| Nm | ||
|---|---|---|
| Pressure sensor to receiver-dryer | 7 to 9 | |
| Expansion valve to evaporator | 4.5 to 6 | |
| Compressor bracket to engine | 35 | |
| Refrigerant line to | ||
| Receiver-dryer | 20 | |
| Expansion valve | 7 | |
| Compressor | 20 | |
| Condenser | 20 | |
| Condensation drain to bulkhead | 5 | |
| Compressor to compressor main bracket | 20 | |
Home/Opel/Zafira/Opel Zafira B (2005-2011)/Repair manual/Air Conditioning/Torque Guide Values - General
Contents
Wiring diagrams Section: Air Conditioning- Air Conditioning Compressor Diagnosis
- Change to Cooling Module Components
- AC General
- Position of the Components in the Passenger Compartment
- Overview of the Components in the Engine Compartment
- Evaporator
- Condenser
- Expansion Valve (Txv)
- Technical Data
- Leak Detection in Refrigerant Circuit
- Condenser and Receiver-Dryer for Astra- G and Zafira
- How to Remove and Install the Condensation Drain
- Torque Guide Values - General
- Techline Diagnostic Software
- Position of Diagnostic Plugs
- Diagram of Refrigerant Circuit
- Position of Service Connections (Up to Model Year 2000)
- How to Drain the Air Conditioning
- Air Conditioning, Evacuate and Charge
- How to Top Up the Compressor Lubricant
- How to Remove and Install (Up to Model Year 2001) the Condenser
- How to Remove and Install (Up to Model Year 2001) the Receiver-Dryer
- How to Remove and Install the Thermostatically Controlled Expansion Valve (Txv)
- How to Remove and Install the Defroster Switch
- How to Remove and Install the Evaporator
- How to Remove and Install the Air Conditioning Pressure Pickup
- How to Remove and Install the Compressor Main Bracket (X16XEL, X18XE1, X20DTL)
- How to Remove and Install the Compressor (X16XEL, X18XE1, X20DTL)
- Compressor Overview - Not Z 22 SE, Y 22 DTR
- How to Remove and Install the Compressor Clutch (Not Z 22 SE, Y 22 DTR)
- How to Remove and Install the Compressor Pulley (Not Z 22 SE, Y 22 DTR)
- How to Remove and Install the Compressor Magnetic Coil (Not Z 22 SE, Y 22 DTR)
- Recirculation Flap - Without Function, AC Company Behr
- Aircondition - Noisy
- How to Remove and Install the Evaporator - Rear AC
- How to Remove and Install the Rear AC Cutoff Valve
- How to Remove and Install the Front Control Switch - Rear AC
- How to Remove and Install the Rear Control Switch - Rear AC
- Location of Rear AC Refrigerant Lines in Vehicle
- How to Remove and Install the Front Right Refrigerant Line - Rear AC
- How to Remove and Install the Centre Right Refrigerant Line - Rear AC
- How to Remove and Install the Rear Right Refrigerant Line - Rear AC
- How to Remove and Install the Rear Refrigerant Line - Rear AC
- How to Remove and Install the Rear Left Refrigerant Line, Rear AC
- How to Remove and Install the Rear AC Orifice
- Torque Guide Values - Rear A/c
- Position of Service Connections (As of Model Year 2000)
- How to Remove and Install the Compressor Main Bracket (Y 20 DTH, Y 22 DTR, Z 16 XE, Z 18 XE)
- How to Remove and Install the Compressor (Y 20 DTH, Y 22 DTR, Z 16 XE, Z 18 XE)
- How to Remove and Install the Compressor (Z 22 SE)
- How to Remove and Install (As of Model Year 2002) the Condenser
- How to Replace (As of Model Year 2002) the Drying Agent Cartridge
- How to Remove and Install the Compressor Support (Z 20 LET)
- How to Remove and Install the Compressor (Z 20 LET)
- How to Remove and Install the Compressor Clutch (Y 22 DTR)
- How to Remove and Install the Compressor Pulley (Y 22 DTR)
- How to Remove and Install the Compressor Magnetic Coil (Y 22 DTR)
- Compressor Overview - Y 22 DTR
- Compressor Overview - Z 22 SE
- How to Remove and Install the Compressor Clutch (Z 22 SE)
- How to Remove and Install the Compressor Pulley (Z 22 SE)
- How to Remove and Install the Compressor Magnetic Coil (Z 22 SE)
- Replace Compressor Seal Ring - Y 22 DTR
- Replace Compressor Seal Ring - Z 22 SE
- How to Remove and Install the Compressor Safety Valve (Z 22 SE)
- How to Remove and Install the Compressor Safety Valve (Y 22 DTR)
- How to Remove and Install the Compressor Control Valve (Y 22 DTR)
- How to Replace the Service Connection Valve (Air Conditioning Charged)
- ABS 5.3
- ABS 5.3/TC/ESP
- Accessories
- Adhesive Foiles
- Air Conditioning
- Airbag
- Antenna
- Anti-Theft Warning System-S
- Automatic Transmission Front Wheel Drive
- Battery
- Board Computer
- Body Equipment
- Brake Hydraulics, Brake Lines
- Brakes
- Central Door Locking System
- Central Electrics
- Central Locking with Atws (Electronic)
- Check Control
- Clutch
- Clutch and Transmission
- Cng
- Communication / Navigation
- Connector pinouts
- Cooling System
- Corrosion Protection
- Diesel Engine
- DOHC Petrol Engine
- Ecc Electronic Climate Control
- Ehps - Electrical Hydraulic Power Steering
- Electrical Equipment and Instruments
- Electrical Socket Front/ Rear
- Electrical Window Winders
- Electronic Cruise Control
- Electronic Traction Control
- Engine and Engine Aggregates
- Engine Electrics
- Exhaust System
- Fittings, Hinges, Locks
- Frame
- Front End
- Front Wheel Brake
- Front Wheel Suspension
- Front Wheel Suspension, Wheels and Tyres
- Fuel and Exhaust System
- Fuel Injection Systems
- Fuel System
- Fuse Box
- General Vehicle Information
- Glass, Window Guides, Window Winders
- Glassfibre Parts (Bolted)
- Graphic Info Display
- Headlamps, Lamps and Horn
- Heating, Ventilation
- Heating, Ventilation, Air Conditioning (HVAC)
- Immobiliser
- Info Display Ccrt 700
- Instruments, Telltales
- Maintenance, Body and Chassis Sheet Metal Parts, Frame
- Manual Transmission Front Wheel Drive
- Mid (Multi Info Display)
- Multitimer
- Other Accessories
- Outside Rear View Mirror
- Paint
- Painting Repair Operations
- Painting Repair System
- Parkpilot
- Radiator Grille
- Radio
- Rear Axle and Rear Wheel Suspension
- Rear Axle Front Wheel Drive
- Rear Wheel Brake
- Roof Luggage Carrier (Railing)
- Seat Heating Systems
- Seats, Upholstery, Inner Trim Panels
- Secondary Air Injection
- Service Brake, Parking Brake
- Sheet Metal Parts (Bolted)
- Sheet Metal Parts (Cement and Seal)
- Sheet Metal Parts (Welded)
- Sliding Roof
- Steering
- Steering Gear
- Steering Intermediate Shaft
- Steering Linkage
- Steering Wheel - Steering Column
- Switches, Control Unit, Relays, Ignition Lock
- TID (Triple Info Display)
- Trailer Hitch
- Trim Panels, Radiator Grille, Spoiler
- Trim Strips, Lettering, Coverings
- Turbo-Charging
- Wheels and Tyres
- Windscreen Wash/wipe System, Heated Screen
- Wiring Harnesses
- Xenon Control Unit (Headlamp Range Control)