re-assembly: elastic auxiliary drive belt (EB2)
- Dismantling - re-assembly: coolant pump drive belt (EB2)
- Dismantling - re-assembly: engine ring seals (EB2)
- Dismantling - re-assembly: balance shafts (EB2)
- Removing-refitting: actuator / variable timing electrovalve (EP6C)
Cylinder head
- Identification - data: engine top (variable valve lift) (EP6C)
- Removing - refitting: cylinder head (on vehicle) (EP6C)
- Removal - refitting: cylinder head on the vehicle (DV6C, DV4C, DV6DTED)
- Removing - refitting: cylinder head cover (DV6C, DV4C, DV6DTED)
- Dismantling - re-assembly: cylinder head cover (EB2)
- Checks - adjustments: valve clearances (EB2)
- Removing-refitting: air inlet manifold (EP6C)
- Removing - refitting: air filter unit (DV6C, DV6DTED)
- Removing - refitting: air inlet pipe (DV6DTED, DV6C)
- Removing - refitting: turbo air cooler by-pass unit (DV6C, DV6DTED, DV4C)
- Removing - refitting: air inlet pipe (DV4C)
- Removing - refitting: air metering unit (DV4C)
- Dismantling - re-assembly: air inlet manifold (EB2)
Timing gear
- Removing - refitting: camshaft (DV6DTED, DV6C)
- Removing - refitting: camshaft housing (DV6C, DV6DTED)
- Removing - refitting: camshafts (EP6C)
- Removal / refitting: camshaft housing (DV4C)
- Dismantling - re-assembly: Camshaft (EB2)
- Checking: setting the valve timing - EP engine (indirect injection) (EP6C)
- Check: setting the valve timing (DV6DTED, DV6C)
- Checks: setting the valve timing (DV4C)
- Check: setting the valve timing (EB2)
- Timing: timing gear (without dismantling the engine EP) (indirect injection) (EP6C)
- Removing - refitting: timing chain - EP engine (indirect injection) (EP6C)
- Removing - refitting: timing belt (DV6DTED, DV6C)
- Removal / refitting: timing belt (DV4C)
- Dismantling - re-assembly: timing belt (EB2)
Air and fuel supply
- Check: Vacuum circuit (DV6DTED, DV6C, DV6ETED, DV4C, DIESEL TURBO DV6DTED M)
- Removing - refitting: inlet air pressure sensor (EP6C)
- Removing - refitting: air cleaner (EP6C)
- Removing-refitting: motorised throttle housing (EP6C)
- Removing - refitting: fuel filter (DV6DTED, DV6C)
- Removing - refitting: inlet air pressure sensor (DV4C)
- Dismantling - re-assembly: air filter unit (EB2)
- Dismantling - re-assembly: fuel pump-gauge assembly (EB2)
- Dismantling - re-assembly: fuel pump-gauge assembly (DV6DTED, DV6C, DV4C)
- Dismantling - re-assembly: Motorised throttle unit (EB2)
- Removing - refitting: fuel pump and gauge assembly (EP6C)
- Removing - refitting: Fuel tank (DV4C, DV6C, DV6DTED)
- Removing - refitting: Fuel tank (EP6C, EB2)
- Removing - refitting: fuel tank filler pipe (EB2, EP6C, DV4C, DV6DTED, DV6C)
- Check: fuel additive circuit
- Removing - refitting: additive pump (DV4C, DV6DTED, DV6C)
- Dismantling - re-assembly: fuel filler cap
- Table: fault codes - Fuel additive pump
- Help in diagnosis: Fuel gauging
Lubrication
- Check: oil pressure (EP6C, EP3C)
- Check: oil pressure (DV6DTED, DV6C)
- Check: oil pressure (DV4C)
- Check: oil pressure (EB2)
- Removing-refitting: oil pressure sensor (EP6C)
- Removing - refitting: oil pressure sensor (DV6DTED, DV6C)
- Removing-refitting: engine oil temperature and level sensor (EP6C)
- Removing - refitting: engine oil temperature and level sensor (DV6DTED, DV6C)
- Removing - refitting: engine oil temperature and level sensor (DV4C)
- Removing - refitting: oil pressure sensor (DV4C)
- Removing - refitting: oil pump (DV6DTED, DV6C, DV4C)
- Dismantling - re-assembly: oil pressure sensor (EB2)
- Dismantling - re-assembly: oil pump (EB2)
- Removing - refitting: oil filter (DV6DTED, DV4C, DV6C)
- Removing - refitting: oil pump electrovalve (EP6C)
- Help in diagnosis: oil level (EP6C, DV4C, DV6C, DV6DTED, EB2)
- Help in diagnosis: oil pressure (DV6C, DV4C, DV6DTED, EB2, EP6C)
Exhaust
- Tightening torques: exhaust system (DV6DTED, DV6C, DV4C)
- Tightening torques: exhaust system (EP6C)
- Tightening torques: exhaust system (EB2)
- Removing - refitting: exhaust manifold (DV6C, DV4C, DV6DTED)
- Removing - refitting: exhaust system (DV4C, DV6DTED, DV6C)
- Dismantling - re-assembly: catalytic converter (EB2)
- Removing - refitting: exhaust system (EP6C)
- Dismantling - re-assembly: exhaust system (EB2)
- Removing - refitting: exhaust manifold / pre-catalyser (EP6C)
- Removing - refitting: particle filter (DV6C, DV4C, DV6DTED)
- Removal / refitting: exhaust gas pressure sensor pressure take-off (DV4C)
- Dismantling - re-assembly: pressure take-off on the exhaust gas differential pressure sensor (DV6C, DV6DTED)
- Forced regeneration: particle filter (technical note)
Cooling system
- Removing - refitting: piloted thermostat (EP6C)
- Removing - refitting: fan (EP6C)
- Removing-refitting: engine cooling radiator (EP6C)
- Removing-refitting: coolant temperature sensor (EP6C)
- Removing - refitting: Coolant pump (EP6C)
- Removing-refitting: coolant outlet housing (EP6C)
- Removing - refitting: coolant pump (DV4C, DV6C, DV6DTED)
- Removing - refitting: fan (DV6DTED, DV6C)
- Removing - refitting: water temperature sensor (DV6C, DV6DTED)
- Removing - refitting: engine cooling radiator (DV6DTED, DV6C)
- Removal / refitting: coolant outlet housing (DV6DTED, DV6C, DV4C)
- Removing - refitting: coolant inlet manifold (DV6DTED, DV6C)
- Dismantling - re-assembly: fan (EB2)
- Dismantling - re-assembly: engine cooling radiator (EB2)
- Dismantling - re-assembly: cooling fan (DV4C)
- Dismantling - re-assembly: engine cooling radiator (DV4C)
- Dismantling - re-assembly: thermostat (EB2)
- Dismantling - re-assembly: Coolant pump (EB2)
- Drain and refill - refilling - bleeding: cooling system
- Help in diagnosis: lighting of the engine coolant temperature warning lamp (DV4C, DV6DTED, DV6C, EB2, EP6C)
Emission control
- Removing - refitting: oxygen sensors (EP6C)
- Removing - refitting: oxygen sensor (DV6C, DV6DTED)
- Removing - refitting: discharge (by-pass) circuit control electrovalve of the exhaust gas recirculation heat exchanger (DV6DTED, DV6C)
- Removing - refitting: exhaust gas recycling (EGR) regulation electrovalve (DV4C)
- Dismantling - re-assembly: oxygen sensors (EB2)
- Removing - refitting: purge canister solenoid valve (EP6C)
- Removing - refitting: electrically-controlled exhaust gas recycling valve (DV6C, DV6DTED)
- Removing - refitting: EGR module assembly (DV6C, DV6DTED)
- Removing - refitting: exhaust gas pressure sensor (DV6DTED, DV6C)
- Removing - refitting: EGR module assembly (DV4C)
- Dismantling - re-assembly: exhaust gas temperature sensor (DV6DTED, DV6C)
- Dismantling - re-assembly: canister discharge solenoid valve (EB2)
Turbocharging
- Checks: boost pressure (DV4C)
- Removing - refitting: turbocharger pressure regulation electrovalve (DV6C, DV6DTED)
- Removing - refitting: turbocharger (DV6C)
- Removing - refitting: turbocharger (DV6DTED)
- Removing - refitting: turbocharger pressure regulation electrovalve (DV4C)
- Removing - refitting: turbocharger (DV4C)
- Dismantling - re-assembly: turbocharger air cooler (DV6DTED, DV6C)